Pentair Raychem PMKG-LE Bedienungsanleitung

1 / 2

PMKG-LE

Low-ProfiLe end SeaL Kit inStaLLation inStructionS

THERMAL MANAGEMENT SOLUTIONS EN-RaychemPMKGLE-IM-H5407501/13

DESCRIPTION

The PMKG-LE is a NEMA Type 4X rated end seal kit designed for

use with Raychem BTV-CR, BTV-CT, QTVR-CT, LBTV2-CT, and

KHP-CR parallel heating cables. It is designed to be placed on the

pipe under the insulation and cladding.

For additional information contact your Pentair Thermal

Management representative or call (800)545-6258.

TOOLS REQUIRED

• Screwdriver • Wirecutters

• Utilityknife

ADDITIONAL MATERIALS REQUIRED

• Onegrommet:(1)

PMK-GK-10 P/N 222724-000 (Package of ten grommets)

• Glassclothtape

– GT-66 Installation temperature above 40°F (4°C)

 –GS-54 Installationtemperatureabove–40°F(–40°C)

(1) Required for LBTV2 (see step 1)

This component is an electrical device that must be installed

correctly to ensure proper operation and to prevent shock or fire.

Read these important warnings and carefully follow all of the

installation instructions.

• Tominimizethedangeroffirefromsustainedelectricalarcing

if the heating cable is damaged or improperly installed, and to

comply with the requirements of Pentair Thermal Management,

agency certifications, and National Electrical Codes, ground-

fault equipment protection must be used. Arcing may not be

stopped by conventional circuit breakers.

• Componentapprovalsandperformancearebasedontheuseof

Pentair Thermal Management-specified parts only. Do not use

substitute parts or vinyl electrical tape.

• Theblackheatingcablecoreisconductiveandcanshort.It

must be properly insulated and kept dry.

• Damagedbuswirescanoverheatorshort.Donotbreakbuswire

strands when scoring the jacket or core.

• Keepcomponentsandheatingcableendsdrybeforeandduring

installation.

• Buswireswillshortiftheycontacteachother.Keepbuswires

separated.

• Useonlyfire-resistantinsulationmaterials,suchasfiberglass

wrap or flame-retardant foam.

WARNING:

KIT CONTENTS

Item Qty Description

A 1 Pressure plate

B 1 End seal body with stainless steel screws

C 1 Red grommet (not for use with LBTV2)

D 1 End seal label

APPROVALS

-W

Class I, Div. 2, Groups A, B, C, D

Class II, Div. 2, Groups F, G

Class III

KHP-CR heating cables only

Hazardous Locations

Nonhazardous Locations

BTV-CR, BTV-CT, QTVR-CT and LBTV2-CT heating cables only

2 / 2THERMAL MANAGEMENT SOLUTIONS EN-RaychemPMKGLE-IM-H5407501/13

WWW.THERMAL.PENTAIR.COM

NORTH AMERICA

Tel: +1.800.545.6258

Fax: +1.800.527.5703

Tel: +1.650.216.1526

Fax: +1.650.474.7711

thermal.info@pentair.com

EuROPE, MIddLE EAsT, AfRICA

Tel: +32.16.213.511

Fax: +32.16.213.603

thermal.info@pentair.com

AsIA PACIfIC

Tel: +86.21.2412.1688

Fax: +86.21.5426.2917

cn.thermal.info@pentair.com

LATIN AMERICA

Tel: +55.11.2588.1400

Fax: +55.11.2588.1410

thermal.info@pentair.com

Pentair, BTV, QTVR, LBTV2 and KHP are owned by Pentair or its global affiliates. All other trademarks are the property of their respective owners. Pentair

reserves the right to change specifications without prior notice.

BTV-CR, BTV-CT, QTVR-CT, LBTV2-CT, KHP-CR

Bus wire

Conductive core

Inner jacket

Braid

Outer

jacket

3/4 in

(20 mm)

• Slidepartsontoheatingcable.

• Removeexposedbraid.

• Secureendsealtopipeusingcorrect

tape(GT-66orGS-54).

• Applyinsulationandcladding.

• Installlabelonoutsideofcladding.

• Leavetheseinstructionswiththeend

user for future reference.

• Lightlyscoreouterjacket.

• Bendheatingcabletobreakjacket

at score, then peel off jacket.

• Pushheatingcable

completely into end

seal body.

• Seatgrommetand

tighten screws.

WARNING: Use of the

wrong grommet can

result in leaks, cracked

components, shock or

dielectric failure, and

will invalidate

approvals and

certifications

• Identifyheatingcabletype.

• Selectcorrectgrommetfromtablebelow.

Heating Cable Type Grommet

BTV, QTVR -CR or -CT RED

LBTV2 -CT K *

KHP -CR RED

*Orderseparately

Identify Heating Cable Type

Andere Pentair Steuereinheit Handbücher

Pentair

Pentair Fleck 5800 XTR Benutzerhandbuch

Pentair

Pentair Aurora CBV-S Bedienungsanleitung

Pentair

Pentair FLECK 5810 Bedienungsanleitung

Pentair

Pentair Keystone Figure 952 NPS 2 Montageanleitung

Pentair

Pentair SUDMO IntelliTop 2.0 Bedienungsanleitung

Pentair

Pentair AUTOTROL 368 Bedienungsanleitung

Pentair

Pentair FLECK 2910 NXT Benutzerhandbuch

Pentair

Pentair E-Box MAESTRO Betriebsanleitung

Pentair

Pentair JUNG PUMPEN BASICLOGO EXM Series Bedienungsanleitung

Pentair

Pentair FLECK 7000XTR Bedienungsanleitung

Pentair

Pentair Anderson Greenwood 93 Series Bedienungsanleitung

Pentair

Pentair Sapag 1100 Montage- und Bedienungsanleitung

Pentair

Pentair FLECK 3150 NXT Benutzerhandbuch

Pentair

Pentair TRACETEK TTDM-128 Service-Handbuch

Pentair

Pentair Goyen Precision P1 Bedienungsanleitung

Pentair

Pentair FLECK 2750 NXT Benutzerhandbuch

Pentair

Pentair SIATA V132-SFE Bedienungsanleitung

Pentair

Pentair PENTEK INTELLIDRIVE PID2000-1123 Bedienungsanleitung

Pentair

Pentair 2750 Bedienungsanleitung

Pentair

Pentair F783E Bedienungsanleitung

Pentair

Pentair AURORA CBV-S5 Bedienungsanleitung

Pentair

Pentair FLECK 4600 SXT Bedienungsanleitung

Pentair

Pentair Goyen Mecair FFA Bedienungsanleitung

Pentair

Pentair Fleck7000SXT Bedienungsanleitung

Beliebte Steuereinheit Handbücher anderer Marken

Festo

Festo Compact Performance CP-FB6-E Stücklistenhandbuch

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Bedienungsanleitung

JS Automation

JS Automation MPC3034A Bedienungsanleitung

JAUDT

JAUDT SW GII 6406 Series Kurzanleitung

Spektrum

Spektrum Air Module System Bedienungsanleitung

BOC Edwards

BOC Edwards Q Series Bedienungsanleitung

KHADAS

KHADAS BT Magic Bedienungsanleitung

Etherma

Etherma eNEXHO-IL Bedienungsanleitung

PMFoundations

PMFoundations Attenuverter Bedienungsanleitung

GEA

GEA VARIVENT Bedienungsanleitung

Walther Systemtechnik

Walther Systemtechnik VMS-05 Bedienungsanleitung

Altronix

Altronix LINQ8PD Montageanleitung

Eaton

Eaton Powerware Series Bedienungsanleitung

WAGO

WAGO 750-407/040-000 Bedienungsanleitung

Sony

Sony CCU-590 Bedienungsanleitung

Graco

Graco 25D614 Bedienungsanleitung

Task Force Tips

Task Force Tips YE-RF-900 Programmierhandbuch

Shini

Shini SPV-U Series Bedienungsanleitung