NUTRICHEF NCPIZOVN Bedienungsanleitung

PortableOutdoorPizzaOven

GasFired,Fire&StoneOutdoorPizzaOven

NCPIZOVN

www.NutrichefKitchen.com2

DANGER

Never operate this appliance unattended. If a re should occur, keep away

from the appliance and immediately call your re department.

Do not attempt to extinguish an oil or a grease re with water.

If you smell gas:

• Shut o gas to the appliance.

• Extinguish any open ame.

• If odor continues, keep away from the appliance and immediately call your

gas supplier or your re department.

• Failure to follow these instructions could result in re, explosion or burn hazard

which could cause property damage, personal injury or death.

WARNINGS

To reduce the risk of re, burn hazard or other injury, read this safety

manual carefully and completely before using this appliance.

Before cleaning, make sure the gas supply and control knob is in the

OFF position and that the burner and oven has cooled.

FOR OUTDOOR USE ONLY

a. Keep the fuel supply hose away from any heated surface(s).

b. The use of alcohol, prescription or non-prescription drugs may impair

the consumer's ability to properly assemble or safely operate the

appliance.

c. Keep children and pets away from the appliance at all times.

d. Do not move the appliance when in use.

e. This appliance is not intended for and should never be used as a heater.

Spiders and insects can nest inside the burner of the appliance and

disrupt gas ow. Inspect the burner at least once a year.

When using a match to light the appliance, make sure to use the included

matchstick holder.

Do not store this appliance indoors unless the gas cylinder is disconnected.

www.NutrichefKitchen.com 3

WARNINGS

Do not store gas cylinder in a building, garage or any other enclosed area

and keep out of reach of children at all times.

This appliance is not intended to be installed in or on recreational

vehicles and/or boats.

Check all gas supply ttings for leaks before each use. Do not use the

appliance until all connections have been checked and do not leak.

Do not smoke while leak testing. Never leak test with an open ame.

When lighting, keep your face and hands as far away from the appliance

as possible.

Minimum clearance from sides of unit to combustible construction is

915mm (36 inches). Minimum clearance from back of unit to combustible

construction is 915mm (36 inches).

This instruction manual contains important information necessary for the

proper assembly and safe use of the appliance. Read and follow all

warnings and instructions before assembling and using the appliance.

Follow all warnings and instructions when using the appliance.

Keep this manual for future reference.

This manual states that a pizza oven shall not be used on or under any

apartment or condominium balcony or deck

This manual includes a list of required parts necessary for the safe

operation of the appliance, directions for proper assembly and for

assembly of installed parts and accessories supplied with the appliance,

and proper procedures for gas leak testing.

This appliance shall be used only outdoors, and shall not be used in a

building, garage, or any other enclosed area.

This manual includes an instruction to clean and inspect the hose before

each use of the appliance. If there is evidence of abrasion, wear, cuts, or

leaks, the hose must be replaced prior to the appliance being put into

operation. The replacement hose assembly shall be that specied by the

manufacturer.

www.NutrichefKitchen.com4

WARNINGS

BEFORE USE

Inspect the gas supply hose prior to turning on the gas. If there is evidence of cut,

wear or abrasion, it must be replaced prior to use. Screw the regulator onto the

gas cylinder. Leak check the hose and regulator connections with a soap and

water solution before lighting the appliance.

Only the pressure regulator and gas hose assembly supplied with this appliance

should be used.

LP GAS CYLINDER WARNING

1. Do not store spare liquid propane gas cylinder under or near this appliance.

2. Never ll the cylinder beyond 80% capacity.

3. Liquid propane cylinder must be tted with an OVERFILL PROTECTION

DEVICE (OPD).

4. If the information above is not followed exactly, a re resulting in death or

serious injury may occur.

5. This manual states that the installation must conform with local codes or, in

the absence of local codes, with the National Fuel Gas Code, ANSI Z223.1/NFPA

54, Storage and Handling of Liqueed Petroleum Gases, ANSI/NFPA 58; or

Natural Gas and Propane Installation Code, CSA B149.1; Propane Storage and

Handling, CSA B149.2

This appliance is not intended to be installed in or on a boat. This appliance

is not intended to be installed in or on a recreational vehicle.

Keep the fuel supply hose away from any heated surface(s).

The appliance should not be located or used under overhead unprotect-

ed combustible construction materials or surfaces. For a pizza oven, the

minimum clearance shall be at least 3m from any structure or combustible

material.

The appliance is not intended for commercial use.

www.NutrichefKitchen.com 5

SAFETY PRACTICES TO AVOID INJURY

When properly cared for, your oven will provide safe, reliable service for many

years. However, extreme care must be used as the oven produces intense heat

that can increase the risk of accidents. When using this oven basic practices

must be followed, including but not limited to following:

• Do not repair or replace any part of the oven unless specically recommended

in this manual. All other service should be referred to a qualied technician.

• Children should not be left alone or unattended in an area where the oven is

being used. Do not allow children to sit, stand or play around the oven at any

time.

• Never let clothing or other ammables come in contact with or too close to any

burner or hot surface until it has cooled. The fabric could ignite, causing serious

personal injury.

• For personal safety, wear proper apparel. Loose ttings garments or sleeves

should never be worn while using the oven. Some synthetic fabrics are highly

ammable and should not be worn while cooking.

• Do not heat unopened food containers as a build-up of pressure may cause the

containers to burst. When lighting the burner, always pay close attention to

what you are doing.

• When using the oven, do not touch the outer shell, stone baking board or

immediate surroundings as these areas become extremely hot and could

cause burns.

• Do not use the oven to cook extremely fatty meats or other products which

increase are-up.

• Keep the area surroundings the oven free from combustible material including

uids, trash and vapours such as gasoline or charcoal lighter uid.

• Do not obstruct the ow of combustion and ventilation air.

• Never use the oven in extremely windy conditions.

• The temperature under the oven is high. Do not place the oven on a table with

ammable table cloths, plastic or any other inammable materials.

1 2

www.NutrichefKitchen.com6

PARTS LIST

1. Pizza Oven

2. Pizza baking stone

ASSEMBLY

Before assembly, make sure all parts are present. If any part is missing or

damaged, do not attempt to assemble the appliance. Contact customer

service for replacement parts.

1. Unfold legs

2. Insert the pizza baking stone

www.NutrichefKitchen.com 7

3. Connecting gas hose to Pizza Oven

Please note the factory setting that the hose has

been assembled to the Pizza Oven.

4. Connecting to gas tank

WARNING

• Please always keep the gas bottle in upright position.

• The size for 20 lbs LP gas cylinder is 12.2 inches in

diameter and 17.9 inches tall

• If the appliance is not in use, the gas must be turned

o at the supply cylinder.

• The cylinder used must include a collar to protect

the cylinder valve.

• The minimum distance for the appliance and the

20lb gas tank is 1m apart.

This gas tting is clockwise. Make sure that the tank is completely switched o

and screw the regulator as far as possible into the gas tank valve.

CONNECTING THE LIQUID PROPANE GAS CYLINDER

1. To connect the liquid propane gas cylinder:

2. The cylinder valve should be in OFF position.

3. Make sure the burner valve is in OFF position.

4. Inspect the valve connections, port and regulator assembly.

Remove debris and inspect the hose for damage.

5. When connecting the regulator assembly to the valve, use your hand to tighten

the nut clockwise until it stops. Use of a wrench could damage the quick

coupling nut and result in a hazardous situation.

6. Open the cylinder valve fully by turning the valve counterclockwise.

7. Before lighting the oven, use a soap and water solution to check all connections

for leaks.

8. If a leak is found, turn the cylinder valve OFF, and do not use the oven until

local liquid propane dealer can make repairs.

www.NutrichefKitchen.com8

9. Turn the oven burner valve OFF and make sure the oven is cool.

10. Turn the liquid propane cylinder valve OFF by turning clockwise until it stops.

11. Detach the regulator assembly from the cylinder valve by turning the quick

coupling nut counterclockwise.

12. Place dust cap for cylinder valve outlet whenever the cylinder is not in use.

13. The LP gas supply cylinder to be used must be constructed and marked in

accordance with the specications for LP gas cylinder, U.S.Department of

Transportation (DOT) or the standard of cylinders, Spheres and tubes for the

Transportation of Dangerous Goods, CAN/CSA-B339

14. The cylinder supply system must be arranged for vapor withdrawal.

LEAK TESTING

GENERAL

Although the gas connections of the appliance are leak tested prior packing

and shipment, a complete test must be performed at the installation site.

Before each use, check all the gas connections for leak testing using the procedure

listed below. If the smell of gas is detected at any time, you should immediately

stop using and check the entire system for leaks.

BEFORE TESTING

Make sure all packing material has been removed from the appliance.

Make a solution of one part liquid detergent and one part water.

You will need a spray bottle, brush or rag to apply the solution to the ttings.

TO TEST

1. Turn the burner valve OFF.

2. Turn the liquid propane cylinder valve on counterclockwise to open the valve.

3. Apply the soap solution to all gas ttings. Soap bubbles would appear where

a leak is present.

4. If a leak is present, immediately turn the gas supply OFF and tighten leaky

ttings.

5. Turn the gas back ON and recheck.

6. Should the gas continue to leak from any of the ttings, turn the gas supply

OFF and contact customer service.

A B C

www.NutrichefKitchen.com 9

OPERATING INSTRUCTIONS

USING THE OVEN

The burner is rated at 14,500BTU/Hr.

To begin:

1. Make sure the oven has been leak tested and properly placed.

2. Remove any remaining packing material.

3. Light the burner using the LIGHTING INSTRUCTIONS below:

LIGHTING AND ADJUST THE FIRE INSTRUCTION

1. Before use please make sure the control knob is in “OFF”position. Then push

the control knob and slowly turn the knob anticlockwise to “HI”position for 5

seconds until you hear a click and the burner ignites (A).

2. You can adjust the re from HI to LOW by slowly turn the control knob

clockwise (B).

3. Please turn the control knob to “HI” position, then push the knob and

colockwise to “OFF” potition to turn o your pizza oven. (C)

TO LIGHT WITH A MATCH

1. If burner will not light after several attempts using the control knob, the burner

may be lit with a match.

2. If you have already attempted to light the burner using the control knob, wait

few minutes for any gas to dissipate.

www.NutrichefKitchen.com10

3. Insert a match into the matchstick holder, ignite the match and insert through

the oven opening to the burner.

4. Push and turn the control knob to HI slowly, the burner should ignite

immediately.

5. If the burner does not light within seconds, turn the control knob OFF and

wait for 5 minutes and try again.

CARE AND MAINTENANCE

Store Pizza oven out of direct sunlight and indoors where possible and when

storing for extended periods of time. The pizza oven should not be exposed to

harsh weather conditions such as snow, heavy rain and strong winds.

Wait for the pizza oven to cool completely before moving.

PIZZA BAKING STONE

1. DO NOT use the stone over an open ame.

2. Avoid extreme temperature change to the stone.

DO NOT place frozen foods on a hot stone.

3. The stone is fragile and can break if bumped or dropped.

4. The stone is very hot during use and stays hot for a long time after use.

5. DO NOT cool the stone with water when the stone is hot.

6. After cleaning the stone with water, please dry the stone before use.

This can be done in a conventional oven at 60°C (140°F) for 2 hours.

MAINTENANCE:

1. kepping appliance area clear and free from combustible materials, gasoline,

and other ammable vapors andliquids;

2. not obstructing the ow of combustion and ventilation air;

3. keeping the ventilation opening(s) of the cylinder enclosure free and clear

from debris;

4. visually checking burner ames, with pictorial representations;

5. cleaning appliance, including special surfaces, with recommended cleaning

agents, if necessary;

6. checking and cleaning burner tubes for insects and insect nests.

A clogged tube can lead to a re beneath the appliance;

Inhaltsverzeichnis

Andere NUTRICHEF Küchengerät Handbücher

NUTRICHEF

NUTRICHEF PKFD58 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PCRM12 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKWTR15 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKELS80 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKOPR15 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKBRTP299 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKBRTP60 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKBRTP99 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKCWC120 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKPC235BK Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKVS20STS Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKPZM12 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKPRC15 Bedienungsanleitung

NUTRICHEF

NUTRICHEF NCDH4S Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKBRTP50 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKMFR10 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKPZ950 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKCWC Series Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKCG20 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKFD16 Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKMFR14 Bedienungsanleitung

NUTRICHEF

NUTRICHEF NCFD14A Bedienungsanleitung

NUTRICHEF

NUTRICHEF PKWTR30 Bedienungsanleitung

NUTRICHEF

NUTRICHEF NCHDMK2 Bedienungsanleitung

Beliebte Küchengerät Handbücher anderer Marken

Tayama

Tayama TYG-35AF Bedienungsanleitung

AEG

AEG 43172V-MN Bedienungsanleitung

REBER

REBER Professional 40 Benutzerhandbuch

North American

North American BB12482G / TR-F-04-B-NCT-1 Bedienungsanleitung

Presto

Presto fountain popper Bedienungsanleitung

Westmark

Westmark 1035 2260 Bedienungsanleitung

Zanussi

Zanussi ZCG64396XA Bedienungsanleitung

HOFFEN

HOFFEN SM-9302M Bedienungsanleitung

Philips

Philips HD3133 Bedienungsanleitung

Ronco

Ronco Beef Jerky Bedienungsanleitung

Hendi

Hendi 470411 Bedienungsanleitung

Livoo

Livoo MEN386 Bedienungsanleitung

croydon

croydon WR-10313-700 Bedienungsanleitung

Chefman

Chefman RJ43-SQ Series Bedienungsanleitung

Vacmaster

Vacmaster VP680 Bedienungsanleitung

Jetmaster

Jetmaster 900HG Bedienungsanleitung

Küppersbusch

Küppersbusch EEH 610.0 Kurzanleitung zur Einrichtung

HURAKAN

HURAKAN HKN-F10 Bedienungsanleitung