Raypak B-206A-MN-C ASME Bedienungsanleitung

Digital Gas Heater

Tool Box Quick Reference Guide

Water Chemistry

GENERAL

Recommended Levels Fiberglass Pools Fiberglass Spas Other Pool & Spa Types

Water Temp. (Deg. F) 68 to 88 89 to 104 68 to 104

pH 7.3 to 7.4 7.3 to 7.4 7.6 to 7.8

Total Alkalinity (PPM) 120 to 150 120 to 150 80 to 120

Calcium Hardness (PPM) 200 to 300 150 to 200 200 to 400

Salt (PPM) 4500 MAXIMUM 4500 MAXIMUM 4500 MAXIMUM

Free Chlorine (PPM)22 to 3 2 to 3 2 to 3

Total Dissolved Solids (PPM) 3000 MAXIMUM33000 MAXIMUM33000 MAXIMUM3

For your health and the protection of your pool equipment, it is essential that your water be chemically balanced1.

The following levels must be used as a guide for balanced water.

1 Damage from corrosive water is not covered under warranty. Consult your product manual for more information.

2 Free Chlorine MUST NOT EXCEED 5PPM.

3 In salt water chlorinated pools, the total TDS can be as high as 6000PPM.

• Occasional chemical shock dosing of the pool or spa water should not damage the heater providing the water is

balanced.

• Automaticchemicaldosingdevicesandsaltchlorinatorsareusuallymoreecientinheatedwater,unlesscontrolled,

they can lead to excessive chlorine level which can damage your heater.

• Further advice should be obtained from your pool or spa builder, accredited pool shop, or chemical supplier for the

correct levels for your water.

• Warning: Electrolytic Corrosion and pH instability may be present with salt chlorinated pools.

Model Number and Serial Number Location

Before you call Raypak service, make sure you have the MODEL NUMBER and SERIAL NUMBER.

Model & Serial

number can also

be found inside the

control panel above

digital display.

Model & Serial

number located

on rating plate.

Model & Serial number located on

carton label.

GENERAL

Minimum Clearances

CLEARANCES

FLOORING: THIS UNIT CAN BE INSTALLED ON COMBUSTIBLE FLOORING. DO NOT INSTALL ON CARPET.

INDOOR

View in. (mm)

TOP (above Drafthood) 30 (762)

WATER SIDE 18 (456)

OPPOSITE SIDE 6 (152)

FRONT (Alcove) Open

BACK 6 (152)

FLOOR 0

OUTDOOR

View in. (mm)

TOP (Stackless) 36 (914)

WATER SIDE 18 (456)

OPPOSITE SIDE 6 (152)

BACK 6 (152)

FLOOR 0

See product manual for more information.

Minimum Clearances* – Outdoor

Forced Air Inlet

4' (1.2 m)

Minimum

3' (0.9 m)

Minimum

10' (3 m)

Minimum

1' (0.3 m)

Minimum

4' (1.2 m)

Minimum

4' (1.2 m)

Minimum

DO NOT install near

sprinklers.

DO NOT install within

3 feet of a heat pump

pool heater or air

conditioning

condensing unit.

*Check state and local codes

before proceeding. The

minimum clearances provided

aredenedbyNFGC(National

Fuel Gas Code).

CLEARANCES

Minimum Clearances – Indoor

CLEARANCES

VENT CAP

2' MIN (0.6 m)

VENT PIPE

DRAFT HOOD

VENTILATION

AIR OPENING

5' MIN

(1.5 m)

HEATER

2' MIN

(0.6 m)

8' (2.4 m)

OR LESS

COMBUSTION

AIR OPENING

The heater must have both combustion air and

ventilation air.

• Ventilation air opening 12”(305 mm) max from the ceiling

• Combustionairopening12”(305mm)maxfromtheoor

All air from outdoors, each opening shall have a net free

area as shown in table.

Model

Unrestricted

Opening

Sq. In. (m2)

Typical

Screened or

Louvered

opening

Sq. In. (m2)

Typical

Screened and

Louvered

opening

Sq. In. (m2)

206/207 50 (0.03) 75 (0.05) 100 (0.06)

266/267 67 (0.04) 101 (0.06) 134 (0.09)

336/337 84 (0.05) 126 (0.08) 168 (0.11)

406/407 100 (0.06) 150 (0.1) 200 (0.13)

Check state and local codes before proceeding. Some states do not recognize the NFGC and require larger openings.

Gas Line Sizing

Maximum Equivalent Pipe Length

Natural Gas 1000 BTU/FT3

0.60SpecicGravity@0.5in.WCPressureDrop

Propane Gas 2500 BTU/FT3

1.53SpecicGravity@0.5in.WCPressureDrop

Model

Input 3/4” 1” 1-1/4” 1-1/2”

(KBTU) N P N P N P N P

206/207 199.5 25 60 90 215 360

266/267 266.0 15 35 50 125 210 480 445

336/337 332.5 10 20 30 80 140 320 290

406/407 399.0 15 20 55 95 225 215 480

GAS SUPPLY

EFFECTS OF LOW GAS PRESSURE

• Pulsatingburnerame

• DelayIgnition/Hardlighto

• Pilot won’t light

• Exposure to condensation

• Emissions not at compliance levels

• Damage to Low NOxburners

Gas Pressure Test

Gas Unit

Type

Supply Pressure Manifold

Pressure

Min. Max.

Nat ATM 6” 10.5” 4.0”

Low NOx5” 10.5” 3.1”

Pro ATM 12” 13” 10.5”

GAS SUPPLY

BURNER

MANIFOLD

SLACK TUBE

MANOMETER

(INDICATES 8" W.C. AS SHOWN)

MANIFOLD

GAS PRESSURE

INLET GAS PRESSURE

GAS

VALVE

• Supply pressures given are under load

(dynamic)

• 1 PSI = 27.7” Water Column

• Propane requires an external “pounds

to inches regulator”

Gas Line Sediment Trap

GAS SUPPLY

Check state and local codes before proceeding. Some states do not recognize the NFGC.

GAS

VALVE

RISER

REDUCER

GAS

COCK

(WITHIN 6 FEET

OF THE HEATER)

CORRECT

PROVIDE CHANGE OF DIRECTION IN GAS FLOW

AS CLOSE AS

PRACTICAL TO HEATER

UNION

GAS

VALVE

RISER

REDUCER

INCORRECT

AS CLOSE AS

PRACTICAL TO HEATER

GAS

COCK

(WITHIN 6 FEET

OF THE HEATER)

UNION

Sediment Trap should be located as close

to the inlet of the appliance as practical.

ELECTRICAL

Power Connections

Note: Heater will not work properly if wired to a 208VAC power source.

Andere Raypak Gasheizung Handbücher

Raypak

Raypak 266L Bedienungsanleitung

Raypak

Raypak 130 Bedienungsanleitung

Raypak

Raypak 300 Handbuch

Raypak

Raypak 206A Handbuch

Raypak

Raypak 266A Bedienungsanleitung

Raypak

Raypak 336A Handbuch

Raypak

Raypak 514-824 Bedienungsanleitung

Raypak

Raypak Digital and Millivolt Gas Heater Gebrauchsanweisung

Raypak

Raypak 206A Handbuch

Raypak

Raypak Residential Series Bedienungsanleitung

Raypak

Raypak B-R259 Handbuch

Raypak

Raypak VERSA 055B Technisches Datenblatt

Beliebte Gasheizung Handbücher anderer Marken

Superior

Superior BGE18NV Bedienungsanleitung

Dru

Dru Room-sealed atmospheric gas-fired heating... Bedienungsanleitung

klover

klover TKR 35 Bedienungsanleitung

Rothenberger Industrial

Rothenberger Industrial 035984 Bedienungsanleitung

New Buck Corporation

New Buck Corporation 34 Bedienungsanleitung

Hargrove

Hargrove Timberland Glow Kurzanleitung

Kinder

Kinder Cameo BF Bedienungsanleitung

Qlima

Qlima GH 438 B-2 Handbuch

Desa

Desa 125-R Bedienungsanleitung

Gasmate

Gasmate AH100 Series Bedienungsanleitung

Medallion

Medallion MBP20TLB Kurzanleitung

Clarke

Clarke DEVIL 910SS Bedienungsanleitung

Brant Radiant Heaters

Brant Radiant Heaters QTD Series Montageanleitung

L.B. White

L.B. White Therma Grow HW220 Handbuch

Sealey

Sealey LP35.V5 Bedienungsanleitung

Italkero

Italkero Falo Evo Bedienungsanleitung

Desa

Desa 30LP Bedienungsanleitung

Williams

Williams 2509822A Bedienungsanleitung