Panasonic NN-GS595A Bedienungsanleitung

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

1/3

ORDERNO.PHAMOS0511035C3

MicrowaveOven

NNGS595A

CHP(HongKong)

CYP(Singapore)

CMP(Malaysia)

CTP(Thailand,Indonesia)

CYT(Others)

CKT(UAE)

CPT(Iran)

CKP(Kuwait,Doha,Qatar,Oman,Bahrain,Pakistan)

CZP(CISCountries)

©2005PanasonicHomeAppliancesMicrowaveOven(Shanghai)Co.,Ltd.

Allrightsreserved.Unauthorizedcopyinganddistributionisaviolationoflaw.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

2/3

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

3/3

10/24/2016 schemat1.png(540×753)

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/doc/…

1/1

10/24/2016 schemat2.png(540×753)

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/doc/…

1/1

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

1/3

2DESCRIPTIONOFOPERATING

SEQUENCE

2.1Variablepowercookingcontrol

HighVoltageInverterPowerSupply(U)controlsoutputpowerbythesignalfromDigitalProgrammerCircuit(DPC).Powerrelay

alwaysstaysON,butPWM(pulsewidthmodulation)signalcontrolsmicrowaveoutputpower.

NOTE:

TheON/OFFtimeratiodoesnotcorrespondwiththepercentageofmicrowavepowersinceapproximately2secondsare

requiredforheatingofmagnetronfilament.

VariablePowerCooking

POWER SETTING OUTPUTPOWER(%) APPROX. MANUALMICROWAVEDUTY

ON(SEC) OFF(SEC)

HIGH 100% 22 0

MEDIUMHIGH 70% 22 0

MEDIUM 55% 22 0

MEDIUMLOW 40% 22 0

LOW 20% 13 9

DEFROST 30% 17 5

2.2InverterpowersupplycircuitNEWH.V.

TheInverterPowerSupplycircuitpoweredfromthelinevoltage,220V50HzACinputsupplies4,000VDCtothemagnetrontube,

andfunctionsinplaceoftheH.V.transformer,theH.V.capacitorandH.V.diode.

1.TheACinputvoltage220240V50HzisrectifiedtoDCvoltageimmediately.

2.DCvoltagewillbesuppliedtotheswitchingdevicescalledIGBT.ThesedevicesareswitchedONOFFbythe20to40

KHzPWM(pulsewidthmodulation)signalfromthemicrocomputerintheDPC.

3.ThisdrivestheHighvoltagetransformertoincreasevoltageupto2,000VAC.

4.Thenthehalfwavedoublervoltagerectifiercircuit,consistingoftheH.V.diodesandcapacitors,generatesthe

necessary4,000VDCneededforthemagnetron.

5.Outputpowerofthemagnetrontubeisalwaysmonitoredbythesignaloutputfromthecurrenttransformerbuiltintothe

invertercircuit.

6.ThissignalisfedbacktothemicrocomputerintheDPCtodetermineoperatingconditionsandoutputnecessaryto

controlPWMsignaltotheInverterPowerSupplyforcontroloftheoutputpower.

2.3Steamdefrost,Autocook&Steamreheat

WhentheAutoControlfeatureisselectedandtheStartpadistapped:

1.Thedigitalprogramercircuitdeterminesthepowerlevelandcookingtimetocompletecookingandindicatesthe

operatingstateinthedisplaywindow.Tableshowsthecorrespondingcookingtimesforrespectiveservingby

categories.

SteamDefrost

SELECTEDWEIGHT COOKINGTIME

1.0kg 15min.20sec.

AutoCook(Rice)

SELECTEDWEIGHT COOKINGTIME

0.2kg 20min.00sec.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

2/3

2.Whencookingtimeinthedisplaywindowhaselapsed,theoventurnsoffautomaticallybyacontrolsignalfromthe

digitalprogrammercircuit.

2.4Oven

ThedigitalprogrammercircuitcontrolstheONOFFtimeoftheheaterinordertocontrolovencavitytemperature.

1.Afterselectingdesiredovencavitytemperatureandpressing[Start]pad,ahighlevelsignalcomesoutmicrocomputer

andappliestopowerrelays,RY4andRY5.

2.WhenRY4&RY5switchtoON,powersourcevoltageisappliedtotheupperandlowerheaters,andtheheatersturn

on.

3.Thedigitalprogrammercircuitsensestheovencavitytemperaturethroughoventempsensor(thermistor).Whenthe

oventemperaturereachesthesettemperature,DPCstopssupplyinghighlevelsignaltothepowerrelays,andthe

heatersturnoff.

4.Aftertheupperandlowerheatersturnoff,theoventemperaturewillcontinueincreasingforawhileandthendecrease

asshowninFigure.

Whentheoventemperaturedropsbelowthesettemperature,thedigitalprogrammercircuitsensesthesignaland

startssupplyingahighlevelsignaltopowerrelaysagain.

2.5Combinationcookcontrol

Combinationcookingisaccomplishedbymicrowaveandgrillcooking(upperheater)beingdonesynchronouslyduringone

combinationcookingcycle.Onecombinationcookingcycleis33seconds.

1.Duringcombinationcooking,thedigitalprogrammercircuitcontrolspowerrelayRY4&RY5ʼsONOFFtime.Inallthree

combinationcookingcategories,powerrelayRY1alwaysstayon,butRY5ʼsONOFFtimeasshowninFigure.

COMBINATION CATEGORY GRILL(RY5) MICROWAVE(RY1)

ON(sec.) OFF(sec.)

COMBINATION CATEGORY GRILL(RY5) MICROWAVE(RY1)

ON(sec.) OFF(sec.)

1 33 0 ON

2 24 9 ON

3 18 15 ON

2.6IRreheat

Thetemperatureoffoodbeingheatedisdetectedbyaninfrared(IR)sensorandyoudonothavetosettime.

2.6.1HowtoreadtemperaturebyIRsensor

IRsensorcanreadfoodtemperaturewithouttouching,IRraysareemittedfromfood.IRsensoristogeneratetemperaturerelated

electricsignaloutputandmicrocomputeristoconvertactualtemperature.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

3/3

2.6.2Operation

IRsensorismountedontoprightofovencavitythroughthehole.Itscansallovercookingshelf.IRsensorhas8eyesandcanread

ovenshelflefttorightatthetime.ThenIRsensorisdesignedtoscanfronttobacktocoverallovershelf.(19points)



2.7Steamfunction(microsteam&steamreheat)

2.7.1WaterSupply

Waterinwatertankwillbepumpedoutandsupplytothesteamgenerationheaterlocatedinsidebackbottomofovencavity.

2.7.2Operation

Whenpressing[start]pad,ovenpreheatwillstartandthenwatersupplybegins.Itwilltake1minuteforpreheating.Whenpreheatis

completed,itwillturnintoactualcookingprocess.Duringheating,thetemperaturesensor(Thermistor)locatedonsteamheaterwill

monitorsteamheatertemperatureandwhenitexceeds95°C,theadditionalwaterwillbesuppliedtomaintainmoisture/steam

withinovencavity.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

1/3

3CAUTIONSTOBEOBSERVEDWHEN

TROUBLESHOOTING

Unlikemanyotherappliances,themicrowaveovenisahighvoltage,highcurrentdevice.Itisfreefromdangerinordinaryuse,

thoughextremecareshouldbetakenduringrepair.

Caution

Servicemenshouldremovetheirwatcheswheneverworkingclosetoorreplacingthemagnetron.

3.1Checkthegrounding

Donotoperateonatwowireextensioncord.Themicrowaveovenisdesignedtobegroundedwhenused.Itisimperative,

therefore,toensuretheapplianceisproperlygroundedbeforebeginningrepairwork.

3.2Inverterwarnings

DANGER,HIGHVOLTAGEANDHIGHTEMPERATURE(HOT/LIVE)OFTHEINVERTERPOWERSUPPLY(U)

TheHighVoltageInverterPowerSupplyhandlesveryhighvoltageandcurrentforthemagnetrontube.Thoughitisfreefrom

dangerinordinaryuse,extremecareshouldbetakenduringrepair.

Thealuminumheatsinkisalsoenergizedwithhighvoltage(HOT),donottouchwhentheACinputterminalsareenergized.The

powerdeviceCollectorisdirectlyconnectedtothealuminumheatsink.

ThealuminumheatsinkmaybeHOTduetoheatenergy,therefore,extremecareshouldbetakenduringservicing.

H.V.Inverterwarning

WARNINGFORINVERTERPOWERSUPPLY(U)GROUNDING

ChecktheHighVoltageInverterPowerSupplycircuitgrounding.Thehighvoltageinverterpowersupplycircuitboardmusthavea

properchassisground.Theinvertergroundingbracketmustbeconnectedtothechassis.Iftheinverterboardisnotgroundeditwill

exposetheusertoveryhighvoltagesandcauseextremeDANGER!Besurethattheinvertercircuitisproperlygroundedviathe

invertergroundingbracket.

10/24/2016 XMLServiceManual

file:///C:/Users/sh.dehghani/Desktop/NNGS595AOTSVC_PHAMOS0511035C3/viewing/SGML_VIEW_DATA/OT/NNGS595A/SVC/PHAMOS0511035C3/inde…

2/3

Groundingoftheinvertercircuitboard

WARNING!DISCHARGETHEHIGHVOLATGECAPACITORS

Forabout30secondsaftertheovenisturnedoff,anelectricchargeremainsinthehighvoltagecapacitorsintheInverterPower

Supplycircuitboard.

Whenreplacingorcheckingparts,removethepowerplugfromtheoutletandshorttheinverteroutputterminalofthemagnetron

filamentterminalstothechassisgroundwithaninsulatedhandlescrewdrivertodischarge.Pleasebesuretotouchthechassis

groundsidefirstandthenshorttotheoutputterminals.

Dischargingthehighvoltagecapacitors

WARNING

Thereishighvoltagepresentwithhighcurrentcapabilitiesinthecircuitsoftheprimaryandsecondarywindings,chokecoiland

heatsinkoftheinverter.Itisextremelydangeroustoworkonornearthesecircuitswiththeovenenergized.DONOTmeasurethe

voltageinthehighvoltagecircuitincludingthefilamentvoltageofthemagnetron.

WARNING

Nevertouchanycircuitwiringwithyourhandorwithaninsulatedtoolduringoperation.

3.3Partreplacement

Whenanypartorcomponentistobereplaced,alwaysensurethatthepowercordisremovedfromthewalloutlet.

3.4Whenthe10Afuseisblownduetotheoperationof

theshortswitch

WARNING

Whenthe10A220Vfuseisblownduetotheoperationoftheinterlockmonitorswitch,replaceallofthecomponents(primarylatch

switch,shortswitchandpowerrelayB(RY1)).

1.Thisismandatory.Referto“adjustmentsandmeasurements”forthelocationoftheseswitches.

2.Whenreplacingthefuse,confirmthatithastheappropriateratingforthesemodels.

Inhaltsverzeichnis

Andere Panasonic Mikrowellenofen Handbücher

Panasonic

Panasonic NN-S960BA Bedienungsanleitung

Panasonic

Panasonic NN-ST25JW Bedienungsanleitung

Panasonic

Panasonic NE-1853 Bedienungsanleitung

Panasonic

Panasonic NN-D851 Bedienungsanleitung

Panasonic

Panasonic NN-CD767MBPQ Produkthandbuch

Panasonic

Panasonic NN-K189M Produkthandbuch

Panasonic

Panasonic NN-SD466 Gebrauchs- und Pflegehandbuch

Panasonic

Panasonic NN-V359WB Bedienungsanleitung

Panasonic

Panasonic NE-9930 Bedienungsanleitung

Panasonic

Panasonic NN-CF873S Bedienungsanleitung

Panasonic

Panasonic NN-S553WF Handbuch

Panasonic

Panasonic NN-SM332M/W Betriebsanleitung

Panasonic

Panasonic Cyclonic Inverter NN-ST975S Bedienungsanleitung

Panasonic

Panasonic NE1257R - COMMERCIAL MICROWAVE OVEN Bedienungsanleitung

Panasonic

Panasonic NE-1252 Bedienungsanleitung

Panasonic

Panasonic NN-GT264MZPE Bedienungsanleitung

Panasonic

Panasonic NN-CT870S Bedienungsanleitung

Panasonic

Panasonic NN-CD550W Bedienungsanleitung

Panasonic

Panasonic Genius NN-SN660S Bedienungsanleitung

Panasonic

Panasonic NN-S592SF Bedienungsanleitung

Panasonic

Panasonic NN-CT559W Produkthandbuch

Panasonic

Panasonic NN-MX26 Bedienungsanleitung

Panasonic

Panasonic NN-S512 Bedienungsanleitung

Panasonic

Panasonic NN-S262SF APH Bedienungsanleitung

Beliebte Mikrowellenofen Handbücher anderer Marken

Daewoo

Daewoo KOG-574R0S Bedienungsanleitung

LG MH7040SS Bedienungsanleitung

Sharp

Sharp R-895(AL)M Bedienungsanleitung

Dometic

Dometic DOTRM13W Bedienungsanleitung

Sanyo

Sanyo EM-X680 Bedienungsanleitung

Sharp

Sharp R-393M Bedienungsanleitung

KitchenAid

KitchenAid KMCX4510 Montageanleitung

Smeg

Smeg S45MCX1 Bedienungsanleitung

Russell Hobbs

Russell Hobbs RHM2044 Bedienungsanleitung

Sunbeam

Sunbeam SMW759 Bedienungsanleitung

Gallet

Gallet FMOE230S Bedienungsanleitung

Bosch

Bosch CEG732X.1B Bedienungsanleitung

Dometic

Dometic Roadmate 230 Bedienungsanleitung

Samsung

Samsung SJ0396W Bedienungsanleitung

Sanyo

Sanyo EM-P494WS Bedienungsanleitung

Sharp

Sharp R-240 Bedienungsanleitung

Electrolux

Electrolux EMS2840 Bedienungsanleitung

Daewoo

Daewoo KOC-984T2S13 Bedienungsanleitung