Philips 3CDC-LC-MP3CD2002 Bedienungs- und Montageanleitung

Service Information

Service

Product Service Group CE Audio

3139 785 30094

2002 - 07 - 17

FW-M355

A02 - 163

CHANGES DURING PRODUCTION

* From production wk233 onwards a new 3CDC-LC-

MP3CD2002 module will be introduced due to cost reduc-

tion.

This new 3CDC-LC-MP3CD2002 module can be recog-

nized by the much smaller square shape MP3CD2002

board instead of a shielded MPEG board.

A completely new chapter 10 is attached.

This chapter will replaced the existing MPEG-01B board

(chapter 8) and 3CDC-LC-VCD module (chapter 10).

This changeover must be synchronized with the following

changes on the Front and Combi board:

Front Board:

7400 3103 308 84531 TMP87CS71BF "M355TIV85431"

Combi Board:

3507 4822 051 30562 5k6 5% 0,1W

3508 4822 051 30562 5k6 5% 0,1W

Already published Service Informations: A02-162 3139 785 30076

10-1

TABLE OF CONTENTS

Service Hints ...................................................................10-2

Wiring Diagram................................................................10-4

Blockdiagram...................................................................10-5

CD PART

Component Layout Main Board ...................................10-6

Circuit Diagram ............................................................10-7

MP3 PART

Component Layout Main Board ...................................10-8

Circuit Diagram ............................................................10-9

Exploded View...............................................................10-10

Partslist..........................................................................10-12

3CDC-LC-MP3CD2002

(3 Disc Carousel Changer+MP3 Board)

Layout stage .2

10-2

The following steps have to be done when replacing the CD mechanism:

1. Disconnect flexfoil cable from the old CD drive

2. Put a paperclip on the flexfoil to short-circuit the contacts (fig.1)

3. Remove the old CD drive

4. Remove paperclip from the flexfoil and connect it to the new drive

5. Position the new CD drive in its studs

6. Remove solder joint from the Laserunit

CHARGED CAPACITORS ON THE SERVO BOARD MAY DAMAGE THE CD DRIVE ELECTRONICS WHEN

CONNECTING A NEW CD MECHANISM. THAT´S WHY, BESIDES THE SAFETY MEASURES LIKE

• SWITCH OFF POWER SUPPLY

• ESD PROTECTION

ADDITIONAL ACTIONS MUST BE TAKEN BY THE REPAIR TECHNICIAN.

fig.1

Attention: The laser diode of this CD drive is protected against ESD by a solder joint which shortcircuits the

laserdiode to ground.

For proper functionality of the CD drive this solder joint must be removed after connection the drive to

the set.

Emergency open

Service hints

In case of a Supply fault, the tray can be opened manually.

1. Remove the top cover of the set to get access to the Changer Module.

2. Turn gearwheel clockwise (as shown in picture below).

CAUTION

10-3

Pos 49 Guiding

Pos 48 Cam

Detail A

Dismantling of Tray

Service hints

1. Open the tray.

2. Release 2x catch as shown in fig. 2 and

Detail A

3. Pull tray out.

fig.2

Assembling of Tray

1. Turn Cam (pos. 48) clockwise to end

position.

2. If necessary - move Guiding (pos. 49) to the

right end position.

3. Insert the Tray.

10-4

Wiring

Disc Motor

Inner switch

Slide Motor

Service Position

10-510-5

VCC

DOBM

D1-D5

D2-D4

7814

1876 1875

1877 1878

7813

TDA7073

HEF4094BT

LD ONLD ON

MON

CD/RW

HF IN

R1,R2

SHIFT

SIGNAL PROCESSOR

CD10

SAA7324 (SAA7325)

TRAY

MOTOR

CAROUSEL

MOTOR

VDD

DIODES

PHOTO

D3D2 D5D1 D4

INNER SWITCH

not on all versions

SWITCH INFO

LASER &

MONITOR

DIODE

TURNTABLE

MOTOR

DISC

CD MECHANISM

CAROUSEL

TRAY

MAINBOARD

DATA

SHR_CL

7801

+3,3V

7802

LASER CONTROL

HF AMPLIFIER

TZA1024

(TZA1025)

5,17,21,52,57

113

+5V

ISLICE

63 51

6,14

STB

1,3

+3,3V

+5V

+3,3V

+10V

7815

+5V

Vref

+3servo

BLOCK DIAGRAM 3CDC-LC

+10V

5V1

EN1

CD DRIVE UP/DOWN SWITCH

1881

1880

TRAY SWITCH

1882

CD POS.1 SWITCH

POS. RECOGNITION

1882 closed if carousel is in Position 1.

1883

1883 open if carousel is in a valid Play-Position.

Closed if the tray is in one endposition.

Open during movement.

Open if the drive is in one endposition.

Closed during movement.

VDD (pin 16)

EN1 (pin 15)

Power on

FOCUS

MOTOR

RADIAL

MOTOR

SLEDGE

MOTOR

TURNTABLE

7803

7802

TDA7073A

TTM +

TTM -

SLEDGE -

SLEDGE +

RAD -

RAD +

FOC -

FOC +

MP3 Version

1802

1805

SHR-DATA

CD_IIS_DATA

IIS_WCLK

IIS_SCLK

External MP3-Decoder

Communication

Front-µP and MP3 module

RAB

RESET

SDA

SHR_CL

SHR_STR

SWITCH INFO

µP_DATA

µP_CLK

µP_FRAME

SICL

µP_CLK

µP_FRAME

µP_DATA

µP_CLK

µP_FRAME

µP_DATA

SILD

+5V

+10V

GND

Supply

Changer

Control Logic

Communication

µP ↔Signal Processor

VAM2201

WCLI

WCLK

SCLI

SCLK

SDI

DATA

CD_IIS_DATA

AU_IIS_DATA AU_IIS_DATA

IIS_WCLK

IIS_SCLK

AU_IIS_DATA

IIS_WCLK

IIS_SCLK

2,6,8,14,15,19

CD_IIS_DATA

IIS_SCLK

IIS_WCLK

1805

Active low pass

Filter

TDA1308

7816

+5V

CD LEFT

CD RIGHT

Analog Audio

DIGITAL AUDIO

MP3 coded

CD-DA coded

SDA

SCL

SILD

RESET

1,3

GND

+5V

GND

+5V

Blockdiagram

10-6 10-6

This assembly drawing shows a summary

of all possible versions.

For components used in a specific version

see schematic diagram respectively partslist. 3CDC-LC-MP3CD2002 Layout stage .2 2002-05-27

3CDC-LC-MP3CD2002 Components seen from Copperside

This assembly drawing shows a summary

of all possible versions.

For components used in a specific version

see schematic diagram respectively partslist. 3CDC-LC-MP3CD2002 Layout stage .2 2002-05-27

3CDC-LC-MP3CD2002 Copperside view

2800 E4

2801 D4

2802 E4

2803 D4

2804 F3

2805 D4

2806 D4

2807 E4

2808 D4

2809 D1

2810 E4

2811 D4

2812 E4

2813 E4

2814 F1

2815 F4

2816 C4

2818 C4

2820 C3

2822 E3

2823 E3

2824 E3

2827 E4

2829 C3

2831 F4

2833 C4

2834 D4

2835 D2

2840 E1

2841 D2

2842 F1

2843 D4

2844 D2

2848 E4

2859 F2

2860 H3

2862 C4

2863 C4

2864 B2

2865 B2

2866 C4

2867 B4

2868 C4

2869 C4

2870 C2

2871 D2

2872 G2

2874 D2

2877 H1

2878 H1

2882 B3

2883 H1

2884 F2

2885 G2

2886 F3

2887 F2

3700 F2

3701 D2

3702 F3

3703 F2

3704 F2

3705 C2

3706 C1

3707 C2

3708 C2

3709 F2

3710 F2

3711 C2

3712 B3

3713 G2

3714 H2

3715 H2

3716 D2

3717 D2

3718 C2

3719 H3

3720 F2

3721 F3

3722 F2

3723 F4

3724 G2

3725 F2

3726 F2

3727 F2

3728 F3

3729 F2

3730 C3

3731 C2

3732 C2

3733 C2

3734 D2

3735 G2

3736 H3

3738 H3

3740 C4

3741 C4

3742 C4

3743 C4

3744 B4

3745 H2

3746 B3

3747 H3

3748 H3

3750 B4

3751 B4

3752 H3

3753 H2

3754 G2

3755 G1

3756 B2

3757 A5

3758 A5

3759 D2

3760 B4

3761 C4

3762 A4

3763 A4

3764 C4

3765 H2

3766 H1

3767 D4

3769 C5

3770 H2

3771 H1

3772 H2

3773 H1

3774 C2

3776 H1

3777 C5

3800 E4

3801 E4

3802 E4

3803 D4

3804 C3

3805 D4

3806 D4

3807 D4

3808 D4

3810 C3

3811 E4

3812 C3

3813 C2

3814 C2

3816 C3

3817 C3

3818 C3

3819 C3

3820 E4

3821 F4

3822 F4

3823 F3

3824 F3

3825 E3

3826 E3

3827 D4

3828 D2

3829 F3

3830 F4

3832 C3

3833 E4

3834 E4

3836 E2

3837 D2

3838 D2

3839 E3

3840 C3

3842 D2

3843 E2

3844 F1

3845 D2

3846 E2

3847 E2

3848 D3

3849 C3

3850 D1

3853 E4

3854 E3

3855 E3

3856 F4

3857 F4

3858 C2

3859 C2

3860 C2

3861 C2

3862 C4

3863 D2

3864 E4

3865 C4

3866 F3

3867 E4

3871 E2

3872 E3

3878 C3

3881 C3

3882 E2

3883 E2

3884 E3

3885 E2

3890 F4

3891 E2

4700 B2

4701 B2

4702 B2

4703 B2

4704 B1

4705 B1

4706 A3

4707 A3

4708 A3

4709 A3

4710 A3

4711 A3

4712 B3

4713 B3

4714 B3

4715 B4

4716 B3

4717 A3

4718 A4

4719 A4

4720 A4

4722 A4

4724 B4

4726 B4

4727 B4

4728 A4

4729 A4

4730 B4

4731 B4

4732 C5

4733 B3

4734 C4

4735 B5

4736 A5

4737 C5

4738 B5

4739 C4

4740 C5

4741 B4

4742 A5

4743 A5

4744 A5

4745 A5

4746 A5

4747 A5

4748 A5

4749 A5

4801 G1

4803 B2

4804 A1

4805 B5

4806 C4

4807 H3

4808 H3

4809 H3

4810 H4

4811 H4

4820 C4

4823 E3

4824 C5

4825 B4

4826 C3

4828 C3

4829 G4

4830 G3

4831 G3

4832 F3

4833 E3

4834 F4

4837 E3

4838 E3

4839 E3

4840 F3

4841 E3

4842 E3

4844 G3

4845 G4

4846 E4

4847 E4

4848 G4

4849 E3

4851 F3

4855 F1

4856 E4

4857 G1

4858 E1

4868 E1

4869 E2

4870 E2

4871 E2

4872 D2

4873 E2

4874 E2

4875 E2

4876 G2

4878 D2

4879 C3

4880 E3

4881 D2

4882 E4

4883 E4

4884 A2

4885 A2

4886 A2

4887 A2

4888 A2

4889 B2

4890 A2

4891 A2

4892 A3

4893 A2

4894 A3

4895 A3

4896 A3

4897 A3

4898 A3

4899 D2

6801 H2

6802 H1

6803 H2

6804 G3

6805 G2

6806 C4

6807 C4

6808 H2

6809 C2

6811 G2

6812 F2

7801 F3

7802 D3

7806 E3

7811 B4

7812 G2

7813 H2

7815 D4

7816 C2

7820 F2

7821 F2

7822 G2

7823 F2

1451 B5

1455 A4

2450 C1

2451 B1

2452 C2

2453 B1

2454 B1

2455 D2

2457 A2

2461 D4

2463 A3

2464 D4

2465 D4

2466 A3

2467 B4

2468 B4

2469 B4

2472 D3

3450 C1

3451 B1

3454 D2

3465 C1

3467 A3

3468 A3

3469 C4

3470 D3

3471 C4

3473 C4

3474 A3

3475 C4

3476 C4

3477 B4

3479 A2

3480 C4

3481 C4

3484 B4

3490 A4

3494 A2

3496 A4

3499 C1

4450 A4

6451 D4

7451 B3

7456 D4

7458 D1

Mapping

Copperside

Componentside

10-710-7

VDD

CAROUSEL

TRAY

Motor driver

3,4

NC 8,11,15

TDA7073A

7814

CAROUSEL

MOTOR

1877

8003

RF-500TB

1878

RF-500TB 1876

8002

1875

TRAY

MOTOR

47u

2873

3K9

3719

3775

3R3

3748

10K

2888

10u

10K

3745

2860

22n

3753

100K

3752

100K

3738

270R

+10V

SER. DATA

LOOPBACK

INTERF.

KILL

TIMING

BITSTREAM DAC SER. DATA

INTERFACE VERSAT.

INTERF.

EBU

INTERF.

CORR.

ERROR

CONTROL

FUNCTION

PRE-

PROCESSING

AUDIO

PROCESSOR

MICROCONTROLLER

INTERFACE

SUBCODE

PROCESSOR

ADDR

SRAM

PEAK

DET.

MOTOR

CONTROL

OUTPUT

STAGES

DIG.

PLL

EFM

DEMOD

VERSATILE

INTERFACE

ADC

VREF GEN.

FRONT

END

V/I

Vgap

VDD

3836

1K8

4K7

3849

DOBM

R1 (CD10)

INNERSW.

VCC

VREF

mainboard

D3 (CD10)

SLIDE

/ SAA7325

2 3 4 5 6 7 8 9 10 11 12 13 14 15

1234

5 6 7 8 9 101112131415

SLIDE

ACCELERATE DISC

D4 (CD10)

CD Drive

Mitsumi

MCD-1b

MCD-2

Sanyo

DA11T3CN

DISC

Signal Processor

TRACK

voltage stab.

GND

BRAKE DISC

to 7802

DISC

GND

MON

DISC

D2 (CD10)

FOCUS

TRACK

SLIDE

3CDC-LC

part 1

Motor driver

D1 (CD10)

R2 (CD10)

from 1801

=MITSUMI drive

=SANYO drive

* SANYO DA11T3CN

MITSUMI MCD 1b

FOCUS

150p

2800

1n5

2814

6K8

3850

3882

100K

33R

3767

220p

2803

+3.3V

220p

2806

220p

2811

1800

FMN 1

100R

3864

+3.3V

3843

33K

3871

68K

2810

180p

4K7

3844

3891

4K7

4R7

3815

3883

3769

100R

7815

BC847B

27K

2822

2n2

3827

15R

3855

2n2

2842

47n

2835

4u7

2819

3830

22K

27K

3800

WCLK

VDDA1

VDDA2

VDDD1P

VDDD2C

VNEG

VPOS

VRIN

VSSA1

VSSA2

VSSD1

VSSD2

VSSD3

WCLI

SCL

SCLI

SCLK

SDA

SDI

SELPLL

SFSY

SILD

STATUS

SUB

TEST1

TEST2

TEST3

V2|V3

KILL

LDON

RAB

RCK

RESETn

SBSY

CL16

CRIN

CROUT

DATA

HFIN

HFREF

IREF

ISLICE

7802

SAA7324

CFLG

CL11

2832

47u

3880

3R3

22K

3826

+3.3V

33K

1n5

2816

3846

3801

10K

2805

220p

3834

22K

4R7

3829

GND

MON

PWRON

RFEQO

RFFB

RGADJ

VCC2

VCCL

7801

CDRW

CFIL

CMFB

DIN

EQSEL

2844

270p

3825

3802

27K

100n

2840 2848

150p

3723

27K

3833

22K

2838

10u

7806

BC847B 3872

3866

4K7 3837

3838

3803

10K

2841

270p

470R

3840

2817

4u7

10K

3805

150p

220K

3848

220p

2827

2833

33p

2834

33p

2801

3865

120R

+3.3V

BZX284

C3V9

6807

68R

3856

3828

22K

10K

3808

4u7

2837

220n

2815

470R

3853

+5V

47p

2823

47K

3842

2818

1n5

3,4

NC 8,11,15

TDA7073A

2843

100n

7807

VDD

FOCUS

TRACK

Servo driver

3,4

NC 8,11,15

TDA7073A7803

3839

100K

1810

330p

68R

3857

2807

3807

10K

22n

2824 10n

2813

47K

3845

47n

2812

3847

10K

3806

6K8

220n

2809

1801 1

2826

2804

4n7

47u

2808

10K

220p

+5V

27K

3811

2802

150p

Vref

InnerSW

120R

3862

+3.3V +5V

+3.3V

Vref

+10V

SLD+

SLD-

DISC-

DISC- DISC+

DISC+

SLD-

2839

47u

3835

3R3 +10V

Vref

IIS_SCLK

IIS_WCLK

InnerSW

+3servo

47u

2828

33R

3863

+3servo HFIN

VrefCD10

AU_IIS_DATA

3814

470R(5x)

3813

3819

27p

2829 1n

2820

3812

3810

RAB

SICL

SILD

SDA

PORE

FOC-

TRACK-

FOC+

TRACK+

FOC+

FOC-

TRACK-

TRACK+

HFIN

to 7801

LDON

3823

3824

100R

3854

4u7

2836

+3.3V

VrefCD10

HF-Amplifier

Laser power control

TZA1024/ TZA1025

3821

3K3

3820

3890

3K3

3822

SHR_CL

RIGHT_OUT

GNDA

GND

LEFT_OUT

SHR_STR

GND

SW_INFO

GND

SHR_DATA

+10V

+5V(+5.6V)

1805

SICL

SILD

RAB

PORE

SDA

+5V

+10V

3881

220R

3878

220R

IIS_WCLK

IIS_SCLK

+5V

SRG8

EN1

STB

CLK

TRAY POS

SHR_STR

SHR_CLK

SHR_DATA

SW_INFO

UP/DOWN

POS1

POS recog.

6802

6801

1880

1881

6803

BAS216(4x)

6808

1882

1883

3776

10K

3771

220p

2883

2877

82p

470R

3772

10K

3773

10K

3766

220p

2878 10K

3765 33K

3730

3770

18751876

SW_INFO

Power on

Output enable delay

BC847B

7812

2872

47n

BZX284

C5V1

6805

4u7

2881

BAS216

6804

3715

100K

3755

220R

22K

3713

10K

3714

220R

3754

+10V

TRAY-MOTOR

CAROUSEL-MOTOR

Changer Control Logic

Internal Supply

7813

HEF4094BT

47K

3747

47K

3736

POS1

1882

POS recog.

1883

8002

CAROUSEL-MOTOR

1876

RF-500TB

SW_INFO

18751

Connection to

Front / Combi Board

RIGHT

LEFT

SW_INFO

10K

Analog Audio

CD_IIS_DATA

470R

3817

3818

470R IIS_SCLK

IIS_WCLK

CD_IIS_DATA

3816

220u

2821

µP_FRAME

µP_DATA

µP_CLK

GND

µP_FRAME

SICL

SILD

SDA

SPDIF_GND

AU_IIS_DATA

CD_IIS_DATA

AU_IIS_DATA

PORE

IIS_SCLK

SPDIF_GND

RAB

GND

+5V

µP_CLK

GND

IIS_WCLK

µP_DATA

µP_FRAME

µP_CLK

µP_DATA

µP_FRAME

µP_CLK

µP_DATA

1802

Connection to

MP3CD2002 Board

3861

+3.3V

2.3V

4.5V

2.3V

3763

22K 22K

3762

3750

3746

10K

TDA1308T

7811-B

2876

220u

3751

2863

220p

2862

220p

3760

10K

3761

10K

2861

10u

3758

100R

2867

220p

3741

22K

2880

10u

3742

22K TDA1308T

7811-A

3757

100R

2882

220p

3743

22K

2879

220u

3740

22K

2869

100p

2868

100p

100R

3764

3744

10K

+5V

LEFT CHANNEL

RIGHT CHANNEL

Active Low Pass

LEFT

RIGHT

3CDC-LC M355(MP3 Version) 2002-05-23

1800 C1

1801 J1

1802 D15

1805 I15

1810 C9

1875 H10

1875 H7

1875 I12

1876 H10

1876 H7

1876 I11

1877 I7

1878 I7

1880 I11

1881 I11

1882 I11

1883 I11

2800 C4

2801 C5

2802 B4

2803 B5

2804 D4

2805 B5

2806 A5

2807 A4

2808 A5

2809 I4

2810 A4

2811 A5

2812 E9

2813 F9

2814 H4

2815 D4

2816 B11

2817 E4

2818 B10

2819 C1

2820 D14

2821 B11

2822 D7

2823 F9

2824 F9

2826 G11

2827 B4

2828 F6

2829 E14

2832 J4

2833 C10

2834 C10

2835 H4

2836 D6

2837 E10

2838 E7

2839 H4

2840 J4

2841 G5

2842 G4

2843 B10

2844 H5

2848 A4

2860 I9

2861 B14

2862 B12

2863 A12

2867 A13

2868 B13

2869 A13

2872 H12

2873 I9

2876 A12

2877 J14

2878 J14

2879 A12

2880 A14

2881 H14

2882 B13

2883 J14

2888 H9

3713 H14

3714 H13

3715 I14

3719 H9

3723 A4

3730 F14

3736 J11

3738 I9

3740 A11

3741 A11

3742 B12

3743 B12

3744 A14

3745 I9

3746 B14

3747 J12

3748 I9

3750 A12

3751 A12

3752 H9

3753 H9

3754 H11

3755 H11

3757 A14

3758 B14

3760 A12

3761 A12

3762 A14

3763 B14

3764 A12

3765 I14

3766 I14

3767 F7

3769 G7

3770 J14

3771 J13

3772 J14

3773 I14

3775 I9

3776 H11

3800 B4

3801 B4

3802 B4

3803 B4

3805 A4

3806 B4

3807 A4

3808 A4

3810 D14

3811 B4

3812 D14

3813 E14

3814 E14

3815 D4

3816 B13

3817 B13

3818 B14

3819 D14

3820 C3

3821 C3

3822 C3

3823 E7

3824 D7

3825 D8

3826 F9

3827 E10

3828 F9

3829 E2

3830 E2

3832 E14

3833 A4

3834 A4

3835 H4

3836 J4

3837 E5

3838 F5

3839 J5

3840 C14

3842 G5

3843 G5

3844 G4

3845 H5

3846 H5

3847 H4

3848 I5

3849 C14

3850 I4

3853 E9

3854 D7

3855 G12

3856 C1

3857 B1

3861 E14

3862 B10

3863 F6

3864 E9

3865 B11

3866 D6

3871 E3

3872 E3

3878 F15

3880 J4

3881 F15

3882 J5

3883 J4

3890 C3

3891 G9

6801 I12

6802 I12

6803 I12

6804 I14

6805 H12

6807 G6

6808 I12

7801 D5

7802 D12

7803 G3

7806 E3

7807 I3

7811

-A

B13

7811

-B

A13

7812 H13

7813 H13

7814 H8

7815 F6

0.2V

1V 1V

2.1V

0.8V

4.7V

U >400mV

->Laser damaged !

ESD sensitive lines!

0.9V

1.7V

1.5V

for CD_DA : 0V

for CD_RW : 3V

for CD_DA : 0V

for CD_RW : 3V

3.2V

1.5V

3.2V

1.5V

3.3V

3.2V

4.2V

3.2V

4.1V

3.3V

10V

1.7V

3.2V

0.8V

1.5V

only if

quartz used

2.8V

1.5V

3.0V

BACD

Σ(A-D)

3.2V

1.6V

5,1V

Carousel stop

Turn left

Turn right

Tray stop

Moving in

Moving out

DC voltages measured in

PLAY MODE

with following conditions:

"+10V" = 10V

"+5V" = 5V

EVM

CH1

CH2

FO, RA, SL

Focus search

Service step 2

TB = 0.5µs/div

800mVpp

EYE-PATTERN

10-8 10-8

21345

1460 A3

2456 A4

2458 D4

2459 D4

2460 D2

2462 C4

2470 B4

2471 C3

3449 C3

3452 B2

3453 A4

3455 B5

3456 D4

3457 D3

3458 D3

3459 C2

3460 C2

3461 B5

3462 C3

3463 C3

3464 C2

3466 A3

3472 D2

3478 B2

3482 B2

3483 B2

3485 B2

3486 A2

3487 A2

3488 B3

3489 B3

3491 B4

3492 A3

3493 B2

3495 B2

3497 B2

3498 D3

4452 A3

4453 B2

5450 D3

6450 C2

7450 B4

7452 C2

7453 C2

7454 C3

7455 D2

7457 B4

7460 B2

1451 B5

1455 A4

2450 C1

2451 B1

2452 C2

2453 B1

2454 B1

2455 D2

2457 A2

2461 D4

2463 A3

2464 D4

2465 D4

2466 A3

2467 B4

2468 B4

2469 B4

2472 D3

3450 C1

3451 B1

3454 D2

3465 C1

3467 A3

3468 A3

3469 C4

3470 D3

3471 C4

3473 C4

3474 A3

3475 C4

3476 C4

3477 B4

3479 A2

3480 C4

3481 C4

3484 B4

3490 A4

3494 A2

3496 A4

3499 C1

4450 A4

6451 D4

7451 B3

7456 D4

7458 D1

Side A Side B

This assembly drawing shows a summary of all possible versions.

For components used in a specific version see schematic diagram

respectively partslist. MP3 CD2002 Layout stage .1 2002 04 09

10-910-9

VSS

Flash

EPROM

GND

For ROM version:TMS320VC5406

For Flash version:TMS320VC5416

GND

CD10_SDA

GND

uP_DATA

.... only for ROM version

CD10_RESET

7456 E12

7457 E9

7458 A1

7460 I12

IIS_SCLK

# .... only for FLASH version

EEPROM

ADJ

LM317D

uP_CLK

DSP

GND

3491 D9

3492 F9

3493 H12

3494 H8

3495 H11

3496 H8

3497 I13

3498 D14

3499 A2

4450 C13

4452 F9

4453 I11

5450 B3

6450 E13

6451 E13

7450 A10

7451 D5

7452 F13

7453 F12

7454-A G11

7454-B F11

7454-C F11

7454-D G11

7455 D13CD10_SICL

AU_IIS_DATA

IIS_WCLK

CD_IIS_DATA

3465 A2

3466 H8

3467 F8

3468 F8

3469 E13

3470 F1

3471 E13

3472 H9

3473 G2

3474 G8

3475 G2

3476 H2

3477 H7

3478 B6

3479 H8

3480 H2

3481 H3

3482 H5

3483 H6

3484 H5

3485 I11

3486 I13

3487 I12

3488 I12

3489 I12

3490 H8

SPDIF_GND

provisional

16.93MHz

+5V

2460 E13

2461 D12

2462 D2

2463 D8

2464 G12

2465 G2

2466 G8

2467 H6

2468 H4

2469 H5

2470 D9

2471 E11

2472 D1

3449 E11

3450 A4

3451 B7

3452 H3

3453 A12

3454 C1

3455 C9

3456 C10

3457 D13

3458 D14

3459 F13

3460 F13

3461 E12

CD10_RAB

CD10_SILD

Voltage stabilisation

3462 E2

3463 F1

3464 F13

1234567891011121314

SPDIF_GND

600R

for 5V front uP

SPDIF

2458 C10

2459 D2

2451 B5

2452 B2

2453 B4

2454 B7

2455 C2

2456 C12

2457 D9

SPDIF

Text version only

+3.3V

SPDIF_GND

only for FLASH version

uP_FRAME

MP3-CD-2002

2467

2462

2468

2459

3488

100K

3489

10K

3499

7454-B

TRST

X1 96

X2|CLKIN 97

27 XF

INT3

25 IOSTRB

22 IS

32 MP|MC

26 MSC

24 MSTRB

NMI

READY

RS 98

23 R|W

TCK

TDI 85

TDO

TMS 89

TOUT

135

HD7

HDS1

127

HDS2

129

HINT

30 HOLD

28 HOLDA

HPI16

HPIENA 92

HRDY

HR|W

IACK

29 IAQ

INT0

INT1

INT2

66 67

128

DVSS9

144

EMU0 83

EMU1|OFF

HAS

HBIL

HCNTL0

HCNTL1

HCS

HD0

58 69

HD1

HD2

HD3 95

120

HD4

HD5

124

HD6

116

21 DS

DVDD1

33 DVDD2

DVDD3

DVDD4

112

DVDD5

DVDD6

130

DVSS1

DVSS2

DVSS3

57 72

DVSS4

DVSS5

DVSS6 93

DVSS7 106

DVSS8

111

CVSS9

D1 100

D10

117

D11

118

D12

119

D13

121

D14

122

D15

123

D2 101

D3 102

D4 103

D5 104

113

114

115

CVDD2

CVDD3

52 68

CVDD4

CVDD5 91

CVDD6

125

CVDD7

142

CVSS1

CVSS10

126

CVSS2

CVSS3

34 CVSS4

CVSS5

CVSS6

50 70

CVSS7

CVSS8 90

BDX0

BDX1

BDX2

BFSR0

BFSR1

BFSR2

BFSX0

BFSX1

BFSX2

31 BIO

CLKMD1

CLKMD2

CLKMD3

CLKOUT 94

CVDD1

134

136

137

138

139

140

141

BCLKR0

BCLKR1

BCLKR2

BCLKX0

48 71

BCLKX1

BCLKX2

BDR0

35 BDR1

BDR2

132

A10

A11

A12

A13

A14

A15

A16 105

A17 107

A18 108

109

A19

133 110

A20

A21

143

A22

7451

131

2466

100n 2463

3474

15R 1u

3465

100R

2451

10K

3468

BC847BW

7456

6451

BZX284-C3V9

FMN

1451

470R

3479

100R

3475

3476

100R

3471

3469

100R

33R

100R

3480

3481

100R

470R

3466

470R

3482

3498

3483

100R

3492

3K3

2450

4450

100n

100R

3496

6450 BZX284-C3V3

7454-C

3497

10K

4453

BC847BW

7460

VSS

WC_

M24C32

7458

SCL

SDA

VCC

42452

74HCT1G04

7457

2453

100n

7454-D

4452

10K

3485

180R

3458

3494

10K

3456

10n

2458

2457

3455

10n

2456

100n

3453

10R

15R

3451

1455

FMN

3452

100R

15R

3484

100n

2469

10K

3495

10K

3493

100n

2471

100n

2470

3491

47R

3467

10K

3449

100R

3450

15R

2454

2465

100n

2460

220u

2461

7455

BC847BW

7453

10K

3464

3460

7452

BC847BW

3459

220R

100R

3462

3463

100R

3473

100K

3487

1460

CSTCV

5450

15R

3454

100n

2455

3457

680R

470R

3477

150K

3478

470R

3472

100n

2464

47R3461

220u

2472

7454-A

74HC00D

3486

3470

15R

DQ6

DQ7

DQ8

DQ9

9NC

RESET

15 RY|BY

VDD 37

11 WE

7A9

BYTE 47

DQ0 29

DQ1 31

DQ10

DQ11

DQ12 39

DQ13 41

DQ14 43

DQ15|A-1 45

DQ2 33

DQ3 35

DQ4

DQ5

A10

5A11

A12

3A13

A14

1A15 48

A16

17 A17

A18

23 A2

21 A4

19 A6

Am29LV800B7450

A0 25

100R

3490

nRW

+3.3V

CD_IIS_DATA

+3.3V

uP_FRAME

SPDIF

+3.3V

+5V

+3.3V

AD0

AD16

DD0

DD1

DD10

DD11

DD12

DD13

DD14

DD15

DD2

DD3

DD4

DD5

DD6

DD7

DD8

DD9

+1.5V

+core

SPDIF_GND

nMSTRB

IIS_SCLK

AU_IIS_DATA

+5V

uP_FRAME

SPDIF

CD10_SILD

IIS_WCLK

CD10_SICL

+3.3V

uP_DATA

+3.3V

uP_CLK

+1.5V

IIS_SCLK

AU_IIS_DATA

CD10_SICL

CD10_SDA

CD10_RAB

CD10_SILD

uP_CLK

uP_DATA

nCD10_RESET

AD3

AD4

AD5

AD6

AD7

AD8

AD9

DD0

DD1

DD10

DD11

DD12

DD13

DD14

DD15

DD2

DD3

DD4

DD5

DD6

DD7

DD8

DD9

+3.3V

SPDIF_GND

nCD10_RESET

CD10_RAB

CD10_SDA

nPS

TMS_RESET

AD1

AD10

AD11

AD12

AD13

AD14

AD15

AD17

AD18

AD2

AD3

AD4

AD5

AD6

AD7

AD8

AD9

AD0

AD1

AD10

AD11

AD12

AD13

AD14

AD15

AD16

AD17

AD18

AD2

+core

CD_IIS_DATA

IIS_WCLK

+core

nPS

+3.3V

+3.3V +3.3V

nRW

nMSTRB

Andere Philips CD-Player Handbücher

Philips

Philips AZ6819/05 Bedienungsanleitung

Philips

Philips AZ 7362 Bedienungsanleitung

Philips

Philips AZ1130 Bedienungsanleitung

Philips

Philips AZ1826/79 Bedienungsanleitung

Philips

Philips SACD900A Bedienungsanleitung

Philips

Philips AZ8348/05 Bedienungsanleitung

Philips

Philips AZ102C Bedienungsanleitung

Philips

Philips AZ1122/78 Bedienungsanleitung

Philips

Philips Jogproof AX2506 Bedienungsanleitung

Philips

Philips AZ 1005 Bedienungsanleitung

Philips

Philips AZ1220 Bedienungsanleitung

Philips

Philips AX5211 Bedienungsanleitung

Philips

Philips AZ 8210 Bedienungsanleitung

Philips

Philips ACT500/00C Bedienungsanleitung

Philips

Philips AZ7462/05 Bedienungsanleitung

Philips

Philips AZ8052 Bedienungsanleitung

Philips

Philips CD Soundmachine AZ1837 Bedienungsanleitung

Philips

Philips AZ 6821 Bedienungsanleitung

Philips

Philips AZ 8057 Bedienungsanleitung

Philips

Philips AZ1302/00 Betriebsanleitung

Philips

Philips AZ1047/94 Bedienungsanleitung

Philips

Philips AZ1134/77 Betriebsanleitung

Philips

Philips AZ1016 Bedienungsanleitung

Philips

Philips AZ 8060 Handbuch

Beliebte CD-Player Handbücher anderer Marken

RCA

RCA RP-7923 Bedienungsanleitung

Pioneer

Pioneer DEH-P3550MP XM Bedienungsanleitung

Lasonic

Lasonic MSU-2020 Bedienungsanleitung

THOMSON

THOMSON RCD150 Bedienungsanleitung

Denon

Denon DCD-1420 Bedienungsanleitung

Panasonic

Panasonic SJ-MR100 Bedienungsanleitung

Onkyo

Onkyo DX-7210 Bedienungsanleitung

Sony

Sony MZ-R3 Bedienungsanleitung

Denon

Denon DVM-4800 Bedienungsanleitung

JBL

JBL MR-32 Bedienungsanleitung

RCA

RCA RCD152 Bedienungsanleitung

Technics

Technics SL-PS770A Bedienungsanleitung

Clarion

Clarion compact disc Bedienungsanleitung

Sony

Sony MZ-M10 Bedienungsanleitung

Rotel

Rotel RCD 975 Bedienungsanleitung

Pioneer

Pioneer CLD-D790 Bedienungsanleitung

Optimus

Optimus CD-8250 Bedienungsanleitung

Audiovox

Audiovox CE101A - annexe 1 Bedienungsanleitung