Manitowoc UDE065A Bedienungsanleitung

Part Number 000014797 Rev02 05/18

Undercounter Ice Machines

Technician’s Handbook

This manual is updated as new information and models are

released. Visit our website for the latest manual.

www.manitowocice.com

Safety Notices

Read these precautions to prevent personal injury:

• Read this manual thoroughly before operating,

installing or performing maintenance on the

equipment. Failure to follow instructions in this

manual can cause property damage, injury or death.

• Routine adjustments and maintenance procedures

outlined in this manual are not covered by the

warranty.

• Proper installation, care and maintenance are essential

for maximum performance and trouble-free operation

of your equipment.

• Visit our website www.manitowocice.com for manual

updates, translations, or contact information for

service agents in your area.

• This equipment contains high voltage electricity and

refrigerant charge. Installation and repairs are to be

performed by properly trained technicians aware of

the dangers of dealing with high voltage electricity

and refrigerant under pressure. The technician

must also be certified in proper refrigerant handling

and servicing procedures. All lockout and tag out

procedures must be followed when working on this

equipment.

• This equipment is intended for indoor use only. Do not

install or operate this equipment in outdoor areas.

• As you work on this equipment, be sure to pay close

attention to the safety notices in this handbook.

Disregarding the notices may lead to serious injury

and/or damage to the equipment.

nWarning

Follow these electrical requirements during

installation of this equipment.

• All field wiring must conform to all applicable

codes of the authority having jurisdiction. It is

the responsibility of the end user to provide the

disconnect means to satisfy local codes. Refer to

rating plate for proper voltage.

• This appliance must be grounded.

• This equipment must be positioned so that the plug

is accessible unless other means for disconnection

from the power supply (e.g., circuit breaker or

disconnect switch) is provided.

• Check all wiring connections, including factory

terminals, before operation. Connections can

become loose during shipment and installation.

• For a cord-connected appliance, the following must

be included:

• Do not unplug by pulling on cord. To unplug,

grasp the plug, not the cord.

• Unplug from outlet when not in use and before

servicing or cleaning.

• Do not operate any appliance with a damaged

cord or plug, or after the appliance malfunctions

or is dropped or damaged in any manner.

Contact the nearest authorized service

facility for examination, repair, or electrical or

mechanical adjustment

nWarning

Follow these precautions to prevent personal injury

during installation of this equipment:

• Installation must comply with all applicable

equipment fire and health codes with the authority

having jurisdiction.

• To avoid instability the installation area must be

capable of supporting the combined weight of the

equipment and product. Additionally the equipment

must be level side to side and front to back.

• Remove front panel before lifting and installing and

use appropriate safety equipment during installation

and servicing. Two or more people are required to

lift or move this appliance to prevent tipping and/

or injury.

• Do not damage the refrigeration circuit when

installing, maintaining or servicing the unit.

• Connect to a potable water supply only.

• This equipment contains refrigerant charge.

nWarning

Follow these precautions to prevent personal injury

while operating or maintaining this equipment.

• Legs or casters must be installed and the legs/casters

must be screwed in completely. When casters

are installed the mass of this unit will allow it to

move uncontrolled on an inclined surface. These

units must be tethered/secured to comply with all

applicable codes. Swivel casters must be mounted

on the front and rigid casters must be mounted on

the rear. Lock the front casters after installation is

complete.

• Some 50 Hz models may contain up to 150 grams

of R290 (propane) refrigerant. R290 (propane)

is flammable in concentrations of air between

approximately 2.1% and 9.5% by volume (LEL lower

explosion limit and UEL upper explosion limit). An

ignition source at a temperature higher than 470°C

is needed for a combustion to occur.

• Refer to nameplate to identify the type of refrigerant

in your equipment.

• Only trained and qualified personnel aware of the

dangers are allowed to work on the equipment.

• Read this manual thoroughly before operating,

installing or performing maintenance on the

equipment. Failure to follow instructions in this

manual can cause property damage, injury or death.

• Crush/Pinch Hazard. Keep hands clear of moving

components. Components can move without

warning unless power is disconnected and all

potential energy is removed.

• Moisture collecting on the floor will create a

slippery surface. Clean up any water on the floor

immediately to prevent a slip hazard.

nWarning

Follow these precautions to prevent personal injury

while operating or maintaining this equipment.

• Objects placed or dropped in the bin can affect

human health and safety. Locate and remove any

objects immediately.

• Never use sharp objects or tools to remove ice or

frost.

• Do not use mechanical devices or other means to

accelerate the defrosting process.

• When using cleaning fluids or chemicals, rubber

gloves and eye protection (and/or face shield) must

be worn.

DANGER

Do not operate equipment that has been misused,

abused, neglected, damaged, or altered/modified

from that of original manufactured specifications.

This appliance is not intended for use by persons

(including children) with reduced physical, sensory

or mental capabilities, or lack of experience and

knowledge, unless they have been given supervision

concerning use of the appliance by a person

responsible for their safety. Do not allow children to

play with, clean or maintain this appliance without

proper supervision.

DANGER

Follow these precautions to prevent personal injury

during use and maintenance of this equipment:

• It is the responsibility of the equipment owner to

perform a Personal Protective Equipment Hazard

Assessment to ensure adequate protection during

maintenance procedures.

• Do Not Store Or Use Gasoline Or Other Flammable

Vapors Or Liquids In The Vicinity Of This Or Any

Other

• Appliance. Never use flammable oil soaked cloths or

combustible cleaning solutions for cleaning.

• All covers and access panels must be in place and

properly secured when operating this equipment.

• Risk of fire/shock. All minimum clearances must be

maintained. Do not obstruct vents or openings.

• Failure to disconnect power at the main power

supply disconnect could result in serious injury or

death. The power switch DOES NOT disconnect all

incoming power.

• All utility connections and fixtures must be

maintained in accordance with the authority having

jurisdiction.

• Turn off and lockout all utilities (gas, electric, water)

according to approved practices during maintenance

or servicing.

• Units with two power cords must be plugged

into individual branch circuits. During movement,

cleaning or repair it is necessary to unplug both

power cords.

We reserve the right to make product improvements at

any time. Specifications and design are subject to change

without notice.

Table of Contents

Part Number 000014797 Rev02 05/18 9

General Information

Model Numbers............................... 17

How to Read a Model Number ................ 19

Ice Machine Warranty Information............ 19

Installation

Location of Ice Machine....................... 21

Ice Machine Clearance Requirements......... 22

Ice Machine Heat of Rejection ................ 22

Leveling the Ice Machine...................... 23

Electrical Requirements....................... 24

Electrical Specifications....................... 24

Water Service/Drains ......................... 26

Water Supply.............................. 26

Cooling Tower Applications................ 27

Maintenance

Cleaning and Sanitizing Procedure U140, U190,

U240, U310 ................................... 29

Preventative Maintenance Cleaning........ 39

Cleaning the Condenser ................... 41

Removal from Service/Winterization ....... 42

Bin Removal............................... 43

Cleaning and Sanitizing Procedure UDE065 .. 44

Cleaning The Condenser................... 50

Removal from Service/Winterization ....... 51

Cleaning and Sanitizing Procedure UDE080 .. 52

Cleaning The Condenser................... 63

Removal from Service/Winterization ....... 64

10 Part Number 000014797 Rev02 05/18

Operation

Sequence of Operation U0140/UF0140/U0190/

UF0190/U240/UF240/U310/UF310 ........... 65

Touch Pad Features........................ 65

Ice Making Sequence of Operation ........... 68

Control board Revisions ................... 68

Software revisions......................... 68

Sequence of Operation .................... 69

Control Board Timers ...................... 71

Safety Limits .............................. 72

U0140/UF0140/U0190/UF0190/U240/UF240/

U310/UF310 Energized Parts Chart......... 74

Operational Checks ........................... 76

Ice Thickness Check ....................... 76

Ice Thickness Adjustment.................. 76

Minimum/Maximum Slab weight .......... 77

Sequence of Operation UDE065 .............. 78

UDE065 Energized Parts Chart ............. 80

Ice Thickness Adjustment.................. 81

Sequence of Operation UDE080 .............. 82

UDE080 Energized Parts Chart ............. 84

Operational Checks UDE080 .................. 86

Siphon System ............................ 86

Water Level ............................... 86

Water Level Check......................... 87

Ice Thickness Check ....................... 88

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Manitowoc Eiswürfelbereiter Handbücher

Manitowoc

Manitowoc S model Bedienungsanleitung

Manitowoc

Manitowoc S1800M Gebrauchsanweisung

Manitowoc

Manitowoc UG Series Bedienungsanleitung

Manitowoc

Manitowoc QM30A Betriebsanleitung

Manitowoc

Manitowoc Indigo I1200 Bedienungsanleitung

Manitowoc

Manitowoc Indigo I0300 Bedienungsanleitung

Manitowoc

Manitowoc Manitowoc NEO U0140 Series Bedienungsanleitung

Manitowoc

Manitowoc S1400M Gebrauchsanweisung

Manitowoc

Manitowoc F-STYLE OR NON MANITOWOC BIN 7601193 Bedienungsanleitung

Manitowoc

Manitowoc NEO Bedienungsanleitung

Manitowoc

Manitowoc SM Series Bedienungsanleitung

Manitowoc

Manitowoc CNF201 Montage- und Bedienungsanleitung

Manitowoc

Manitowoc RNS0244 Bedienungsanleitung

Manitowoc

Manitowoc B150 Bedienungsanleitung

Manitowoc

Manitowoc CrystalCraft Premier Bedienungsanleitung

Manitowoc

Manitowoc KEY CARD KIT K00152 Bedienungsanleitung

Manitowoc

Manitowoc Koolaire K Series Bedienungsanleitung

Manitowoc

Manitowoc G200 Series Bedienungsanleitung

Manitowoc

Manitowoc RFF Bedienungsanleitung

Manitowoc

Manitowoc K00459 Bedienungsanleitung

Manitowoc

Manitowoc Welbilt Indigo NXT QuietQube Bedienungsanleitung

Manitowoc

Manitowoc QR0320A Bedienungsanleitung

Manitowoc

Manitowoc UG080A Bedienungsanleitung

Manitowoc

Manitowoc QM45 Series Leitfaden

Beliebte Eiswürfelbereiter Handbücher anderer Marken

Hoshizaki

Hoshizaki KMD-460MWJ Bedienungsanleitung

Sub-Zero

Sub-Zero 315I Gebrauchsanweisung

Unold

Unold 48945 Bedienungsanleitung

Kenmore

Kenmore 2217402A Bedienungsanleitung

Cornelius

Cornelius WM600 Betriebsanleitung

GE XPIO43SCSS Bedienungsanleitung

Hoshizaki

Hoshizaki KMD-901MAH Bedienungsanleitung

Whynter

Whynter FIM-450HA Bedienungsanleitung

U-Line

U-Line UMCR014-SC01A Installationshandbuch

Andrew James

Andrew James AJ000522 Bedienungsanleitung

Scotsman

Scotsman CME1356 Bedienungsanleitung

Scotsman

Scotsman ACM 25 Bedienungsanleitung

Kärcher

Kärcher IP 120 Bedienungsanleitung

U-Line

U-Line SS1095 Bedienungsanleitung

Maytag

Maytag MIM1554WRS - Ice Maker Bedienungsanleitung

Hoshizaki

Hoshizaki KM-630MAH Bedienungsanleitung

Princess

Princess Yonanas Bedienungsanleitung

Unold

Unold 48946 Bedienungsanleitung