Philips MCM103 Bedienungsanleitung

Version 1.4

MCM103

3141 785 34454

Micro Hi-Fi System /98/96/93

Published by LX 1125 Service Audio Subject to modification

system or transmitted, in any form or by any means, electronic, mechanical, photocopying,

or otherwise without the prior permission of Philips.

CONTENTS

Technical specification ..................................................................1-2

Service measurement setup..........................................................1-3

Service aids .................................................................................1-4

Instructions on CD playability ................................................2-1..2-2

Block diagram................................................................................3-1

Wiring diagram...............................................................................4-1

Disassembly diagram............ ........................................................5-1

Main board

Circuit diagram ..................................................................6-1..6-4

Layout diagram..................................................................6-5..6-6

Display board

Circuit diagram .........................................................................7-1

Layout diagram..................................................................7-2..7-3

AMP board

Circuit diagram .........................................................................8-1

Layout diagram.........................................................................8-2

Exploded view diagram .................................................................9-1

Mechanical parts list......................................................................9-2

Electrical parts list........................................................................10-1

MCM103B/77/12

Rated Output Power 2X5W RMS

Frequency Response 60 - 16kHz, ±3dB

Signal to Noise Ratio >65dB

Aux Input 0.5 V RMS 20kohm

Disc

Laser Type Semiconductor

Disc Diameter 12cm/8cm

Support Disc CD-DA, CD-R,

CD-RW, MP3-CD,

WMA-CD

Audio DAC 24Bits / 44.1kHz

Total Harmonic

Distortion <1%

Frequency Response 60Hz -16kHz (44.1kHz)

S/N Ratio >65dBA

Tuner

Tuning Range FM: 87.5 - 108 MHz

Tuning Grid 50 KHz

Sensitivity

- Mono, 26 dB S/N

Ratio

< 22 dBf

Search Selectivity < 36 dBu

Total Harmonic

Distortion < 3%

Signal to Noise

Ratio > 45 dBu

Speakers

Speaker

Impedance 4ohm

Speaker Driver 3.5”

Sensitivity >82dB/m/W

General information

AC power 110 - 127/220-240 V,

50/60 Hz

Operation Power

Consumption 20 W

Standby Power

Consumption < 4 W

USB Direct Version 2.0/1.1

Dimensions

- Main Unit

(W x H x D)

- Speaker Box

(W x H x D)

150 x 152 x 250 mm

150 x 152 x 197 mm

Weight

- With Packing

- Main Unit

- Speaker Box

5.14 kg

2.002 kg

2 x 0.895 kg

TECHNICAL SPECIFICATION

1 - 2

Type /Versions:

Features

Board in used:

MCM103

Service policy

DISPLAY BOARD

MAIN BOARD

AMP BOARD

* TIPS : C -- Component Lever Repair.

M -- Module Lever Repair

-- Used

/05 /96 /55 89/21B/

Feature diffrence

RDS

VOLTAGE SELECTOR

ECO STANDBY - DARK

C/M

Type /Versions:

MCM103

/05 /96 /55 89/16/85/

VERSION VARIATION

39/

C/M

77B/

C/M

1-3

LF Generator

e.g. PM5110

Recorder

Use Universal Test Cassette CrO2 SBC419 4822 397 30069

LEVEL METER

e.g. Sennheiser UPM550

with FF-filter

S/N and distortion met

e.g. Sound Technology ST170

DUT

or Universal Test Cassette Fe SBC420 4822 397 30071

LEVEL METER

e.g. Sennheiser UPM550

with FF

filter

S/N and distortion meter

e.g. Sound Technology ST1700B

DUT

Use Audio Signal Disc

(replaces test disc 3)

SBC429 4822 397 30184

Bandpass

250Hz-15kHz

e.g. 7122 707 48001

LF Voltmeter

e.g. PM2534

DUT

S/N and distortion meter

e.g. Sound Technology ST1700B

Frame aerial

e.g. 7122 707 89001

Tuner AM (MW,LW)

To avoid atmospheric interference all AM-measurements have to be carried out in a Faraday´s cage.

Use a bandpass filter (or at least a high pass filter with 250Hz) to eliminate hum (50Hz, 100Hz).

RF Generator

e.g. PM5326

Ri=50:

Bandpass

250Hz-15kHz

e.g. 7122 707 48001

LF Voltmeter

e.g. PM2534

DUT

RF Generator

e.g. PM5326

S/N and distortion meter

e.g. Sound Technology ST1700B

Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz).

Ri=50:

Tuner FM

MEASUREMENT SETUP

1-4

SERVICE AIDS

GB WARNING

All ICs and many other semi-conductors are

susceptible to electrostatic discharges (ESD).

Careless handling during repair can reduce life

drastically.

When repairing, make sure that you are

connected with the same potential as the mass

of the set via a wrist wrap with resistance.

Keep components and tools also at this

potential.

ESD

CLASS 1

LASER PRODUCT

Safety regulations require that the set be restored to its original

condition and that parts which are identical with those specified,

be used

Safety components are marked by the symbol !.

Lead free

Set remains closed!

Play a CD

for at least 10 minutes

playability

ok ?

playability

ok ?

add Info for customer

"SET OK"

check playability

playability

ok ?

check playability

return set

Customer complaint

"CD related problem"

"fast" lens cleaning

3For flap loaders (= access to CD drive possible)

cleaning method 4is recommended

INSTRUCTIONS ON CD PLAYABILITY

2 - 1

Exchange CDM

1-4For description - see following pages

PLAYABILITY CHECK

For sets which are compatible with CD-RW discs

use CD-RW Printed Audio Disc ....................7104 099 96611

TR 3 (Fingerprint)

TR 8 (600µ Black dot) maximum at 01:00

• playback of these two tracks without audible disturbance

playing time for: Fingerprint 10seconds

Black dot from 00:50 to 01:10

• jump forward/backward (search) within a reasonable time

For all other sets

use CD-DA SBC 444A..................................4822 397 30245

TR 14 (600µ Black dot) maximum at 01:15

TR 19 (Fingerprint)

TR 10 (1000µ wedge)

• playback of all these tracks without audible disturbance

playing time for: 1000µ wedge 10seconds

Fingerprint 10seconds

Black dot from 01:05 to 01:25

• jump forward/backward (search) within a reasonable time

CUSTOMER INFORMATION

It is proposed to add an addendum sheet to the set which

informs the customer that the set has been checked

carefully - but no fault was found.

The problem was obviously caused by a scratched, dirty or

copy-protected CD. In case problems remain, the customer

is requested to contact the workshop directly.

The lens cleaning (method 3) should be mentioned in the

addendum sheet.

The final wording in national language as well as the printing

is under responsibility of the Regional Service Organizations.

LIQUID LENS CLEANING

Because the material of the lens is synthetic and coated

with a special anti-reflectivity layer, cleaning must be done

with a non-aggressive cleaning fluid. It is advised to use

“Cleaning Solvent

The actuator is a very precise mechanical component and

may not be damaged in order to guarantee its full function.

Clean the lens gently (don’t press too hard) with a soft and

clean cotton bud moistened with the special lens cleaner.

The direction of cleaning must be in the way as indicated in

the picture below.

Before touching the lens it is advised to clean the

surface of the lens by blowing clean air over it.

This to avoid that little particles make scratches on

the lens.

INSTRUCTIONS ON CD PLAYABILITY

2 - 2

BLOCK DIAGRAM

3-1 3-1

WIRING DIAGRAM

4-1 4-1

DISPLAY BOARD

CON9

REM1

D23

CON12

CON13

CON11

CON14

J701

CON3

J12

CON4

CON8

CON201

CON108

J702

CON5

CON2

CON7

CON1

POWER/

AMP BOARD

CON6 JACK1 SPEAKER JACK BOARD

MAIN BOARD

CON10

JK1

JK2

CDM (SANYO DA11B3VZ)

SPEAKER JACK

5-1 5-1

DISASSEMBLY DIAGRAM

BOTTOM CAB.

Dismantling of the Bottom Cabinet

Dismantling of the Front Cabinet and PCB Board.

1)Remove 2 screws A as indicated.

2)Remove 6 screws B as indicated to loosen the Bottom Cabinet.

1)Remove 2 screws C as indicated to loosen the Front Cabinet.

2)Remoce 9 screws D as indicated to loosen the Display Board.

3)Remove 2 screws E as indicated to loosen the Main Board.

CIRCUIT DIAGRAM - MAIN BOARD

PART1

6-1 6-1

Andere Handbücher für MCM103

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Philips Stereoanlage Handbücher

Philips

Philips BTM2360/55 Bedienungsanleitung

Philips

Philips Streamium MCi500H/12 Bedienungsanleitung

Philips

Philips Magnavox FW380C Bedienungsanleitung

Philips

Philips FW-V220 Bedienungsanleitung

Philips

Philips FWM35/19 Bedienungsanleitung

Philips

Philips FW-C255 Bedienungsanleitung

Philips

Philips MCD2160/12 Bedienungsanleitung

Philips

Philips MCM196D Bedienungsanleitung

Philips

Philips FW325/22 Bedienungsanleitung

Philips

Philips MCD2010 Bedienungsanleitung

Philips

Philips FW-i1000 Bedienungsanleitung

Philips

Philips MCM299/55 Bedienungsanleitung

Philips

Philips F1275 Bedienungsanleitung

Philips

Philips FCD 585 Bedienungsanleitung

Philips

Philips FW350C Bedienungsanleitung

Philips

Philips FWM185 Bedienungsanleitung

Philips

Philips CD Soundmachine AZ1837 Bedienungsanleitung

Philips

Philips FW-C10 Bedienungsanleitung

Philips

Philips MCM138D/12 Bedienungsanleitung

Philips

Philips FW350C/22 Bedienungsanleitung

Philips

Philips MC108/05 Bedienungsanleitung

Philips

Philips MC-M570 Bedienungsanleitung

Philips

Philips FW830C Bedienungsanleitung

Philips

Philips FWM779 Bedienungsanleitung

Beliebte Stereoanlage Handbücher anderer Marken

LG CM3330B Bedienungsanleitung

Sony

Sony SS-CEP50 Bedienungsanleitung

Cetacea Sound

Cetacea Sound CVS-II Bedienungsanleitung

Aiwa

Aiwa XR-H66MD Bedienungsanleitung

Denon

Denon UCD-250 Bedienungsanleitung

Sanyo

Sanyo DC-MX41i Bedienungsanleitung

Sharp

Sharp CD-ES600V Bedienungsanleitung

Exibel

Exibel BDX600-UK Bedienungsanleitung

Sanyo

Sanyo DC-F320 Bedienungsanleitung

Sharp

Sharp CD-C462 Bedienungsanleitung

Onkyo

Onkyo CBX 300 - CD / MP3 Clock Radio Bedienungsanleitung

Aiwa

Aiwa XR-EM70 Bedienungsanleitung

Cyrus

Cyrus Lyric Bedienungsanleitung

Philips/Magnavox

Philips/Magnavox Magnavox FW 62C Bedienungsanleitung

RCA

RCA RS3965SB Bedienungsanleitung

Sharp

Sharp XL-UH240 Bedienungsanleitung

LG FB165DAB Bedienungsanleitung

Sanyo

Sanyo DC-UB1475M/XE/UK Bedienungsanleitung