ProAir Electra Kool Bedienungsanleitung
2900 County Rd 6 W~ Elkhart, IN 46514
574-264-5494/Toll Free: 800-338-8544/Fax: 547-264-2194
Service Manual
For
Rooftop RV Air Conditioner
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
2 | P a g e
Table of contents
Warning and Safety Statement
Cool Mode operation
Maintenance
Troubleshooting Chart
Wire Schematic
Unit Drawing (50 001 911)
Plenum Drawing (52 001 125)
Warranty Registration
Warranty Procedure
Warranty Checklist
Page
3 - 4
5
5
6
7 - 12
8 - 10
11 - 12
13
13
14
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
3 | P a g e
Warning & Safety Statement
Only trained and fully qualified techniciansshould
test, repair oradjust vehicle refrigeration
equipment. Even something as "simple" as
tightening a belt can put the uniformed individual at
serious personal risk.
PersonalProtectiveGear
When workingon and
aroundtransport
refrigeration units, it's
important to wear
protective clothing. It's
important toprotect
yourself from battery acid,
hot coolant, refrigerants, refrigerant oils, flying dirt.
debris, and noise.
High Voltage
When working on all-electric units
you may beexposed to high
voltage. To work
safely on this
equipment, you MUST fully
understand and follow safe
electrical
work practices.
Toxic Gas
Frostbite
Liquid refrigerant in contact with your skin will
cause severe injury. Always wear eyeprotection
and protective clothing and use extremecare when
opening valves and removingcaps,gauges,
refrigerant lines,etc.
May Start Automatically
All-Electric units
have an
auto-start
feature that
may
start thesystem
without warning.
Keep all service doors
closed and
guardsin
placewhen
not
working on the
unit. Placethe unit
'
ON/OFFswitch in
the
OFFposition and disconnect the negative
battery
cablebeforeworkingonornear
componentsthat
rotate during normal operation.
Refrigerants in the
presence of an open flame
produce toxic gases.
These gases are severe
respiratory irritants
capable of causing death.
Usecaution when working
with refrigerant in aclosed
orconfined area with a limited air supply such as a
trailer, container or hold of a ship. Refrigerant
displaces air and can cause death due to suffocation.
HotSurfaces
Ventilation
Thecompressordischarge
manifold, engineexhaust
system, and otherunit
componentsmay be extremely
hot. These surfaces can cause
severe bums.
Soldering may produce harmful
gases. Make surethe area is well
ventilated when soldering.
"""'
A
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
4 | P a g e
Rotating
Fan
Use extreme
caution when
working on or
around
equipment having
Rotatingfans,pulleysand
belts.
•
Never applyheat to pressurized containers or
pressurized refrigerant lines.
•
Observe all safety placards on the unit and
caution statements in unit documentation.
•
Never operate theunit with the discharge
service valve front-seated (closed).
•Be sure gauge manifold hoses are in good
condition. Never let them contact belts, fans,
pulleys or hot surfaces.
Units should be switched OFF before working
on or
near fans.belts and pulleys.
Steam
Removing or loosening the
radiator cap of a
unit that is at or above operating
temperature may cause
severeburns
due to violent
hot water and steam emissions.
Allow the cooling system to cool
before loosening or
removing the radiator cap
or any other cooling
system components.
Additional Safety Tips
Observe your shop's lock-out I tag-out
requirements. Truck ignition keys must be
secured and the wheels chocked.
•
Use extreme caution when working on
ladders
and work platforms. Use ladders
and/or overhead harnesses in the manner
prescribed by the manufacturer of these
products.
•
Do not wear a wrist watch, rings, or other
jewelry while working on or around
equipment.
These items may catch on
equipment or conduct
dangerous electrical
current that may result in
severe personal
injury or death.
•
Be sure all mounting bolts are the correct length
for
the application and are securely tightened.
•
Refrigeration oil can damage eyes and cause skin
irritation. Avoid prolonged contact with
the skin
or clothing.
•
Refrigerants and refrigerant oils may be
flammable or explosive under certain
conditions. Use care when using any type of
ignition source near refrigerant lines and
components.
•
Never unsolder tubing or components on a
sealed
and pressurized system. Always verify
the
refrigerant has been removed from the
portion of
the system being repaired.Check that
service valves
are mid-seated and uncapped to
allow rising
pressure to vent.
02
AJ•
•
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
5 | P a g e
Cool Mode Operation
1. Select “COOL”mode to turn on air conditioning.
2. Set desired temperature on control panel.
3. Select desired blower speed with slide bar on control panel.
4. Auto mode when selected will select a fan speed depending upon the difference between the set temperature
and ambient room temperature. Will control the temperature within ± 2°of set point.
Maintenance
Return Air Filter Cleaning (FIGURE #1):
1. Turn system off.
2. Turn knobs counter-clockwise ¼ of turn to remove intake grill and filter.
3. Remove dirt and dust from filter with vacuum and wash filter with soap and water. Filter should be
cleaned once a month during normal conditions and daily or weekly if conditions are warranted.
Note: Never run the air conditioner without the return air filter. Running the air conditioner without a
filter may allow the evaporator coil to be plugged with dirt which will affect the performance of the air
conditioner.
Condenser Coil Cleaning: It is recommended that you clean the condenser and fins every year with
soapy or non-acid coil cleaning liquid in normal conditions or more frequently in extreme conditions to
maintain the efficiency of your RV air conditioner. Eventually, if not cleaned properly the condenser fins
may become clogged with dirt and dust. Do not use high pressure water or steam to clean condenser
fins.
1/4 Turn Knobs
Intake Filter
Intake Grill
FIGURE #1
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
6 | P a g e
TROUBLESHOOTING CHART
Symptom
Probable Solution
UNIT WILL NOT TURN ON
1. Make sure vehicles master switch is on.
2. Check to make sure connections are tight at POS and GROUND
studs at evaporator base.
3. Check for 12 volts at POS stud and ground at GROUND studs on
evaporator base.
EVAPORATOR BLOWER INOP
1. Make sure control panel is ON and calling for a desired fan speed.
2. Check for blown 5 AMP fuse and 20 AMP blower fuse (FIGURE
#2) behind return air filter.
3. Check for 12 volts and ground at studs on evaporator base.
4. Check harnesses to ensure wires going in and out of connectors
match and are inserted into connectors correctly.
5. Check to make sure connectors are plugged into mating
connectors correctly.
6. Contact ProAir for service options.
UNIT NOT COOLING, CONDENSER
FAN AND COMPRESSOR NOT
RUNNING
1. Check to make sure control panel is in COOL mode.
2. Set desired thermostat temperature on controller below inside
ambient temperature.
3. Check for blown 20 AMP condenser fuse (FIGURE #2) behind
return air filter.
4. Check harnesses to ensure wires going in and out of connectors
match and are inserted into connectors correctly.
5. Check to make sure connectors are plugged into mating
connectors correctly.
6. Contact ProAir for service options.
UNIT NOT COOLING, CONDENSER
FAN RUNNING, COMPRESSOR NOT
RUNNING
1. Check for blown 5 AMP fuse (FIGURE #2) behind return air
filter.
2. Check harnesses to ensure wires going in and out of connectors
match and are inserted into connectors correctly.
3. Check to make sure connectors are plugged into mating
connectors correctly.
4. Contact ProAir for service options.
6 PIN CONNECTOR
3 PIN CONNECTOR
Condenser Fuse
20 Amp w/Red Wire
w/white stripe
5 Amp Fuses
Blower Fuse 20 Amp
w/Red Wire
ProAir Relay Harness
FIGURE #2
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
7 | P a g e
A
B
C
F
E
D
C
B
A
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
8 | P a g e
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
9 | P a g e
PRODUCT: 12v Rooftop RV Operation & Service Manual
RELEASE DATE: 1/4/19
REVISION DATE: 1/4/19, Rev. A
PART NUMBER: 09 000 545
10 | P a g e
Inhaltsverzeichnis
Andere ProAir Klimaanlage Handbücher
