Nibe F1155 Series Benutzerhandbuch

Installer manual

LEK

NIBE™ F1155

Ground source heat pump

IHB GB 1428-4

231565

4XLFN JXLGH

1DYLJDWLRQ

2N EXWWRQ FRQILUPVHOHFW

%DFN EXWWRQ EDFNXQGRH[LW

&RQWURO NQRE PRYHLQFUHDVHUHGXFH

A detailed explanation of the button functions can be found on page 31.

How to scroll through menus and make different settings is described on page 33.

6HW WKH LQGRRU FOLPDWH

;

The mode for setting the indoor temperature is reached, when in the start mode in the main menu, by pressing

the OK button twice. Read more about the settings on page 35.

,QFUHDVH KRW ZDWHU YROXPH

;

;

To temporarily increase the amount of hot water (if a hot water heater is installed to your F1155), first turn the

control knob to mark menu 2 (water droplet) and then press the OK button twice. Read more about the settings

on page 43.

In event of disturbances in comfort

If a disturbance in comfort of any type occurs there are some measures that can be taken before you need to

contact your installer. See page 65 for instructions.

Table of Contents

21 Important information

2Safety information

52 Delivery and handling

5Transport

5Assembly

6Supplied components

6Removing the covers

73 The heat pump design

7General

8Distribution boxes

9Cooling section

114 Pipe connections

11General

12Dimensions and pipe connections

12Brine side

13Heating medium side

13Hot water heater

14Docking alternatives

165 Electrical connections

16General

18Connections

20Settings

23Optional connections

26Connecting accessories

276 Commissioning and adjusting

27Preparations

27Filling and venting

28Start guide

29Post adjustment and venting

317 Control - Introduction

31Display unit

32Menu system

358 Control - Menus

35Menu 1 - INDOOR CLIMATE

43Menu 2 - HOT WATER

45Menu 3 - INFO

46Menu 4 - HEAT PUMP

51Menu 5 - SERVICE

599 Service

59Service actions

6510 Disturbances in comfort

65Info-menu

65Manage alarm

65Troubleshooting

6711 Accessories

6912 Technical data

69Dimensions and setting-out coordinates

70Technical specifications

76Index

1Table of Contents |NIBE™ F1155

Safety information

This manual describes installation and service proced-

ures for implementation by specialists.

This appliance can be used by children

aged from 8 years and above and per-

sons with reduced physical, sensory or

mental capabilities or lack of experience

and knowledge if they have been given

supervision or instruction concerning

use of the appliance in a safe way and

understand the hazards involved. Chil-

dren shall not play with the appliance.

Cleaning and user maintenance shall

not be made by children without super-

vision.

Rights to make any design or technical

modifications are reserved.

©NIBE 2014.

Symbols

NOTE

This symbol indicates danger to machine or

person.

Caution

This symbol indicates important information

about what you should observe when main-

taining your installation.

TIP

This symbol indicates tips on how to facilitate

using the product.

Marking

The CE marking means that NIBE ensures that the

product meets all regulations that are placed on it

based on relevant EU directives. The CE mark is obligat-

ory for most products sold in the EU, regardless where

they are made.

Serial number

The serial number can be found at the bottom right of

the front cover and in the info menu (menu 3.1).

6HULDO QXPEHU

Caution

Always give the product's serial number (14

digits) when reporting a fault.

Country specific information

Installer manual

This installer manual must be left with the customer.

NIBE™ F1155Chapter 1 | Important information2

1 Important information

Inspection of the installation

Current regulations require the heating installation to be inspected before it is commissioned. The inspection must

be carried out by a suitably qualified person. Fill in the page for information about installation data in the User

manual.

DateSignatureNotesDescription

✔

Brine (page 12)

System flushed

System vented

Antifreeze

Level/Expansion vessel

Particle filter

Safety valve

Shut off valves

Circulation pump setting

Heating medium (page 13)

System flushed

System vented

Expansion vessel

Particle filter

Safety valve

Shut off valves

Circulation pump setting

Electricity (page 16)

Fuses heat pump

Fuses property

Outside sensor

Room sensor

Current sensor

Safety breaker

Earth circuit-breaker

Setting of emergency mode thermostat

Miscellaneous

Guarantee submitted

3Chapter 1 | Important informationNIBE™ F1155

Contact information

KNV Energietechnik GmbH, Gahberggasse 11, 4861 SchörflingAT

Tel: +43 (0)7662 8963-0 Fax: +43 (0)7662 8963-44 E-mail: mail@knv.at www.knv.at

NIBE Wärmetechnik AG, Winterthurerstrasse 710, CH-8247 FlurlingenCH

Tel: (52) 647 00 30 Fax: (52) 647 00 31 E-mail: inf[email protected] www.nibe.ch

Druzstevni zavody Drazice s.r.o, Drazice 69, CZ - 294 71 Benatky nad JizerouCZ

Tel: +420 326 373 801 Fax: +420 326 373 803 E-mail: [email protected] www.nibe.cz

NIBE Systemtechnik GmbH, Am Reiherpfahl 3, 29223 CelleDE

Tel: 05141/7546-0 Fax: 05141/7546-99 E-mail: inf[email protected] www.nibe.de

Vølund Varmeteknik A/S, Member of the Nibe Group, Brogårdsvej 7, 6920 VidebækDK

Tel: 97 17 20 33 Fax: 97 17 29 33 E-mail: inf[email protected] www.volundvt.dk

NIBE Energy Systems OY, Juurakkotie 3, 01510 VantaaFI

Puh: 09-274 697 0 Fax: 09-274 697 40 E-mail: inf[email protected] www.nibe.fi

NIBE Energy Systems France Sarl, Zone industrielle RD 28, 01600 ReyrieuxFR

Tel : 03 88 06 24 10 Fax : 03 88 06 24 11 E-mail: inf[email protected] www.nibe.fr

NIBE Energy Systems Ltd, 3C Broom Business Park, Bridge Way, Chesterfield S41 9QGGB

Tel: 0845 095 1200 Fax: 0845 095 1201 E-mail: inf[email protected] www.nibe.co.uk

NIBE Energietechniek B.V., Postbus 634, NL 4900 AP OosterhoutNL

Tel: 0168 477722 Fax: 0168 476998 E-mail: inf[email protected] www.nibenl.nl

ABK AS, Brobekkveien 80, 0582 Oslo, Postadresse: Postboks 64 Vollebekk, 0516 OsloNO

Tel. sentralbord: +47 23 17 05 20 E-mail: [email protected] www.nibeenergysystems.no

NIBE-BIAWAR Sp. z o. o. Aleja Jana Pawła II 57, 15-703 BIAŁYSTOKPL

Tel: 085 662 84 90 Fax: 085 662 84 14 E-mail: sekretariat@biawar.com.pl www.biawar.com.pl

Tel./fax +7 831 419 57 06 E-mail: [email protected] www.nibe-evan.ru

NIBE AB Sweden, Box 14, Hannabadsvägen 5, SE-285 21 MarkarydSE

Tel: +46-(0)433-73 000 Fax: +46-(0)433-73 190 E-mail: inf[email protected] www.nibe.se

For countries not mention in this list, please contact Nibe Sweden or check www.nibe.eu for more information.

NIBE™ F1155Chapter 1 | Important information4

Transport

F1155 should be transported and stored vertically in a

dry place. When being moved into a building, F1155

may be leant back 45 °.

NOTE

The product can be tail heavy!

If the cooling module is pulled out and transported

upright, F1155 can be transported on its back.

Remove the outer panels in order to protect them when

moving in confined spaces inside buildings.

Pulling out the cooling module

To simplify transport and service, the heat pump can

be separated by pulling the cooling module out from

the cabinet.

See page 61 for instructions about the separation.

Assembly

႑Position F1155 on a firm base that can take the

weight, preferably on a concrete floor or foundation.

Use the product's adjustable feet to obtain a horizont-

al and stable set-up.

30 - 50 mm

႑The area where F1155 is located must be equipped

with floor drainage.

႑Install with its back to an outside wall, ideally in a

room where noise does not matter, in order to elim-

inate noise problems. If this is not possible, avoid

placing it against a wall behind a bedroom or other

room where noise may be a problem.

႑Wherever the unit is located, walls to sound sensitive

rooms should be fitted with sound insulation.

႑Route pipes so they are not fixed to an internal wall

that backs on to a bedroom or living room.

Installation area

Leave a space of 800 mm in front of the product. Ap-

prox 50 mm free space is required in order to open the

side hatches. The hatches do not need to be opened

during service, all service on F1155 can be carried out

from the front. Leave space between the heat pump

and wall behind (and any routing of supply cables and

pipes) to reduce the risk reproduction of any vibration.

(50) (50)





* A normal installation needs 300 - 400 mm (any side) for connec-

tion equipment, i.e. level vessel, valves and electrical equipment.

5Chapter 2 | Delivery and handlingNIBE™ F1155

2 Delivery and handling

Supplied components

LEK

Room sensorCurrent sensorOutside sensor

1x3x1x

(only 3x400V)

LEK

O-ringsSafety valve

(0.3 MPa) (3 bar)

Level vessel

1x 8x

Conex connectorsParticle filter

5x2x

LEK

Aluminium tape

LEK

Insulation tapeTubes for sensorsTemperature

sensor 1x3x

Location

The kit of supplied items is placed in packaging on top

of the heat pump.

Removing the covers

Front cover

LEK

1. Remove the screws from the lower edge of the

front cover.

2. Lift the cover out at the bottom edge and up.

Side covers

LEK

The side covers can be removed to facilitate the install-

ation.

1. Remove the screws from the upper and lower

edges.

2. Twist the cover slightly outward.

3. Move the hatch outwards and backwards.

4. Assembly takes place in the reverse order.

NIBE™ F1155Chapter 2 | Delivery and handling6

General

F1155

UB1

EB1

QM34

QM31

UB2

QM32

QM33

XL1

XL6 XL7

XL2XL9

QN10

PF1

PF3

PF2

BT2

UB3

AA4

AA4-XJ3

SF1

W130

View from behind

%)

Pipe connections

Connection, heating medium flowXL 1

Connection, heating medium returnXL 2

Connection, brine inXL 6

Connection, brine outXL 7

Connection, hot water heaterXL 9

HVAC components

Shut-off valve, heating medium flowQM 31

Shut off valve, heating medium returnQM 32

Shut off valve, brine outQM 33

Shut-off valve, brine inQM 34

Shuttle valve, climate system/water heaterQN 10

Sensors etc.

Flow meter**BF 1

Outdoor temperature sensor*BT 1

Temperature sensors, heating medium flowBT 2

**Only heat pumps with energy meter

* Not illustrated

Electrical components

Display unitAA 4

AA4-XJ3 USB socket

AA4-XJ4 Service outlet (No function)

Immersion heaterEB 1

SwitchSF 1

Network cable for NIBE UplinkTM

W130

Miscellaneous

Rating platePF 1

Type plate, cooling sectionPF 2

Serial number platePF 3

Cable gland, incoming electricityUB 1

Cable glandUB 2

Cable gland, rear side, sensorUB 3

Designations in component locations according to

standard IEC 81346-1 and 81346-2.

7Chapter 3 | The heat pump designNIBE™ F1155

3 The heat pump design

Distribution boxes

F1155

FD1

AA1

FA1

AA3

AA2AA23

Electrical components

Immersion heater cardAA 1

Base cardAA 2

Input circuit boardAA 3

Communication boardAA 23

Miniature circuit-breakerFA 1

Temperature limiter/Emergency mode thermo-

stat

FD 1

Designations in component locations according to

standard IEC 81346-1 and 81346-2.

NIBE™ F1155Chapter 3 | The heat pump design8

Andere Handbücher für F1155 Series

Inhaltsverzeichnis

Andere Nibe Wärmepumpe Handbücher

Nibe

Nibe CLIMATEMASTER TRANQUILITY 16 Series Betriebsanleitung

Nibe

Nibe F110 Benutzerhandbuch

Nibe

Nibe F110 Bedienungsanleitung

Nibe

Nibe Fighter 2005 Bedienungsanleitung

Nibe

Nibe F205P Bedienungsanleitung

Nibe

Nibe ACVM 270 Bedienungsanleitung

Nibe

Nibe Fighter 200P Bedienungsanleitung

Nibe

Nibe S735 Originalbetriebsanleitung

Nibe

Nibe FIGHTER 1127 Bedienungsanleitung

Nibe

Nibe F730 Benutzerhandbuch

Nibe

Nibe F1155 Series Bedienungsanleitung

Nibe

Nibe F750 Betriebsanleitung

Nibe

Nibe F2026 Bedienungsanleitung

Nibe

Nibe F470 Benutzerhandbuch

Nibe

Nibe F2040 Series Benutzerhandbuch

Nibe

Nibe F1345 Series Bedienungsanleitung

Nibe

Nibe SMO 10 Original Betriebsanleitung

Nibe

Nibe F130 Bedienungsanleitung

Nibe

Nibe F470 Benutzerhandbuch

Nibe

Nibe F730 Benutzerhandbuch

Nibe

Nibe F470 Benutzerhandbuch

Nibe

Nibe F1126 Bedienungsanleitung

Nibe

Nibe HBS 05 Benutzerhandbuch

Nibe

Nibe F2040-6 Benutzerhandbuch

Beliebte Wärmepumpe Handbücher anderer Marken

MICROWELL

MICROWELL HP 1000 GREEN Bedienungsanleitung

Sanyo

Sanyo SAP120FCH Bedienungsanleitung

Daikin

Daikin EHYHBH05AA Bedienungsanleitung

Panasonic

Panasonic WH-SDF03E3E5 Leitfaden

Bryant

Bryant 544B Bedienungsanleitung

Airxcel

Airxcel 45000 Series Handbuch

Mitsubishi Electric

Mitsubishi Electric PUZ-SWM60VAA Bedienungsanleitung

Dimplex

Dimplex LI 16I-TUR Benutzerhandbuch

Carrier

Carrier WSHP Open v3 Kurzanleitung zur Einrichtung

TGM

TGM CTV14CN018A Bedienungsanleitung

Carrier

Carrier 38MGQ Series Bedienungsanleitung

Kokido

Kokido K2O K880BX/EU Fehlerbehebungshandbuch

Viessmann

Viessmann VITOCAL 300-G PRO Type BW 2150 Kurzanleitung

Carrier

Carrier 48EZN Bedienungsanleitung

Viessmann

Viessmann KWT Vitocal 350-G Pro Series Betriebsanleitung

Ariston

Ariston NIMBUS Bedienungsanleitung

Weishaupt

Weishaupt WWP L 7 Benutzerhandbuch

GE Zoneline AZ85H09EAC Bedienungsanleitung