Pig DRM652 / 7848 Bedienungsanleitung
PIG®Waste Compactor Manual
Model Numbers: DRM652 / 7848 - Electric Waste Compactor
DRM653 / 7849 - Electric Waste Compactor with Waste Pump
DRM654 / 7850 - Air Waste Compactor
DRM655 / 7851 - Spark Resistant Waste Compactor
DRM656 / 7852 - Spark Resistant Waste Compactor with Waste Pump
DRM345 / 7818 - Air Waste Pump Kit
Shown: DRM653/7849: Electric Compactor with Waste Pump
New Pig
One Pork Avenue • Tipton, PA 16684-0304
Table of Contents
Introduction_______________________________________Page 3
Section I - Electric Compactors
1 Setup Instructions_______________________________Page 4
2 Operating Instructions ___________________________Pages 5-6
3 Product Data Sheets _____________________________Pages 7-10
4 Exploded View ________________________________Page 11
5 Parts List _____________________________________Pages 12-14
6 Electrical Schematic for DRM652/7848 _____________Page 15
7 Electrical Schematic for DRM653/7849 _____________Page 16
8 Preventative Maintenance_________________________Page 17
9 Trouble Shooting Guide __________________________Page 17
Section II - Air Compactors
1 Setup Instructions_______________________________Page 18
2 Operating Instructions ___________________________Pages 19-20
3 Product Data Sheets _____________________________Pages 21-26
4 Exploded View ________________________________Page 27
5 Parts List _____________________________________Pages 28-30
6 Air Schematics ________________________________Page 31
7 Preventative Maintenance_________________________Page 32
8 Trouble Shooting Guide __________________________Page 33
Section III - Waste Pump
1 Optional Waste Pump____________________________Pages 34-35
2
3
Introduction
PIG®Waste Compactor
Waste disposal is one of the most challenging issues industries face today. The average
disposal cost for a 55-gallon drum can range from $200-$700. Further complicating the
disposal picture is the shrinking number of active landfills. As a result, companies are pursuing
innovative ways to reduce their disposal costs.
In 1994, New Pig developed the PIG®Waste Compactor to compact absorbents and other soft
wastes. The Compactor significantly reduces waste to a fraction of its original volume
resulting in dramatically lower disposal costs. The original pump kit captures segregated
liquids for reuse or recycling.
To determine just how much money a PIG®Waste Compactor could save you, we conducted a
research study. Our results found that 100% of users significantly reduced the number of
drums they sent out for disposal. Compaction ratios ranged from a high of 6:1 to a low of 2:1.
New Pig's Product Development Team has designed the following features to insure safe
operation: an improved ram guard completely encloses the top of the drum and drum door
interlocks prevent access during operation. In fact, the PIG®Waste Compactor is approved by
the Canadian Standards Association, an OSHA-recognized testing laboratory.
Use your PIG®
Waste Compactor
to crush:
• Absorbents
• Wipers
• Rags
• Plastic
• Paper
• Cardboard
• Paper filters
• Other soft materials
(not recommended for wood,
metal or other hard materials)
Section I - Electric Compactors
1 Setup Instructions
1) Remove PIG®Waste Compactor from pallet and place on floor.
2) If desired, permanently mount the compactor to the floor using the pre-drilled holes in the
base. Up to 1/2" floor anchors can be used. Floor anchoring not required for operation
(anchors not included).
3) Power source required: 120 Volt AC with 15 amp breaker.
4) Wire unit to terminal block inside closure through hole marked 120 Volt AC 15 amp as
shown in schematic. (Note: wiring should be performed by a qualified electrician)
4
2 Operating Instructions
Always wear the proper safety equipment when operating this unit.
1) Open safety cover.
2) Tilt unit back with drum in
place to facilitate loading.
3) Return to upright locked position
and close safety cover.
5
4) Move directional lever on electric
pump to the down position and
depress operation button to
compact. Continue to compact until
the pump stops (reaching maximum
pressure).
5) To raise the ram, release button to
stop, move directional lever on
electric pump to the up position and
depress operation button.
Note: Unit will not operate if the unit is not in the upright position or safety cover is not closed.
6
Item# DRM652 / 7848 • PIG®Electric Compactor
DESCRIPTION- An electric operated compaction device used to increase the amount
of waste that can fit into a disposal drum.
Packaging: 1 Box/Pallet
Color: Black/Yellow
Weight: 506 lbs.
# Per Pallet: 1
Dimensions:
Overall Dimensions - 67 1/8" H x 31 1/2" W x 38" D
Ram Diameter - 22" O.D.
Hand Remote - Cord Length: 6'
Composition: Hot rolled steel, structural c-channel and aluminum.
Power Supply: 120 Vac
Amp Draw: 10 amps under maximum load
Motor: 1/2 HP - 3450 RPM
Elec. Connection: Power supply connection to be provided by customer
Average Cycle Time: 1 Minute
FEATURES/BENEFITS
• CSA/UL approved / Tested to meet safety requirements.
• "Ram Guard" covers top of drum / Prevents any possible hand injuries.
• Microswitch prevents use of compactor until cover is shut.
• 120 VAC/10 AMP hydraulic pump / Easy power supply is readily available.
• 12,000 lbs. of downward compaction force / High compaction capacity.
• Compacts as many as 6 drums into 1 / Reduces waste stream and disposal costs.
• One minute cycle time / Compacts quickly and saves time.
• Hand Remote Control / Easy operation.
• Tilt back frame / Allows drum to be filled with materials without having to move
drum away from compactor.
• Safety interlock / Won't run unless the unit is in the locked upright position.
7
Product Data Sheet
Item # DRM652 / 7848 Page 2
FEATURES/BENEFITS (Continued)
• Automatic shut off / Unit will only run when the button is depressed.
• Raised steel base plate under drum / Prevents the bottom of the drum from bowing
under the pressure of compaction.
• View port on ram guard / Allows the user to safely view what is happening in the
drum without opening the lid.
• Mounting holes in the base plate / Allows permanent mounting to floor.
• Drain holes in the ram plate / Allows liquid collected on the top of the ram
plate to drain back into the drum when the plate is lifted.
APPLICATIONS
Designed to assist in waste minimization programs by allowing the user to fit
more soft waste in each disposal drum. Designed to compact absorbents, rags,
paper filters and trash. * The unit is NOT for use with metal, flammables, wood
or other hard materials or crushing steel drums.
Rev. 10/01/97
8
Item# DRM653 / 7849 • PIG®Electric Compactor With Waste Pump
DESCRIPTION- An electric operated compaction device used to increase the amount
of waste that can fit into a disposal drum. Includes a waste pump that allows removal of free standing liquids
from the compaction process.
Packaging: 1 Box/Pallet
Color: Black/Yellow
Weight: 524 lbs.
# Per Pallet: 1
Dimensions:
Overall Dimensions - 67 1/8" H x 31 1/2" W x 38" D
Ram Diameter - 22" O.D.
Hand Remote - Cord Length: 6'
Waste Pump Hoses - Intake/Outlet: 5/8" I.D. x 7'
Composition: Hot rolled steel, aluminum and structural c-channel
Power Supply: 120 VAC
Amp Draw: 10 amps under maximum load
Motor: 1/2 HP - 3450 RPM
Elec. Connection: Power supply connection to be provided by customer
Waste Pump: 3 to 4 gal./min.
Average Cycle Time: 1 Minute
FEATURES/BENEFITS
• CSA/UL approved / Tested to meet safety requirements.
• "Ram Guard" covers top of drum / Prevents any possible hand injuries.
• Microswitch prevents use of compactor until cover is shut.
• 120 VAC/10 AMP hydraulic pump / Easy power supply is readily available.
• 12,000 lbs. of downward compaction force / High compaction capacity.
• Self-priming 3 to 4 gal./min. diaphragm waste pump / High output pump that can
run dry without damage.
• 20 mesh easy clean filter system / Keeping large particles from damaging and
clogging pump.
9
Product Data Sheet
Item # DRM653 / 7849 Page 2
FEATURES/BENEFITS (Continued)
• Corrosion and chemically resistant / No metal parts coming in contact with
liquids being pumped.
• Tilt back frame / Allows drum to be filled with materials without having to move
drum away from compactor.
• Safety interlock / Won't run unless the unit is in the locked upright position.
• One minute cycle time / Compacts quickly and saves time.
• Compacts as many as 6 drums into 1 / Reduces waste stream and disposal costs.
• Hand Remote Control / Easy operation.
• Automatic shut off / Unit will only run when the button is depressed.
• Drain holes in the ram plate / Allows liquid collected on the top of the ram
plate to drain back into the drum when the plate is lifted.
• Raised steel base plate under drum / Prevents the bottom of the drum from bowing
under the pressure of compaction.
• Mounting holes in the base plate / Allows permanent mounting to floor.
• View port on ram guard / Allows the user to safely view what is happening in the
drum without opening the lid.
APPLICATIONS
Designed to assist in waste minimization programs by allowing the user to fit more soft waste in each disposal
drum. Designed to compact absorbents, rags, paper filters and trash. * The unit is NOT for use with metal,
flammables, wood or other hard materials or crushing steel drums.
Rev. 10/01/97
10
Dieses Handbuch passt für folgende Modelle
5
Inhaltsverzeichnis
Andere Pig Müllpresse Handbücher
Beliebte Müllpresse Handbücher anderer Marken
Whirlpool
Whirlpool GX900QPLQ - 15" Trash Compactor Bedienungsanleitung
Vestil
Vestil FM-T-DUMP Bedienungsanleitung
GE
GE GCG1700P Handbuch
Euro Shatal
Euro Shatal RP4014-50 Bedienungsanleitung
third coast equipment
third coast equipment SP3410 Bedienungsanleitung
Cucine Oggi
Cucine Oggi EKKO CUBE 40 9000 Bedienungsanleitung
