Roccbox RBX1.1 Bedienungsanleitung
GAS BURNER
USER MANUAL
ROCCBOX 2018
2
ROCCBOX 2018
3
DANGER
If you smell gas:
• Shut gas off to the appliance.
• Extinguishanyopename.
• If odour continues, keep away from the
applianceandimmediatelycallyourre
department.
This instruction manual contains important
information necessary for the proper
assembly and safe use of the appliance.
Read and follow all warnings and instructions
before assembling and using the appliance.
Follow all warnings and instructions when
using the appliance.
Keep this manual for future reference.
Never operate this appliance in enclosed
areas.
Failure to follow these instructions could
resultinreorexplosionwhichcouldcause
property damage, personal injury or death.
• Never operate this appliance unattended.
• Never operate this appliance within 5ft
(1.5m) of any structure, combustible
material or other gas cylinder.
• Never operate this appliance within 25ft
(7.5m)ofanyammableliquid.
• Do not ll cooking vessel beyond the
limitation of the door dimensions.
• Heated liquids remain at scalding
temperatures long after cooking
process. Never touch cooking appliance
untilliquidshavecooledto115OF (45OC)
or less.
• If a re should occur, keep away from
the appliance and immediately call
your re department. Do not attempt
toextinguishanoiloragreaserewith
water.
ROCCBOX 2018
4
Most res are caused by a build up of grease, or (if using gas) an
improper gas connection.
Ensure all people and pets are kept as far away as possible.
If you are able, turn the gas off at the cylinder or the on/off valve
where applicable. Use a re extinguisher if possible. If water is
the only re retardant available, thoroughly soak the area around
the appliance. When spraying water on the Roccbox itself, do not
use a strong jet of water, as this may cause splashing of burning
grease, resulting in a further spreading of the re.
FIRE
GENERAL SAFETY
Carbon Monoxide is a highly poisonous gas which can be produced
when the device isn’t recieving enough ventilation. We therefore
recommend using the gas and wood burners in a well ventilated
area away from direct wind and to never cover the oven mouth.
It is difcult to know if your device is producing Carbon Monoxide
as it is an odourless and colourless gas. It can, however cause
these symptoms when you are exposed to it:
Tightness across the forehead
Headache,
Weakness,
Dizziness,
Nausea,
Vomiting,
Coma, intermittent convulsions,
Depressed heart action, slowed respiration,
If the exposure has been severe it may cause death.
CARBON MONOXIDE
Warning: Contact your local municipality for any building codes
regulating the installation of outdoor barbecue appliances. Out-
door
installations must conform to local codes or, in the absence of
local codes, with the following:
USA: National Fuel Gas Code, ANSI Z223.1/NFPA 54
CAN: CGA: B149.1 Natural Gas Propane Installation Code.
AUST/NZ: Australian Standards Code AS: 5601 as well as the
requirements of any local council, gas electricity authority or
other statutory regulation.
Spanner tighten all gas ttings as per instructions. Do not modify
the appliance. Parts sealed by the manufacturer or the company
shall not be manipulated.
ROCCBOX 2018
5
PRODUCT INFORMATION
GENERAL SAFETY
Roccbox Limited.
Units 18 & 19, Radar Way, Christchurch, Dorset, BH23 4FL UK.
Appliance Name Roccbox oven
Model/Type No. RBX1.1
Trade name Roccbox
Total nominal heat output for the gas burner 14330 BTU/HR
Injector size 1.1mm
Gas Type Propane Gas Pressure 11 “W.C.
Use outdoors only.
Read the instructions before using the appliance.
WARNING: accessible parts may be very hot. Keep young children away.
WARNING! Do not use spirit or petrol for lighting or re-lighting!
ROCCBOX 2018
6
UNFOLD LEGS
SETTING UP THE GAS
1 2 3
FIRING UP GAS
45 6
ROCCBOX 2018
7
Prior to use, check the oven and burner and
venturi for blockages (eg, food residue or
insect nests - Wasps, Bees or Ants.) If an
insect nest is found they can be dangerous
and must be cleaned out thoroughly. Please
refer to the cleaning and maintenance
sections at the end of this chapter for
guidance on how to do this.
Should the appliance go out for any reason,
turn off the control knob and the cylinder
gas valve. Wait 5 minutes before attempting
to relight the appliance.
Some foods produce ammable fats and
juices. Attend to an operating Roccbox at
all times. Damage caused by fat and grease
res is not covered by warranty. If a grease
or fat re should occur, immediately turn
off burner knob and the gas cylinder valve
until the re is out. Remove all food from the
appliance.
A leak test must be carried out prior to
using the appliance for the rst time and
whenever the gas cylinder is relled or
whenever the gas hose and regulator have
been disconnected from the gas cylinder or
appliance.
WARNING
GAS SAFETY
FIRING UP GAS
Please take a moment to review all of the safety requirements before operating the
appliance when using gas.
• Do not disconnect any gas ttings while the appliance is operating.
• Check all gas hose lines and connections for cuts, cracks and other damage.
• Gas cylinders must not be stored in enclosed areas.
• Keep the fuel supply hose away from heated surfaces or direct sunlight.
• Do not use any additional ammable substance whilst operating with gas.
• Do not touch! The Roccbox can get extremely hot when in operation. Be sure
to wear protective gloves.
• Keep the cylinder outdoors in it’s upright position.
• Do not connect multiple gas canisters to Roccbox or store a spare within the
same vicinity.
• A regulator which complies with EN16129 must t between the gas canister
and the oven.
• Do not position the gas canister under the oven.
• Never use a naked ame to check for gas leaks.
• Do not use natural gas! It can damage the oven.
• Maximum length of hose cannot exceed 1.5m. In Finland, hose length cannot
exceed 1.2m.
• National requirements state how often to replace the hose. Please review this
for your area.
• Never ll the cylinder beyond 80 percent full.
• Make sure the exible tube is not twisting when the appliance is in operation.
ROCCBOX 2018
8
WARNING
Ensure that the LP cylinder or
regulator valve is closed.
Do not store a spare LP cylinder
under or near this appliance.
CONNECTING TO GAS
STEP 1 Check that the gas you have is
Propane LPG.
The gas cylinder used must have
a safety collar to protect the valve
assembly. Do not use a cylinder
that is rusty, dented or has a
damaged valve.
For US Canadian Customers
Gas cylinder, must be constructed
and marked in accordance with the
specications for LP gas cylinders,
U.S. Department of Transportation
(DOT) or the Standard for
Cylinders, Spheres and Tubes for
the Transportation of Dangerous
Goods, CAN/CSA-B339.
WARNING
If at any point you smell gas:
Shut off the gas from the canister,
turn off the switch on the Roccbox and
extinguish any open ames.
If odour continues, move away from the
oven and gas supply then contact your gas
supplier or re service.
FIRING UP GAS
MAX: 13 kg / 29 lb.
MIN: 4kg / 9 lb.
CAPACITY
ROCCBOX 2018
9
FIRING UP GAS
PUSH FIT GAS REGULATOR
CLOCKWISE/ANTICLOCKWISE GAS REGULATOR
CONNECTING TO GAS
STEP 2 Connect the regulator to the gas canister, following the
instructions for your regulator accordingly. Don’t force
the regulator as this could damage the gas bottle.
ROCCBOX 2018
10
To test for gas leaks, apply a
mixture of soapy water to these
highlighted areas using a brush as
well as any areas that show cracks.
on the piping.
Roccbox connection
Valve connection
Hose connection
GAS LEAKS
FIRING UP GAS
WARNING
Check for gas leaks every time you
disconnect and reconnect a gas
tting.
Do not ignite burners when leak
checking.
Do not use an open ame to check
for gas leaks. Do not create sparks
or have open ames in the area
whilst changing gas supply.
The changing of gas canisters
must be carried out away from any
sources of ignition.
Inhaltsverzeichnis
