Pacific Living PL8304SS Bedienungsanleitung

MODEL: PL8304SS / PL8BLK - Outdoor Pizza Oven without cart

ASSEMBLY AND OPERATING INSTRUCTIONS

1. This is instruction manual contains important information necessary for the proper

assembly and safe use of the appliance.

2. Read and follow all warnings and instructions before assembling and using the appliance.

3. Follow all warnings and instructions when using the appliance.

4. Keep this manual for future reference.

Note to installer: Leave this Owner’s Manual with the consumer after delivery and\or installation.

Note to customer: Leave this Owner’s Manual in a convenient place for future reference.

1. Do not store or use gasoline or other

flammable liquids or vapors in the vicinity of

this or any other appliance.

2. An LP cylinder not connected for use should

not be stored in the vicinity of this or any other

appliance.

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. Open oven door.

4. If odor continues, keep away from the

appliance and immediately call your gas

supplier or your fire department.

Failure to follow these instructions could

result in fire, explosion or burn hazard, which

could cause property damage, personal

injury or death.

△

!WARNING: FOR OUTDOOR USE ONLY

△

!DANGER

△

!DANGER

1. Never operate this appliance unattended.

2. Never operate this appliance within 10 feet (3.05m) of any other gas cylinder.

3. Never operate this appliance with 25 feet (7.5m) of any flammable liquid.

4. If a fire should occur, keep away from the appliance and immediately call your fire

department. Do not attempt to extinguish an oil or grease fire with water.

5. Heated liquids remain at scalding temperatures long after the cooking process. Never touch

cooking appliance until liquids have cooled to 115oF (45oC) or less.

Failure to follow these instructions could result in fire, explosion or burn hazard, which could

cause property damage, personal injury or death.

△

!DANGER

1. Warning and Safety Information 3

2. Illustrated Parts List 6

3. Hardware Pack Contents 7

4. Exploded View 8

5. Assembly Instructions 9

6. LP Gas Assembly 11

7. Natural Gas Conversion Instructions 16

8. Operating Instructions 22

9. Care and Maintenance 24

10. Troubleshooting 31

11. Warranty 33

Table of Contents

If these instructions are ignored, there is a possibility of a hazardous fire or explosion which could result in

physical in injury or property damages! It is your responsibility to assemble, operate and maintain your gas

grill properly.

READ ALL WARNINGS AND INSTRUCTIONS PRIOR TO ASSEMBLING AND OPERATING YOUR

GRILL

△

!The installation of this appliance must conform with local codes or, in the absence of local codes, with

the National Fuel Gas Code. ANSI Z223.1/NFPA 54, storage and handling of Liquefied Petroleum Gases.

ANSI/NFPA 58; Or Natural Gas and Propane Installation Code, CSA B149.1; Propane Storage and

Handling. CSA B149.2.

△

!This oven is intended for use outdoors and should not be used in a building, garage or any other

enclosed or covered area.

△

!This outdoor oven is not intended for installation in or on recreation vehicles and/or boats.

△

!A minimum clearance of 61 cm (24 inches) from combustible constructions to the sides of the grill and

61 cm (24 inches) from the back of the grill to combustible constructions must be maintained. This outdoor

cooking gas appliance must not be placed under overhead combustible construction.

△

!The use of an electrical source requires that when installed, the grill must be electrically grounded in

accordance with local codes or, in the absence of local codes, with ANSI/NFPA 89, or the Canadian

Electrical Code, CSA C22.1. Keep electrical supply cords and the fuel supply hose away from heated

surfaces.

△

!Inspect the hoses before each use for excessive abrasion or wear, or cuts that may affect safe

operation of the grill. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be

replaced prior to the grill being put into operation. The replacement hose assembly must be those specified

by the manufacturer.

△

!Keep your oven in an area clear and free from combustible materials, gasoline and other flammable

vapors and liquids.

△

!DO NOT obstruct the flow of combustion and ventilation air to this appliance.

△

!Keep the ventilation openings of the tank enclosure free and clear from debris.

△

!Check all gas connections for leaks with a soapy water solution and brush. Never use an open flame to

check for leaks.

△

!Never use charcoal in the oven.

1. Warnings and Safety Instructions

WARNINGS:

△

!Never use the grill in windy areas.

△

!Only a 9 kg (20 lb.) LP-gas cylinder is allowed. The cylinder must

be constructed and marked in accordance with the Specifications for

LP Gas Cylinders of the U.S. Department of Transportation (D.O.T.) or

the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres

and Tubes for Transportation of Dangerous Goods. A9 kg

(20 lb.) LP-Gas cylinder’s dimensions are:

△

!Never use the grill without the drip tray installed and hung under the

burner box. Without the drip tray, hot grease and debris could leak downward and produce a fire hazard.

△

!Use only the gas pressure regulator supplied with this appliance. This regulator is set for an outlet

pressure of 11.0 WC.

△

!The cylinder used must include a collar to protect the cylinder valve.

△

!Do not store a spare LP-gas cylinder under or near the appliance.

△

!Never fill the cylinder beyond 80 percent full.

△

!If the information in “17” and “18” is not followed exactly, a fire causing death or serious injury may

occur.

△

!The outdoor cooking gas appliance must be isolated from the gas supply piping system by closing its

individual manual shutoff valve during any pressure testing of the gas supply system at test pressures

equal to or less than 1/2 psi (3.5 kPa).

△

!CALIFORNIA PROPOSITION 65 WARNING: The burning of gas cooking fuel generates some

byproducts that are on the list of substances known by the State of California to cause cancer, reproductive

harm, or other birth defects. To reduce exposure to these substances, always operate this unit according to

the use and care manual, ensuring you provide good ventilation when cooking with gas.

△

!This appliance is not intended for commercial use.

△

!The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly

assemble or safely operate the appliance.

△

!Do not leave the appliance unattended. Keep children and pets away from the appliance at all times.

△

!This appliance is not intended for and should never be used as a heater.

△

!This appliance will be hot during and after use. Use insulated oven mitts or gloves for protection from

hot surfaces or splatter from cooking liquids.

We urge you to read this manual carefully and follow the recommendations enclosed. This will ensure you

receive the most enjoyable and trouble-free operation of your new gas grill. We also advise you retain this

manual for future reference.

Your grill has been designed to operate using only the gas specified by the manufacturer on the rating plate.

Do not attempt to operate your grill on other gases. Failure to follow this warning could lead to a fire hazard

and bodily harm and will void your warranty.

Make certain your LP (propane) tank is filled by a reputable propane dealer. An incorrectly filled or an

overfilled LP tank can be dangerous. The overfilled condition combined with the warming of the LP tank (a

hot summer day, tank left in the sun, etc.) can cause LP gas to be released by the pressure relief valve on

the tank since the temperature increase causes the propane to expand. LP gas released from the tank is

flammable and can be explosive. Refer to your Owner’s Manual for more information concerning filling your

LP tank.

IMPORTANT!

WARNING

Part Number

Description

QTY

Oven Body

Smoker box

Cooking Grate

Pizza Stone

Bottom Grill

Flame Tamer

Drip Tray

Control Knob

PVC Feet

Manifold and Regulator

2. Illustrated Parts List

The following list is included inside the pizza oven carton:

The following list is included inside the pizza oven carton, and needed when the user is assembling the

pizza oven.

Phillips Head

Screwdriver 1 pc

The following list is included inside the pizza oven carton EXCEPT for the Natural Gas Hose** This can be

purchased separately from Pacific Living. It is needed when the gas type is changed from LP to NG.

11X11 mm Wrench

1 pc

Orifice Removal

Tool

1 pc

Phillips Head Screwdriver

1 pc

Conversion Screw

1 pc

φ1.80 Orifice

1 pc

17X19 mm Wrench

1 pc

Natural Gas Hose **

1pc

3. Hardware Pack Contents

Battery 1 pc

No.

Part Name

QTY

No.

Part Name

QTY

Heat Shield Pipe

Round Temp. Gauge

Oven Back heat Shield

Left Glass Fixing Bracket

Light Assembly

Control Panel

Handle buckle

Knob Bezel Assembly

Gas Pipe

Control Knob

Chimney Assembly

Light Switch

Cooking Grate

Oven Door Assembly

Smoker Box

Oven Door Hinge

Pizza Stone

Glass Pressing

Bottom Grill

Oven Left Supporting Assembly

Oven Interior Assembly

Drip Tray Left Support Bracket

Ignition Pin

Oven Back Panel

Round Burner Assembly

Drip Tray Right Support Bracket

Oven Exterior

Oven Right Bracket Assembly.

Fascia heat shield

Manifold and Regulator

Oven Front Panel

Ignition Rod Assembly

Rear Panel

Rail Support

Electronic igniter

Two Globular Guide Rail

Orifice Holder

Drawer fascia

Thermocouple

Door Handle

Valve Assembly

Drawer

Viewing window

Drawer Interior Panel

Door Handle Assembly

Drip Tray

Door Heat Shield Assembly

Oven Supporting Beam

Right Glass Fixing Bracket

Flame Tamer Assembly

Glass Fixing Bracket

PVC Feet

4. Exploded View

Before beginning assembly of product, make sure all parts are present. Compare parts with package

contents list and hardware contents list. If any part is missing or damaged, do not attempt to assemble the

product.

Step 1：

Feet Assembly

Attach 4pcs M5*30 Cross recessed cheese head

screws and 4pcs PVC feet (Part I) and 4pcs washer

to the oven bottom as shown. Horizontally place

washers first, then use the screws going through the

PVC feet and washers.

Step 2：

Chimney Assembly

Secure chimney using 3 M4*8 Eleven word trough

pan head screws as shown.

Step 3：

Rear Panel Assembly

Secure rear panel using 4pcs heat shield pipe, 4pcs

M5*35 Cross recessed pan head screw and 4pcs

washer.

5. Assembly Instructions

Step 4：

Oven Body Assembly

Install Cooking Grate (Part C), bottom grill (Part

E), a knob, Pizza Stone (Part D), Smoker Box

(Part B)and Drip Tray (Part G) as shown.

Step 5：

Your complete pizza oven is now assembled.

Andere Handbücher für PL8304SS

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Pacific Living Küchengerät Handbücher

Pacific Living

Pacific Living PL8430SSBG070 Bedienungsanleitung

Beliebte Küchengerät Handbücher anderer Marken

Tayama

Tayama TYG-35AF Bedienungsanleitung

AEG

AEG 43172V-MN Bedienungsanleitung

REBER

REBER Professional 40 Benutzerhandbuch

North American

North American BB12482G / TR-F-04-B-NCT-1 Bedienungsanleitung

Presto

Presto fountain popper Bedienungsanleitung

Westmark

Westmark 1035 2260 Bedienungsanleitung

Zanussi

Zanussi ZCG64396XA Bedienungsanleitung

HOFFEN

HOFFEN SM-9302M Bedienungsanleitung

Philips

Philips HD3133 Bedienungsanleitung

Ronco

Ronco Beef Jerky Bedienungsanleitung

Hendi

Hendi 470411 Bedienungsanleitung

Livoo

Livoo MEN386 Bedienungsanleitung

Vogue

Vogue D446 Bedienungsanleitung

croydon

croydon WR-10313-700 Bedienungsanleitung

ADE

ADE AUTOMATIC-L Bedienungsanleitung

Chefman

Chefman RJ43-SQ Series Bedienungsanleitung

Vacmaster

Vacmaster VP680 Bedienungsanleitung

Jetmaster

Jetmaster 900HG Bedienungsanleitung