MrHeater Portable Buddy MH9BX Montageanleitung

COMPACT PROPANE HEATER

Part No. MH9BX

Portable Buddy

User Manual and

Product Specications

by PRIMUS

Image for representation purposes only and may differ from actual product.

DO NOT: Operate this appliance before reading the instruction booklet

DO NOT: Place articles on or against this appliance

DO NOT: Store chemicals, ammable materials or spray aerosols near this appliance

DO NOT: Operate with panels, covers or guards removed from this appliance.

DO NOT: Operate in an enclosed area without ventilation

DO NOT: Operate in a boat, caravan or tent

IMPORTANT

Read these instructions for use carefully. Familiarise yourself

with the appliance before connecting it to its gas container.

Keep these instructions for future reference.

Important

1. Please read all instructions carefully.

2. Dispose of all polythene packaging

carefully and keep out of the hands of

young children.

Safety warning

Please read all safety warning and assembly

instructions before use. Retain all information

for future reference. Failure to follow the

instructions may cause personal injury and/or

damage.

1. Never use in unventilated or enclosed

areas. This heater consumes air and could

endanger life if used in unventilated or

enclosed areas.

2. Only non rellable 468g disposable

cylinders are to be used with this appliance.

CAUTION - IT MAYBE HAZARDOUS TO

ATTEMPT TO FIT OTHER TYPES OF GAS

CONTAINERS.

3. Never leave heater unattended when in use.

CAUTION - accessible parts may be very hot.

Keep young children away.

4. Always use oven mitts/oven gloves when

handling the heater after use.

Installation, operation and

maintenance instructions

Safety information: if you smell gas

• If there is a leak on your appliance (smell of

gas), immediately attempt to turn off.

• Remove the appliance to a well ventilated

location away from any ignition source.

• Only check for leaks outdoors using soapy

water.

• Do not try to detect leaks using a ame.

• When leak has stopped, ventilate and

disperse gas from the area before

continuing.

IMPORTANT: read this instruction for use

carefully. Familiarise yourself with the appliance

before connecting it to the gas bottle. This

appliance is for use with disposable propane

cartridges only.

• Do not remove regulator, connect to

high-pressure canister or use adaptors.

• When changing gas cartridge ensure that

it is undertaken in a well ventilated area,

preferably outside and away from sources

of ignition such as naked ames, pilot

ames, electrical and heating equipment

and people.

• To check if cartridge has sufcient gas

pick up cartridge and shake from side to

side. If there is movement or the sounds of

liquid moving inside the cartridge then it will

contain gas.

FOR OUTDOORS USE ONLY - ONLY USE IN

WELL VENTILATED AREAS.

This appliance shall only be used in an above

ground open air situation with natural ventilation,

without stagnant areas, where gas leakage and

products of combustion are rapidly dispersed

by wind and natural convection.

CARBON MONOXIDE HAZARD — THIS

APPLIANCE CAN PRODUCE CARBON

MONOXIDE WHICH HAS NO ODOUR.

USING IT IN AN ENCLOSED SPACE (FOR

EXAMPLE, CARAVAN, TENT, CAR, MOBILE

HOME) MAY CAUSE DEATH.

THIS APPLIANCE IS ONLY TO BE USED

ON SOLID AND STABLE HORIZONTAL

SURFACES.

Safety Instructions

Caution

NEVER assemble or operate the unit on

unstable or uneven ground. Always operate

in open and well-ventilated areas.

NEVER operate inside a tent, caravan, camper

trailer vehicle or boat.

NEVER leave the unit unattended

whilst operating.

NEVER open the control panel or

dis -assemble unit.

This appliance is not intended for use by young

children or inrm person unless they have been

adequately supervised by a responsible person

to ensure that they can use the appliance

safely. Young children should be supervised

to ensure that they do not play with the

appliance. This appliance is to be installed as

per local regulation and in accordance with

AS5601/AG601.

Safety after installation

The purpose of this section is to direct your

attention to the possibility of accidents that can

be avoided.

• This appliance is not to be used in enclosed

areas and must be operated away from any

type of ammable material or liquid.

• This appliance must be operated a

minimum of 100mm from all solid or non-

combustible surfaces.

• During the operation of this appliance all air

openings and vents must be kept free from

obstructions to ensure correct operation.

• Remember the appliance produces heat,

therefore some parts will get hot. Allow to

cool before touching.

• Do not leave children unattended near the

appliance when in use.

• Do not store or use petrol or other

ammable liquids in the vicinity of this or any

other appliance.

• Do not modify this appliance.

• Do not use adaptors.

• Do not allow clothing to pass over or lay on

the appliance.

• Protect the appliance from wind and drafts

when in use.

• Do not operate appliance below ground

level or in areas where unburned gas could

build up.

• Do not move appliance while operating

• Clean after use.

• Do not use this appliance if it is leaking,

damaged or does not work properly.

• Do not use this appliance if it has damaged

or worn seals.

• This appliance must only be serviced by an

authorised person.

• Store the gas cartridge outdoors in a well

ventilated area or in a storage area compliant

with AS1596. 1. Control knob

2. Burner tile

3. Folding carry handle

4. Propane cartridge cavity

Product Identication

Safety Instructions

This appliance shall only be used in an above ground open air situation with natural ventilation,

without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by

wind and natural convection. Any enclosure in which the appliance is used shall comply with one

of the following:

(A) An enclosure with walls on all sides, but with

no overhead cover.

(B) Within a partial enclosure that includes an

overhead cover and no more than two walls.

overhead cover and more than two walls,

the following shall apply:

(1) At least 25% of the total wall area is

completely open.

(2) 30% or more in total of the remaining wall

side, back and front wall areas is open and

unrestricted.

(3) In the case of balconies, 20% or more of

the total wall area shall remain open and

unrestricted”

Lighting and Operating Instructions

Step 1

WARNING: Always inspect propane cylinder

and heater propane connections for damage,

dirt, and debris before attaching propane

cylinder. Do not use if head of cylinder is

damaged, punctured or deteriorated.

• Use only LP Gas cylinders marked

in accordance with the U.S. Dept. of

Transportation (DOT).

• Use only 468g disposable cylinders that

mate with No. 600 valve connection.

• Heater and attached cylinder must be in an

upright position during operation.

• Make sure four-position Control Knob is in

“OFF” position.

Step 2

• Swivel regulator outward for easy tank

installation. Screw 468g disposable LP Gas

supply cylinder clockwise (from bottom) into

portable heater until hand-tight.

• Check cylinder connection for leaks with

soapy water at the threaded connection

under the domed plastic cover where the

cylinder screws into the regulator. SEE

WARNING! ON THE UNDERSIDE OF THE

DOMED PLASTIC COVER.

Step 3

• Slightly depress and turn Control Knob

counterclockwise to “PILOT” position and

depress to light.

• If heater does not light, hold down for

approximately 30 seconds; release and

depress again. Repeat until pilot lights.

Step 4

• After pilot lights, hold down for 30-60

seconds and then release knob. Knob

should return to fully extended position.

• To operate heater, slightly depress Control

Knob and gently turn to lock in the “HI”.

position to light burner tile. Leave on “HI”

position until burner tile turns bright orange.

• After burner tile has turned bright orange,

adjust heat output by turning Control Knob

to desired position (“LO” or “HI” setting).

Warning:

DO NOT OPERATE HEATER UNLESS CONTROL KNOB IS LOCKED IN A POSITION

MARKED “HI”, “LO” or “PILOT”.

NEVER SET CONTROL KNOB BETWEEN LOCKED POSITIONS. POOR COMBUSTION AND

HIGHER LEVELS OF CARBON MONOXIDE MAY RESULT.

• To shut off heater, slightly push down and

turn Control Knob clockwise to

“OFF” position.

• CAUTION: After turning heater off, wire

guard will remain hot. Allow to thoroughly

cool before storing.

• Do not operate, store or remove cylinder

near ammable items or ignition sources.

• LP-GAS CYLINDERS MUST BE

DISCONNECTED FROM HEATER WHEN

NOT IN USE!

Shut Down Instructions



Appliance is only to be serviced or repaired

by an authorised service centre. Return

appliance to place of purchase or contact

Primus Customer Service (contact details

on back cover).

Always keep the heater area clear and free

from combustible materials, gasoline and other

ammable vapors and liquids.

Keep the vent areas (slots in the bottom and

the top at the front and rear of heater) clear at

all times.

Visually inspect the pilot ame and burner

periodically during use. The pilot ame should

be blue in color (not yellow) and will extend

beyond the thermocouple.

The ame will surround the thermocouple just

below the tip.

A slight yellow ame may occur where the pilot

ame and main burner ame meet. The burner

should be bright orange (with a slight blue color

around the border, a red-orange haze that is

visible on the ceramic tile is acceptable) and

without a noticeable ame. A blue ame that

rolls out at the top of the ceramic tile indicates

an accumulation of dust, lint or spider webs

inside the casing assembly and main burner

assembly. If the pilot is yellow or the burner has

a noticeable ame, cleaning may be required.

Use the following procedure to inspect the

casing assembly and main burner assembly.

Maintenance

Replacement Parts List

1. 32017 Knob, Valve, Safety, Red

32019 Knob, Valve, Safety, Green

2. 32054 Valve, Assy, Control

3. 32056 Tube, Burner, Main

4. 32053 Tube, Inlet, Assy

5. 32051 Guard, Wire

32061 Guard, Wire, Heavy

6. 33092 Panel, Front, Metal, Red

33094 Panel, Front, Metal, Yellow

33093 Panel, Front, Metal, Green

7. 75191 Panel, Back, Metal,

w/32004, Red

75194 Panel, Back, Metal,

w/32004, Yellow

75196 Panel, Back, Metal,

w/32004, Green

8. 32027 Brkt, Valve

9. 32028 Heat, Shield

10. 32015 Handle, Back, Plastic, Gray

32074 Handle, Back, Plastic, Black

11. 32014 Handle, Front, Plastic, Gray

32072 Handle, Front, Plastic, Black

12. 75198 Assy, Regulator, w/Support

13. 32080 Housing, Left, Plastic, Gray

32085 Housing, Left, Plastic, Black

14. 32021 Reector, Metal

15. 33088 Tile, Replacement Kit, MH9BX

16. 32032 Burner, Assy

17. 33090 Housing, Right, Plastic, Gray

33091 Housing, Right, Plastic, Black

18. 32068 Orice, Assy with O-Ring

19. 32052 Orice, Holder

20. 32023 Floor, Panel, Metal

21. 73403 Switch, Tipover

22. 32046 Brkt,ODS

(Oxygen Depletion Sensor)

23. 73404 ODS, Pilot, Assy

24. 32057 Tube, Pilot, Assy

25. 32067 Magnet, Tank

No Part # Description No Part # Description No Part # Description

Problem Remedy

If Spark electrode does not produce

spark.

Check spark electrode; if defective, replace ODS

(Oxygen Depletion Sensor).

Check igniter wire is correctly attached to spark

electrode.

Check igniter wire; if damaged, replace.

Check piezo igniter; if defective, replace control

valve.

If Spark electrode produces spark but

pilot does not light.

No gas to heater – install disposable cylinder or

connect hose and lter where required and turn on

valve at remote cylinder.

Check if “PILOT” position is properly aligned – turn

gas control knob to “PILOT” position and depress.

Check is pilot is blocked from spider web or dirt –

clean pilot, see MAINTENANCE.

If Pilot ame does not stay lit when knob

is released.

Check if control knob in “PILOT” position not

completely depressed or held in long enough to

purge air from lines.

If pilot ame is not surrounding thermocouple – clean

pilot, see MAINTENANCE.

Check if pilot assembly is defective – replace.

Check if tip switch wires are disconnected – connect.

If Main burner does not ignite. Check if main burner orice is blocked – clean

burner, see MAINTENANCE.

If Heater keeps shutting “OFF” during

normal operation.

Check if pilot is blocked – clean pilot, see

MAINTENANCE.

Tip over switch may have been activated from

bumping heater. Re-light.

Check if regulator is defective - Replace regulator.

Check for internal contamination - Replace control

valve and regulator.

Call Technical Services for additional information.

Troubleshooting Instructions

This Appliance

- Must only be serviced by an authorised person

- Suitable for camping use only

- Shall NOT be exposed to moisture or rain

- Shall only be used with a propane gas cartridge certied to:

DOT2P, UN2037, EN417

- May be hazardous to attempt to t other types of gas containers

- Only be used in a well ventilated area

- Can produce carbon monoxide which has no odor.

Using it in an enclosed space (e.g. caravan, tent, car, mobile home) may cause death.

AS 2658:2008

Cert. GSCS20069

SAI Global

AS 2658:2008

Cert. GSCS20054

SAI Global

AS 2658:2008

Cert. GSCS20055

SAI Global

AS 2658 1988

Cert. GSCS20063

SAI Global

AS 2658 2008

Cert. GSCS20063

SAI Global

AS 2658 2008

Cert. GSCS20108

SAI Global

AS 2658 2008

Cert. GSCS20148

SAI Global

AS 2658 2008

Cert. GSCS20148

SAI Global

AS 4551-2008

Cert. GSCS20131

SAI Global

AS 2658:2008

Cert. GSCS20193

SAI Global

Specications

Part No: MH9BX

Dimensions: 330 x 204 x 343mm

Net Weight: 3.69kg (excluding cylinder)

Injector Size: 0.93mm

Gas Consumption: 9.5 Mj/hr

189 g/hr

Andere Handbücher für Portable Buddy MH9BX

Inhaltsverzeichnis

Andere MrHeater Gasheizung Handbücher

MrHeater

MrHeater Plaque MHVFR20TB LP Montageanleitung

MrHeater

MrHeater Little Buddy MH4B Bedienungsanleitung

MrHeater

MrHeater MHBF10LP Kurzanleitung

MrHeater

MrHeater MH40 NG Montageanleitung

MrHeater

MrHeater MH125LP Montageanleitung

MrHeater

MrHeater SUNRITE SRC15T Bedienungsanleitung

MrHeater

MrHeater MH500LPT Montageanleitung

MrHeater

MrHeater F274800 Montageanleitung

MrHeater

MrHeater MH15C Montageanleitung

MrHeater

MrHeater MHT 45 Montageanleitung

MrHeater

MrHeater MHBF10NG Kurzanleitung

MrHeater

MrHeater MHVFR10NG Montageanleitung

MrHeater

MrHeater MH12B Montageanleitung

MrHeater

MrHeater HeatStar MHVFB10LP Kurzanleitung

MrHeater

MrHeater MRHNF299810 Montageanleitung

MrHeater

MrHeater MHVFRD20LPT Montageanleitung

MrHeater

MrHeater Blue Flame MHVFB10LP Kurzanleitung

MrHeater

MrHeater MHBF10LP Kurzanleitung

MrHeater

MrHeater MH9BX Montageanleitung

MrHeater

MrHeater HS25NG/LP Montageanleitung

MrHeater

MrHeater MHVFG30TB LP Montageanleitung

MrHeater

MrHeater MHVFGH30LPT Montageanleitung

MrHeater

MrHeater MH40 LP Bedienungsanleitung

MrHeater

MrHeater MHVFIH10LPT Bedienungsanleitung

Beliebte Gasheizung Handbücher anderer Marken

Superior

Superior BGE18NV Bedienungsanleitung

Dru

Dru Room-sealed atmospheric gas-fired heating... Bedienungsanleitung

klover

klover TKR 35 Bedienungsanleitung

Rothenberger Industrial

Rothenberger Industrial 035984 Bedienungsanleitung

New Buck Corporation

New Buck Corporation 34 Bedienungsanleitung

Hargrove

Hargrove Timberland Glow Kurzanleitung

Kinder

Kinder Cameo BF Bedienungsanleitung

Qlima

Qlima GH 438 B-2 Handbuch

Desa

Desa 125-R Bedienungsanleitung

Gasmate

Gasmate AH100 Series Bedienungsanleitung

Medallion

Medallion MBP20TLB Kurzanleitung

Clarke

Clarke DEVIL 910SS Bedienungsanleitung

Brant Radiant Heaters

Brant Radiant Heaters QTD Series Montageanleitung

L.B. White

L.B. White Therma Grow HW220 Handbuch

Sealey

Sealey LP35.V5 Bedienungsanleitung

Italkero

Italkero Falo Evo Bedienungsanleitung

Desa

Desa 30LP Bedienungsanleitung

Williams

Williams 2509822A Bedienungsanleitung