Nikon AF-S DX NIKKOR 18-105mm f/3.5-5.6 ED VR Betriebsanleitung

作成承認印配布許可印

JAA80551-R.3757.A

JAA80551

Printed in Japan September 2008

AF-S DX Zoom-Nikkor

18-105mm f/3.5-5.6G ED VR

REPAIR MANUAL

Ｍ

サービス

計画課

INC

JAA80551-R.3757.A

- 󲦑・AF-S DX 8-05/3.5-5.6G ED VR -

Before Disassembly / Reassembly / Adjustment

This lens will require optical lens alignment after assembly, in case the 5th lens-group unit is removed.

At repair service facilities, therefore, where this alignment work can not be performed, do NOT remove the 5th

lens-group unit.

This lens also has the VR (vibration-reduction) unit mounted in order to correct camera shake.

To keep the accuracy of this function for stabilizing the image, in case the fixed ring unit (gyro FPC), main PCB

unit, or the 3-4G lens group unit (VR unit) is replaced, be sure to make the VR adjustment by using the VR lens

adjustment equipment (J15380).

At repair service facilities where the "VR lens adjustment equipment" is not prepared, do NOT disassemble nor

repair the above-mentioned parts.

The VR adjustment is NOT necessary except for disassembling the above-mentioned parts.

Caution :

When disassembling/(re)assembling, be sure to use the conductive mat (J5033) and wrist strap

(J5033-5) for static protection of electrical parts.

When disassembling, make sure to memorize the processing state of wires, screws to be fixed and

their types, etc.

Because prototypes are used for "Disassembly", "Assembly", and "Adjustment", they may differ

from the actual products in forms, etc.

Because pictures are processed by a special method, they may differ from the actual ones in texture.

・Lead-free solder is used for this product.

・For soldering work, the special solder and soldering iron are required.

・Do NOT mix up lead-free solder with traditional solder.

・Use the special soldering iron respectively for lead-free solder and lead solder.

They cannot be used in common.

Points to notice for Lead-free solder products

INC

JAA80551-R.3757.A

- 󲦑・AF-S DX 8-05/3.5-5.6G ED VR -

Plastic Mold (PM) parts

Regarding plastic mold (PM) parts of this product, there are two combinations (Pattern A and B) but note that

these two are not interchangeable (so can not be mixed up).

Therefore, whenever the below parts are replaced, be sure to check the IDNO (identification number) of the

(old) part before replacement, and select appropriate parts with the same pattern according the chart.

< Identification No. and Interchangeability >

Description in Repair Manual Pattern A Pattern B

Zoom index ring 1C999-705A 1C999-705B

Fixed ring unit 1C999-706A 1C999-706B

Fixed tube unit 1C999-728A 1C999-728B

3-4 lens-group unit 1C999-707A 1C999-707B

MF ring unit 1C999-727A 1C999-727B

Zoom ring unit 1C999-730A 1C999-730B

Cover ring 1C999-731A 1C999-731B

Segment gear unit 1C999-733A 1C999-733B

Filter ring 1K631-991A 1K631-991B

Rear cover 1K631-997A 1K631-997B

Focus sliding ring 1K632-003A 1K632-003B

1st lens group unit 1B101-012A 1B101-012B

2nd lens group unit 1C999-726A 1C999-726B

5th lens group unit 1B101-015A 1B101-015B

INC

JAA80551-R.3757.A

- 󲦑3・AF-S DX 8-05/3.5-5.6G ED VR -

＜IDNO position ＞

Zoom index unit Fixed ring unit Fixed tube unit

1C999-705A: Numeral 1 or 2

1C999-705B: Numeral 3 or 4

1C999-706A: Numeral 1 or 2

1C999-706B: Numeral 3 or 4

1C999-728A:Numeral 1 or 2

1C999-728B: Numeral 3 or 4

3-4G lens group unit MF ring unit Zoom ring unit

1C999-707A: Numeral 1 or 2

1C999-707B: Numeral 3 or 4

1C999-727A: No. of dots 1 or 2

1C999-727B: No. of dosts 3 or 4

1C999-730A: Numeral 1 or 2

1C999-730B: Numeral 3 or 4

The identification no. (IDNO) of parts is mentioned in the red circle as below.

Note: The dot and numeral are engraved in the part as follows.

Dot Numeral

INC

JAA80551-R.3757.A

- 󲦑・AF-S DX 8-05/3.5-5.6G ED VR -

Cover ring Segment gear unit Filter ring

1C999-731A: Numeral 1 or 2

1C999-731B: Numeral 3 or 4

1C999-733A: Numeral 1 or 2

1C999-733B: Numeral 3 or 4

1K631-991A: No. of dots 1 or 2

1K631-991B: No. of dots 3 or 4

Rear cover ring Focus sliding ring 1st lens group unit

1K631-997A: Numeral 1 or 2

1K631-997B: Numeral 3 or 4

1K632-003A: Numeral: 1 or 2

1K632-003B: Numeral 3 or 4

1B101-012A: Numeral: 1 or 2

1B101-012B: Numeral 3 or 4

2nd lens group unit 5th lens group unit

1C999-726A: No. of dots 1 or 2

1C999-726B: No. of dots 3 or 4

1B101-015A: Numeral 1 or 2

1B101-015B: Numeral 3 or 4

Index

INC

JAA80551-R.3757.A

- 󲦑・AF-S DX 18-10/3.-.6G ED VR -

1. Disassembly

・Remove the VR name plate (#71).

・Remove the name plate (#72).

VR name plate / name plate

Disassembly of Body

#71

#72

Caution: Removing the name plate (#72) and VR name plate (#71) are NOT necessary except when the

fixed tube unit (B27), name plate (#72), or VR name plate (#71) are replaced.

△（Addition）

Changed page △× 1 September.2．2008

INC

JAA80551-R.3757.A

- 󲦑6・AF-S DX 8-05/3.5-5.6G ED VR -

Sheet / Rubber ring

・Remove the rubber ring (#35).

・Peel off the polyester tape [TA-0018 (15×20mm)×2] from the two gate sections of the zoom ring unit, [only

when replacing the zoom ring unit (B37)].

#35

Gate section of Zoom ring unit

TA-0018 (15×20mm)

・Remove the sheet (#131) from zoom ring unit (B37).

#131

B37

INC

JAA80551-R.3757.A

- 󲦑・AF-S DX 8-05/3.5-5.6G ED VR -

Rear cover ring

・Take out the three screws (#107), and remove the rear cover ring (#39).

#39

#107×3

・Set the zoom ring unit (B37) to WIDE-end, and remove the sheet (#48) from 1st lens-group unit (B40).

1st lens-group unit

B37

#48

B40

INC

JAA80551-R.3757.A

- 󲦑8・AF-S DX 8-05/3.5-5.6G ED VR -

・Set the zoom ring unit (B37) to WIDE-end. Then remove the 1st lens group unit (B40) and the washer (#80)

while holding the zoom ring unit (B37) by the hand.

#80

B40

B37

INC

JAA80551-R.3757.A

- 󲦑・AF-S DX 8-05/3.5-5.6G ED VR -

・Set the zoom ring unit (B37) to WIDE-end, and remove sheet (#133) from 2nd lens group unit (B2042)

[Only replace sheet (#133)].

#133

B37

B2042

2nd lens group unit

Caution : "R1 surface" of the 2nd lens group unit (B2042) is aspheric lens.

Therefore, if dusts are attached to the lens surface of the 2nd lens group unit (B2042), blow

them away with a blower as much as possible. If impossible, dip a wiping cloth (Savina

Minimax) a little in ethanol, and wipe the surface lightly.

Surface of R1

・Mount the focus sliding-frame fixed ring of the 2nd lens-G wrench (J11363). Then, turn it around until the

two protrusions (of the focus sliding-frame fixed ring) are fit in the two cutouts of the focus sliding frame

(#56).

Note: When the two protrusions (of the focus sliding-frame fixed ring of [J11363]) are fit in the two

cutouts of the focus sliding frame (#56), rotating the lens barrel on the whole is impossible with

this fixed ring being fastened.

Protrusion

Focus sliding-frame

fixed ring of [J11363]

B37

INC

Andere Handbücher für AF-S DX NIKKOR 18-105mm f/3.5-5.6 ED VR

Inhaltsverzeichnis

Andere Nikon Kameraobjektiv Handbücher

Nikon

Nikon AF-S NIKKOR 500mm f/5.6E PF ED VR Bedienungsanleitung

Nikon

Nikon AF-S NIKKOR Bedienungsanleitung

Nikon

Nikon AF DX Fisheye-Nikkor 10.5mm f/2.8G ED Bedienungsanleitung

Nikon

Nikon Nikkor 45mm f/2.8P Bedienungsanleitung

Nikon

Nikon Prostaff 3 Bedienungsanleitung

Nikon

Nikon JAA79551 Betriebsanleitung

Nikon

Nikon AF-S DX VR Zoom-Nikkor 55-200mm f/4-5.6G... Bedienungsanleitung

Nikon

Nikon AF-S DX NIKKOR 16-85mm f/3.5-5.6G ED VR Bedienungsanleitung

Nikon

Nikon AI-S Zoom-Nikkor 25-50mm f/4 Bedienungsanleitung

Nikon

Nikon Nikkor Z MC 105mm F2.8 VRS Bedienungsanleitung

Nikon

Nikon AF-S NIKKOR 200mm f/2G ED VR II Bedienungsanleitung

Nikon

Nikon f/3.5-5.6G ED VR Bedienungsanleitung

Nikon

Nikon 1 NIKKOR 10mm f/2.8 Bedienungsanleitung

Nikon

Nikon 1 NIKKOR VR 10-30mm f/3.5-5.6 Bedienungsanleitung

Nikon

Nikon AF-S VR 70-200mm f/2.8G IF-ED Bedienungsanleitung

Nikon

Nikon AF-S VR Zoom-Nikkor 70-300mm f/4.5-5.6G... Bedienungsanleitung

Nikon

Nikon AF-S NIKKOR 200mm f/2G ED VR II Bedienungsanleitung

Nikon

Nikon NIKKOR Z DX 12-28mm f/3.5-5.6 PZ VR Bedienungsanleitung

Nikon

Nikon AF Micro-Nikkor 60 mm f/2.8D Bedienungsanleitung

Nikon

Nikon PC Nikkor 35mm f/2.8 Bedienungsanleitung

Nikon

Nikon NIKKOR Z 58mm f/0.95 S Noct Bedienungsanleitung

Nikon

Nikon AF-S Zoom-Nikkor 24-85mm f/3.5-4.5G IF-ED... Bedienungsanleitung

Nikon

Nikon AF-S DX Zoom Nikkor 18-135/3.5-5.6G ED Betriebsanleitung

Nikon

Nikon 24mm F/1.4G ED AF-S Nikkor Bedienungsanleitung

Beliebte Kameraobjektiv Handbücher anderer Marken

THORLABS

THORLABS ELL15 Bedienungsanleitung

FUJICA

FUJICA ZC1000 Bedienungsanleitung

Tamron

Tamron A09 Handbuch

Sony

Sony SEL-55210 Bedienungsanleitung

Sony

Sony VCL-HG2037 Bedienungsanleitung

Honeywell

Honeywell HLM25V6F12 Bedienungsanleitung

Sony

Sony VCL-ST30 Bedienungsanleitung

Canon

Canon FD 35 - 70 mm Bedienungsanleitung

Sony

Sony SAL-85F14Z - 85mm f1.4 Carl Zeiss Planar T Coated Telephoto... Bedienungsanleitung

ARRI

ARRI Lenses Bedienungsanleitung

Olympus

Olympus M.Zuiko Digital ES 300mm f4.0 IS PRO Bedienungsanleitung

Sony

Sony VCL-DE07T Bedienungsanleitung

Canon

Canon FD Lens Handbuch

Tamron

Tamron A036 Bedienungsanleitung

Samsung

Samsung 20-50mm F3.5-5.6 ED II Bedienungsanleitung

Tamron

Tamron 272E Bedienungsanleitung

Sinar

Sinar Rolleiflex 6008 AF Bedienungsanleitung

Rokinon

Rokinon SP 85mm F1.2 Bedienungsanleitung