Raven SmarTrax Steering Kit Bedienungsanleitung
SmarTrax™ Installation Manual
Case MX 180-270 Series Wheel Tractors
While every effort has been made to ensure the accuracy of this document,
Raven Industries assumes no responsibility for omissions and errors. Nor is any
liability assumed for damages resulting from the use of information contained
herein.
Raven Industries shall not be held responsible or liable for the effects of
atmospheric conditions and sunspot activity on the performance of our products.
Raven Industries cannot guarantee the accuracy, integrity, continuity, or
availability of the GPS signal from the U.S. Department of Defense/NAVSTAR
GPS satellites, the OmniSTAR correction service or the WAAS correction
service.
Raven Industries accepts no responsibility for the use of the signal for other than
the stated purpose. Raven Industries shall not be responsible or liable for
incidental or consequential damages or a loss of anticipated benefits or profits,
work stoppage or loss or impairment of data arising out of the use, or inability to
use, the SmarTrax or any of its components.
Disclaimer
Manual # 016-0190-006
1
C H A P T E R
1
INTRODUCTION
Congratulations on your purchase of the Raven SmarTrax system! This system is designed
to provide cutting-edge, hands-free steering of your machine via GPS coordinates.
The instructions in this document are to be ussed to install the Smartrax Steering Kit for the
following models of CASE Wheel Tractors:
MX180,MX200,MX220,MX240,andMX270
Case MX 180-270 Series Wheel Tractors SmarTrax Installation Manual
2
Basic Kit
Contents
Below you will see the kit contents that you should have received with this SmarTrax
kit.
Case MX 180-270 Series Wheel Tractors SmarTrax Kit Contents
ytitnauQnoitpircseDmetIrebmuNtraP
1SPS,tiK100-1810-360
1072XMesaC,dlofinaM,.dyH,tekcarB,tnemdleW015-9510-611
1edirrevO/dioneloS,ciluardyH,elbaC664-1710-511
1sgtF/WjdAraB001-51,DH,orciM,erusserP,hctiwS470-0000-224
1feileR/WSLretneCdesolC,.dyH,evlaV660-3000-433
4daeHxeH"8/7x81-61/5,tloB401-2500-113
1gnoLmm52xmm61cirteMxeH,tloB900-0700-113
4"61/5,kcoL,rehsaW910-0001-313
1noitallatsnI,launaM600-0910-610
1xartramS,noitallatsnI,launaM120-1009-610
1petStoNoD,gninraW,lebaL886-9510-140
1gnirepmaT,gninraW,lebaL986-9510-140
3F/MCIJ6-,leviwS°54,woblE,.gtF720-2100-333
4F/M/MSFRO8-,eeTnuRleviwS,retpadA,.gtF820-2100-333
4F/MCIJ6-,leviwS°09,woblE,.gtF240-2100-333
4FJ6"386-S09FF8,dyH,esoH920-0001-412
1FJ6"084-S09FF6,.dyH,esoH030-0001-412
1FJ6"086-MF6,.dyH,esoH130-0001-412
Manual # 016-0190-006
3
C H A P T E R
2
SAFETY
Important: Hydraulics are under pressure. Never attempt to
open or work on a hydraulic system with the equipment running.
Care should always be taken when first opening a system that
was previously pressurized.
When disconnecting the hydraulic hoses or when purging is required, be aware
that the hydraulic oil within the machine system may be extremely hot and under
high pressure. Caution must be exercised. Any work carried out on the hydraulic
system must be performed in accordance with the machine manufacturerer’s
approved maintenance instructions. Raven Industries recommends that appropri-
ate protective equipment be worn when working on the hydraulic system. Ob-
jects or materials that are able to bypass the machine’s hydraulic filtration system
will adversely reduce performance and possibly damage the hydraulic valves.
Do not reverse the power leads. Doing so will cause severe damage to the
equipement. Always check to make sure that the power leads are connected to
the right polarity as marked. Ensure that the power cable is the last cable to be
connected.
Hydraulic
Safety
Requirements
Electical
Safety
Requirements
Case MX 180-270 Series Wheel Tractors SmarTrax Installation Manual
4
We welcome your feedback about this manual. If you have any comments or
suggestions for improvement, please let us know by contacting our Customer
Support Center by any of the following methods:
Via phone: 1-800-243-5435
Viamail:
Raven Industries
FlowControlDivision
205 E. 6th St.
Sioux Falls, SD 57104
Via email: [email protected]
Contacting
Raven
Industries
Manual # 016-0190-006
5
C H A P T E R
3
MOUNTING THE BRACKET AND VALVE
1. The Smartrax Valve and Pressure Switch are both mounted on the
supplied mounting bracket.
2. The Steering Override Pressure Switch is connected directly to the PS
Port on the Smartrax Valve.
3. The mounting point for the Steering Assist Valve Bank and Steering
Override Pressure Switch is located on the front of the transmission
housing, above and in front of the RHS rear axle in the wheel arch, and
behind the hydraulic pump.
SteeringAssist Valve Bank mounting location
Installing
Steering Assist
Valve Bank &
Steering
Override
Pressure
Switch
Case MX 180-270 Series Wheel Tractors SmarTrax Installation Manual
6
Steering Assist Valve Bank & Pressure Switch
(NOTE: Valve in picture differs from one currently used.)
4. Mount the Smartrax Valve w/Pressure Switch attached on the mounting
bracket using the supplied bolts.
Bracket mounting area
Steering Assist Valve Bank mounted
Manual # 016-0190-006
7
C H A P T E R
4
HYDRAULICS
Steering Assist
Valve Bank
Hose Routing
Location of tractor SCU - Close-up View
Case MX 180-270 Series Wheel Tractors SmarTrax Installation Manual
8
2. Attach the tee connectors supplied to the L, R, P, and Tports of the
SCU.
The figure below shows the tractor SCU ports before installation.
Important: Take precautions to prevent any contaminates
being introduced into the tractors hydraulic system.
Helpful Hint: The L& Rtee connectors should be
positioned towards the LHS of the tractor while the P& T
connectors should be positioned to the RHS of the tractor to
provide easy installation of the hydraulic hoses.
Ports T, P, A, and B connections on SCU before install
T, P, A, and B tee connections on SCU after install
Inhaltsverzeichnis
Andere Raven Traktorzubehör Handbücher
Raven
Raven TC1 Bedienungsanleitung
Raven
Raven AutoBoom Bedienungsanleitung
Raven
Raven AutoBoom XRT Bedienungsanleitung
Raven
Raven AccuBoom Bedienungsanleitung
Raven
Raven SmarTrax Bedienungsanleitung
Raven
Raven SmarTrax Bedienungsanleitung
Raven
Raven SBGuidance Auto Bedienungsanleitung
Raven
Raven ICD Sidekick Pro Bedienungsanleitung
Raven
Raven SmarTrax Bedienungsanleitung
Raven
Raven SmarTrax MD Gebrauchs- und Pflegehandbuch
Raven
Raven SmarTrax Bedienungsanleitung
Raven
Raven SmarTrax Bedienungsanleitung
Raven
Raven RS1 Bedienungsanleitung
Raven
Raven VSN Bedienungsanleitung
Raven
Raven AccuBoom Bedienungsanleitung
Raven
Raven AutoBoom Rogator 54 Series 1997+ Bedienungsanleitung
Raven
Raven SmarTrax Bedienungsanleitung
Raven
Raven RS1 Bedienungsanleitung
Raven
Raven SmarTrax Bedienungsanleitung
Raven
Raven SC1 Bedienungsanleitung
