Oceanic 0CS30 Bedienungsanleitung

April ‘13

Oceanic Sauna Heater Manual

Thank you for choosing to buy our Oceanic Sauna heater; please take the time to read

these instructions before you begin as they contain important information about the

installation and maintenance requirements.

“Oceanic” sauna heaters are available in specifications from 3kw to 9kw and are

equipped with our OC-SA digital controller. With this not only can you control the temperature and time

duration of your sauna bath but also the light of the sauna room, alter the temperature display between

Centigrade and Fahrenheit; as well as displaying the sauna heater’s status.

Every “Oceanic” sauna heater is thoroughly tested before leaving the factory.

IMPORTANT

•Read the manual before installation and operation and then keep it for reference

•This equipment must be installed by competent person

•This equipment must be connected to an all pole isolator of the correct rating

•Disconnect the power supply before exposing electrical connections

•All heaters can be connected single phase(230v) or triple phase(400v), this can be easily changed by

adding bridge connectors across the connections L1, L2 and L3.

•5 core silicon bound heat proof cable must be used to wire from the control to the heater. (For 230v and

400v) Wire the letters with the corresponding letters on the heater. For example: U V W on the control

go to U V W on the heater, the three lives for the elements, the reason for having three is because each

element is controlled individually. When the heater reaches the desired temp it cuts out two elements.

•The sauna heater should not be used for any other purpose

•Do not cover the heater or allow contact with flammable materials such as toweling – Risk of fire.

•Do not operate sauna heater without sauna stone

•Do not touch the heater when operational as it is very hot

•Sauna heater must have right earth connection, the earth wire should be bigger than the power supply

wire to sauna heater

•The sauna controller should be installed on a dry wall outside the sauna cabin

Oceanic Sauna Heater

SAFETY PRECAUTIONS FOR SAUNA

•Elderly persons, pregnant women, or these suffering heart disease, high blood pressure, diabetes or

not in good health are advised to seek medical opinion before using a sauna room;

•Do not smoke in the sauna room;

•Avoid using the sauna room immediately after strenuous exercise;

•Do not use the sauna room when under the influence of alcohol;

•Leave the sauna room at once if you feel sleepy, sick or uncomfortable;

•Ensure there is good ventilation for the sauna room

•We do not recommend this product is used by children under 16 years old;

•Commercial operators should post a notice of these precautions in a prominent position

•The sauna controller should be installed on a dry wall outside the sauna cabin

Oceanic Sauna Heater

Simple Diagram

Oceanic Sauna Heater

Chapter One: Specification

1. Parameter and size of sauna heater (chart 1)

Chart 1

Model

Power Input Size (mm) Heat

element

quantity

Sauna

stone

(Kg)

(Kw) 1N~ 3N~ L W H

0CS30 3.0 230V 410 280 570 2 12-14

0CS40 4.0 230V 410 280 570 2 13-15

OCS45 4.5 230V 400 410 280 570 3 14-16

OCS60 6.0 230V 400 410 280 570 3 16-18

OCS80 8.0 230V 400 410 280 570 3 18-20

OCS90 9.0 230V 400 410 280 570 3 18-20

2. Parameter and size of OC-SA controller (chart 2)

Chart 2

Model Input Output Load power Size (mm)

1N~ 3N~ 1N~ 3N~ (Kw) L W H

OC-SA I 230V

230V

3~4 248 217 78

OC-SA II 230V

400V

230V

400V 4.5~9 280 217 78

3. Parameter and size of temperature sensor (chart 3)

Chart 3

Model Detected scope Cut off on high temperature Size (mm)

F L W H

OC-S 0~110 32~230 120 248 76 42 27

4. Circuit Diagram for sauna heater and controller

i. Sauna heater circuit diagram (Fig 1)

(Fig 1)

OC30~OC40 Circuit diagram OC45~OC90 Circuit diagram

Oceanic Sauna Heater

ii. Circuit Diagram for controller (Fig2, Fig3)

(Fig 2)

(Fig3)

Oceanic Sauna Heater

Chapter Two: frame and functions

1. Sauna heater frame and parts

(1) Sauna heater frame (Fig 4)

(Fig 4)

(2) Parts Chart 4

No. Parts

1 Inner shell

2 Stone bracket

3 Shell

4 Heat element

5 Fix bracket

6 Cover Panel

7 Terminal

Oceanic Sauna Heater

2. Controller frame and parts

•Controller frame (Fig 5)

(Fig 5)

•Keys and LED instruction (Chart 5)

Chart 5

No. Parts Description

1 High1 LED Indicator LED on when sauna over heats (serious hazard)

(Reset Manually)

2 Wait LED Indicator LED when timer is on (B Model)

3 High Heat 2 Only for use in U.S.A, ignore if it doesn’t apply to you.

4 Heating LED Indicator LED on when heating

5 Heat preservation LED Indicator LED for Heat preservation (one element remains

on)

6 A model LED Indicator LED for A model when heater is on

7 B model LED Indicator LED B model, means sauna heater is a timer

8 Light LED Indicator LED when lamp is on in sauna room

9 Temp display windows Displays the temperature of sauna room

10 Time display window Displays the time remaining for the timer or heating.

Time Increase button

“▲” Increase button

12 Time decrease button or

“▼” Decrease button

13 Model switch button Switch between timer and heating program

C /

F button Switch the temperature display between centigrade and

Fahrenheit

15 Light Push for a few seconds to turn on the light in sauna room

16 ON/OFF Push to turn the heater On or Off

17 Temp Increase button

“▲” Increase button

18 Temp decrease button

“▼” Decrease button

19 Controller shell Protects the electronics from damage or users injury.

Oceanic Sauna Heater

3.Temp sensor frame and parts

•Temp sensor frame (Fig 6)

(Fig6)

•Temp sensor instruction (chart 6)

Chart 6

No. Parts Description

1 Circuit board Circuit board

2 Bracket Bracket

3 Cover Protects the electronics

4 Heat resistance Detects temperature

5 High Temp cut of switch When temperature in sauna room exceed 120

C or 248

Oceanic Sauna Heater

Chapter Three: installation

1. Important

•Confirm the model you have selected is suitable for your sauna room, please refer to chart 7

•Ensure the power supply is suitable for the sauna heater

•Isolate the power supply before installation

•The installation position must comply with the minimum distance in chart 7; also consider the safety

and convenience (chart 8)

•The minimum height of your sauna room must be 1900mm, please refer fig 7C

•Do not install the sauna heater on the floor or in a cabinet

•Do not cover the sauna heater back with asbestos cement or similar material

•The wire which enters the sauna room must be type 60245 IEC 66 HO7RN-F (BSEN 6141) please

refer to chart 7

•Do not install two or more sauna heaters in one sauna room.

•The sauna heater becomes very hot when operating and must be guarded to protect incase of

accidental contact, please see the sizes in fig 7D and also refer to charts 7 & 8

•The upper supporting screws must be fixed tightly, there is a 3mm gap between the screw head and

wall (refer fig 4A, fig 4B), additional retaining screws should be inserted into the round holes to prevent

the heater being lifted.

•The sauna controller should be installed on a dry wall outside the sauna cabin

•The controller should be kept at a height of between 1200MM-1500MM so that it is easily controlled

and operated

•Temperature sensors should be installed in sauna room but not directly above sauna heater, the height

should be 1500-1800mm from floor. The horizontal distance to sauna heater should exceed 500mm

Oceanic Sauna Heater

Chart 7

Model

Sauna room Min distance from sauna

heater to (mm) Current (A) Fuse (A)

Volume

) Min

height

(Mm)

Distance to

shelf over

500mm

above the

floor

Ceiling

Floor

230V

1N~ 400V

3N~ 230V

1N~ 400V

3N~

Min Max

0CS30 2 4 1900 50 1100 180 13 20

0CS40 3 5 1900 50 1100 180 17 25

OCS45

4 6 1900 80 1100 180 19.5 6.5 25 10

OCS60

5 8 1900 150 1100 180 27 9 40 16

OCS80

7 11 1900 200 1100 180 35 12 60 20

OCS90

8 12 1900 200 1100 180 39 13 60 20

Fig 7A fig 7B fig 7C

OCS90

OCS80

OCS45

OCS60

OCS40

OCS30

4 5

2 31

C D

50 70 280 100

1002807050

150130 290 200

120100 280 150

10080 280 100

200290130 150

Model Min distance

（

mm)

、

Cover panel

、

entry and wire

anchorage

、

power supply

、

Juction box

、

conducting wire

、

controller

、

lamp

Fig 7D chart 8 fig 8

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Oceanic Heizung Handbücher

Oceanic

Oceanic OCEAISH1000W3 Bedienungsanleitung

Oceanic

Oceanic OCEABH1500W2 Bedienungsanleitung

Oceanic

Oceanic C75-5 Bedienungsanleitung

Oceanic

Oceanic OCEACV130S6 Bedienungsanleitung

Oceanic

Oceanic BIC Series Gebrauchsanweisung

Oceanic

Oceanic Apollo Gebrauchsanweisung

Oceanic

Oceanic OCEAISHGB1000W2 Bedienungsanleitung

Oceanic

Oceanic OCEASFC1800W2 Bedienungsanleitung

Oceanic

Oceanic OCEASF2000W4 Bedienungsanleitung

Oceanic

Oceanic OC-Mini-1 Bedienungsanleitung

Oceanic

Oceanic OCEACV130T6 Bedienungsanleitung

Oceanic

Oceanic OCEASFC1800W Bedienungsanleitung

Oceanic

Oceanic OCEABH1500W Bedienungsanleitung

Oceanic

Oceanic OCEAIFC1000W Bedienungsanleitung

Oceanic

Oceanic HT10BJ Bedienungsanleitung

Oceanic

Oceanic SPG05B-20E2 Bedienungsanleitung

Oceanic

Oceanic OCEACV100IFW2 Bedienungsanleitung

Oceanic

Oceanic OCEAISHFT1000W Bedienungsanleitung

Oceanic

Oceanic OCEACV2000 Bedienungsanleitung

Oceanic

Oceanic OCS B Series Gebrauchsanweisung

Oceanic

Oceanic Apollo Gebrauchsanweisung

Oceanic

Oceanic BIC Series Gebrauchsanweisung

Oceanic

Oceanic OCS30 Gebrauchsanweisung

Oceanic

Oceanic OCEASF2000 Bedienungsanleitung

Beliebte Heizung Handbücher anderer Marken

oventrop

oventrop Regucor Series Bedienungsanleitung

Blaze King

Blaze King CLARITY CL2118.IPI.1 Bedienungsanleitung

ELMEKO

ELMEKO ML 150 Bedienungsanleitung

BN Thermic

BN Thermic 830T Bedienungsanleitung

KING

KING K Series Leitfaden

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Kurzanleitung

Well Straler

Well Straler RC-16B Bedienungsanleitung

EUROM

EUROM 333299 Bedienungsanleitung

Heylo

Heylo K 170 Bedienungsanleitung

Eterna

Eterna TR70W Bedienungsanleitung

Clarke

Clarke GRH15 Bedienungsanleitung

IRSAP

IRSAP The Radiator Company Ovali Bedienungsanleitung

Empire Heating Systems

Empire Heating Systems WCC65 Bedienungsanleitung

Wetekom

Wetekom 92 86 43 Bedienungsanleitung

Desa

Desa SPC170-F Bedienungsanleitung

Watlow

Watlow Watrod Electric Tubular Heaters Bedienungsanleitung

Haverland

Haverland ECO-DRY GPS Series Stücklistenhandbuch

Stelpro

Stelpro ASILVC2060 Series Bedienungsanleitung