LG LWD3081ST - Double Electric Oven Referenzhandbuch

* Subject: Unit dead because of an open thermostat generally after a self clean.

* Bulletin Registration Date: 30th. Mar. 2011 * Effective from Date: 1st. Apr. 2011

Service Bulletin

Electric Range

Bulletin Number: 0ETO20110061

1/3

*Applicable for models:

General information

Technical information

Applicable in warranty: YES NO Also applicable outside YES NO

of warranty:

Applicable only with symptoms YES NO

below:

Applicable with every repair: YES NO

*2) Problem / Cause:

1. The connector on the oven thermostat is not tight enough causing excessive

heat in the area causing the thermostat to open.

2. Vent trim not installed or not installed properly.

*1) Symptoms / Customer Complaint:

Unit is dead after customer runs a self clean cycle in the oven.

*Applicable Serial Number:

Buyer Model : LWD3081ST, LWS3081ST, LWD3010ST, LWS3010ST

LSWD305ST, LSWS305ST

LWD3081ST: 807KMxx00001 ~ 103KMxx00063

LWS3081ST: 809KMxx00001 ~ 102KMxx00135

LWD3010ST: 007KMxx00001 ~ 101KMxx00063

LWS3010ST: 008KMxx00001 ~ 102KMxx00082

LSWD305ST: 003KMxx00001 ~ 007KMxx00100

LSWS305ST: 003KMxx00001 ~ 007KMxx00110

< EBG51439301 >

Melted thermostat

1. USA

LWD3081ST: 810KMxx00001 ~ 103KMxx00020

LWS3081ST: 810KMxx00001 ~ 103KMxx00210

2. Canada

Service Bulletin

Electric Range

Bulletin Number: 0ETO20110061

*3) Solution:

Replace both the open thermostat and the main wiring harness, and verify the vent trim is installed

properly. After replacing the thermostat the oven will operate. However if the customer runs

another self clean the issue may occur again. Both The updated harness and verification of the vent

trim prevents this issue from occurring multiple times.

2/3

No. buyer Model Location

Number Before(P/no.) After(P/no.)

Order this Part Description

1 LWD3081ST 5014 EAD51438701 EAD51438703 Main Harness

2 LWS3081ST 5014 EAD51439101 EAD51439103 Main Harness

3 LWD3010ST 5014 EAD51438702 EAD51438704 Main Harness

4 LWS3010ST 5014 EAD51439102 EAD51439104 Main Harness

5 LSWD305ST 5014 EAD51438701 EAD51438703 Main Harness

6 LSWS305ST 5014 EAD51439101 EAD51439103 Main Harness

a. Replace all open thermostats. There are 4 thermostats on the double oven and 2

thermostats on the single wall oven. Refer to page 3 table “Thermostats” of this document

for applicable part numbers.

b. Replace the main wiring harness. See table below for updated part #’s for each

model.

[Before] [After]

* Explanation of the differences between harness

- Before the harness had 2 wires coming off the

Thermostat with the new harness there is only a

single wire coming off the thermostat.

- Some receptacles and sleeves are changed.

2 1 1 1

[Before] [After]

Service Bulletin

Electric Range

Bulletin Number: 0ETO20110061

*3) Solution:

3/3

*4) SVC Bulletin History:

Prior Bulletins: Bulletin number: Date: Content: M/S:

c. Verify the vent trim is installed properly:

- Vent trim: Location No 5527, P/no MJZ41753801

The vent trim should be properly assembled on the front bottom of the oven. In addition,

check the angle between the vent trim and the front bottom of oven (the angle should be

50˚). The angle can be checked by measuring distance between the vent trim and the

bottom. If the distance is shorter than 0.31inch(8mm) or there is no vent trim installed,

the temperature at the electric components (such as thermostat) will overheat during

operation.

Metal trim

Angle:

50˚

Distance:

0.31inch(8mm)

*Thermostat

Description Loc/No. P/No Location Remark

Thermostat 5116 6930W1A003X Upper/Single

Cavity_Up LWD3081ST,LWD3010ST,LSWD305ST

LWS3081ST,LWS3010ST,LSWS305ST

Thermostat 5117 EBG51439301 Upper/Single

Cavity_Lo LWD3081ST,LWD3010ST,LSWD305ST

LWS3081ST,LWS3010ST,LSWS305ST

Thermostat 5118 6930W1A003D Lower Cavity_Lo LWD3081ST,LWD3010ST,LSWD305ST

Thermostat 5119 EBG51439302 Lower Cavity_Up LWD3081ST,LWD3010ST,LSWD305ST

Andere Handbücher für LWD3081ST - Double Electric Oven

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere LG Ofen Handbücher

LG WCEP6423 Bedienungsanleitung

LG WSEP4723 Series Bedienungsanleitung

LG LWS3081ST Bedienungsanleitung

LG LWS3081ST - 30in Single Electric Wall Oven Bedienungsanleitung

LG LDE3037ST Bedienungsanleitung

LG LWS3081ST - 30in Single Electric Wall Oven Bedienungsanleitung

LG WSES4728F Bedienungsanleitung

LG SolarDOM MA3882QS Bedienungsanleitung

LG LWS3081ST - 30in Single Electric Wall Oven Bedienungsanleitung

LG MP-9482SCR Bedienungsanleitung

LG LSWS306ST Bedienungsanleitung

LG LWS3081ST - 30in Single Electric Wall Oven Bedienungsanleitung

LG BIDLOV Bedienungsanleitung

LG SolarDOM MP9485FRB Bedienungsanleitung

LG LB652082S Bedienungsanleitung

LG MP-9485SR Bedienungsanleitung

LG MP-3297IXC Bedienungsanleitung

LG LDG3019ST Bedienungsanleitung

LG WCES6428F.BRSLSTD Bedienungsanleitung

LG LWS3010ST Bedienungsanleitung

LG Dios MZ948CB Bedienungsanleitung

LG LWD3063BD.BBDLLGA Bedienungsanleitung

LG LDG3037ST Bedienungsanleitung

LG ES330S Bedienungsanleitung

Beliebte Ofen Handbücher anderer Marken

Bosch

Bosch HVA531NS0 Bedienungsanleitung

Electrolux

Electrolux EOF6P46X Bedienungsanleitung

NEFF

NEFF B44S32 5GB Series Bedienungsanleitung

Combi

Combi BLODGETT BC142GDS Bedienungsanleitung

AEG

AEG COMPETENCE 311704300 Bedienungsanleitung

Rational

Rational SCC WE 61G Bedienungsanleitung

Smeg

Smeg DOSPA38X Installations- und Betriebshandbuch

Electrolux

Electrolux air-o-convect 20 GN 2/1 Bedienungsanleitung

Miele

Miele HR 1954-2 Bedienungsanleitung

KHIND

KHIND OT50 Bedienungsanleitung

Henny Penny

Henny Penny Smoker Box Bedienungsanleitung

Lang

Lang ECOD-AP Bedienungsanleitung

AEG

AEG BEK455310M Bedienungsanleitung

Frigidaire

Frigidaire FNGE90JGR Bedienungsanleitung

Hotpoint

Hotpoint FE9 S831 JSH IX Bedienungsanleitung

GE Advantium SCB2000 Bedienungsanleitung

AEG

AEG DE401301DM Bedienungsanleitung

DeLonghi

DeLonghi XA660 Handbuch