Nor-tec NH Series Bedienungsanleitung

Series

Installation and

Operation Manual

Includes installation, operation

maintenance and troubleshooting

information for your NHRS Resistive

Element Steam Humidifier

2530618-*| 08 SEP 2010

Important: Read and save these instructions. This guide to be left with equipment.

Thank you for choosing NORTEC.

Proprietary Notice

This document and the information disclosed herein are proprietary data of WALTER MEIER LTD. Neither this

document nor the information contained herein shall be reproduced used, or disclosed to others without the

written authorization of WALTER MEIER LTD., except to the extent required for installation or maintenance of

recipient’s equipment. All references to the NORTEC name should be taken as referring to WALTER MEIER LTD.

Liability Notice

NORTEC does not accept any liability for installations of humidity equipment installed by unqualified personnel

or the use of parts/components/equipment that are not authorized or approved by NORTEC.

INSTALLATION DATE (MM/DD/YYYY)

MODEL #

SERIAL #

CYLINDER #

TABLE OF CONTENTS

10-00 INTRODUCTION

1. PRE-INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

2. PACKAGING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3

3. PRE-INSTALLATION EQUIPMENT VERIFICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

10-10 INSTALLATION PROCEDURES

1. HUMIDIFIER INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2. STEAM DISTRIBUTOR INSTALLATION FOR THE ASD, BSD, CSD . . . . . . . . . . . . . . . . . . . . .27

3. SAM-E SHORT ABSORPTION MANIFOLD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33

4. BLOWER PACKS (BOBP, RMBP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .41

10-20 OPERATION

1. OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

2. NHRS OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47

10-30 MAINTENANCE PROCEDURES

1. NHRS MAINTENANCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62

10-40 TROUBLESHOOTING

1. TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68

2. START-UP CHECK LISTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72

3. MAINTENANCE CHECK LISTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75

10-50 TECHNICAL

1. EXPLODED VIEWS - PLUMBING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78

2. EXPLODED VIEWS ELECTRICAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80

WARRANTY



Introduction

CAUTION: Servicing

Disconnect main power before any servicing.

The plumbing and electrical compartments contain high voltage components and

wiring. Access should be limited to authorized personnel only.

During and following operation of the humidifier, the steam and components in

contact with the steam such as the cylinder, blower pack, steam lines, steam

distributors, and condensate lines can become hot and can burn if touched.

Walter Meier does not accept any liability for installations of humidity equipment

installed by unqualified personnel or the use of parts/components/equipment

that are not authorized or approved by Walter Meier.

CAUTION: Electrical

All electrical work should be done according to local electrical code.

Electrical connection to be performed by a licensed electrician.

CAUTION: Plumbing

Plumbing to be performed by a licensed plumber.

Drain water from humidifier can be very hot. Do not drain to public sink.

All plumbing work should be done according to local plumbing code.

CAUTION: Installation

Do not mount on hot surfaces

Do not mount in area where freezing can occur

Do not mount on vibrating surface

Do not mount on floor

The NHTC produces steam at atmospheric pressure no devices which could block

steam output should be connected to the steam outlet.

Steam lines must be installed so that no restriction can produce backpressure in

the humidifier.

Regardless of selecting On/Off or modulating control method, NORTEC humidifiers

must have a closed circuit across its On/Off security loop control terminal to

operate. NORTEC highly recommends the use of a high limit humidistat and an air

proving switch in series for this function.

Page 1

10-00

INTRODUCTION

Page 2

Figure 1. NHRS

Page 3

1. PRE-INSTALLATION

A. RECEIVING & UNPACKING EQUIPMENT

(1) Check packing slip to ensure ALL material has been delivered. All material

shortages are to be reported to NORTEC within 48 hours from the receipt of

good. NORTEC assumes no responsibility for any material shortages beyond this

period.

(2) Inspect shipping boxes for damage and note damages on shipping waybill

accordingly. After unpacking, inspect equipment for damage. If damage is found

notify shipper promptly. All NORTEC products are shipped on a FOB factory

basis. Any and all damage, breakage or loss claims are to be made directly to

the shipping company.

2. PACKAGING

A. GENERAL

(1) The equipment packaging is standardized in that each box will contain the same

base content. The following paragraphs identify the content of each box.

B. HUMIDIFIER AND CONTROL BOX

(1) The typical equipment found in the humidifier and control box are shown in

Figure 2. The contents are listed on the box. If controls and any other small

accessories are placed in the box they will be listed on the box.

C. DISTRIBUTOR BOX

(1) Depending on the equipment ordered the following distributor box configurations

may be received.

(2) For equipment received if an ASD, BSD, CSD distributors are ordered refer to

Figure 3.

(3) For equipment received if a SAM-e is ordered refer to Figure 4.

(4) For equipment received if a RMBP is ordered refer to Figure 5.

Page 4

H096

BOX WITH

ABBREVIATED

INSTRUCTIONS

AND BOX

CONTENT

STICKERS

CONTROLS

(IF ORDERED

ONLY)

BAG WITH

MANUAL,

CLAMPS,

HOSE SECTION

HUMIDIFIER

STEAM HOSE

SECTION (NOT

SUPPLIED IF BUILT

ON BLOWER PACK

ORDERED)

Figure 2. Humidifier Box

Figure 3. Distributor Box

Figure 4. SAM-e Distributor Box

Figure 5. Remote Mounted Blower Pack Box

Page 5

3. PRE-INSTALLATION EQUIPMENT VERIFICATION

A. GENERAL

(1) Ensure the available voltage and phase correspond with humidifier voltage and

phase as indicated on the humidifier’s specification label.

(2) Ensure that the external fuse disconnect is sufficient size to handle the rated

amperage as indicated on the humidifier’s specifications label. Refer to local building

codes.

(3) Report any discrepancy immediately to the site engineer.

(4) Location and mounting is described in Chapter 10-10.

(5) For typical installation see Figures 6 & 7.

Andere Handbücher für NH Series

Inhaltsverzeichnis

Andere nor-tec Luftbefeuchter Handbücher

nor-tec

nor-tec Se Series Bedienungsanleitung

nor-tec

nor-tec MHTC Bedienungsanleitung

nor-tec

nor-tec NHTC Bedienungsanleitung

nor-tec

nor-tec Gas-fired Humidifier Betriebsanleitung

nor-tec

nor-tec MH Series Bedienungsanleitung

nor-tec

nor-tec Electric Steam Humidifiers Bedienungsanleitung

nor-tec

nor-tec Se Series Bedienungsanleitung

nor-tec

nor-tec GS 600 Betriebsanleitung

nor-tec

nor-tec 132-3091 Technisches Dokument

nor-tec

nor-tec NHRS 135-180 Bedienungsanleitung

nor-tec

nor-tec Electric Steam Humidifiers Fehlerbehebungshandbuch

nor-tec

nor-tec MES2 Bedienungsanleitung

nor-tec

nor-tec MES Electrode Betriebsanleitung

nor-tec

nor-tec HP Series Bedienungsanleitung

nor-tec

nor-tec MH Series Installations- und Betriebshandbuch

nor-tec

nor-tec GS Series Bedienungsanleitung

nor-tec

nor-tec livesteam Bedienungsanleitung

nor-tec

nor-tec GH Series Betriebsanleitung

nor-tec

nor-tec SE 50 Bedienungsanleitung

nor-tec

nor-tec NH Series Bedienungsanleitung

nor-tec

nor-tec None Betriebsanleitung

nor-tec

nor-tec Steam Injection Humidifiers Wartungs- und Serviceanleitung

nor-tec

nor-tec RH Series Bedienungsanleitung

nor-tec

nor-tec BLOWER PACKS Bedienungsanleitung

Beliebte Luftbefeuchter Handbücher anderer Marken

Boneco

Boneco H300 Bedienungsanleitung

Bionaire

Bionaire CM1 Handbuch

Air-O-Swiss

Air-O-Swiss AOS 7131 Handbuch

KING

KING K 5002 Rainbow Bedienungsanleitung

Crane

Crane EE-6902 Bedienungsanleitung

Glaziar

Glaziar Ness Bedienungsanleitung

Philips

Philips DreamStation Go Abmessungen

Honeywell

Honeywell MISTMATE HUL520BC Bedienungsanleitung

Stadler Form

Stadler Form Hera Bedienungsanleitung

Hunter

Hunter 31206 Bedienungsanleitung

TaoTronics

TaoTronics TT-AH004 Bedienungsanleitung

adorini

adorini Cigar Heaven Bedienungsanleitung

Lanaform

Lanaform Aroma Bedienungsanleitung

Aprilaire

Aprilaire 800 Series Bedienungsanleitung

Pyle

Pyle SereneLife PHUMDIF8 Bedienungsanleitung

Trotec

Trotec B 200 Bedienungsanleitung

Pure Humidifier

Pure Humidifier EC Series Bedienungsanleitung

Crane

Crane EE-864 Bedienungsanleitung