Masterbuilt CG600S Bedienungsanleitung
Manual Code : 9804210067 211103-GH
CG600S
Charcoal Wagon
Manual applies to the following model number(s)
Two people recommend for assembly
These numbers are located on the rating label of the grill.
Mfg. Date - Serial Number Your model number
SH19041319
Please record this information immediately and keep in a safe
place for future use.
IMPORTANT
Master it. Masterbuilt.
Welcome to the family. Let’s get started.
WARNINGS AND IMPORTANT SAFEGUARDS
• This manual contains important information necessary for the proper assembly and safe use of the appliance.
• Read and follow all warnings and instructions before assembling and using the appliance.
• Keep this manual for future reference.
WARNING
Failure to follow these instructions could result in fire, explosion or burn
hazard which could cause property damage, personal injury, or death.
READ ALL INSTRUCTIONS
• Always use grill in accordance with all applicable local, state, and federal fire codes.
• Before each use check all nuts, screws, and bolts to make sure they are tight and secure.
• Never operate grill under overhead construction such as roof coverings, carports, awnings, or overhangs.
• Grill is for OUTDOOR HOUSEHOLD USE ONLY.
• Never use inside enclosed areas such as patios, garages, buildings, or tents.
• Never use inside or on recreational vehicles or boats.
• Maintain a minimum distance of 3m (9.8ft) from overhead construction, walls, rails or other structures.
• Keep a minimum 3m (9.8ft) clearance of all combustible materials such as wood, dry plants, grass, brush, paper.
• Never use grill for anything other than its intended use. This grill is NOT for commercial use.
• Accessory attachments not supplied by Masterbuilt are NOT recommended and may cause injury.
• Use of alcohol, prescription, or non-prescription drugs may impair user’s ability to properly assemble or safely operate grill.
• Keep a fire extinguisher accessible at all times while operating grill.
• When cooking with oil or grease, have a type BC or ABC fire extinguisher readily available.
• In the event of an oil or grease fire do not attempt to extinguish with water. Immediately call the fire department. A type BC
or ABC fire extinguisher may, in some circumstances, contain the fire.
• Use grill on a level, non-combustible, stable surface such as dirt, concrete, brick, or rock. An asphalt surface (blacktop) may
not be acceptable for this purpose.
• Grill MUST be on the ground. Do not place grill on tables or counters. Do NOT move grill across uneven surfaces.
• Do not use grill on wooden or flammable surfaces.
• Keep grill clear and free from combustible materials such as gasoline and other flammable vapors and liquids.
• Do not leave grill unattended.
• Keep children and pets away from grill at all times. Do NOT allow children to use grill. Close supervision is necessary when
children or pets are in the area where grill is being used.
• Do NOT allow anyone to conduct activities around grill during or following its use until it has cooled.
• Never use glass, plastic, or ceramic cookware in grill. Never place empty cookware in grill while in use.
• Never move grill when in use. Allow grill to cool completely (45°C (below 115°F)) before moving or storing.
• Do not store grill with hot ashes or charcoal inside grill. Store only when fire is completely out and all surfaces are cold.
• Never use grill as a heater (READ CARBON MONOXIDE HAZARD).
• The grill is HOT while in use and will remain HOT for a period of time afterwards and during cooling process. Use CAUTION.
Wear protective gloves/mitts.
CARBON MONOXIDE HAZARD
• Burning wood, charcoal or propane gives offcarbon monoxide, which has no odor and can cause death.
• DO NOT burn wood, charcoal or propane inside homes, vehicles, tents, garages or any enclosed areas.
• Use only outdoors where it is well ventilated.
2
WARNINGS AND IMPORTANT SAFEGUARDS
• Be careful when removing food from grill. All surfaces are HOT and may cause burns. Use protective gloves/mitts or long,
sturdy, cooking tools for protection from hot surfaces or splatter from cooking liquids.
• DO NOT bump or impact the grill to prevent personal harm, damage to grill, or spillage/splashing of hot cooking liquid.
• Do not touch HOT surfaces
• Grill is hot during use. Keep face and body away from door(s) and vents. Steam and hot air are expelled during use.
• Air dampers are HOT while the grill is in use and during cooling; wear protective gloves when adjusting.
• Grill has an open flame. Keep hands, hair, and face away from flame. Do NOT lean over grill when lighting. Loose hair and
clothing may catch fire.
• DO NOT obstruct flow of combustion and ventilation.
• Do not cover cooking racks with metal foil. This will trap heat and may cause damage to the grill.
• Never leave HOT coals or ashes unattended.
• Do not cook before the charcoal has a coating of ash.
• Do not remove ashcan while ashes and charcoal are HOT.
• Use protective gloves when handling this grill or working with fire. Use protective gloves or long, sturdy fireplace tools when
adding wood or charcoal.
• Use only charcoal lighting fluid. Never use gasoline, alcohol or other highly volatile fluids to ignite charcoal. These fluids can
explode causing injury or death.
• Never overfill charcoal grate. This can cause serious injury as well as damage to the grill.
• WARNING! Do not use spirit or petrol for lighting or re-lighting!
• Do not cook before the fuel has a coating of ash.
• WARNING! This barbecue will become very hot, do not move it during operation.
• Do not use indoors!
• WARNING! Do not use spirit or petrol for lighting or re-lighting! Use only firelighters complying to EN 1860-3!
• WARNING! Keep children and pets away.
• Do not use the barbecue in a confined and/or habitable space e.g. houses, tents, caravans, motor homes, boats. Danger of
carbon monoxide poisoning fatality.
DO NOT EXCEED A TOTAL OF 2 KG/4 LBS. OF CHARCOAL
• Never add additional lighter fluid once charcoal has ignited. Follow directions on lighter fluid container.
• Dispose of cold ashes by placing them in aluminum foil, soaking with water, and discarding in a non-combustible container.
• Keep lid open during the lighting process. Do not close the lid until the flames have burned down. Failure to follow this
instruction may result in damage to painted surfaces due to eccessive heat.
3
SAVE THESE INSTRUCTIONS
This product does not come with charcoal or wood chunks.
Packing Contents
IMPORTANT: Remove all packing contents before assembly
It is important that you remove all paper, packing foam and
cardboard from unit before assembly.
Located on the body of the grill is a support bar used for shipping
purposes only. This bar must be removed so that you may
successfully assemble your grill. Location of this bar is shown
here. The bar is no longer needed at this time.
Remove support bar
Your grill features an internal shield to prevent common paint-peeling due to
excessive heat.
Heat Shield
Improved Heat Protection
4
Structural Proximity and Safe Usage Recommendations
REMINDER: Maintain a minimum distance of
3m (9.8ft)
from rear, sides and top of grill to overhead construction,
walls, rails or other combustible construction. This
clearance provides adequate space for proper combustion,
air circulation and venting.
3m (9.8ft)
3m (9.8ft)
3m (9.8ft)
Hardware
Do not fully tighten the screws until all steps have been completed.
This will allow all screws to assembly properly.
IMPORTANT
When you un-pack your grill, remove all parts and packaging material from the box and inside the grill.
Make sure you have all the items on the parts list. Carefully check the unit and make sure there is no damage.
DO NOT RETURN TO RETAILER for assembly assistance, missing or
damaged parts. Please contact MASTERBUILT Customer Service at
www.masterbuilt.com/pages/support. Please have the model number
and serial number available. These numbers are located on the silver
rating label on the grill.
STOP
•BEFORE ASSEMBLY READ ALL INSTRUCTIONS CAREFULLY.
• Assemble on a clean flat surface
• Tools needed: Adjustable wrench, Phillips head screwdriver
• Approximate assembly time: 2 hours.
• Actual product may differ from picture shown.
• It is possible that some assembly steps have been completed in the factory.
Item Qty Description
A 0/2 M5x15 Hex Phillips Head Screw
B 2/4 M5 Nut
C 1 M4 Nut
D 1 M4x10
E 2 Charcoal Access Door Hindge Pins
F 8 M6x15 Shoulder Bolt
G 2 M6x10 Phillips Head Screw
H 12 M5x10 Phillips Head Screw
I 4 M5x8 Shoulder Screw
J 6 M6 KEPS Nut
K 1 M6x21 Shoulder Screw
L 2 #10 Lock Washer
M 2 M10 Locknut
N 2 M10 Nut
O 48 M6x15 Phillips Head Screw
5
6
Actual product may differ from picture shown.
Tools needed for assembly:
8-inch long Phillips head screwdriver,
Pliers or Adjustable Wrench
Item #
Qty
Description
1 1 Cooking Grid Rear Frame
2 3 Cooking Grid
31
Cooking Grid Front Frame w/Handle
4 2 Smoke Stack Cap
5 2 Smoke Stack
6 1 Temperature Gauge
7 2 Lid Handle Stand O
8 1 Lid Handle
9 2 Folding Side Shelf
10 1 Slotted Adjustment Panel
11 1 Charcoal Tray Linkage Assembly
12 1 Charcoal Tray Linkage Knob
13 1 Lid and Firebox Assembly
14 1 Left Rear Leg #3
15 1 Left Front Leg #4
16 1 Right Rear Leg #1
17 1 Right Front Leg #2
18 1 Wheel Axle
Item #
Qty
Description
19 2 Wheel
20 1 Cart Bottom Shelf
21 1 Cart Front Panel
22 1 Cart Rear Panel
23 1 Ash Tray
24 1 Firebox Right Lower Panel
25 2 Damper
26 1 Firebox Left Lower Panel
27 2 Charcoal Door Hinge
28 1 Charcoal Door
29 2 Charcoal Door Handle
30 2 Charcoal Door Handle Washer
31 2 Charcoal Door Locking Latch
32 1 Charcoal Tray Lift Assembly
33 1 Charcoal Tray
34 2 Cooking Grid Side Frame
35 2 Locking Casters
3
8
2
6
5
9
10
1
4
15
19
14
17
22
20
21
13
16
33
32
23
35
7
34
12
27
30
29
31
18
9
26 24
11
25
Parts List
28
14
Assembly
1
2
3
O
G
O
G
X2
O
G
X2
26
15
24
17
16
O
O
O
O
X4
O
X4
O
OO
20
22
DO NOT FULLY TIGHTEN SCREWS.
DO NOT FULLY TIGHTEN SCREWS.
7
8
Assembly
4
5
X4
O
O
O
O
O
21
19
19
M
X2
M
M
18
35
FULLY TIGHTEN ALL SCREWS.
Assembly
6
7
25
25
I
I
X4
I
27
27
H
X8
H
H
9
10
Assembly
8
9
X14
O
OO
O
O
OO
O
O
X4
O
OO
8
7
7
787
REMOVE
SUPPORT
BAR
Inhaltsverzeichnis
Andere Masterbuilt Raucher Handbücher
Masterbuilt
Masterbuilt MB20100112 Bedienungsanleitung
Masterbuilt
Masterbuilt CS40G1DW Bedienungsanleitung
Masterbuilt
Masterbuilt 20070407 DIGITAL SMOKEHOUSE Leitfaden
Masterbuilt
Masterbuilt 20051011 Leitfaden
Masterbuilt
Masterbuilt GMES Bedienungsanleitung
Masterbuilt
Masterbuilt 20070910 DIGITAL SMOKEHOUSE Leitfaden
Masterbuilt
Masterbuilt 20070710 Bedienungsanleitung
Masterbuilt
Masterbuilt MES 130P Bedienungsanleitung
Masterbuilt
Masterbuilt 20070211 Leitfaden
Masterbuilt
Masterbuilt MB20075617 Bedienungsanleitung
Masterbuilt
Masterbuilt ES40G1.5DW1 Bedienungsanleitung
Masterbuilt
Masterbuilt 20070411 Bedienungsanleitung
Masterbuilt
Masterbuilt CS40G1DW Bedienungsanleitung
Masterbuilt
Masterbuilt 20060516 Leitfaden
Masterbuilt
Masterbuilt MES 30B Bedienungsanleitung
Masterbuilt
Masterbuilt K42802 Gebrauchs- und Pflegehandbuch
Masterbuilt
Masterbuilt MB20071322 Bedienungsanleitung
Masterbuilt
Masterbuilt PORTABLE SMOKER BAG Bedienungsanleitung
Masterbuilt
Masterbuilt 20250918 Bedienungsanleitung
Masterbuilt
Masterbuilt 20050211 Leitfaden
Beliebte Raucher Handbücher anderer Marken
Smoke hollow
Smoke hollow 30166E Bedienungsanleitung
oklahoma joes
oklahoma joes 15202037 Bedienungsanleitung
Trail Embers
Trail Embers SMK7030AS Bedienungsanleitung
Klarstein
Klarstein 10031325 Bedienungsanleitung
Kingsford
Kingsford SC2315801-KF Bedienungsanleitung
Char-Broil
Char-Broil 1000 Bedienungsanleitung
Char-Broil
Char-Broil 12701705 Bedienungsanleitung
Rosle
Rosle Silence Bedienungsanleitung
Royal Catering
Royal Catering RCRO-1300 Bedienungsanleitung
New Braunfels
New Braunfels Bandera 09201553 Bedienungsanleitung
Char-Broil
Char-Broil 12101625 Bedienungsanleitung
Pit Boss
Pit Boss PBVPS1 Stücklistenhandbuch