Nomix Enviro Frontline Compact Bedienungsanleitung
The Click & Spray
low volume
TDC herbicide
application
system
INSTRUCTIONS
frontlinecompact
Contents
Section 1:
Introduction 3
Section 2:
Component List 4
Section 3:
Quick Start 7
Section 4:
Preparing the Frontline Compact for Use
Personal Protective Equipment (PPE) 9
Inserting the batteries 9
Inserting the herbicide cartridge 10
Priming 10
Calibrating 11
Selecting a disc 12
Section 5:
Operating the Frontline Compact
Spraying 13
Avoiding spray drift 13
Optimum spray pattern 13
Section 6:
Cleaning the Frontline Compact 14
Section 7:
Storing the Frontline Compact 15
Section 8:
Safety Tips 16
Section 9:
Troubleshooting 17
Section 1: Introduction
The Frontline Compact is a lightweight hand-held low
volume herbicide applicator, designed for use with our
range of Nomix Total Droplet Control (TDC) herbicides.
Nomix TDC is a unique system, combining pre-mixed,
highly eective herbicides with easy to use, ecient
applicators.
Nomix TDC delivers a constant, uniform droplet size and
spray pattern, significantly reducing run-o and virtually
eliminating spray drift and droplet bounce. In times of
increased environmental and legislative pressure, the
Frontline Compact delivers ecient, compliant, cost
eective and accurate herbicide applications every time.
Nomix TDC herbicides are supplied in 750ml cartridges
that connect directly to the lance. This eliminates the
need to carry a heavy knapsack, as with conventional
applicators. This system is ideal for use where smaller
volumes of herbicide are applied.
3
Section 2: Component List
1Spray head
a) Flow rate window
b) Flow rate indicator
c) Flow rate control
2Control panel
a) Spray width control
b) Pacing control
3Trigger lock
4 Trigger
3
4
b
b
c
a
a
4
5Spiral disc
6Square disc
7Serrated disc
8Disc ejector tool
9Batteries
a) Battery housing
b) Batteries
ab
5
10 Herbicide cartridge
11 Calibration cup
12 Carry case*
* This item does not form part
of our standard components.
It can be purchased from
Nomix Enviro.
Please telephone 0800 0324352.
Section 2: Component List (cont.)
6
1Select an approved Nomix
TDC herbicide
2Shake the herbicide cartridge
vigorously for at least one
minute
3Insert the cartridge into the
end of the lance and secure it
with the retaining clip
4Prime your Frontline Compact
Section 3: Quick Start
7
5Calibrate your Frontline
Compact
6 Select a disc
Spiral - Narrow spray
Square - Medium Spray
Serrated - Wide Spray
7You are ready to spray
Please Note: For full operator
instructions, always refer to
sections 4 & 5.
Section 3: Quick Start (cont.)
8
Section 4: Preparing for Use
Personal Protective
Equipment (PPE)
The minimum PPE recommended
for use is:
• Coveralls
• Suitable protective gloves
• Wellington boots.
Always refer to the herbicide
product label for the
recommended PPE.
Inserting the batteries
Insert the four AA batteries
(included) into the battery
compartment. Slide open and lift
the battery compartment, then
insert the batteries in the
sequence shown.
9
Section 4: Preparing for Use (cont.)
Inserting the herbicide
cartridge
• Select an approved TDC
herbicide.
• Read the label for full product
information and application rates.
• Shake the herbicide cartridge
vigorously for at least
one minute.
• Hold the lance with the spray
head pointing down.
• Insert the herbicide cartridge
into the end of the lance and
push it in.
• Close the retaining clip to secure.
Priming
ALWAYS PRIME THE LANCE
BEFORE USE
Priming fills the lance with
herbicide and removes air bubbles,
which could interrupt
the chemical flow or cause
the lance to drip.
• Ensure there is no disc attached.
If a disc is present, remove it
using the disc ejector tool.
• Turn the variable spray width
control to the ‘O’ (12 o’clock)
position.
• Set the flow rate indicator on the
spray head to ‘Prime’.
10
Inhaltsverzeichnis
Andere Nomix Enviro Spritzpistole Handbücher
