Roadtrek Motorhome sprinter Bedienungsanleitung

Sprinter Models Owner’s Manual

Including

Limited Warranty Information

WARNINGS & CAUTIONS

DDooccNNoo::21906540-RSAD RReevv::01 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000066

WARNINGS AND CAUTIONS

This manual contains WARNINGS against operating

procedures which could result in an accident or bodily injury.

The manual also contains CAUTIONS against procedures

which could result in damage to your vehicle.

If you do not read the entire manual you may miss important

information. Observe all Warnings & Cautions.

WARNINGS & CAUTIONS

DDooccNNoo::21906540-RSAD RReevv::01 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000066

WARNINGS:

SEAT BELTS:

Only forward facing seats equipped with factory installed seat belts are to be occupied while the vehicle is in

motion. All passengers must be seated in these seats only, with the seat belts fastened while the vehicle is in

motion.

TV:

The flat screen TV should not be stored inside the Roadtrek in temperatures below -4°F, (-20°C) to reduce the

chance of damage from the cold. The operating temperature of the monitor is recommended between 50°F

and 104°F, (10°C and 40°C) with a humidity range of 10% to 80%, non condensing.

If your vehicle is equipped with an optional flat screen TV, the TV must be off and in the stored position

during travel.

PROPANE:

Propane tanks shall not be placed or stored inside your vehicle. Propane tanks are equipped with safety

devices which relieve excessive pressure by discharging gas to the atmosphere.

To reduce the danger of fire or explosion do not store gasoline or other flammable liquids inside your vehicle.

Ensure that you purchase propane from a reputable propane facility. Contaminated propane is a common

cause of system failure.

Do not refuel the propane tank to more than 80% of its capacity.

The propane tank valve must be closed and ALL PILOT LIGHTS, APPLIANCES, AND THEIR IGNITERS,

(see Operating Instructions) SHALL BE TURNED OFF during refueling of the motor fuel tank and/or the

propane fuel tank. Only qualified personnel should refuel your propane tank.

APPLIANCES:

It is not safe to use cooking appliances for space heating purposes due to the danger of asphyxiation.

The propane stove needs fresh air for its safe operation.

Portable fuel burning equipment, including wood or charcoal grills and stoves, should not be used inside

your vehicle. Use of this type of equipment inside your vehicle may cause a fire or asphyxiation.

PROPANE LEAK DETECTOR:

Do not block the air circulation in the area where the Propane Leak Detector is located.

Battery disconnect switch must be in the “ON” position for the propane detector to function.

CARBON MONOXIDE LEAK DETECTOR:

Do not block the air circulation in the area where the carbon monoxide leak detector is located.

Battery disconnect switch must be in the “ON” position for the Carbon Monoxide Leak Detector to function.

WARNINGS & CAUTIONS

DDooccNNoo::21906540-RSAD RReevv::01 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000066

110 VOLT ELECTRICAL SERVICING:

Prior to servicing the 110 volt Galley GFCI & Audio/Video cabinet interior receptacles, unplug the output lead

from the power inverter.

EXTERIOR ACCESS DOORS:

Ensure power cord and city water line are disconnected and in their stored positions before the vehicle is put in

motion.

CAUTIONS:

CLOVERLEAF DINING TABLE:

Cloverleaf dining table is heavy, bend knees while lifting.

EXTRA COUNTER SPACE:

Make sure the stove is off and has cooled prior to lowering the stove cover.

TV:

When the vehicle is in motion it is recommended that the TV be “OFF” and in the stored position.

The flat screen TV, (option TF) should not be stored inside the Roadtrek in temperatures below -4°F, (-20°C).

The operating temperature of the monitor is recommended between 50°F & 104°F, (10°C – 40°C) with a humidity

range of 10%-80%, non condensing.

To remove the T/V, remove the four mounting bolts on the back of the T/V mounting bracket and remove the

RCA cables, power supply cable and antenna cable.

AUXILIARY BATTERY:

Battery acid can burn skin and clothing. Protective eye wear and gloves should be worn when handling batteries.

REPLACING THE AUXILIARY BATTERY:

Ensure that the inverter is disconnected prior to disconnecting the auxiliary battery.

GENERATOR:

When launching a boat using your Roadtrek, it is important to know that the generator MUST NOTbe

submerged in water.When using the generator as the main power sorce to run the appliances, refer to the

generator owners manual for proper use and maintinance.

WASTE WATER STORAGE AND DUMPING SYSTEM:

Ensure that both the black and gray water gate valves are closed, (inward position) before using the waste water

system.

Under moderate subfreezing conditions, antifreeze is required in the exterior fresh water tank, black and gray

waste water tanks, water system should be winterized.

THE WARNINGS AND CAUTIONS IN THE QUICK REFERENCE ARE AN OVERVIEW AND THERE

ARE MORE NOTES AND INSTRUCTIONS WITHIN THIS MANUAL.

CUSTOMER SERVICE PROCEDURES

DDooccNNoo::21906540-RSAD RReevv::01 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000066

OBTAINING MOTORHOME SERVICE

The solution to all your Roadtrek concerns starts with your Roadtrek Dealer

Roadtrek Dealer

The dealership should always be given the

opportunity to resolve your concerns prior to

contacting Home & Park Motorhomes

Roadtrek Dealer Dodge/Chrysler Dealer

Contact Service Writer

at Roadtrek Dealership

If situation is

not resolved

If situation is

not resolved

If situation is

not resolved

If situation is

not resolved

If situation is

not resolved

If situation is

not resolved

If situation is

not resolved

If situation is

not resolved

Contact Service Manager

at Roadtrek Dealership

Contact Dealer Principal

at Roadtrek Dealership

Contact

Home & Park Motorhomes

Contact

Home & Park Motorhomes

Advise the Service Department

that you have a

Dodge Sprinter Van

that requires service.

Note: Using the word “Motorhome” may cause

the dealer to shy away from service.

Most automotive dealers have the service

capabilities to handle the 1 ton van.

Contact Service Writer

Contact Service Manager

Contact Chassis

Customer Service Department

for assistance.

Customer Service will issue a file for your records.

Contact Dealer Principal

TABLE OF CONTENTS

DDooccNNoo::21906540-RSAD RReevv::01 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000066BB--11

Introduction __________________________________________________________________________________________________ A-1

Weight Ratings ________________________________________________________________________________________________ A-2

Specifications, (Automotive/Motorhome) ________________________________________________________________________A-3

Appliance Log ________________________________________________________________________________________________A-4

Manufacturer Contact Information ______________________________________________________________________________A-5

Daily Living __________________________________________________________________________________________________ B-1

Captain’s Seats ________________________________________________________________________________________________ B-1

Seat Belt Usage ________________________________________________________________________________________________ B-1

Cloverleaf Dining Table __________________________________________________________________________________________ B-2

Dinette Table __________________________________________________________________________________________________ B-3

SSlleeeeppiinnggFFaacciilliittiieess______________________________________________________________________________________________ B-4

Rear Twin Beds ________________________________________________________________________________________ B-4

Rear King Bed __________________________________________________________________________________________ B-5

Front Lounge Seats______________________________________________________________________________________ B-6

WWaasshhrroooommaannddSShhoowweerrAArreeaa______________________________________________________________________________________ B-7

Front and Rear Washroom Doors __________________________________________________________________________B-7

Washroom Exhaust Fan __________________________________________________________________________________B-7

WWaasshhrroooommFFaacciilliittiieess____________________________________________________________________________________________ B-8

Toilet ________________________________________________________________________________________________ B-8

Permanent Bathroom Shower ____________________________________________________________________________ B-8

Extra Counter Space ____________________________________________________________________________________________ B-9

TV __________________________________________________________________________________________________________ B-9

EExxtteerriioorrAAcccceesss

sDDoooorrss__________________________________________________________________________________________ B-10

Driver Side Access Doors ________________________________________________________________________________ B-10

Propane Access Door __________________________________________________________________________________ B-11

Rear Storage Area ______________________________________________________________________________________ B-11

Auxiliary Battery ______________________________________________________________________________________________ B-12

Replacing the Auxiliary Battery __________________________________________________________________________________B-12

Spare Tire Storage ____________________________________________________________________________________________ B-13

Caution Note, (Mineralling) ______________________________________________________________________________________B-13

Signal Selection Switch__________________________________________________________________________________________B-14

Audio/Video Cabinet __________________________________________________________________________________________B-14

RSA Elevation Diagram __________________________________________________________________________________________B-15

RSA Floorplan ________________________________________________________________________________________________B-16

Electrical System ______________________________________________________________________________________________ E-1

Inverter/Charger ________________________________________________________________________________________________E-1

10V Inverter/Charger Shut Down __________________________________________________________________________________E-1

Inverter/Charger Start up After Automatic Safety Shut Down ____________________________________________________________E-1

Dry Camping Battery Conservation ________________________________________________________________________________E-1

Receptacle Functionality__________________________________________________________________________________________E-1

12V DC/110V AC Inverter/Charger/Distribution Panel __________________________________________________________________ E-2

External Electrical Source Connection ______________________________________________________________________________ E-2

Generator ____________________________________________________________________________________________________ E-2

Monitor Panel __________________________________________________________________________________________________ E-3

Auxiliary Battery and Battery Separator ____________________________________________________________________________ E-4

Automotive Battery ____________________________________________________________________________________________ E-4

Interior Cab Light ______________________________________________________________________________________________ E-4

Water Heater __________________________________________________________________________________________________E-4

Rear Storage Light ______________________________________________________________________________________________E-4

Electrical System Legend ________________________________________________________________________________________ E-5

Electrical Distribution/Fuse Panel __________________________________________________________________________________E-6

Electrical System Schematic ______________________________________________________________________________________ E-7

Propane & Safety System ______________________________________________________________________________________ F-1

Propane Tank __________________________________________________________________________________________________ F-1

Appliances ____________________________________________________________________________________________________ F-1

Refueling Procedures ____________________________________________________________________________________________ F-2

Regulator ____________________________________________________________________________________________________ F-2

Propane Leak Detector __________________________________________________________________________________________ F-2

Carbon Monoxide Leak Detector __________________________________________________________________________________ F-2

Smoke Detector ________________________________________________________________________________________________ F-3

Propan System Diagram __________________________________________________________________________________________F-4

TABLE OF CONTENTS

DDooccNNoo::21906540-RSAD RReevv::01 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000066BB--11

Water Systems ________________________________________________________________________________________________ G-1

Water Heater Bypass System______________________________________________________________________________________ G-1

Fresh Water Tank Drain __________________________________________________________________________________________ G-1

To De-Winterize ________________________________________________________________________________________________ G-1

Fresh Water Tank ______________________________________________________________________________________________ G-2

Filling the Fresh Water Tank ______________________________________________________________________________________ G-2

City Water Connection __________________________________________________________________________________________ G-3

Waste Water Storage and Dumping System ________________________________________________________________________ G-4

Waste Water Tank Preparation ____________________________________________________________________________________G-4

Waste Water Tank Dumping ______________________________________________________________________________________ G-5

Waste Water Tank Flushing ______________________________________________________________________________________ G-6

Outside Shower ________________________________________________________________________________________________ G-6

Potable Water System Draining __________________________________________________________________________________ G-6

Potable Water System Sanitizing __________________________________________________________________________________ G-7

Water System Winterizing ________________________________________________________________________________________G-7

Water Tank/System Location Diagram ______________________________________________________________________________G-8

Water Tank Top Down Diagram ____________________________________________________________________________________G-9

Water Tanks Bottom Up Diagram ________________________________________________________________________________G-10

Tire Fundamentals ____________________________________________________________________________________________ H-1

UTQGS Information ____________________________________________________________________________________________ H-2

Owner Maintenance ____________________________________________________________________________________________ I-1

Exterior Washing ________________________________________________________________________________________________ I-1

Other Maintenance ______________________________________________________________________________________________ I-1

Winter Storage__________________________________________________________________________________________________ I-1

Inside Your Vehicle ______________________________________________________________________________________________ I-1

Outside Your Vehicle ____________________________________________________________________________________________ I-1

Spring Start-Up ________________________________________________________________________________________________ I-2

Tires __________________________________________________________________________________________________________ I-2

Cargo Carrying Capacity __________________________________________________________________________________________ I-2

Owner Maintenance Checks ______________________________________________________________________________________ I-2

When You Stop for Fuel __________________________________________________________________________________________ I-2

At Least Monthly ________________________________________________________________________________________________ I-2

At Least Once Every Three Months__________________________________________________________________________________ I-2

At Least Twice A Year ____________________________________________________________________________________________ I-3

At Least Once A Year ____________________________________________________________________________________________ I-3

Auxiliary Battery ________________________________________________________________________________________________ I-3

Aluminum Wheel Maintenance ____________________________________________________________________________________ I-4

Limited Warranty Information __________________________________________________________________________________ J-1

Limited Warranty Definitions ______________________________________________________________________________________ J-1

Home & Park Limited Warranty Registration__________________________________________________________________________ J-1

Automotive Warranty - DaimlerChrysler, (Dodge Sprinter Chassis) ____________________________________________________ J-1 - J-2

Automotive Customer Service & Roadside Assistance Numbers __________________________________________________________ J-2

Appliance Warranty ____________________________________________________________________________________________ J-2

Home & Park Limited Motorhome Warranty ______________________________________________________________________ J-3 - J-4

Customer Assistance __________________________________________________________________________________________ K-1

Reporting Safety Defects, (U.S. Only)________________________________________________________________________________ K-1

Roadtrek Ambassador Potential Customer Referral Program for Roadtrek Owners __________________________________________ K-1

Roadtrek Club International ______________________________________________________________________________________ K-2

Address, Phone & Facsimile Numbers, and E-mail ____________________________________________________________________ K-2

Website ______________________________________________________________________________________________________K-2

Roadtrek International Chapter FMCA / A Roadtrek Owners’ Club Membership Forms __________________________________ L-1

CChhaannggeeooffOOwwnneerrNNaammeeoorrAAddddrreessssForm______________________________________________________________________ M-1 - M-2

Potential Customer Referral Card __________________________________________________________________________ M-3 - M-4

INTRODUCTION

DDooccNNoo::21906540-RSAD RReevv::01 CCooppyyrriigghhtt©©HHaannmmaarrMMoottoorrCCoorrppoorraattiioonn22000066AA--11

A WORD TO ROADTREK OWNERS...

This manual has been prepared to acquaint you with the operation, maintenance and warranties of your new

Roadtrek Motorhome Van. Your vehicle has been designed, engineered and manufactured to provide you with

the utmost in pleasure, dependability and quality. It is important that you read the contents of this manual,

that of the Dodge chassis and those of other components, and follow the instructions and recommendations

contained in each to help assure the most enjoyable and trouble free operation of your vehicle.

We would like to take this opportunity to thank you for selecting a Roadtrek product, and assure you of our

continuing commitment to your recreational vehicle pleasure, safety and satisfaction.

INTRODUCTION

This manual has been written to provide you with the information required to properly operate and maintain your

new Roadtrek. After reading this manual, be sure to keep it in your vehicle as a reference.Your Roadtrek dealer will

be glad to answer any further questions about the operation of your vehicle.

IMPORTANT

Every reasonable precaution has been undertaken in the preparation of this manual resulting in the utmost

accuracy possible at the time of publication. However, due to the continuing improvement and refinement of our

products and normal changes in information and procedures, Home & Park shall assume no responsibility

whatsoever for errors or omissions in the manual’s contents.

Further, Home & Park shall not be held liable or assume any obligations or responsibilities whatsoever for any loss,

damage or injury directly or indirectly caused by, arising or resulting from, or as a consequence of the use or

nonuse of the information contained herein or the operation or non-operation of any items mentioned herein. And

finally, Home & Park shall be indemnified and saved harmless from all losses, expenses, claims and demands

whatsoever.

INTRODUCTION

Weight Ratings

Gross Vehicle Weight Rating, (GVWR): is the maximum

permissible weight of this vehicle when fully loaded. It

includes all weight at the vehicle axle(s).

Unloaded Vehicle Weight, (UVW): is the weight of this

motorhome as manufactured at the factory. It includes all

weight at the vehicle axle(s). If applicable, it also includes full

generator fluids, including fuel, engine oil and coolants.

Cargo Carrying Capacity, (CCC): is equal to GVWR minus

each of the following: UVW, full fresh, (potable) water weight,

(including water heater), and full propane weight and SCWR.

Gross Combined Weight Rating, (GCWR): means the

maximum allowable loaded weight of this motorhome and

any towed trailer or towed vehicle.

Canadian Models - Seating Capacity Weight Rating, (SCWR)

US Models - Sleeping Capacity Weight Rating, (SCWR):

is the manufacturer’s designated number of sleeping

positions multiplied by 154 pounds, (70 kilograms).

Gross Axle Weight Rating, (GAWR): is the value specified as

the load carrying capacity of a single axle system, as

measured at the tire-ground interfaces.

Towing Guidelines: Consult Dodge Sprinter Owners

Manual(s) for specific weighing instructions and towing

guidelines, including auxiliary brake requirements for any

towed trailer or towed vehicle.

Weighing Procedure: Prior to weighing each unit, the fuel

tank must be full, as well as the fresh water tank. All tires must

be of equal pressure, and any snow must be removed.

Note: the weighing must be done on level ground!

Equipment: 2 Portable Scales, (including electrical power source), 2 wooden ramps, lift and pressure gauge.

Alternate: D.O.T. approved customer scales.

Note: Wooden ramps must be equal to or less than 1/8" of the height of the scales being used.

Procedure:

1) Fill Fuel Tank.

2) Fill Fresh Water Tank.

3) Measure all tire pressures and equalize if necessary.

4) Place wooden ramps below rear wheels, (using lift or driving onto ramps for levelling vehicle; N/A if

commercial scales used).

5) Place scales under front wheels.

6) Record scale readings.

7) Repeat for rear wheels.

Sample of Canadian Weight label:

Sample of US Weight label:

Inhaltsverzeichnis

Andere Roadtrek Automobil Handbücher

Roadtrek

Roadtrek SS-Ideal Bedienungsanleitung

Roadtrek

Roadtrek 210 SPRINTER Bedienungsanleitung

Roadtrek

Roadtrek SS Agile 2017 Bedienungsanleitung

Roadtrek

Roadtrek TS Adventurous Bedienungsanleitung

Roadtrek

Roadtrek SS Agile 2016 Bedienungsanleitung

Beliebte Automobil Handbücher anderer Marken

Toyota

Toyota 2000 Tundra Bedienungsanleitung

CITROËN

CITROËN DS4 DSign Bedienungsanleitung

Cadillac

Cadillac CTS 2008 Bedienungsanleitung

Porsche

Porsche Boxster S Bedienungsanleitung

KIAM

KIAM SPORTAGE 2014 Stücklistenhandbuch

GMC

GMC 2013 Terrain Montageanleitung

Lexus

Lexus 2015 CT 200h Bedienungsanleitung

GMC

GMC T-Series 1999 Bedienungsanleitung

Mercury

Mercury 1998 Mystique Bedienungsanleitung

Mercury

Mercury 2007 Mariner Bedienungsanleitung

Mazda

Mazda 2007 Mazdaspeed 3 Leitfaden

Mazda

Mazda 2014 CX-5 Bedienungsanleitung

GMC

GMC Chevrolet Express 2022 Bedienungsanleitung

GMC

GMC 1997 Jimmy Bedienungsanleitung

Chevrolet

Chevrolet 2012 Malibu Bedienungsanleitung

Skoda

Skoda FABIA RS - ANNEXE 118 Bedienungsanleitung

Seat

Seat toledo Bedienungsanleitung

PEUGEOT

PEUGEOT 206 CC Bedienungsanleitung