Panasonic SRTEG10 - RICE COOKER - MULTI LANGUAGE Bedienungsanleitung

Order No. PHAT060512C3

(REVISION : NOV. 2013)

Service Manual

Electric Rice Cooker

SR-TEG10

SR-TEG18

distribution is a violation of law.

There are special components used in this equipment which are important for safety. These parts are marked by

in the Schematic Diagrams, Circuit Board Diagrams, Exploded Views and Replacement Parts List. It is essential that

these critical parts should be replaced with manufacturer’s specified parts to prevent shock, fire or other hazards. Do

not modify the original design without permission of manufacturer.

IMPORTANT SAFETY NOTICE

The service information is designed for experienced repair technicians only and is not designed for use by the general

public. It does not contain warnings or cautions to advise non-technical individuals of potential dangers in attempting

to service a product. Products powered by electricity should be serviced or repaired only by experienced professional

technicians. Any attempt to service or repair the product or products dealt within this service information by anyone

else could result in serious injury or death.

WARNING

Destination

Malaysia

Product Colour

Soft Pink (SP)

Harmony Orchid (HO)

Platinum Silver (PS)

Champagne Gold (CN)

- 2 -

CONTENT

Page

6 - 7

13 - 14

1. Specification

2. Parts Identification

3. Schematic Diagram

3.1 Circuit Diagram

3.2 Wiring Diagram

4. Troubleshooting Guide

5. Testing Procedure

5.1 Bubbling Test

5.2 Evaporation Test

5.3 Heat reserving Test

5.4 Boiling control lever adjustment

6. Disassembly

6.1 Hinge cover removal

6.2 Inner enclosure and Upper frame removal

7. Parts Exploded View and Replacement Parts List

7.1 Parts Exploded View : Body

7.2 Parts Exploded View : Packing

7.3 Replacement Parts List : SR-TEG10 / SR-TEG18

Detail Change Notice

SR-TEG10 / SR-TEG18

- 3 -

1. SPECIFICATION

MODEL

Destination

SR-TEG10 SR-TEG18

Malaysia

Plug S3P

Power Supply

Power Consumption

Cooking Capacity

Product Dimension

Keeping Warm

240V / 50Hz

1.0 m

134°C + 6°C

142°C

Steaming basket, Scoop, Measuring cup

32W 33W

Cooking

White Rice

450W 630W

Width

Power Cord

Center Thermostat Working Temperature

Thermal Fuse Specification

Weight (Approx.)

Accessories

* Specification subject to change without notice.

Length

1 ~ 5 cups 3 ~ 10 cups

Depth

248 mm 276 mm

Height

274 mm 274 mm

275 mm 275 mm

2.5 Kgs. 3.1 Kgs.

SR-TEG10 / SR-TEG18

- 4 -

2. PARTS IDENTIFICATION

Accessories

Steaming basketRice scoopMeasuring cup

(Approx 180 ml)

SR-TEG10 / SR-TEG18

Cook lamp

Warm lamp

Switch

- 5 -

3. SCHEMATIC DIAGRAM

3.1 Circuit Diagram

3.2 Wiring Diagram

BlackBlack

Thermal

Fuse

Power

Black

Red

Micro Switch Orange

(White : 18/Yellow : 10)

EGreen

Rice Cook

Lamp

Keep Warm

Lamp

Side

Heater

Cast

Heater

Thermal

Fuse

SR-TEG10 / SR-TEG18

Thermal Fuse Lead

Wire B (Black)

Lamp Lead Wire B

(White : 18 / Yellow : 10)

Body Earth Lead Wire (Green)

To inlet

Side Heater Lead

Wire A (Red)

Lamp Lead Wire C (Red)

Thermal Fuse Lead Wire A (Black)

Lamp Lead Wire A (Black)

Lamp Lead Wire C (Red)

Lamp Lead Wire B (White)

Side Heater Lead Wire

B (Orange)

Rice Cooking Lever

- 6 -

4. TROUBLESHOOTING GUIDE

Condition

Rice boiling section

• Rice is not boiling.

(The indicating lamp

does not come on)

• Rice is not boiling.

(The indicating lamp

is lit)

Troubleshooting Remedy

Is the power cord conductive? • Replace the cord.

• Replace the micro switch.

• Adjust the control lever.

• Replace the cast heater.

• Replace the micro switch.

• Explain the proper operation.

• Isolate the cause which melt

the thermal fuse, correct

the cause and replace the fuse.

• The thermal fuse is

blown off.

Yes

Is the thermal fuse conductive?

Yes

Is the micro switch (across C to NC)

conductive when the rice boiling process

is turned on?

Is the micro switch (across C to NC)

conductive when the rice boiling process

is turned off?

Yes

Is the rice boiling control lever properly

adjusted?

The operation is wrong.

(Forcibly flow the electric current).

(Check with the evaporation test).

• Adjust the control lever.

Yes

Is the rice boiling control lever properly

adjusted?

Yes

• Replace the center thermostat.

Does the center thermostat operate

properly?

Yes

Is the cast heater conductive? No

When receiving a rice boiler to be repaired, be sure to check that the main body is completely provide with the inner pan

and the inner lid, ask the condition (phenmenon) of the trouble in detail. Before troubleshooting single parts, be sure to

disconnect the power supply plug from the receptacle.

SR-TEG10 / SR-TEG18

- 7 -

Condition Troubleshooting Remedy

• Replace the center thermostat.

• Replace the inner pan or the

cast heater.

• Replace the cast heater.

• Explain the proper operation.

• Earlier cut off.

• Excessive burning

• Poor boiling up.

• Too hard

• Too soft

• Cored rice

Insufficient boiling

• Immediately after the switch is turned

off, open the cap.

• Rice is excessive or insufficient.

• Water is excessive or insufficient.

• The switch is turned off once during

boiling.

• Rice has not been scooped and mixed

well.

Is the pan bottom properly contacted with

the cast heater?

Is the cast heater conductive?

Improper operation

Yes

• Explain the proper operation.

• Mixed rice is boiled.

• Rice is not washed sufficiently.

(Bran remains still).

• The pan bottom is conditioned to

generate burning easily.

• Germ rice or wheat-mixed rice is boiled.

• The voltage is lower than specified.

• Water is excessive.

Improper operation

Yes

(Check with the bubbling test).

Does the center thermostat operate

properly?

Yes

(Check with the operation test).

• Adjust the control lever.

Is the rice boiling control lever properly

adjusted?

• Replace the center thermostat.

Does the center thermostat operate

properly?

Yes

(Check with the evaporation test).

• Adjust the control lever.

Is the rice boiling control lever properly

adjusted?

(More than light

brown)

SR-TEG10 / SR-TEG18

- 8 -

5. TESTING PROCEDURE

5.1 Bubbling test

Input the pan in the main body, lightly rotate the pan clockwise and counter clockwise to settle the pan on the

heating plate properly.

1. Fill water until center area of the pan bottom is dipped and close the lid. Then turn on the boiling switch.

5.2 Evaporation test

1. Check that bubbling is proper, open the lid and place a weight.

2. Fully cover 2 to 3 sheet of tissue paper (gauze is also applicable) on the pan bottom and continuously

flow electric current.

Note : To prevent plastic parts from deformation caused by steam, be sure to open the lid fully.

Note : To prevent tissue paper from floating because of bubbling, previously hole the paper.

3. Water on the pan bottom is completely evaporated to be empty. This timing is an follows :

Within 1 minute before the boiling switch is turned off.

Within 1 minute after the boiling switch is turned off.

Place a weight so that its gravity center may be aligned at the center

2. When it beings boiling to produce steam. Remove the lid immediately check the bubbling condition on

the pan bottom.

3. As show in the figture.

If it is improper, it may result from the insufficient contact between the pan bottom and heating plate.

Check the pan bottom and the heating plate for foreign material remainder. Clean off the foreign materials

or replace the parts.

Bubbles generate through out the circumference of the pan bottom...............................................Proper

Bubbles does not generate on more than one quater part of the pan bottom circumference..........Improper

Bubbling

SR-TEG10 / SR-TEG18

- 9 -

5.3 Heat reserving test

The above conditions are proper.

1. Put approx. 1 liter of water and the thermometer [ repairing tool (mercury thermometer ASN-150H) ] in

the pan, close the lid and turn on the boiling switch.

2. When it beings boiling to generate steam turn off the boiling switch.

Within 69°C - 77°C .....................................Proper

If outside 69°C - 77°C, check TRS mounting for irregularity, if it is proper, replace warming heater.

If it is improper, check the contact between the pan bottom, the heating plate and the center thermostat.

Repair or replace if necessary.

3. Add water or keep the lid opened until the reading of the thermometer falls to approx. 70°C.

4. When it becomes approx. 70°C, close the lid. After the warming heater is activated for 1 hour or more,

check the heat reserving temperature.

Top view of pan

Holes on the

tissue paper

Pan flange

Tissue paper

Mercury thermometer

Urethane foam blocks

Mercury thermometer

Inner Pan

5.4 Boiling control lever adjustment

Such a mechanical operation as center thermostat goes up and down is used to turn on and off the

micro-switch. Check and adjust this relationship as shown below.

The auxiliary lever presses the push-button.

(The heat reserving lamp come on).

To gain the above relationship, adjust the auxiliary lever by bending it with long nose pliers.

The auxiliary lever does not press the

push-button.

(The boiling indication lamp comes on).

Checking

Adjusting

When the boiling switch is turned on When the boiling switch is turned off

SR-TEG10 / SR-TEG18

- 10 -

6.1 Hinge cover removal

1. Remove the dew collector.

2. Remove the hinge cover mounting screws.

3. As show in the figure, insert a narrow flat head screwdriver from just below and pry off the hinge cover.

6.2 Inner enclosure and Upper frame removal

1. As show in the figure, pry up three fastening hooks. Fixing the upper frame, turn the inner enclosure in

the arrow direction.

2. The upper frame will be seperated from the inner enclosure and the upper frame.

SR-TEG10 / SR-TEG18

Note : When assembling, refer to the illustration without the position relationship between the Inner Enclosure

and the Upper Frame.

6. DISASSEMBLY

Andere Handbücher für SRTEG10 - RICE COOKER - MULTI LANGUAGE

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Panasonic Reiskocher Handbücher

Panasonic

Panasonic sr-tem18 Bedienungsanleitung

Panasonic

Panasonic SR-ZS185 Bedienungsanleitung

Panasonic

Panasonic SR-CX108 Bedienungsanleitung

Panasonic

Panasonic SR-DE103 Bedienungsanleitung

Panasonic

Panasonic SR-G18FG Bedienungsanleitung

Panasonic

Panasonic SR-W18HSXP Bedienungsanleitung

Panasonic

Panasonic SR-W18FXP Bedienungsanleitung

Panasonic

Panasonic SR-W18FGSWUA Bedienungsanleitung

Panasonic

Panasonic RICE-O-MAT SR-W06NA Bedienungsanleitung

Panasonic

Panasonic SR-W18PA Bedienungsanleitung

Panasonic

Panasonic SR-W18GSLRA Bedienungsanleitung

Panasonic

Panasonic SR-G06G Bedienungsanleitung

Panasonic

Panasonic Rice-o-mat SR-W10SXN Bedienungsanleitung

Panasonic

Panasonic SR-TEM181 Bedienungsanleitung

Panasonic

Panasonic SR-SH Bedienungsanleitung

Panasonic

Panasonic SR-ZE185 Bedienungsanleitung

Panasonic

Panasonic SR-SH10RP Bedienungsanleitung

Panasonic

Panasonic SR-Y18FG Bedienungsanleitung

Panasonic

Panasonic SR-CP108 Bedienungsanleitung

Panasonic

Panasonic SRMS102 - RICE COOKER - MULTI LANGUAGE Bedienungsanleitung

Panasonic

Panasonic SR-DE103 Bedienungsanleitung

Panasonic

Panasonic SRPRA18N Bedienungsanleitung

Panasonic

Panasonic SR-42HZP Bedienungsanleitung

Panasonic

Panasonic SRSH15PA - RICE COOKER-LOW Bedienungsanleitung

Beliebte Reiskocher Handbücher anderer Marken

bene casa

bene casa BC-43923 Kurzanleitung

Cuckoo

Cuckoo CRP-M1059F Series Bedienungsanleitung

Zojirushi

Zojirushi NMDC-R10 Bedienungsanleitung

Cuckoo

Cuckoo CR-0351F series Bedienungsanleitung

TECHWOOD

TECHWOOD TCRV-2504 Bedienungsanleitung

Sencor

Sencor SRM 2800SS Bedienungsanleitung

Philips

Philips HD4760 Bedienungsanleitung

Sanyo

Sanyo EC-234 Bedienungsanleitung

ECG

ECG RZ 18 Bedienungsanleitung

Cuisinart

Cuisinart CRC-400 Service-Handbuch

Tiger

Tiger JKT-S10U Bedienungsanleitung

Premium

Premium PRC1547 Bedienungsanleitung

Aroma

Aroma ARC-703-G Bedienungsanleitung

Hitachi

Hitachi RZ-EMA5 Bedienungsanleitung

Sanyo

Sanyo EC310 - 10 Cup Basic Rice Cooker Bedienungsanleitung

Kambrook

Kambrook Rice Master KRC410BSS Bedienungsanleitung

Proctor-Silex

Proctor-Silex RC13 Bedienungsanleitung

Imusa

Imusa GAU-00022 Bedienungsanleitung