Reznor CAUA Bedienungsanleitung

Revision: CAUA-COND-DRAIN (03-22) 165012-A

BURNER CONDENSATE DRAIN KIT INSTALLATION FOR GAS-

FIRED INDOOR HEATER

Supersedes: CP-CAUA-DK (04-16) PN165012R5

MODEL CAUA WITH COOLING COIL

Table 1. Burner Condensate Drain Kit (PN 165951) Components

Item No. Component Description PN (Quantity)

1 Tubing (not shown) 3/8 ID × 6 feet 165955 (1)

2 Threaded ﬁtting 90-degree, 1/4 NPT × 3/8, nylon 165952 (1)

3 Brass nut 1/4 NPT 110628 (1)

4 Hex locknut 1/4, silver-colored (T&B #139) 171527 (1)

5 Washer Sealing 165953 (1)

6 Wire tie (not shown) Nylon (T&B #TY-24M) 20913 (2)

7 Snap bushing (not shown) Heyco #SB 625-8 87556 (1)

•When a cooling coil is installed on a model CAUA heater, a burner condensate drain line must be installed. The

burner condensate drain kit (PN 165951) includes all of the parts needed to install the drain line.

•Refer to the installation manual provided with the heater for important safety information.

•Ensure that all components shown in Figure 1 and listed in Table 1 are available before beginning installation.

INSTALLATION

Install the burner condensate drain as follows. Item numbers in parentheses refer to Figure 1.

1. If unit is installed, turn OFF gas and electric power and allow unit to cool.

2. Remove burner compartment door.

NOTE: Depending on the date of manufacture, the burner box cover is in either two sections—top

left and top right extending over the front—or in three sections—top left, top right, and a separate

front cover.

Figure 1. Burner Box with Cover Removed (Refer to Table 1)

Speciﬁcations and illustrations subject to change without notice or incurring obligations.

Latest version of this manual is available at www.reznorhvac.com.

CAUA-COND-DRAIN (03-22) 165012-A

INSTALLATION—CONTINUED

3. Remove burner box cover:

a. If front burner cover IS NOT separate piece, disconnect ﬂame sensor wire and ﬂame rollout switch wires on

left side of burner box cover, disconnect silicone tubing from static tap, and remove top left cover.

b. If front of burner cover IS separate piece, remove front section only.

4. On side of cabinet that is most convenient for drain line, locate and remove hole plug in cabinet and insert snap

bushing (7).

5. Assemble brass nut (3), sealing washer (5), and threaded ﬁtting (2) as shown in Figure 1.

6. Remove plug from hole in bottom center of burner pan and install threaded ﬁtting (2) up through hole so that hose

barb is toward bushing in side of cabinet. Secure ﬁting using hex locknut (4).

7. Under burner, install tubing (1) onto hose barb on threaded ﬁtting (2). Ensure that tubing is secure.

8. Extend tubing (1) out through cabinet side, maintaining downward slope. Just outside of cabinet, make loop in

hose to create trap. Secure loop using wire ties (6).

9. Continue downward with tubing and connect it into coil drain pipe.

10. Install burner box cover removed in step 3 and burner compartment door removed in step 2.

11. If unit is installed, start up unit in accordance with instructions in installation provided with unit and check for

proper operation.

Andere Handbücher für CAUA

Inhaltsverzeichnis

Andere Reznor Heizung Handbücher

Reznor

Reznor EURO-C 4000 RJL Benutzerhandbuch

Reznor

Reznor GUARDIAN GB Bedienungsanleitung

Reznor

Reznor UBX Series Betriebsanleitung

Reznor

Reznor V3 Series Leitfaden

Reznor

Reznor ACT03 Bedienungsanleitung

Reznor

Reznor Euro-T 2530D Bedienungsanleitung

Reznor

Reznor UEZ Bedienungsanleitung

Reznor

Reznor UESA-3 Betriebsanleitung

Reznor

Reznor AB-2 Series Beilage

Reznor

Reznor CAUA Bedienungsanleitung

Reznor

Reznor UBX Handbuch

Reznor

Reznor ACR1000SE6-1PH Bedienungsanleitung

Reznor

Reznor UDSBD-4E Leitfaden

Reznor

Reznor FT Series Bedienungsanleitung

Reznor

Reznor UEAS Bedienungsanleitung

Reznor

Reznor FSE series Montageanleitung

Reznor

Reznor FT Bedienungsanleitung

Reznor

Reznor VR Series Betriebsanleitung

Reznor

Reznor EURO-X 1000 D Bedienungsanleitung

Reznor

Reznor GUARDIAN GB 1500 Bedienungsanleitung

Reznor

Reznor UDAP Leitfaden

Reznor

Reznor RIH Betriebsanleitung

Reznor

Reznor UDBP Leitfaden

Reznor

Reznor Comet+ Bedienungsanleitung

Beliebte Heizung Handbücher anderer Marken

oventrop

oventrop Regucor Series Bedienungsanleitung

Blaze King

Blaze King CLARITY CL2118.IPI.1 Bedienungsanleitung

ELMEKO

ELMEKO ML 150 Bedienungsanleitung

BN Thermic

BN Thermic 830T Bedienungsanleitung

KING

KING K Series Leitfaden

Empire Comfort Systems

Empire Comfort Systems RH-50-5 Kurzanleitung

Well Straler

Well Straler RC-16B Bedienungsanleitung

EUROM

EUROM 333299 Bedienungsanleitung

Heylo

Heylo K 170 Bedienungsanleitung

Eterna

Eterna TR70W Bedienungsanleitung

Clarke

Clarke GRH15 Bedienungsanleitung

IRSAP

IRSAP The Radiator Company Ovali Bedienungsanleitung

Empire Heating Systems

Empire Heating Systems WCC65 Bedienungsanleitung

Wetekom

Wetekom 92 86 43 Bedienungsanleitung

Desa

Desa SPC170-F Bedienungsanleitung

Watlow

Watlow Watrod Electric Tubular Heaters Bedienungsanleitung

Haverland

Haverland ECO-DRY GPS Series Stücklistenhandbuch

Stelpro

Stelpro ASILVC2060 Series Bedienungsanleitung