Rancilio EGRO 55 Series Bedienungsanleitung

EGRO 55 SERIES TECHNICAL MANUAL

EGRO 55 SERIES

TECHNICAL MANUAL

This page is intentionally left blank.

TABLE OF CONTENTS:

SECTION 1: INTRODUCTION

SECTION 2: INSTALLATION

SECTION 3: PROGRAMMING

SECTION 4: ELECTRICAL

SECTION 5: HYDRAULIC

SECTION 6: ADJUSTMENTS AND MAINTENANCE

This page is intentionally left blank.

EGRO 55 SERIES TECHNICAL MANUAL

SECTION 1:

INTRODUCTION AND OVERVIEW

TABLE OF CONTENTS: SECTION 1

Page

1.1 MACHINE OVERVIEW.................................................................................................................. 2 - 3

1.1a. Model 5511- identiﬁes parts of machine................................................................................................. 2

1.1b Model 5513 - identiﬁes parts of the machine and the Model KS Fridge....................................................... 3

1.2 SAFETY PRECAUTIONS................................................................................................................. 4

1.3 PRE-INSTALLATION REQUIREMENTS............................................................................................. 5 - 6

1.3a Pre-install requirements for Model 5511.................................................................................................. 5

1.3b Pre-install requirements for Model 5513 with KS fridge.............................................................................. 6

This page is intentionally left blank.

- Section 1: Page 2 - E55_TM_S1_IntroV3

EGRO 55 SERIES TECHNICAL MANUAL

MODEL 5511

1.1a MACHINE OVERVIEW: MODEL 5511

# ITEM

1 Bean Hoppers (capacity 2.8 lbs of coffee beans)

2 Display screen

3 Key pad

4 Programming key

5 Hot water spout

6 Grounds drawer door + access to main power & water switches

7 Drip tray

8 Coffee outlet

9 Legs

10 Temperature Sensitive (TS) Steam Wand

11 Stainless steel outlet cover

12 TS Steam wand activation button

13 Front door to machine

14 Cleaning tablet access door

EGRO 55 SERIES TECHNICAL MANUAL

- Section 1: Page 3 - E55_TM_S1_IntroV3

1.1b. MACHINE OVERVIEW: MODEL 5513

CLOSE-UP OF MACHINE PARTS

MODEL 5513

# ITEM

Model 5513 includes items 1-14 as described on the previous page PLUS the following items...

15 Above the counter Model KS refrigerator

16 Model KS fridge door latch

17 Model KS fridge door

18 AFV (Air Foam Valve)

19 Frother heads

20 Milk pump housing

21 Hoses to Milk gallon

22 Standard US gallon of Milk

CLOSE-UP OF FRIDGE PARTS

- Section 1: Page 4 - E55_TM_S1_IntroV3

EGRO 55 SERIES TECHNICAL MANUAL

1.2 SAFETY PRECAUTIONS

GENERAL SAFETY RULES

Do not leave packing materials (plastic bags, expanded polystyrene, nails, cardboard, etc.) within the

reach of children, as these items are a potential source of danger.

Verify that the electrical data of the machine corresponds with the electrical supply network before

connecting the machine to the power source. PLEASE NOTE: Egro Model 55 series machines require 208V

30amp main power supply. If you are located in a area which experiences ﬂuctuations in power which cause

the main power supply to drop below 208V, it is highly recommended that you install a power booster in line

with the Egro 55 series equipment.

Electrical adaptors, multiple sockets, and or extensions should not be used.

Request a detailed description of the available power from an electrician. The electrical outlet must have

the following safety features:

- Dedicated ground

- Wiring suitable for wattage capacity

- Circuit breaker

Install the machine on a water repellent surface (laminate, steel, ceramic etc.). Keep the machine away

from heat sources (oven, stove, ﬁreplace, etc.) and away from extreme cold, the temperature should not

fall below 41oF.

Do not leave the machine exposed to harmful environmental elements, such as rain, snow, or humidity.

Do not obstruct the drain on the drip tray. Be sure drain tray is clean and waste can easily ﬂow into the

drain tube.

Store the packed machine in a dry warm place. Do not store where the temperature may fall below 41oF.

Do not stack heavy items on the packaging.

In case of emergency, such as the machine catching on ﬁre, unusual noises coming from the machine,

overheating etc, maintain your personal and the safety of those around you FIRST. When it’s safe,

immediately disconnect the power and close all water taps.

Use only authorized spare parts in order to avoid compromising the safety and proper functioning of the

machine.

Equipment installed incorrectly can cause damage to people and items for which the manufacturer cannot

be responsible.

EGRO 55 SERIES TECHNICAL MANUAL

- Section 1: Page 5 - E55_TM_S1_IntroV3

1.3a PRE-INSTALLATION REQUIREMENTS FOR EGRO MODEL 5511

ELECTRICAL REQUIREMENTS

NEMA L6-30R (220 volt - 30 amp) receptacle is required.

PLEASE NOTE: Egro coffee machines do not use a neutral line. A dedicated

ground wire is required for proper performance.

= Ground

= Hot leg

COUNTER TOP REQUIREMENTS

WATER REQUIREMENTS

Machine requires a cold water line with a male 3/8” NPT ﬁtting and a manual

shut off valve (within in 4ft. of machine).

Water should be installed in accordance with local laws.

Hardness of water going to espresso machine should be tested and should be

less than 3 GPG or the warranty of the machine may be voided.

PLEASE NOTE: A water ﬁltration and softening system can be purchased

through Rancilio or a high quality espresso equipment ﬁltration system may

be used, however all pre-installed systems are subject to inspection and

approval by a certiﬁed Rancilio technician.

DRAIN REQUIREMENTS

Machine requires a 1 inch (inter diameter) drain pipe installed .

Connection for drain hose must be 12 inches below counter top and less than

4 feet from the intended location of the machine.

Drain must be installed in accordance with local laws.

COFFEE REQUIREMENTS

On installation day you must have 2lbs of each types of coffee (i.e. 2lbs of

regular espresso beans & 2lbs of decaf espresso beans) you are serving.

ALL REQUIREMENTS ARE NECESSARY FOR EACH MACHINE INSTALLED

(TWO MACHINES = DOUBLE COUNTER SPACE, 2 ELECTRICAL LINES, 2 WATER LINES, 2 DRAINS ETC...)

Counter must be able to support 150lbs (300lbs for 2

machines).

Counter space available must be 18”W x 261

”D x

39”H*.

Counter needs a 31

inch access hole for electrical

lines, water, and/or drain hoses. Hole should be

located in the center of where the machine will be

placed.

* These dimensions include 6” of clearance on all sides of the machine.

1(ø30mm)

2(3/8" NPT)

3(3/8" BSPT)

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Rancilio Kaffeemaschine Handbücher

Rancilio

Rancilio Baby 9 Bedienungsanleitung

Rancilio

Rancilio Classe 8 S Bedienungsanleitung

Rancilio

Rancilio Classe 8 S Bedienungsanleitung

Rancilio

Rancilio Classe 7E Bedienungsanleitung

Rancilio

Rancilio CLASSE 5 Bedienungsanleitung

Rancilio

Rancilio EGRO ONE Touch Pure Coffee Bedienungsanleitung

Rancilio

Rancilio Classe 8 S Bedienungsanleitung

Rancilio

Rancilio EPOCA E Bedienungsanleitung

Rancilio

Rancilio Millennium Bedienungsanleitung

Rancilio

Rancilio Classe 7E Bedienungsanleitung

Rancilio

Rancilio EPOCA E Bedienungsanleitung

Rancilio

Rancilio CLASSE 9 Bedienungsanleitung

Rancilio

Rancilio CLASSE 11 Series Bedienungsanleitung

Rancilio

Rancilio EGRO 5513 Bedienungsanleitung

Rancilio

Rancilio Classe 8 DE Bedienungsanleitung

Rancilio

Rancilio CLASSE 7 Bedienungsanleitung

Rancilio

Rancilio CLASSE 5 S Bedienungsanleitung

Rancilio

Rancilio Classe 9 RE Bedienungsanleitung

Rancilio

Rancilio CLASSE 10 Bedienungsanleitung

Rancilio

Rancilio Classe 8 DE Bedienungsanleitung

Rancilio

Rancilio CLASSE 7 Bedienungsanleitung

Rancilio

Rancilio Epoca S Bedienungsanleitung

Rancilio

Rancilio Classe 6 E Bedienungsanleitung

Rancilio

Rancilio EPOCA E Bedienungsanleitung

Beliebte Kaffeemaschine Handbücher anderer Marken

Taurus

Taurus Livorno 6 Bedienungsanleitung

Delta-q

Delta-q QUICK Bedienungsanleitung

Bunn

Bunn LCA-1 Fehlerbehebungshandbuch

Black & Decker

Black & Decker BLACK DECKER HOME DE790 Montageanleitung

Saeco

Saeco Vienna Plus Sup 018M Bedienungsanleitung

DeLonghi

DeLonghi DC300 Bedienungsanleitung

INCAPTO

INCAPTO BXCO1470E Bedienungsanleitung

Bosch

Bosch TASSIMO finesse TAS16B Series Bedienungsanleitung

Exido

Exido 245-072 Bedienungsanleitung

Animo

Animo OptiVend Choco Bedienungsanleitung

Siemens

Siemens TQ505DF Series Bedienungsanleitung

DeLonghi

DeLonghi ECI341 Bedienungsanleitung

Krups

Krups KT406511 Bedienungsanleitung

Cimbali

Cimbali M32 Classic Bedienungsanleitung

Philips

Philips HL3844N Bedienungsanleitung

Bosch

Bosch TES 515 SERIES Bedienungsanleitung

Tekmatix

Tekmatix TMFM - 65 Bedienungsanleitung

Scarlett

Scarlett SC-CM33005 Bedienungsanleitung