Maxwell VWC 1000 50TDC Bedienungsanleitung

1000 & 1500 Windlass

Manual

VETUS–MAXWELL APAC Ltd

Copyright Vetus-Maxwell APAC Ltd. All rights

reserved.

Vetus-Maxwell APAC Ltd reserves the right to make

engineering refinements on all products without notice.

Always consult manual supplied with product as details

may have been revised.

Illustrations and specifications are not binding as to

detail.

P103103 Rev.5.00 01/10/12

Vetus-Maxwell APAC Ltd 1000 1500 Windlass 1

Table of Contents

Preliminary Information .............................................................................................................. 2

Introduction............................................................................................................................... 2

Components ............................................................................................................................. 2

Important Safety Information .................................................................................................... 3

Parts of the Windlass ............................................................................................................... 4

Parts of the Gearbox ................................................................................................................ 8

Ordering Spare Parts.............................................................................................................. 10

Chain Selection Guide............................................................................................................ 11

Installation.................................................................................................................................. 12

General Requirements ........................................................................................................... 12

Installation Instructions ........................................................................................................... 13

Wiring Instructions.................................................................................................................. 16

Operation.................................................................................................................................... 21

Anchoring Tips........................................................................................................................ 21

Lowering the Anchor............................................................................................................... 21

Raising the Anchor ................................................................................................................. 21

Free falling the Anchor ........................................................................................................... 22

Raising the Anchor Manually .................................................................................................. 22

Using the Warping Drum ........................................................................................................ 22

Maintenance ............................................................................................................................... 23

Trouble Shooting Guide............................................................................................................ 25

Reference Information............................................................................................................... 26

Specifications ......................................................................................................................... 26

Dimensions............................................................................................................................. 27

Typical Greasing Instructions ………………………………………………………………………28

Additional Resources

The following resources are included at the back of this manual:

Deck Cutout Details

Warranty Form

Contact Details (on back cover)

Note: For your nearest retailer, service agent or representative please refer to our website

www.maxwellmarine.com

21000 1500 Windlass Vetus-Maxwell APAC Ltd

Preliminary Information

Introduction

Congratulations on your purchase of a Maxwell windlass. Please read these instructions carefully to

enable you to correctly install and maintain the windlass for years of trouble-free operation.

Note

Failure to follow the correct installation, operation or maintenance instructions will jeopardise your safety

and could invalidate the warranty.

Components

In addition to this instruction manual, the following components may be included with the windlass:

•Windlass

•Remote up/down control panel

•Circuit breaker/isolator panel

•12V or 24V reversing solenoid

•Clutch Lever

•Deckplate gasket

•Motor Bolt Kit

•Template (At rear of manual)

•Small parts:

•Nuts

•Flat washer

•Spring washer

Vetus-Maxwell APAC Ltd 1000 1500 Windlass 3

Important Safety Information

•Make sure your windlass has been correctly specified before installation - Personal safety may

depend on it. The windlass must have a maximum pull capacity of at least three times the

combined weight of the anchor and chain.

•For automatic operation to be possible, the anchor must be self launching.

•Never use the windlass under power with the lever inserted in the clutch nut.

•Keep hands, feet, loose clothing and hair well clear of the windlass and rope/chain during

operation.

•While raising the anchor, run the boat's engine above idle. This will minimise the power drain on

the batteries.

•Never operate the windlass from a remote station without having a clear view of the windlass.

•When operating the chainwheel pawl, keep fingers away from incoming chain.

•Do NOT use the windlass as a mooring point. When anchoring or mooring, secure the line directly

to a bollard or deck cleat.

•Do NOT use the windlass to pull the boat forward when raising the anchor. Use the boat's engine

to drive the boat up to the anchor.

•Do NOT attempt to break free a fouled anchor with the windlass. Secure the line to a bollard or

cleat and use the boat's engine to break the anchor out.

•Always firmly tie down the anchor when under way or in heavy seas. Do not rely on the windlass as

a securing device.

•Always turn the circuit breaker/isolator switch off when the windlass is not in use and before you

leave the boat.

•Tie the end of the anchor chain rode to a secure fixture in the chain locker.

•Do NOT use the windlass to haul a person up a mast.

41000 1500 Windlass Vetus-Maxwell APAC Ltd

VW and VWLP Windlass Parts

Fig 1: VW and VWLP Windlass Parts

Vetus-Maxwell APAC Ltd 1000 1500 Windlass 5

VW and VWLP Windlass Parts

Item No. Component description Qty Part to order Includes items

1 Cap 1 P101615 1,3,4,7,10,15,25(x2)

2 Label - 1000 1 6424 2

Label - 1500 1 6425 2

3 Screw - 3/8" x 1" 1 P101615 1,3,4,7,10,15,25(x2)

4 Washer 1 P101615 1,3,4,7,10,15,25(x2)

5 Clutch Nut 1 *P101621 or P101622 1,2,5

6 Drum - VWC 1 3436 6

7 Circlip 1 P101615 1,3,4,7,10,15,25(x2)

8 Clutch Cone 2 P101623 8(x2)

9 Chainwheel 1 3173 9

10 "V" Ring Seal 1 P101615 1,3,4,7,10,15,25(x2)

11 Retaining Collar 1 **P101664 or P101665 or P101666 11,28,29

12 Emergency Crank Lever 1 P20044 12

13 Pin - Pawl 1 P101620 13,14,15

14 Pawl 1 P101620 13,14,15

15 Washer 1 P101615 1,3,4,7,10,15,25(x2)

16 Cheese Head Screw - M8 x 16 2 P101626 16(x2),17(x1)

17 Stripper 1 P101626 16(x2),17(x1)

18 Deckplate 1 **P101627 or P101628 or P101629 11,18,20(x4),21(x4),22(x4),23(x4),28,29

19 Gasket 1 3474 1

Stud - 50TDC 4 P101612 20,21,22,23

Stud - 100TDC 4 P101613 20,21,22,23

Stud - 150TDC 4 P101614 20,21,22,23

21 Washer 4 **P101612 or P101613 or P101614 20,21,22,23

22 Spring Washer - 3/8" 4 **P101612 or P101613 or P101614 20,21,22,23

23 Nut - 3/8" 4 **P101612 or P101613 or P101614 20,21,22,23

Shaft - VW - 50TDC 1 6152 24

Shaft - VW - 100TDC 1 6151 24

Shaft - VW - 150TDC 1 6150 24

Shaft - VWLP - 50TDC 1 6203 24

Shaft - VWLP - 100TDC 1 6204 24

Shaft - VWLP - 150TDC 1 6205 24

25 Key - VW 2 P101615 1,3,4,7,10,15,25(x2)

25 Key - VWLP 1 P101615 1,3,4,7,10,15,25(x2)

26 Circlip 1 P101619 26,27,38,41

27 Key 1 P101619 26,27,38,41

28 Bearing 1 **P101664 or P101665 or P101666 11,28,29

Spacer Tube - 50TDC 1 **P101664 11,28,29

Spacer Tube - 100TDC 1 **P101665 11,28,29

Spacer Tube - 150TDC 1 **P101666 11,28,29

30 Locknut 1 P100088 30,31,32

31 O-Ring 1 P100088 30,31,32

32 Collar 1 P100088 30,31,32

33 Gearbox - 1000 - 44:1 1 P100900

Gearbox - 1500 - 56:1 1 P102730

Motor - 12v - 1000W - with 1000 VWC/VWLP 1 P11112 34

Motor - 24v - 1000W - with 1000 VWC/VWLP 1 P11114 34

Motor - 12v – 1200W - with 1500 VWC/VWLP 1 P11165 34

Motor - 24v - 1200W - with 1500 VWC/VWLP 1 P11166 34

Motor - Hydraulic 1 P14366 34

35 Bolt - Hex Hd M8x25 - With 12 or 24V Motor 2 P12487 35(x2),36(x2),37(x2),42(x1)

36 Washer - Spring - M8 -With 12 or 24V Motor 2 P12487 35(x2),36(x2),37(x2),42(x1)

Washer - Spring - M8 -With Hydraulic Motor 2 P12488 36(x2),37(x4),39(x2),40(x2)

37 Washer - Flat - M8 -With 12 or 24V Motor 2 P12487 35(x2),36(x2),37(x2),42(x1)

Washer - Flat - M8 -With Hydraulic Motor 4 P12488 36(x2),37(x4),39(x2),40(x2)

38 Clip 1 P101619 26,27,38,41

39 Bolt - Hex Hd M8x30 - With Hydraulic Motor 2 P12488 36(x2),37(x4),39(x2),40(x2)

40 Nut - M8 - With Hydraulic Motor 2 P12488 36(x2),37(x4),39(x2),40(x2)

41 Tension Pin 1 P101619 26,27,38,41

42 O-Ring 1 P12487 35(x2),36(x2),37(x2),42(x1)

**P101621 = 1000, P101622 = 1500

**P101627 = 50mm TDC, P101628 = 100mm TDC, P101629 = 150mm TDC

**P101612 = 50mm TDC, P101613 = 100mm TDC, P101614 = 150mm TDC

**P101664 = 50mm TDC, P101665 = 100mm TDC, P101666 = 150mm TDC

61000 1500 Windlass Vetus-Maxwell APAC Ltd

VWC and VWCLP Windlass Parts

Fig 2: VWC and VWCLP Windlass Parts

Vetus-Maxwell APAC Ltd 1000 1500 Windlass 7

VWC and VWCLP Windlass Parts List

81000 1500 Windlass Vetus-Maxwell APAC Ltd

Gearbox Parts (44:1 & 56:1)

Fig 3: Gearbox Parts (44:1 & 56:1)

Drainage Slot

Location of serial number

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Maxwell Winde Handbücher

Maxwell

Maxwell VWC 2500 Bedienungsanleitung

Beliebte Winde Handbücher anderer Marken

WARRIOR

WARRIOR Trojan 40PUS12 Kurzanleitung

SVERO

SVERO 16 Bedienungsanleitung

Warrior Winches

Warrior Winches C10000NH Bedienungsanleitung

Badland Winches

Badland Winches 68146 Bedienungsanleitung

Bush

Bush II Series Bedienungsanleitung

Badland

Badland APEX 5500 Bedienungsanleitung

Quadratec

Quadratec Q9000 Synthetic Handbuch

C-Max

C-Max VIGO Bedienungsanleitung

Comeup

Comeup DV-9 Bedienungsanleitung

Orvea

Orvea Italwinch 805 Bedienungsanleitung

Prowinch

Prowinch PWJTHF300 Bedienungsanleitung

Clas Ohlson

Clas Ohlson LD2000-A Bedienungsanleitung

Topex

Topex 97X080 Bedienungsanleitung

Eastbound

Eastbound MotoWinch 1707001 Bedienungsanleitung

Runva

Runva EWD8000 Kurzanleitung

Ingersoll-Rand

Ingersoll-Rand LIFTSTAR FG 1500/CN Series Installationsanleitung

Granit

Granit 11157675 Bedienungsanleitung

TREX

TREX TB75 Bedienungsanleitung