Maytag MDG75PNH Bedienungsanleitung

MDG75PNH and MDG75MNV

(1,000 CFM/Phase 7 with S.A.F.E.)

Installation Manual

122002JEV/mcronan Part No. 113394

RETAIN THESE INSTRUCTIONS IN A SAFE

PLACE FOR FUTURE REFERENCE

WARNING: For your safety the information in

this manual must be followed to minimize the

risk of fire or explosion or to prevent property

dama e, personal injury or death.

 Do not store or use asoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

 WHAT TO DO IF YOU SMELL GAS:

 Do not try to li ht any appliance.

 Do not touch any electrical switch; do not

use any phone in your buildin .

 Clear the room, buildin or area of all

occupants.

 Immediately call your as supplier from a

nei hbors phone. Follow the as suppliers

instructions.

 If you cannot reach your as supplier, call

the fire department.

 Installation and service must be performed by a

qualified installer, service a ency or the as

supplier.

AVERTISSEMENT: Assurez-vous de bien

suivre les instructions données dans cette notice

pour réduire au minimum le risque dincendie

ou dexplosion ou pour éviter tout domma e

matériel, toute blessure ou la mort.

 Ne pas entreposer ni utiliser dessence ni

dautres vapeurs ou liquides inflammables à

proximité de cet appareil ou de tout autre

appareil.

 QUE FAIRE SI VOUS SENTEZ UNE ODEUR

DE GAZ:

 Ne pas tenter dallumer dappareils.

 Ne touchez à aucun interrupteur. Ne pas

vous servir des téléphones se trouvant dans

le bâtiment.

 Évacuez la pièce, le bâtiment ou la zone.

 Appelez immédiatement votre fournisseur

de az depuis un voisin. Suivez les

instructions du fournisseur.

 Si vous ne pouvez rejoindre le fournisseur

de az, appelez le service des incendies.

 Linstallation et lentretien doivent être assurés par

un installateur ou un service dentretien qualifié

ou par le fournisseur de az.

Retain This Manual In A Safe Place For Future Reference

This product embodies advanced concepts in en ineerin , desi n, and safety. If this product is properly maintained, it will

provide many years of efficient, trouble free, and most importantly safe operation.

ONLY qualified technicians should service this equipment.

OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment or specified in the installation manual included with

the dryer.

The following FOR YOUR SAFETY caution must be posted near the dryer in a prominent location.

IMPORTANT NOTE TO PURCHASER

Information must be obtained from your local as supplier on the instructions

to be followed if the user smells as. These instructions must be posted in a

prominent location near the dryer.

We have tried to make this manual as complete as possible and hope you will find it useful. The manufacturer reserves the

ri ht to make chan es from time to time, without notice or obli ation, in prices, specifications, colors, and material, and to

chan e or discontinue models. The illustrations included in this manual may not depict your particular dryer exactly.

Important

For your convenience, log the following information:

DATE OF PURCHASE ________________________________ MODEL NO. __________________________________________

DEALERS NAME __________________________________________________________________________________________

Serial Number(s) ________________________________________________________________________________________

________________________________________________________________________________________

For replacement parts, contact the dealer from which the dryer was purchased or contact:

Maytag Co.

403 West Fourth Street North

Newton, Iowa 50208

(641) 787-7000

FOR YOUR SAFETY

Do not store or use asoline or

other flammable vapors and

liquids in the vicinity of this or

any other appliance.

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser dessence

ni dautres vapeurs ou liquides

inflammables à proximité de cet

appareil ou de tout autre appareil.

IMPORTANT

YOU MUST DISCONNECT AND LOCK OUT THE ELECTRIC SUPPLY AND THE GAS

SUPPLY BEFORE ANY COVERS OR GUARDS ARE REMOVED FROM THE

MACHINE TO ALLOW ACCESS FOR CLEANING, ADJUSTING, INSTALLATION, OR

TESTING OF ANY EQUIPMENT PER OSHA (Occupational Safety and Health

Administration) STANDARDS.

WARNING

CHILDREN SHOULD NOT BE ALLOWED TO PLAY ON OR NEAR THE DRYER(S).

CHILDREN SHOULD BE SUPERVISED IF NEAR DRYERS IN OPERATION.

CAUTION

DRYERS SHOULD NE ER BE LEFT UNATTENDED WHILE IN OPERATION.

FOR YOUR SAFETY

DO NOT DRY MOP HEADS IN THE DRYER.

DO NOT USE DRYER IN THE PRESENCE OF DRY CLEANING FUMES.

WARNING

UNDER NO CIRCUMSTANCES sh uld the dryer d r switches, lint drawer switch,

r heat safety circuit ever be disabled.

Caution: Label all wires prior to

disconnection when servicing controls. Wiring

errors can cause improper operation.

«Attention: Au moment de lentretien des

commandes, étiquetez tous les fils avant de

les débrancher. Des erreurs de câblage

peuvent entraîner un fonctionnement

inadéquat et dangereux.»

WARNING

The dryer must never be perated with any f the back guards, uter t ps, r service

panels rem ved. PERSONAL INJURY OR FIRE COULD RESULT.

IMPORTANT

PLEASE OBSERVE ALL SAFETY PRECAUTIONS displayed n the equipment and/ r

specified in the installati n manual included with the dryer.

WARNING

DRYER MUST NEVER BE OPERATED WITHOUT THE LINT FILTER/SCREEN IN

PLACE, EVEN IF AN EXTERNAL LINT COLLECTION SYSTEM IS USED.

Dryer must not be installed or stored in an area where it will be exposed to water or weather.

The wiring diagram for the dryer is located in the front electrical control box area.

IMPORTANT

Dryer must be installed in a l cati n/envir nment, which the ambient temperature

remains between 40° F (4.44° C) and 130° F (54.44° C).

Table of Contents

SECTION I

SAFETY PRECAUTIONS ........................................................................................ 3

SECTION II

SPECIFICATIONS ..................................................................................................... 5

A. Specifications ............................................................................................................................. 5

B. Component Identification ............................................................................................................ 7

SECTION III

INSTALLATION PROCEDURES ........................................................................... 9

A. Location Requirements ............................................................................................................... 9

B. Unpackin /Settin Up ............................................................................................................... 10

C. Dryer Enclosure Requirements .................................................................................................. 11

D. Fresh Air Supply Requirements ................................................................................................. 12

E. Exhaust Requirements ............................................................................................................... 13

F. Electrical Information ................................................................................................................ 18

G. Gas Information ........................................................................................................................ 22

H. Preparation For Operation/Start-Up ......................................................................................... 26

I. Preoperational Tests ................................................................................................................. 27

J. Preoperational Instructions ........................................................................................................ 29

K. Shutdown Instructions ............................................................................................................... 30

SECTION IV

SERVICE/PARTS INFORMATION ...................................................................... 31

A. Service ..................................................................................................................................... 31

B. Parts ........................................................................................................................................ 31

SECTION V

ROUTINE MAINTENANCE .................................................................................. 32

A. Cleanin ................................................................................................................................... 32

B. Adjustments ............................................................................................................................. 33

C. Lubrication ............................................................................................................................... 33

D. Lint Drawer Removal ................................................................................................................ 34

SECTION VI

DATA LABEL INFORMATION ............................................................................. 35

SECTION VII

PROCEDURE FOR FUNCTIONAL CHECK OF REPLACEMENT

COMPONENTS........................................................................................................ 36

SECTION VIII

MANUAL RESET BURNER HI-LIMIT INSTRUCTIONS ............................... 38

A. Phase 7......................................................................................................................................38

B. Dual Timer ................................................................................................................................38

SECTION I

SENSOR ACTIVATED FIRE E TINGUISHING (S.A.F.E.) SYSTEM............39

SECTION I

SAFETY PRECAUTIONS

WARNING: For your safety, the information in this manual must be followed to minimize the risk of

fire or explosion or to prevent property damage, personal injury, or loss of life.

WARNING: The dryer must never be operated with any of the back guards, outer tops, or

service panels re oved. PERSONAL INJURY OR FIRE COULD RESULT.

1. DO NOT store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other

appliance.

2. Purchaser and user should consult the local gas supplier for proper instructions to be followed in the event

the user smells gas. The instructions should be posted in a prominent location.

3. WH T TO DO IF YOU SMELL G S:

a. DO NOT try to light any appliance.

b. DO NOT touch any electrical switch.

c. DO NOT use any phone in your building.

d. Clear the room, building, or area of ALL occupants.

e. Immediately call your gas supplier from a neighbors phone. Follow the gas suppliers instructions.

f. If you cannot reach your gas supplier, call the fire department.

4. Installation and service must be performed by a qualified installer, service agency, or gas supplier.

5. Dryers must be exhausted to the outdoors.

6. lthough Maytag produces a very versatile dryer, there are some articles that, due to fabric composition or

cleaning method, should not be dried in it.

WARNING: Dry only water washed fabrics. DO NOT dry articles spotted or washed in dry

cleaning solvents, a combustible detergent, or all purpose cleaner.

EXPLOSION COULD RESULT.

WARNING: DO NOT dry rags or articles coated or contaminated with gasoline, kerosene, oil, paint,

or wax.

EXPLOSION COULD RESULT.

WARNING: DO NOT dry mop heads. Contamination by wax or flammable solvents will create a

fire hazard.

WARNING: DO NOT use heat for drying articles that contain plastic, foam, sponge rubber, or

similarly textured rubber materials. Drying in a heated basket (tumbler) may damage

plastics or rubber and may be a fire hazard.

7. program should be established for the inspection and cleaning of lint in the burner area, exhaust ductwork,

and area around the back of the dryer. The frequency of inspection and cleaning can best be determined

from experience at each location.

WARNING: The collection of lint in the burner area and exhaust ductwork can create a potential fire

hazard.

8. For personal safety, the dryer must be electrically grounded in accordance with local codes and/or the

National Electrical Code NSI/NFP NO. 70-L TEST EDITION or in Canada, the Canadian Electrical

Codes Parts 1 & 2 CS C22.1-1990 or L TEST EDITION.

NOTE: Failure to electrically ground the dryer properly will VOID THE WARRANTY.

9. UNDER NO CIRCUMSTANCES should the dryer door switches, lint drawer switch, or heat safety

circuit ever be disabled.

WARNING: PERSONAL INJURY OR FIRE COULD RESULT SHOULD THE DRYER

DOOR SWITCHES, LINT DRAWER SWITCH, OR HEAT SAFETY CIRCUIT

EVER BE DISABLED.

10. This dryer is not to be used in the presence of dry cleaning solvents or fumes.

11. Remove articles from the dryer as soon as the drying cycle has been completed.

WARNING: Articles left in the dryer after the drying and cooling cycles have been completed can

create a fire hazard.

12. READ AND FOLLOW ALL CAUTION AND DIRECTION LA ELS ATTACHED TO THE

DRYER.

13. For safety, proper operation, and optimum performance, the dryer must not be operated with a load less

than sixty-six percent (66%) 50 lbs (22.7 kg) of its rated capacity.

WARNING: YOU MUST DISCONNECT AND LOCK OUT THE ELECTRIC SUPPLY

AND THE GAS SUPPLY BEFORE ANY COVERS OR GUARDS ARE

REMOVED FROM THE MACHINE TO ALLOW ACCESS FOR CLEANING,

ADJUSTING, INSTALLATION, OR TESTING OF ANY EQUIPMENT PER

OSHA (Occupational Safety and Health Administration) STANDARDS.

IMPORTANT: Dryer must be installed in a location/environ ent, which the a bient

te perature re ains between 40º F (4.44º C) and 130º F (54.44º C).

SECTION II

SPECIFICATIONS

A. SPECIFICATIONS

Shaded areas are stated in metric equivalents 2/5/04

*ALL reversing dryers are supplied with two (2) 3-phase (3ø) motors standard: a /2 hp (0.37 kW) blower motor and a /2 hp (0.37 kW) drive motor.

** Size of piping to dryer varies with installation conditions. Contact factory for assistance.

NOTE: The manufacturer reserves the right to make changes in specifications at any time without

notice or obligation.

Gas

)THGIEWYRD(YTICAPACMUMIXAMsbl57 gk43

RETEMAID)RELBMUT(TEKSAB73 mc49

HTPED)RELBMUT(TEKSAB63 mc5.19

ROTOM)RELBMUT(TEKSAB 1

*k547.0

)RETEMAID(GNINEPOROOD2/1-12 mc16.45

EMULOV)RELBMUT(TEKSABtfuc4.22 muc436.0

)RETEMAID(NOITCENNOCTSUAHXE8mc3.02

WOLFRIAmfc0001 mmc3.82

RENIATNOC04/02REPSREYRD02/01

KCURT35/84REPSREYRD62/42

NOITCENNOCRETAW.E.F.A.SHN5.11-4/3

ELBALIAVAEGATLOVzH06/05w4,3ø3-ø1v064-021

)DETARCNU(THGIEW.XORPPAsbl127 gk723

)DETARC(THGIEW.XORPPAsbl177 gk7.943

TUPNITAEHrh/utB000,571 rh/lack001,44

NOITCENNOCEPIPTELNI**.T.P.N.F4/3

NOTE: Manufacturer reserves the right to make changes in specifications at any time without notice or

obligation.

Specifications  Gas

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Maytag Trockner Handbücher

Maytag

Maytag MDE28PDCZW Bedienungsanleitung

Maytag

Maytag NEPTUNE MD68 Bedienungsanleitung

Maytag

Maytag MEDB855DC Bedienungsanleitung

Maytag

Maytag MEDB766FW0 Bedienungsanleitung

Maytag

Maytag YMEDB765FC Bedienungsanleitung

Maytag

Maytag MGDE500VW2 Bedienungsanleitung

Maytag

Maytag MDE17MN Bedienungsanleitung

Maytag

Maytag MLG27PN Bedienungsanleitung

Maytag

Maytag MGDZ400TQ0 Bedienungsanleitung

Maytag

Maytag Performance Series W10057353A Bedienungsanleitung

Maytag

Maytag W10240878A Bedienungsanleitung

Maytag

Maytag MDE6700A Series Handbuch

Maytag

Maytag YMEDB755DW1 Bedienungsanleitung

Maytag

Maytag MDG52 Bedienungsanleitung

Maytag

Maytag MDE17MN Bedienungsanleitung

Maytag

Maytag MLG35 Bedienungsanleitung

Maytag

Maytag Epic W10150638A Bedienungsanleitung

Maytag

Maytag MDG31 Handbuch

Maytag

Maytag MDG30PCCWW Bedienungsanleitung

Maytag

Maytag MEDC400VW - Centennial Electric Dryer Bedienungsanleitung

Maytag

Maytag MD6200 Bedienungsanleitung

Maytag

Maytag MD-24 Bedienungsanleitung

Maytag

Maytag MGDB980BW0 Bedienungsanleitung

Maytag

Maytag NEPTUNE MD68 Bedienungsanleitung

Beliebte Trockner Handbücher anderer Marken

Bosch

Bosch WTA79200GB Bedienungsanleitung

Amana

Amana W10233410A Bedienungsanleitung

Miele

Miele TWH 780 WP Bedienungsanleitung

Asko

Asko T760 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Bedienungsanleitung

Bosch

Bosch Logixx 10 WTB76556GB Technisches Datenblatt

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Bedienungsanleitung

Electrolux

Electrolux EW2H328R2 Bedienungsanleitung

Beko

Beko DS8433RX1M Bedienungsanleitung

Dawlance

Dawlance Spinner DS 6000 C Bedienungsanleitung

Electrolux

Electrolux TP5080TW Bedienungsanleitung

AEG

AEG TR838P4OB Bedienungsanleitung

Indesit

Indesit IDV 75 Bedienungsanleitung

Infiniton

Infiniton SD-DG85C Bedienungsanleitung

BOMANN

BOMANN WT 5019 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Bedienungsanleitung

Asko

Asko T793C Bedienungsanleitung

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Bedienungsanleitung