Nokia RH-17 Series Leitfaden
CCS Technical Documentation
RH-17 Series Transceivers
Issue 1 04/2003 Confidential Nokia Corporation
Troubleshooting — Antennas
RH-17
Troubleshooting — Antennas CCS Technical Documentation
Page 2 Nokia Corporation Confidential Issue 1 04/2003
CCS Technical Documentation Troubleshooting — Antennas
RH-17
Issue 1 04/2003 Nokia Corporation Confidential Page 3
Contents Page No
Troubleshooting - Antennas........................................................................................... 5
Appearance of the Phone .............................................................................................5
Failures and Corrective Measures ...............................................................................6
Missing Internal Antenna or Whip Antenna ............................................................. 6
Damaged RF Feed Pin or Ground Pin....................................................................... 6
Wrong Internal Antenna Installed............................................................................. 7
Obstructed RF Feed and Ground Pads for the Internal Antenna............................... 8
Broken or Missing Antenna Clip .............................................................................. 8
Obstructed Whip Stopper.......................................................................................... 9
Grounding of Display Frame..................................................................................... 9
Misinstalled Whip................................................................................................... 12
Damaged Whips...................................................................................................... 12
Detuning Circuit for Bottom Antenna Clip............................................................. 12
RF Connector Failure.............................................................................................. 13
RH-17
Troubleshooting — Antennas CCS Technical Documentation
Page 4 Nokia Corporation Confidential Issue 1 04/2003
CCS Technical Documentation Troubleshooting — Antennas
RH-17
Issue 1 04/2003 Nokia Corporation Confidential Page 5
Troubleshooting - Antennas
This troubleshooting guide addresses potential failures that will affect the antenna per-
formance of the RH-17 phone, and how to correct these failures.
For additional information, refer to Haukka Antenna RF Specifications and Plan
(DHS02290-EN-1.0)
Appearance of the Phone
Figure 1: Front of RH-17
Figure 2: Back of RH-17
Figure 3: Back and Top of RH-17
Note in Figure 3 that when the whip antenna is properly installed, the cap “clicks” into
the D-cover when the whip is fully retracted.
RH-17
Troubleshooting — Antennas CCS Technical Documentation
Page 6 Nokia Corporation Confidential Issue 1 04/2003
Failures and Corrective Measures
Missing Internal Antenna or Whip Antenna
Figure 4: RH-17 D-cover assembly
Note that the whip antenna must be inserted prior to inserting the internal antenna.
If the internal antenna is missing, install one. If the radiator looks obviously damaged,
then replace the internal antenna.
If no antenna is installed, the antenna gain will be degraded by more than 25 dB.
If the whip antenna is missing, then remove the internal antenna, install a whip, and
reinstall the internal antenna.
Damaged RF Feed Pin or Ground Pin
Figure 5: Top and Bottom View of the RH-17 Internal Antenna
If either the RF feed pin or ground pin are broken, or bent such that either pin will not
touch the PWB, then the internal antenna must be replaced. If the springs for the RF or
ground pin appear damaged, then the internal antenna must be replaced. If the slot in
CCS Technical Documentation Troubleshooting — Antennas
RH-17
Issue 1 04/2003 Nokia Corporation Confidential Page 7
the radiator has a significantly different shape, then the correct internal antenna must
be installed. Be aware that the shape of the slot can vary slightly. The length of the hor-
izontal slot can vary by a few millimeters, because the antennas are tuned for each batch
of plastic frames. If there is any other obvious damage to the radiator (dents, corrosion),
then the antenna should be replaced. If the pin gets stuck or has excessive friction in the
plastic tube/guiding feature, then the spring will not work properly, and the antenna
should be replaced.
If the RF feed doesn’t touch the PWB, then the antenna gain will degrade by more than
25 dB. If the ground pin doesn’t touch the PWB, then the antenna gain may degrade
about 5 dB to 10 dB.
Wrong Internal Antenna Installed
Figure 6: Top and bottom view of RH-3 antenna
The RH-17 and RH-3 antennas share the same mechanical interface with the D-cover. As
a result, either antenna may be installed in either phone. The important differences visu-
ally in the antennas are that the slot pattern is very different, and there also is a GPS
antenna present in the RH-3 which is absent in the RH-17.
If the wrong antenna is installed, install the correct one.
Installing an RH-3 antenna in the RH-17 phone will change the antenna gain by a few
dB at 850 MHz, and the phone will not be compliant with FCC submission. Installing a
RH-17 antenna in a RH-3 phone will degrade the PCS performance by at least 6 dB, as
the RH-17 antenna is not tuned for PCS. In addition, if an RH-17 antenna is installed in
the RH-3, GPS will degrade by about 25 dB as the RH-17 doesn’t have a GPS antenna.
RH-17
Troubleshooting — Antennas CCS Technical Documentation
Page 8 Nokia Corporation Confidential Issue 1 04/2003
Obstructed RF Feed and Ground Pads for the Internal Antenna
Figure 7: PWB layout of RF feed and ground pads, and bottom antenna clip
If the RF feed pad is obstructed, removed, or covered, then the RF feed pin will not touch
the PWB and then the antenna gain will degrade by more than 25 dB. If the ground pad
is obstructed, removed, or covered, then the ground pin will not touch the PWB, and then
the antenna gain may degrade about 5 to 10 dB. If corrosion is present or the pad is
missing, then most likely the PWB and phone needs to be replaced. In either pad is
obstructed or covered, the pad should be cleared and/or cleaned.
Broken or Missing Antenna Clip
Figure 8: Bottom antenna clip
If the bottom antenna clip does not contact the whip stopper, when the whip is fully
retracted, then the internal antenna gain will degrade by about 4-5 dB in the RX portion
of CELL band. If the antenna clip is installed backwards, is damaged, or is missing, then
install a new bottom antenna clip in the correct position.
CCS Technical Documentation Troubleshooting — Antennas
RH-17
Issue 1 04/2003 Nokia Corporation Confidential Page 9
Obstructed Whip Stopper
Figure 9: Whip stopper as shown when the whip is fully retracted
If the whip stopper is corroded or blocked by the whip straw, then the whip assembly
needs to be replaced. If the whip stopper is obstructed or dirty, then the obstruction
and/or dirt needs to be removed. If the whip stopper doesn't properly contact the bot-
tom antenna clip, then the internal antenna gain will degrade by about 4-5 dB in the RX
portion of CELL band.
Grounding of Display Frame
Figure 10: Display assembly
Note that the display frame is grounded to the PWB through the two ground clips. The
grounding of the display frame will impact the radiation performance of the phone. If
the clips are not touching the PWB, or are corroded, or obstructed, then the display
frame should be replaced.
RH-17
Troubleshooting — Antennas CCS Technical Documentation
Page 10 Nokia Corporation Confidential Issue 1 04/2003
The following figures show the contact between the display frame ground clips and the
PWB in greater detail.
Figure 11: Ground clip on the left side of the display frame
Figure 12: Ground clip on the right side of the display frame
Andere Handbücher für RH-17 Series
4
Inhaltsverzeichnis
Andere Nokia Handy Handbücher
Nokia
Nokia N95 8GB Technisches Datenblatt
Nokia
Nokia 002F581 Bedienungsanleitung
Nokia
Nokia 5710 XpressAudio Bedienungsanleitung
Nokia
Nokia 2100 - Cell Phone - GSM Bedienungsanleitung
Nokia
Nokia E66 Bedienungsanleitung
Nokia
Nokia 6250 Bedienungsanleitung
Nokia
Nokia TA-1174 Bedienungsanleitung
Nokia
Nokia N97 N97 Bedienungsanleitung
Nokia
Nokia E61 Bedienungsanleitung
Nokia
Nokia Lumia 800 Bedienungsanleitung
Nokia
Nokia E71 Bedienungsanleitung
Nokia
Nokia HANDSET 6280 Bedienungsanleitung
Nokia
Nokia 8.3 Bedienungsanleitung
Nokia
Nokia N71 Bedienungsanleitung
Nokia
Nokia 6265 Bedienungsanleitung
Nokia
Nokia 2730 classic Bedienungsanleitung
Nokia
Nokia Asha 302 Bedienungsanleitung
Nokia
Nokia NSE-1 Series Montageanleitung
Nokia
Nokia 6086 - Cell Phone 5 MB Bedienungsanleitung
Nokia
Nokia COMMUNICATOR 9210i Kurzanleitung
