Porter-Cable PCXH80KT Montageanleitung

PCXH80KT, PCXH140KT,

PCXH210KT

WARNING: If the information in this manual is not followed exactly, a fire or

explosion may result causing property damage, personal injury or loss of life.

— Donotstoreorusegasolineorotherflammablevaporsandliquidsinthevicinityofthisorany

otherappliance.

— Servicemustbeperformedbyaqualifiedserviceagency.

Thisisanunventedportableheater.Itusesair(oxygen)fromtheareainwhichitisused.Adequate

combustionandventilationairmustbeprovided.Refertopage3.

KEROSENE FORCED-AIR HEATER

OPERATINGINSTRUCTIONSANDOWNER’SMANUAL

READ INSTRUCTIONS CAREFULLY:Readandfollowallinstructions.Placeinstructionsinasafe

placeforfuturereference.Donotallowanyonewhohasnotreadtheseinstructionstoassemble,

light,adjustoroperatetheheater.

Model#

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

27354REVA

PorterCable,4825Highway45North,Jackson,Tennessee38305•888-848-5175

Porter Cable | Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

CONTENTS

WARNINGS................................................................................. 2

HEATERSPECIFICATIONS............................................................. 3

OPERATINGPRECAUTIONS.......................................................... 3

SAFETYPRECAUTIONS................................................................ 3

OPERATINGINSTRUCTIONS........................................................ 4

MAINTENANCE,STORAGEANDSERVICE................................... 4

TROUBLESHOOTING.................................................................... 6

WIRINGDIAGRAM...................................................................... 7

PARTSLIST.................................................................................. 8

EXPLODEDVIEW......................................................................... 9

WARRANTY...............................................................................12

INSTRUCTIONSFORORDERINGPARTS.......................................12

LANGUAGES

ENGLISH...........................................................................1-12

FRENCH.................................................................................1-12

SPANISH................................................................................1-12

WARNING:

• DONOTUSEGASOLINE,NAPHTHAORVOLATILE

FUELS.

• STOPHEATERBEFOREADDINGFUELS.

• ALWAYSFILLOUTDOORSAWAYFROMOPEN

FLAME.

• DONOTUSEEXTERNALFUELSOURCE.

• DONOTOPERATEHEATERWHEREFLAMMABLE

LIQUIDSORVAPORSMAYBEPRESENT.

• DONOTSTARTHEATERWHENCHAMBERISHOT.

• DONOTSTARTHEATERWHENEXCESSFUELHAS

ACCUMULATEDINTHECHAMBER.

• DONOTPLACECOOKINGUTENSILSONTOPOF

THEHEATER.

• PLUGELECTRICALCORDINTOAPROPERLY

GROUNDEDTHREE-PRONGRECEPTACLE.

GENERAL HAZARD WARNING:

 FAILURETOCOMPLYWITHTHEPRECAUTIONSAND

INSTRUCTIONSPROVIDEDWITHTHISHEATER,CAN

RESULTINDEATH,SERIOUSBODILYINJURYAND

PROPERTYLOSSORDAMAGEFROMHAZARDSOF

FIRE,EXPLOSION,BURN,ASPHYXIATION,CARBON

MONOXIDEPOISONING,AND/ORELECTRICALSHOCK.

ONLYPERSONSWHOCANUNDERSTANDANDFOL-

LOWTHEINSTRUCTIONSSHOULDUSEORSERVICE

THISHEATER.

 IFYOUNEEDASSISTANCEORHEATERINFORMATION

SUCHASANINSTRUCTIONSMANUAL,LABELS,ETC.

CONTACTTHEMANUFACTURER.

WARNING:

 FIRE,BURN,INHALATION,ANDEXPLOSIONHAZARD.

KEEPSOLIDCOMBUSTIBLES,SUCHASBUILDING

MATERIALS,PAPERORCARDBOARD,ASAFEDISTANCE

AWAYFROMTHEHEATERASRECOMMENDEDBYTHE

INSTRUCTIONSNEVERUSETHEHEATERINSPACES

WHICHDOORMAYCONTAINVOLATILEORAIRBORNE

COMBUSTIBLES,ORPRODUCTSSUCHASGASOLINE,

SOLVENTS,PAINTTHINNER,DUSTPARTICLESOR

UNKNOWNCHEMICALS.

WARNING:

COMBUSTIONBY-PRODUCTSPRODUCEDWHENUSING

THISPRODUCTCONTAINCARBONMONOXIDE,A

CHEMICALKNOWNTOTHESTATEOFCALIFORNIA

TOCAUSECANCERANDBIRTHDEFECTS(OROTHER

REPRODUCTIVEHARM).

THISPRODUCTCONTAINSCHEMICALSKNOWNTOTHE

STATEOFCALIFORNIATOCAUSECANCERANDBIRTH

DEFECTSOROTHERREPRODUCTIVEHARM.

WARNING:

 NOTFORHOMEORRECREATIONALVEHICLEUSE

WARNING:

 YOURSAFETYISIMPORTANTTOYOUANDTO

OTHERS,SOPLEASEREADTHESEINSTRUCTIONS

BEFOREYOUOPERATETHISHEATER.

The State of California requires the following warning:

WARNING:

CARBON MONOXIDE CAN KILL YOU

 USINGAPORTABLEHEATERINANENCLOSEDAREA

CANPRODUCEDEADLYCARBONMONOXIDE.

PCXH80KT WARNING:

Not suitable for use on wood floors or other

combustible materials. When used the heater

should rest on a suitable insulating material at

least 1 inch thick and extending 3 feet or more

beyond the heater in all directions.

Porter Cable| Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

SPECIFICATIONS

OPERATING PRECAUTIONS

Thisisakerosene,direct-fired,forcedairheater.It’sintendeduse

isprimarilytemporaryheatingofbuildingsunderconstruction,

alterationorrepair.

Direct-Firedmeansthatallofthecombustionproductsenterthe

heatedspace.Eventhoughthisheateroperatesverycloseto100

percentcombustionefficiency,itstillproducessmallamounts

ofcarbonmonoxide.Carbonmonoxide(calledCO)istoxic.CO

canbuildupinaheatedspaceandfailuretoprovideadequate

ventilationcouldresultindeath.Thesymptomsofinadequate

ventilationare:

• headache

• dizziness

• burningeyesandnose

• nausea

• drymouthorsorethroat

BesuretofollowadviceaboutventilationintheSafety

Precautionssection.

ForcedAirmeansthatablowerorfanpushestheairthroughthe

heater.Propercombustiondependsuponthisairflow;therefore,

theheatermustnotberevised,modifiedoroperatedwith

partsremovedormissing.Likewise,safetysystemsmustnotbe

circumventedormodifiedinordertooperatetheheater.

Whentheheateristobeoperatedinthepresenceofotherpeople

theuserisresponsibleforproperlyacquaintingthosepresent

withthesafetyprecautionsandinstructions,andofthehazards

involved.

SAFETY PRECAUTIONS

1. RecommendedforusewithNo.1-Kkerosenefuel.Factorytested

forusewithNo.2-Kkerosene,No.1orNo.2Diesel,No.1orNo.2

fueloilorJP8JetAfuelandthesefuelsmaybeusedaswell.Never

usegasoline,biodiesel,oildrainedfromcrankcases,naphtha,

paintthinners,alcoholoranyotherhighlyflammablefuels.

2. Checktheheaterthoroughlyfordamage.DONOToperatea

damagedheater.

3. DONOTmodifytheheateroroperateaheaterwhichhasbeen

modifiedfromitsoriginalcondition.

4. Suitableforeitheroutdoororindoorusewhereadequate

ventilationisprovided.Neveruseinareasnormallyfor

habitation.Notforusewhereexposedtoweather.

5. Useinwellventilatedareas,provideatleast2sq.ft.(0.19

sq.m.)ofopeningnearthefloorand2sq.ft.(0.19sq.m.)

neartheceilingdirectlytooutdoors.Increaseairopeningsas

markedforeachadditionalheater.

6. Alwayskeepcombustibles,likepaperandwoodatleast8

ft.(2.4m)fromtheheateroutletand3ft.(1.0m)from

thetop,sidesandinlet.Locate10ft.(3.0m)fromcanvas

orplasticcoveringsandsecurethemtopreventflapping

movement.

7. Caution:Duetothehighsurfaceandexhausttemperatures,

adultsandchildrenmustobserveclearancestoavoidburns

orclothingignition.DoNotTouch.Keepchildren,clothing,

andcombustibleaway.

8. Installtheheatersuchthatitisnotdirectlyexposedtowater

spray,rainand/orwater.

9. Neveruseinareasnormallyforhabitationand/orwhere

childrenmaybepresent.

10. Operateonlyonastable,levelsurface.(PCXH80KT–See

woodfloorwarning).

11. Donotusewithductwork.Donotrestrictinletorexit.

12. Useonlywithelectricalpowerspecified.Theelectrical

connectionandgroundingmustcomplywithNational

ElectricalCode–ANSI/NFPA70(USA)andCSAC22.1

CanadianElectricalCode,Part1(Canada).

13. Useonlyaproperlygrounded3-prongreceptacleor

extensioncord.

14. Donotmove,handle,orservicewhilehotorinoperation.

15. Useonlyinaccordancewithlocal,state(provincial)or

nationalrequirements,ordinancesandcodes.

CAUTION: CSA certified for use with only No. 1-K kerosene fuel.

Factory Tested: Kerosene, Diesel #1 and #2, Fuel Oil #1 and #2, JP8 (Jet A Fuel), Biodiesel blends B2, B5, B10, and B20

Model 80KT 140KT 210KT

Burn Rate: 80,000 Btu/hr (23.4 kW) 140,000 Btu/hr (41.2 kW) 210,000 Btu/hr (61.5 kW)

Fuel Rate: 0.59 gal/hr (2.2 L/hr) 1.0 gal/hr (3.9 L/hr) 1.6 gal./hr (6.0 L/hr)

Electrical Input: 115V, 60Hz, 4.0a 115V, 60Hz, 5.5 A 115V, 60Hz, 5.5 A

Line Protection: 10 amps 10 amps 10 amps

Min. Operating Voltage: 110V 110V 110V

Pressure Setting: 4.2 psig (29 kPa) 6.8 psig (47 kPa) 8.4 psig (58 kPa)

Max. Outlet Temperature: 1300oF (704oC) 1300oF (704oC) 1300oF (704oC)

Fuel Tank Capacity: 6 gallons (22.7 L) 10 gallons (37.9 L) 15 gallons (56.8 L)

Ignition: Direct Spark, Continuous Direct Spark, Continuous Direct Spark, Continuous

Spark Generator: Igniter 16.5 kV, 0.2 A Igniter 16.5 kV, 0.2 A Igniter 16.5 kV, 0.2 A

Primary Safety Control: Solid State Control Solid State Control Solid State Control

Certication:    

Porter Cable | Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

Notes:

• Incoldweather(below10°F),startingmaybeimprovedby

holdingafingerovertheventholeofthepumpadjustment

screwcapuntiltheheaterstarts.

• Thisunitisequippedwithaninterruptcircuit.Theresetis

integratedintothe“On/Off”switch.Iftheunitdoesnot

start,toggletheswitchto“Off”,wait5min.andtoggle

theswitchto“On”.

HEATER SHUT DOWN

1. Push“On/Off”switchto“Off”position.Forextended

shutdown,unplugheaterfrompowersource.

RESTART AFTER SAFETY SHUTDOWN

1. Toggleswitchto“OFF”position,wait5minutes.Restart.

MAINTENANCE AND STORAGE

WARNING.Topreventpersonalinjury,unplugtheheaterfrom

thewalloutletbeforeservicing.

Formaximumefficiencyandtrouble-freeservice,makethe

followingperiodicmaintenance,cleaningandinspections.

ADJUSTING PUMP PRESSURE

Duetovaryingfuelviscositiesandnormalcomponentwearthe

pumppressureonthisheatermayneedtobeadjusted.

FUELPRESSUREADJUSTMENTSCREW

(locatedattherearoftheheater)

PRESSUREGAUGE

ADJUSTMENT PROCEDURE

1.  Fillfueltank.

2.Startheater.

3.Locatethepressureadjustmentscrewandpressuretap,

picturedabove,locatedonthebackofthepowerpack

assemblyandaccessiblebythehandleoftheheater.

4.Removeandtherubbercapoverthefuelpressureadjustment

screw.

5.Usingaflatbladedscrewdriver,turnthepumppressure

adjustmentscrew:

•clockwise toincreasepumppressure

•counter-clockwise todecreasepumppressure

Byusingtheinstalledpressuregaugeyoumayquantitatively

calibratethepressure.Themanufacturer’srecommendedpump

pressuresareinthespecificationschartonpage3.

OPERATING INSTRUCTIONS

UNPACKING

1. Removeheaterfromcarton.

2. Removeallprotectivematerialwhichmayhavebeenapplied

totheheaterforshipment.

3. Checktheheaterforpossibleshippingdamage.Ifany

damageisfoundimmediatelycontactthemanufacturerat

888-848-5175.

ASSEMBLY (For140,000and210,000BTU/hrmodelsonly)

Wheels,axle,andhandlesarefoundintheshippingcartonalong

withmountinghardware.

1. Handlescomepre-assembledonthetank.Thetransport

handleandsupportfootsimplysnapintoplace.

2. Toassemblethewheels,firstInstalloneofthelargelocknut

ontotheendoftheaxle.

3. Slideonewheelontotheaxlenexttothenut,thenone

spacer.

4. Slidethepartiallyassembledaxlethroughthewheelsupport

frame.

5. Slidethespacerontotheaxlenexttothewheelsupport.

6. Slidethewheel,thenlargelastlargelocknutontotheaxle.

Usingtwoadjustablewrenchesholdbothnutsandtighten.

DONOTOVERTIGHTEN.

PREPARING FOR OPERATION

1. Checktheheaterforpossibleshippingdamage.Ifanyis

found,immediatelycontactthemanufacturerat

888-848-5175.

2. Followallofthe“Precautions”.

3. Fillthefueltankwithcleankerosene.Inextremelycold

weather,condensationmaydevelopinthetankanditis

recommendedthatatablespoonofde-icerbeaddedfor

eachgallon(3.78Liters)offuelinthetank.Whenfilling

theheater,useatleast2gallons(7.57liters)offuel.Besure

heaterislevelanddonotoverfill.Useafunnelorcanwitha

longfillspout.

IMPORTANT: Before filling fuel tank the first time or after ex-

tended storage periods, drain the fuel tank of any moisture

or condensation.

4. Locateheateratasafedistancefromcombustiblematerials.

ModelPCXH80KTisnotsuitableforuseonwoodfloorsor

othercombustiblematerials.Whenused,theheatershould

restonsuitableinsulatingmaterialatleast1inchthickand

extending3ft.ormorebeyondtheheaterinalldirections.

HEATER START UP

1. Turnthermostattolowestsetting,andmakesure“On/Off”

switchis“Off”.Plugtheheaterintoagrounded115V,60Hz,

1Øoutlet.Turnthermostattohighestsetting.Startheater

bypushingtoggleswitchto“On”position(lightsignifies

switchisin“ON”position).Adjustthermostattodesired

setting.Heaterwillcycleon/offasheatisrequired.

EXTENSIONCORDREQUIREMENTS:Upto100’(30.5m)use

16awg.conductor.101’-200’(30.5-61.0m)use14awg.

conductor.

Porter Cable| Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

6.Thedesiredqualitativeburnercharacteristicsarethatthenose

coneinthecombustionchambershouldbecherryredwithno

darkspotsandtheflameshouldnotextendbeyondthenose

cone.

IMPROPER PRESSURE ADJUSTMENT

Problem:  Heaterdoesnothaveastrongconsistentflame.

  Heatersmokesandspitsrawfuel.

  Noseconedoesnotgetcherryred.

Adjustment:Pumppressureistoolow.

  Turnadjustmentscrewclockwisetoincreasepump

  pressure.

Problem: Flameextendsbeyondtheendoftheheater.

Adjustment:Pumppressureistoohigh.

  Turnadjustmentscrewcounterclockwiseto

  decreasepumppressure.

DAILY SCHEDULE

1. GENERAL.Makegeneralvisualinspectionofheaterforloose

ordamagedparts.Checknutsandboltstoinsureagainst

loosenesscausedbyvibrationorroughhandling.Damaged

partsshouldberepairedorreplacedbeforeusingheater

again.Checkheateroperationtobesureitisoperating

normally(See“Servicing”sectionfordescriptionofnormal

operation).

2. FILTERS.Dirtyairorfuelfilterswillcauseanimbalancein

theair-fuelmixture.Thebestindicationthatthiscondition

existsisanincreaseinodorsordifficultygettingyourheater

toignite.Thisheatershouldneverbeoperatedwithoutthe

filtersinplace.Ifrequired,cleanfiltersasdescribedunder

“500Hours”and“AnnualSchedules”.

500 HOUR SCHEDULE

1. AIRINTAKEFILTER.Removeandwashthefilterelement

withamilddetergent,drythoroughlyandreplace.Donot

oilthefilterelement.Ifyourheaterisusedwherethere

isconsiderabledustordirt,cleanasoftenasnecessary

(approximatelyevery50hrs.).

2. REMOVEDUST.Cleanheatertwiceaseason(moreoften

underdustyconditions).Removeaccumulateddustfromthe

transformer,burner,motorandfanbladeswithcompressed

air.Wipeareacleanwithacleandrycloth.Inspectareato

ensureallforeignmaterialsareremoved,especiallyaround

theburnerandcombustionarea.

3. CADCELL.Cleantheglassportionofthecadcellwithasoft

drycloth.

4. NOZZLE.Accumulationofdirtfromfuelandcarbonfrom

thecompressorvaneswilleventuallyfillupthepassages

inthenozzle,resultinginreductionoffuelandairflow.

Pressurewillgraduallyincreasegivingimproperfuel-air

mixtureandexcessodorandsmoke.Ifthisoccurs,replace

thefuelnozzle.

5. FUELTANK.Cleantwiceaseason(duringfrequentlyused

periods,cleantwiceamonth).Drainandflushthefueltank

withcleanfueloil.

ANNUAL SCHEDULE

1. AIROUTPUTFILTER.Removetheairoutputfilterandtap

thecontaminatedsidegentlyonasolidobjecttoremove

contaminates.Compressedairorliquidsshouldnotbeused

tocleanthisfilter.Reinstallcleanedfilterinfilterbodyinthe

samepositionasitwaswhenremoved.Ifthefilterappears

extremelydirty,replaceitwithanewfilterofthesame

type.Whenreplacingthefiltercover,besurethegasketis

firmlyinplaceandthescrewsinthefiltercoveraretightto

preventairleaks.

2. FUELFILTER.Removethefuelfilterfromfuellineanddirect

compressedairthroughthefilterintheoppositedirection

offuelflow.Safetyglassesshouldbewornwhenusing

compressedair.

3. AIRANDFUELLINES.Iftheairorfuellinesareremoved

duringcleaning,besureallconnectionsaretightbefore

operatingunit.

STORAGE

Storetheheaterinadrylocationfreefromfumesordust.

Attheendofeachheatingseason,cleantheheaterasdescribed

intheMAINTENANCEsection.Drainandflushthefueltankwith

cleanfuel.Themanufacturerrecommendscompletelyfillingthe

tankwithfuelforextendedstoragetominimizecondensation

insidethetank.

Itisrecommendedtoonlystorekeroseneincontainersthatare

marked“KEROSENE”.

SERVICING

Ahazardousconditionmayresultifaheaterisusedthathasbeen

modifiedorisnotfunctioningproperly.

Whentheheaterisworkingnormally:

* Theflameiscontainedwithintheheater.

* Theflameisessentiallyyellow.

* Thereisnostrongdisagreeableodor,eyeburningorother

physicaldiscomfort.

* Thereisnosmokeorsootinternalorexternaltotheheater.

* Therearenounplannedorunexplainedshutdownsofthe

heater.

Digital Thermostat Codes

Code Description

CH Continuous Heat

F2 Thermostat Fault

LO Environment Temperature is below 16�F

HI Environment Temperature is higher than 99�F

Porter Cable | Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

TROUBLE SHOOTING

SYMPTOM TROUBLE SHOOTING

HighlimitswitchOpenCircuit 1) Makesureheateriscooledoff,toggleswitchto“OFF”position,wait5minutesandretry.

Sparks,callingforflame,but 1) Checkwiringtomotor(perwiringschematicinmanual).

noorslowmotoroperation 2) Makesurethatthepressuregaugeisinplaceandnotdamaged.

  3) Adjustpressureforproperheateroperationpermanual.

  4) WithheaterdisconnectedfromACsource,rotatefanclockwisetoverifymotorisfree.

  5) Removeairfilterhousingfrommotorandinspectthepumprotorfordamage.Ifdamaged,replacerotorassembly.

  6) Ifwiringiscorrect,pumprotorisokay,andmotorisnotrotatingfreely,replacemotororpower-packassembly.

  7) Ifproblempersists,replaceoilflamecontrolassembly.

  8) Checkforsparkarchingfromtheelectrodeassembly,tothecombustioncylinder.

  9) Checkthecadcellforcontinuity.

NoSpark  1) Checklengthandgageofextensioncordforproperamp.draw.(Checkrequirementsonpage4.)

  2) Checkwiringtoigniter(perwiringschematicinmanual).

  3) Checkgapbetweenelectrodeprobes(2.3-3mm).

  4) Stillnospark,replaceigniterassembly.

  5) Replaceoilflamecontrolassembly.

AbnormalMotorOperation- 1) Motorspeedtoolow(Motorshouldoperateat3450rpm)-Replacemotor.

MotoroverheatsorStops 2) WithheaterdisconnectedfromACsource,rotatefanclockwisetoverifymotorisfree.

  3) Removeairfilterhousingfrommotorandinspectthepumprotorfordamage.Ifdamaged,replacerotor

   assembly.

  4) Ifwiringiscorrect,pumprotorisokay,andmotorisnotrotatingfreely,replacemotororpower-packassembly.

  5) Replaceoilflamecontrolassembly.

UnabletoDetectFlame 1) Checkwiringtocadcell(perwiringschematicinmanual).

  2) Cleancadcellphotocell.

   a) Slidecadcelloutofcadcellholder.

   b) Pushthephotocelloutoftheblackrubbercadcellhousingbypushingonthe2purplewires.

   c) Cleanthephotocellwithasoftclothandrubbingalcohol.

   d) Pullthephotocellbackintothecadcellhousingandreinstallintoholder.

   e) Testheater.

  3) Iftheheaterstilldoesnotoperate,replacecadcell.

  4) Replaceoilflamecontrolassembly.

FlameControlFailure 1) Checkwiringinheater(perwiringschematicinmanual).

  2) Replaceoilflamecontrolassembly.

Porter Cable| Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

The parts lists and wiring diagram show the heater as it was

constructed.Donotuseaheaterwhichisdi󰀨erentfrom

thatshown.Heaterperformanceise󰀨ectedbyairpressure

setting.Ifthereisanyuncertaintyabouttheairpressure

WIRING DIAGRAM

setting, have it checked.

Aheaterwhichisnotworkingrightmustberepaired,butonly

byatrained,experiencedserviceperson.

WHT

RED

BLUE

BROWN

RED

Porter Cable | Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

PARTS LIST

* Not shown in drawing

REF

PART # DESCRIPTION

127175 80KFuelTank

227176 FuelFilterRubberGrommet

327177 FuelGauge

426959 FuelCap

6n/a FrontandBackSaddles

727178 80KLowerBarrel

827179 RubberGrommets

9n/a AirDeflectorFin(see#50)

10 27180 HighLimitSwitchBracket

11 27181 115HighLimitSwitch

12 F226865 CADCellFlameSensor

13 n/a PhotoCell(see#12)

14 27182 IgniterElectrode

15 27183 Nozzleadapter

16 27184 RubberFuelTube

17 27185 RubberAirTube

18 n/a FuelLineClamp

19 27186 80KNozzle

20 27187 80KFrontCover

21 27356 80KTopRearCover

22 27189 80KInletGrill

23 n/a StrainRelief

24 n/a PowerCord

25 2719 0 80KControlSideBlackSaddle

26 27191 IgnitionTransformer

27 27192 80KBlackSaddle

28 n/a FuelFilter(see#70)

29 27163 OBEHandle

30 n/a 80KFAKMotor(see#67)

31 27193 80KMotorBracket

32 27194 80KFanBlade

33 27195 StartCapacitor

REF

PART # DESCRIPTION

34 n/a AluminumOutletHousing(see#67)

35 n/a PumpRing(see#67)

36 n/a SichuanRotor(see#67or68)

37 n/a PlasticPumpDriveKey(see#67or68)

38 n/a Vanes(see#67or68)

39 27196 PlasticInletHousing

40 n/a InlethousingGasket(see#70)

41 n/a ClothDustFilter(see#70)

42 n/a SmallMetalMesh

43 27197 Smallfoamfilter

44 n/a SteelBallbearing(see#69)

45 n/a Pressureadjustmentspring(see#69)

46 n/a Nylonplug(see#69)

47 n/a Nylonpumpadjusmentscrew(see#69)

48 n/a FoamFilter(see#70)

49 n/a 80KCombustionTube(see#50)

50 27198 CombustionChamberAssembly

51 2719 9 CircuitBoard

52 2720 0 SinglePolePowerSwitch

53 27201 ThermostatKnob

59 27202 PhotoCellBracket

60 n/a BrassBarbElbow(see#67)

61 n/a TemperatureControlProbePlate

62 27203 CircuitBoardMountingBracket

63 n/a RearGuardMetalClip

64 2720 4 PantekThermostatBoard

66 n/a SaddleMountingStud

67 27205 PowerPackAssembly

68 F226831 RotorKit(rotor,vanes,nyloninsert)

69 F266842 PumpAdjustmentKit

70 F221887 FilterServiceKit

Porter Cable| Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

Kerosene Forced Air Heater • Model PCXH80KT

Filter Kit

Porter Cable | Kerosene Forced Air Heater Operating Instructions and Owner’s Manual

NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!NEVER LEAVE THE HEATER UNATTENDED WHILE BURNING!

PARTS LIST

#14 0 K 210K DESCRIPTION

127225 27226 FuelTank

227176 27176 FuelFilterRubberGrommet

327177 27177 FuelGauge

426959 26959 FuelTankCap

5 n/a n/a RearSaddleBracket

6n/a n/a FrontSaddleMount

727 211 27212 LowerBarrel

827179 27179 Grommet

927180 27180 HighLimitSwitchBracket

10 27181 27181 HighLimitSwitch

11 F226865 F226865 PhotoCellAssembly

12 n/a n/a PhotoCellSensor(see#11)

13 27182 27182 IgniterElectrode

14 27183 27183 NozzleAdapter

15 27231 27231 RubberAirTube

16 27233 27233 RubberFuelTube

17 n/a n/a FuelLineClamp

18 27235 27236 Nozzle

19 27214 27215 FrontCover

20 27357 27358 RearCover

21 27237 27237 InletGrill

22 n/a n/a StrainRelief

23 n/a n/a PowerCord

24 27220 27221 RightSaddle

25 27191 27191 Transformer

26 27223 27224 ControlSideLeftSaddle

27 n/a n/a OilFilter(see#75)

28 27239 27240 WheelAxle

29 27241 27242 Wheel

30 27359 27359 TransportHandle

31 27360 27360 LeftLiftHandle

32 27361 27361 RightLiftHandle

33 27362 27363 FrontLiftHandle

34 27364 27364 LowerFootAdapterTube

35 27365 27365 Foot

36 n/a n/a Motor(see#72)

37 27253 27253 MotorBracket

#14 0 K 210K DESCRIPTION

38 27255 27256 FanBlade

39 27195 271 Capacitor

40 n/a n/a PumpPlate(see#72)

41 n/a n/a PumpRing(see#72)

42 n/a n/a Rotor(see#mand73)

43 n/a n/a PlasticPumpDriveKey(see#72or73)

44 n/a n/a Vanes(see#72or73)

45 n/a n/a PlasticInletHousing(see#72)

46 n/a n/a InletHousingGasket(see#75)

47 n/a n/a Filter(see#75)

49 27197 n/a SmallFoamFilter(see#75)

50 n/a n/a SteelBallBearing(see#74)

51 n/a n/a AdjustmentSpring(see#74)

52 27273 27273 PressureGauge

53 n/a n/a PumpAdjustmentScrew(see#74)

54 n/a n/a LargeDustproofSponge(see#75)

55 27257 27258 CombustionChamberAssembly

56 n/a n/a AirDeflectorAssembly(see#55)

57 2719 9 2719 9 CircuitBoard

58 2720 0 2720 0 SinglePoleSwitch

59 27201 27201 ThermostatKnob

60 27260 27260 HandleTubePlug

61 N/A N/A Gasket

62 27262 27262 DrainPlugwithGasket

63 27202 27202 PhotoCellBracket

64 n/a n/a BrassBarbElbow

65 n/a n/a TemperatureControlProbeClip

66 27203 27203 CircuitBoardBracket

67 27174 2716 0 CordWrap

68 27265 27266 MetalStandoff

69 2720 4 2720 4 ThermostatBoard

70 n/a n/a SpringClip

71 27269 27269 WheelHardwareKit(notpictured)

72 27271 27272 PowerPack

73 F226831 F226831 RotorKit

74 F266842 F266842 AdjustmentKit

75 F221887 F221887 FilterKit

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Sprachen:

Andere Porter-Cable Heizung Handbücher

Porter-Cable

Porter-Cable PCXH125FAV Montageanleitung

Beliebte Heizung Handbücher anderer Marken

oventrop

oventrop Regucor Series Bedienungsanleitung

Blaze King

Blaze King CLARITY CL2118.IPI.1 Bedienungsanleitung

ELMEKO

ELMEKO ML 150 Bedienungsanleitung

BN Thermic

BN Thermic 830T Bedienungsanleitung

KING

KING K Series Leitfaden

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Kurzanleitung

Well Straler

Well Straler RC-16B Bedienungsanleitung

EUROM

EUROM 333299 Bedienungsanleitung

Heylo

Heylo K 170 Bedienungsanleitung

Eterna

Eterna TR70W Bedienungsanleitung

Clarke

Clarke GRH15 Bedienungsanleitung

IRSAP

IRSAP The Radiator Company Ovali Bedienungsanleitung

Empire Heating Systems

Empire Heating Systems WCC65 Bedienungsanleitung

Wetekom

Wetekom 92 86 43 Bedienungsanleitung

Desa

Desa SPC170-F Bedienungsanleitung

Watlow

Watlow Watrod Electric Tubular Heaters Bedienungsanleitung

Haverland

Haverland ECO-DRY GPS Series Stücklistenhandbuch

Stelpro

Stelpro ASILVC2060 Series Bedienungsanleitung