Matador J210S Bedienungsanleitung

MEAT BONE SAW

INSTRUCTION

For Your Own Safety, Read Instruction

Manual Before Operating this Equipment

- 2-

CONTENTS

1. BreifIntroduction&SafetyInstruciton

2. Charactor

3.Components

4. PartsExplodeDiagram

5. Operation

6. Cleanning

7. PartsNameReferencetable

8. TechnicalParameters

9. PackingList

5

6-7

8-9

- 3-

- 4-

WARNING

SAFTEY INSTRUCTIONS

Brief Instruction

• Theinstructionmanualshowsthesafetyoperationforuserreference.

• Mustreadtheinstructionscarefullyandcorrectunderstandingofitsoperation

methodsandvariousconsiderations,thenoperateorrepairandmaintenance

• Keepthismanualandplacednearthemachine,sothatcancheckatany

time ！

• Please wear prope working clothes、Security

posture and operate correctly ！

• Before use, please check again for this machine.

Pleasebesuretocheckfortheworktableofactivitiesifitwillbechangedintransit,if

there'sanylooseforfasteningscrews,ifthereisashiftofmotorbackcover!

• Please make sure to install leakage protection

devices, must be connected with the earth wire! ！

• Wore Gloves when replacing the Saw Band ！

• Never Position Fingers or thumbs in line with the cut!

Seriouspersonalinjurycouldoccur.

• DO NOT BACK MEAT AWAY fromthebladewhilethesawisrunning.

Planyourcutssoyoualwayscutthroughthemeat.Ifyouneedtobackthemeatout,

turnthebandsawoffandwaitforthebladetocometoacompletestop.Donottwistor

putexcessivestressonthebladewhilebackingmeataway

• Donot operate the emergency stop frequently In

case of damage the motor!

Charactor



1.TooTightprotectiondeviceofbandsaw!

2.Themotoroverheatingprotectiondevice.

3.Poweroffwhendooropenningsafetyprotectiondevice.

4.0.2secondsfortheemergencybrakeprotectiondevice,10timesbeyondtheEuropeanUnion's

safetystandards.(eustandards:EN60335-2-6420tharticle111)

5.Largeworkingtable,workmoresecure,moreeasily.

6.Drivenwheeldetachablewash,nohealthcorner.

7.Machinescanbedirectlysprayirrigation,clearnmoreeasilyandhealth.

Components

SawBandtensioningKnob

DrivenWheel

VerticalClampingdevice

Sawband

Meatstopper

Carryingtable

TableSlider

DrivingWheel

MeatResidue

CollectingPan

BottomDoor

Locker

TopDoorLocker

SawProtecting

Cover

MeatStopperFixer

EmergencyStop

ON/OFFSwitch

- 5-

- 6-

- 7-

Operation

A. Loosenthemeatstopper

C.Startthemachine

DEF.Putthefoodonmovable

worktingtable,thenTake

sawguardontheright

protectionlevel,promotejob

boards,tobringfoodtothe

saw(Thedrivingspeed

differsaccordingtothe

differentfood,andbaseson

thenormalrunningofsaw

bandasalimition.Repeat

theoperationfortimesuntil

thecuttingoperationis

completed,thentrunoffthe

powersupply! Never

Position Fingers or

thumbs in line with the

cut!

B. Confirmthecuttingthickness

byadjustingthedistance

betweenfrontandrearmeat

stoppersandbandsaw

- 8-

(A)

(C)

(E)

(B)

(D)

(F)

Cleaning

A. Opentheprotectiondoor B. Takeouttheresiduepan

(A) (B)

Notice:

- 9-

CDE.LossenthetensioningKnobtorelaxthebandsawthendemountthesaw(Wearinggloves

before)。Onehandpressdownthetensioningknob,onehandupwardlifttheDrivenwheel

outandclean

F. Pleaseuselowpressuresquirtgunto

spraytheinteriormincedmeat,then

reinstallmentinorder. Electrical

parts(as exterior control

knob,switch....) can't be directly

sprayed by squirt gun.

1)Duringremountingthesawband,

checkthetoothdirection,positionand

makesurethatthesawbandshall

beclosetothebackingwheelfaceof

lowerclampingdevice(Theposition

ofbackingwheelhasbeenpresetat

delivery)



2)Rotatetopwheelwithhandandmake

surethatitrunssmoothlyandthe

sawteethstandoutonthewheel(if

necessary,itcanberealizedtoadjust

theregulatingdeviceontthetopwheel)

- 10-

SN PartsDescription SN PartsDescription

1 BottomLockingBlock 29 MeatStopper

2 BottomDoorlockerseat 30 Motor

3 SawProtectingCover 31 CarryingPlate

4 TopLockingBlock 32 CarryingPlateSeat

5 TopDoorlockerseat 33 Movableworkingtable

6 Door 34 RightSlideRail

7 DrivenwheelCover 35 TherightwheelFrame

8 Drivenwheel 36 LockingBlock

9 DrivenwheelBearing（6004） 37 Lockinghandle

10 Sealingring 38 Lockingbolt

11 Drivenwheelaxle 39 Rollershaft

12 Drivenwheelstand 40 Rolleraxle（627）

13 Drivenslidecarriage 41 Roller

14 Adjustingnut 42 Railcarriageframe

15 Springseat 43 LeftSlideRail

16 Spring 44 LeftRollerframe

17 TensioningKnob 45 MeatScrappingPlate

18 tensioningnut 46 MeatScrappingseat

19 tensioningshaftscrew 47 MeatScrappingPlate

20 Framebolt 48 BandSawGuideSeat

21 SlideCarriagePressingPlate 49 DoorSwithseat

22 Enclosure 50 Footpad

23 BandSawGuideSeat 51 Baseseat

24 BandSawBlocker 52 DrivingWheel

25 BandSawGuidePlate 53 ResidueCollectingPan

26 MotorCover 54 DrivingWheelaxleSleeve

27 MeatStopperLockerBolt（M8） 55 BandSaw

28 MeatStopperseat

Parts Description

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Matador Gesehen Handbücher

Matador

Matador BHD220 Bedienungsanleitung

Beliebte Gesehen Handbücher anderer Marken

RIDGID

RIDGID BS1400 Bedienungsanleitung

ATIKA

ATIKA BWS 400-2 Bedienungsanleitung

RGC

RGC FS20 Bedienungsanleitung

Makita

Makita M2300 Bedienungsanleitung

IMET Spa

IMET Spa BASIC 300 PLUS SHI Bedienungsanleitung

IMET Spa

IMET Spa SIRIO 370 AF-E Bedienungsanleitung

Optimum

Optimum OPTisaw CS 275 Bedienungsanleitung

Makita

Makita BPB180 Bedienungsanleitung

Stihl

Stihl MS 462 C-M Bedienungsanleitung

AEG

AEG TS 250 K Bedienungsanleitung

Meec tools

Meec tools 004665 Bedienungsanleitung

Makita

Makita LS1018L Bedienungsanleitung

Ryobi

Ryobi RCS1400 Bedienungsanleitung

DeWalt

DeWalt DCS391 Bedienungsanleitung

Sealey

Sealey SA72 Bedienungsanleitung

skilsaw

skilsaw SPT88 Montageanleitung

Urrea

Urrea SI810 Abmessungen und Installationsanleitung

EINHELL

EINHELL BKG 210/1 Bedienungsanleitung