Sanyo KHS1232 Gebrauchsanweisung

REFERENCE NO. TD701219

TECHNICAL DATA

12KHS32

SPLIT SYSTEM AIR CONDITIONER

FILE NO.

Indoor Model No. Product Code No.

KHS1232 1 852 658 14

Outdoor Model No. Product Code No.

CH1232 1 852 754 05

CH1232

KHS1232

Indoor Unit Outdoor Unit

095-313SanyoTD00.12.1311:12AMページA

IMPORTANT!

Please Read Before Starting

This air conditioning system meets strict safety and operating

standards. As the installer or service person, it is an important

part of your job to install or service the system so it operates

safely and efficiently.

For safe installation and trouble-free operation, you must:

●Carefully read this instruction booklet before beginning

●Follow each installation or repair step exactly as shown

●Observe all local, state, and national electrical codes

●Pay close attention to all warning and caution notices

given in this manual

This symbol refers to a hazard or

unsafe practice which can result

in severe personal injury or

death.

This symbol refers to a hazard or

unsafe practice which can result

in personal injury or product or

property damage.

If Necessary, Get Help

These instructions are all you need for most installation

sites and maintenance conditions. If you require help for a

special problem, contact our sales/service outlet or your

certified dealer for additional instructions.

In Case of Improper Installation

The manufacturer shall in no way be responsible for

improper installation or maintenance service, including fail-

ure to follow the instructions in this document.

SPECIAL PRECAUTIONS

When Wiring

ELECTRICAL SHOCK CAN CAUSE SEVERE

PERSONAL INJURY OR DEATH. ONLY A

QUALIFIED, EXPERIENCED ELECTRICIAN

SHOULD ATTEMPT TO WIRE THIS SYSTEM.

• Do not supply power to the unit until all wiring and tubing

are completed or reconnected and checked.

• Highly dangerous electrical voltages are used in this sys-

tem. Carefully refer to the wiring diagram and these

instructions when wiring. Improper connections and inade-

quate grounding can cause accidental injury or death.

• Ground the unit following local electrical codes.

• Connect all wiring tightly. Loose wiring may cause over-

heating at connection points and a possible fire hazard.

When Transporting

Be careful when picking up and moving the indoor and out-

door units. Get a partner to help, and bend your knees when

lifting to reduce strain on your back. Sharp edges or thin alu-

minum fins on the air conditioner can cut your fingers.

When Installing…

…In a Ceiling or Wall

Make sure the ceiling/wall is strong enough to hold the

unit’s weight. It may be necessary to construct a strong

wood or metal frame to provide added support.

…In a Room

Properly insulate any tubing run inside a room to prevent

“sweating” that can cause dripping and water damage to

walls and floors.

…In Moist or Uneven Locations

Use a raised concrete pad or concrete blocks to provide a

solid, level foundation for the outdoor unit. This prevents

water damage and abnormal vibration.

…In an Area with High Winds

Securely anchor the outdoor unit down with bolts and a

metal frame. Provide a suitable air baffle.

…In a Snowy Area (for Heat Pump-type Systems)

Install the outdoor unit on a raised platform that is higher

than drifting snow. Provide snow vents.

When Connecting Refrigerant Tubing

• Keep all tubing runs as short as possible.

• Use the flare method for connecting tubing.

• Apply refrigerant lubricant to the matching surfaces of the

flare and union tubes before connecting them, then tighten

the nut with a torque wrench for a leak-free connection.

• Check carefully for leaks before starting the test run.

NOTE:

Depending on the system type, liquid and gas lines may be

either narrow or wide. Therefore, to avoid confusion the

refrigerant tubing for your particular model is specified as

either “narrow” or “wide” rather than as “liquid” or “gas.”

When Servicing

• Turn the power OFF at the main power box (mains)

before opening the unit to check or repair electrical parts

and wiring.

• Keep your fingers and clothing away from any moving

parts.

• Clean up the site after you finish, remembering to check

that no metal scraps or bits of wiring have been left inside

the unit being serviced.

WARNING

CAUTION

095-313SanyoTD00.12.1311:12AMページi

Table of Contents

Page

1. OPERATING RANGE .................................................................................................................. 1

2. SPECIFICATIONS........................................................................................................................ 2

3. DIMENSIONAL DATA .................................................................................................................. 5

4. COOLING CAPACITY .................................................................................................................. 7

5. HEATING CAPACITY ................................................................................................................... 9

6. AIR THROW DISTANCE CHART ................................................................................................ 10

7. REFRIGERANT FLOW DIAGRAM .............................................................................................. 12

8. INSTALLATION INSTRUCTIONS ................................................................................................ 13

9. ELECTRICAL DATA ..................................................................................................................... 18

10. ELECTRIC WIRING DIAGRAMS................................................................................................. 19

095-313SanyoTD00.12.1311:12AMページii

1. OPERATING RANGE

Temperature Indoor Air Intake Temp. Outdoor Air Intake Temp.

Cooling Maximum 95°F DB / 71°F WB 115°F DB

Minimum 67°F DB / 57°F WB 67°F DB

Heating Maximum 80°F DB / 67°F WB 75°F DB / 65°F WB

Minimum — DB / — WB 17°F DB / 15°F WB

095-313SanyoTD00.12.1311:12AMページ1

Power Source 230 / 208V – Single phase – 60Hz

Cooling Heating

Capacity BTU/h 11,700 / 11,500 13,000 / 12,700

kW 3.43 / 3.37 3.81 / 3.72

Air circulation (High) ft3/min. 360 / 330

Moisture removal (High) Pints/h 3.3 / 3.2 —

Voltage rating V 230 / 208 230 / 208

Available voltage range V 253 to 187

Running amperes A 5.5 / 5.9 5.1 / 5.4

Power input W 1,210 / 1,180 1,170 / 1,120

Power factor % 95 / 96 99 / 99

S.E.E.R. (H.S.P.F.) 10.0 / 10.0 (6.8 / 6.8)

Compressor locked rotor amperes A 34

Heater element kW 1.5 / 1.23

Controls / Temperature control Microprocessor / I.C. thermostat

Control unit Wireless remote control unit

Timer ON/OFF, 24-hours & Program

Fan speeds Indoor / Outdoor 3 and Auto / 2 (Auto)

Airflow direction (Indoor) Horizontal Manual

Vertical Auto

Air filter Washable, Anti-mold

Compressor Rotary (Hermetic)

Refrigerant / Amount charged at shipment lbs. (g) R22 / 2.51 (1,140)

Refrigerant control Capillary tube

Operation sound Indoor – Hi / Me / Lo dB-A 43 / 39 / 36

Outdoor – Hi dB-A 49

Refrigerant tubing connections Flare type

Max. allowable tubing length at shipment ft. (m) 33 (10)

Refrigerant tube Narrow tube in. (mm) 1/4 (6.35)

diameter Wide tube in. (mm) 1/2 (12.7)

Refrigerant tube kit / Accessories Optional / Hanging wall bracket

Indoor unit Outdoor unit

Unit dimensions Height in. (mm) 14-3/16 (360) 20-7/8 (530)

Width in. (mm) 38-31/32 (990) 29-17/32 (750)

Depth in. (mm) 7-13/16 (198) 11-1/32 (280)

Package dimensions Height in. (mm) 10-23/32 (272) 23-1/2 (597)

Width in. (mm) 42-17/32 (1,080) 35-13/32 (899)

Depth in. (mm) 18-1/32 (458) 13-27/32 (352)

Weight Net lbs. (kg) 29.7 (13.5) 92.5 (42.0)

Shipping lbs. (kg) 37.4 (17.0) 99.1 (45.0)

Shipping volume ft3(m3) 4.8 (0.13) 6.5 (0.18)

Performance

Electrical Rating

Features

Dimensions & Weight

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Remarks: Rating conditions are:

Cooling: Indoor air temperature 80°F DB/67°F WB

Outdoor air temperature 95°F DB/75°F WB

Heating: Indoor air temperature 70°F DB

Outdoor air temperature 47°F DB/43°F WB

2. SPECIFICATIONS

2-1. Unit Specifications

Indoor unit KHS1232

Outdoor unit CH1232

095-313SanyoTD00.12.1311:12AMページ2

2-2. Major Component Specifications

2-2-1. Indoor Unit

Indoor unit KHS1232

Remote Control Unit RCS-KHS2422W

POW-KHS1222-A

Control circuit fuse AC 250V - 3A

Switch Ass’y SW-KHS2412W

AH-KH1212

Input (230 / 208V) kW 1.5 / 1.23

Protective thermostat OFF 140 ± 5°F, ON 122 ± 9°F

Thermo fuse Cut-off 341 + 2, –5°F, 277V - 15A

Type Cross-flow

Number … Dia. and length in. (mm) 1 … O.D. 4 (100), L 30 (760)

Model … Number UF4Q-11A6P … 1

No. of pole … rpm (230V, High) 4 … 1,330

Nominal output W 10

Coil resistance ΩBRN – WHT: 281.6

(Ambient temp. 68°F) WHT – VLT: 45.3

VLT – ORG: 56.0

ORG – YEL: 117.0

YEL – PNK: 59.4

Safety

Type Internal protector

Operating Open °F 248 ± 9

devices temp. Close Automatic reclosing

Run capacitor µF 0.8

VAC 440

Model M2EA24ZA01

Rating 208 to 230V, 60Hz

No. of pole … rpm 8 … 3

Output W 2.5

Coil resistance (at 68°F) kΩ16.45 ± 15%

Coil Aluminum plate fin / Copper tube

Rows … Fins per inch 2 … 14.1

Face area ft.2(m2) 2.08 (0.19)

Controller

PCB

Fan

Heater Element

(Aux. Heater)

Fan Motor

Heat

Exch.

Louver

Motor

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

095-313SanyoTD00.12.1311:12AMページ3

POW-CH1232

Control circuit fuse AC 250V - 3A

Type Rotary (hermetic)

Model … Number C-R95H6E … 1

No. of cyl. … rpm 1 … 3,500

Nominal output W 950

Compressor lubricant cc 600

Coil resistance ΩC – R: 1.89

(Ambient temp. 77°F) C – S: 4.90

Type Internal External

Overload relay models — MST00AKU-9200

Safety Operating Open °F — 275 ± 9

devices temp. Close °F — 156 ± 27

Operating amp. —Trip in 6 to 16 sec.

(Ambient temp. 77°F) at 21.0A

Run capacitor µF 20

VAC 400

Crank case heater 230V - 20W

Type Propeller

Number … Dia. in. (mm) 1 … 15-3/4 (400)

Model UE6S-21L6P

No. of pole … rpm (230V, High) 6 … 840

Nominal output W 20

Coil resistance

ΩBRN – WHT: 201.7

WHT – YEL: 156.1

(Ambient temp. 68°F) YEL – PNK: 27.1

Safety

Type Internal protector

Operating Open °F 248 ± 9

devices temp. Close Automatic reclosing

Run capacitor µF 2.5

VAC 440

Coil Aluminum plate fin / Copper tube

Rows … Fins per inch 2 … 15.9

Face area ft.2(m2) 3.29 (0.30)

External Finish Acrylic baked-on enamel finish

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Compressor

Fan Motor Fan

Heat

Exch.

Controller

PCB

2-2-2. Outdoor Unit

Outdoor unit CH1232

095-313SanyoTD00.12.1311:12AMページ4

38-31/32

14-3/16

7-13/16

Rear panel

(Center point of gravity)

Drain hose O.D. 1-1/4

Narrow tube O.D. 1/4

Wide tube O.D. 1/2

Center of

tubing hole

(For right rear)

5-19/32

1-61/64

Wireless remote

control unit

6-7/64

2-13/64 19/32

Dimension: in.

3. DIMENSIONAL DATA

Indoor unit KHS1232

095-313SanyoTD00.12.1311:12AMページ5

4 ×15/32 dia. hole

Air intake

Air discharge

23-15/16 2-3/8

29-17/32

Air

intake

Check port

2-1/4 11-1/32

20-7/8

21/32

2-23/32 2-3/8

1/4" narrow tubing

service valve

1/2" wide tubing

service valve

10-23/32

11-7/8

Dimension: in.

Outdoor unit CH1232

095-313SanyoTD00.12.1311:12AMページ6

TC : Total Cooling Capacity (BTU/h)

SHC : Sensible Heat Capacity (BTU/h)

KW : Compressor Input (kW)

Rating conditions (* mark) are: Outdoor ambient temperature 95°F DB

Indoor unit entering air temperature 80°F DB/67°F WB

Rating Capacity: 11,700 BTU/h Air Flow Rate: 360 CFM

Evaporator Condenser

Ent. Temp. °F (°C) Ambient Temp. °F (°C)

WB DB 75 85 95 105 115

(23.9) (29.4) (35.0) (40.6) (46.1)

TC 11,580 11,060 10,530 9,930 9,130

KW 0.89 0.97 1.05 1.14 1.25

59 72 (22.2) SHC 8,690 8,430 8,170 7,880 7,500

(15.0) 76 (24.4) SHC 9,850 9,590 9,340 9,050 8,670

80 (26.7) SHC 11,070 10,810 10,530 9,930 9,130

84 (28.9) SHC 11,580 11,060 10,530 9,930 9,130

88 (31.1) SHC 11,580 11,060 10,530 9,930 9,130

TC 11,980 11,610 11,150 10,540 9,710

KW 0.89 0.98 1.07 1.16 1.28

63 72 (22.2) SHC 7,260 7,090 6,890 6,620 6,260

(17.2) 76 (24.4) SHC 8,430 8,260 8,050 7,780 7,420

80 (26.7) SHC 9,650 9,480 9,270 9,000 8,640

84 (28.9) SHC 10,810 10,640 10,440 10,170 9,710

88 (31.1) SHC 11,980 11,610 11,150 10,540 9,710

TC 12,310 12,110 *11,700 11,060 10,300

KW 0.90 0.99 1.08 1.18 1.31

67 72 (22.2) SHC 5,800 5,720 5,550 5,290 4,980

(19.4) 76 (24.4) SHC 6,960 6,880 6,710 6,450 6,150

80 (26.7) SHC 8,180 8,100 7,930 7,670 7,370

84 (28.9) SHC 9,350 9,260 9,100 8,830 8,530

88 (31.1) SHC 10,510 10,430 10,260 10,000 9,700

TC 12,690 12,480 12,170 11,620 10,940

KW 0.91 1.00 1.10 1.21 1.33

71 72 (22.2) SHC 4,290 4,210 4,090 3,890 3,640

(21.7) 76 (24.4) SHC 5,460 5,380 5,260 5,060 4,810

80 (26.7) SHC 6,670 6,590 6,480 6,270 6,030

84 (28.9) SHC 7,840 7,760 7,640 7,440 7,190

88 (31.1) SHC 9,000 8,930 8,810 8,600 8,360

TC 12,940 12,800 12,520 12,070 11,580

KW 0.93 1.02 1.11 1.24 1.37

75 76 (24.4) SHC 3,960 3,910 3,820 3,670 3,510

(23.9) 80 (26.7) SHC 5,180 5,130 5,030 4,890 4,720

84 (28.9) SHC 6,340 6,290 6,200 6,050 5,890

88 (31.1) SHC 7,510 7,460 7,360 7,220 7,050

4. COOLING CAPACITY

Indoor unit KHS1232

Outdoor unit CH1232

230V single phase 60Hz

095-313SanyoTD00.12.1311:12AMページ7

Andere Handbücher für KHS1232

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sanyo Klimaanlage Handbücher

Sanyo

Sanyo SAP-K91AHA Betriebsanleitung

Sanyo

Sanyo PNR-XS1872 Bedienungsanleitung

Sanyo

Sanyo 26KHS72R Installations- und Benutzerhandbuch

Sanyo

Sanyo RS1211 Bedienungsanleitung

Sanyo

Sanyo KS1822 Bedienungsanleitung

Sanyo

Sanyo KS3082 Bedienungsanleitung

Sanyo

Sanyo 09KHS71 Bedienungsanleitung

Sanyo

Sanyo SAP-K71GH Betriebsanleitung

Sanyo

Sanyo STW0633H1-S Bedienungsanleitung

Sanyo

Sanyo SAP-KRV91EH Betriebsanleitung

Sanyo

Sanyo 36T72R Betriebsanleitung

Sanyo

Sanyo SAP-C302AH-S Betriebsanleitung

Sanyo

Sanyo 42TW72R Bedienungsanleitung

Sanyo

Sanyo XMS1272 Betriebsanleitung

Sanyo

Sanyo SAP-KRV91EH Betriebsanleitung

Sanyo

Sanyo SAP-K181AA Betriebsanleitung

Sanyo

Sanyo W-3WAY ECO-i WCHDZ26053 Installations- und Benutzerhandbuch

Sanyo

Sanyo SAP-URV246EH Bedienungsanleitung

Sanyo

Sanyo 18KM12W Bedienungsanleitung

Sanyo

Sanyo STW0622C2 Bedienungsanleitung

Sanyo

Sanyo CH0971 Betriebsanleitung

Sanyo

Sanyo KS2432 Bedienungsanleitung

Sanyo

Sanyo KMHS0772 Betriebsanleitung

Sanyo

Sanyo C2462R Handbuch

Beliebte Klimaanlage Handbücher anderer Marken

Panasonic

Panasonic CS-E12HKEW Bedienungsanleitung

nedis

nedis ACMB1WT7 Bedienungsanleitung

Daikin

Daikin FCFV50A Bedienungsanleitung

Fujitsu

Fujitsu Inverter ASBA30JFC Bedienungsanleitung

Toshiba

Toshiba RAS-M10SMUV-E Bedienungsanleitung

Daikin

Daikin FXLQ20MAVE Bedienungsanleitung

CIAT

CIAT Magister 2 Series Leitfaden

Bestron

Bestron AAC6000 Bedienungsanleitung

Frigidaire

Frigidaire FFRE0533S1E0 Bedienungsanleitung

Samsung

Samsung AS09HM3N Bedienungsanleitung

Frigidaire

Frigidaire CRA073PU11 Betriebsanleitung

Soleus Air

Soleus Air GB-PAC-08E4 Bedienungsanleitung

McQuay

McQuay MCK020A Bedienungsanleitung

Webasto

Webasto Frigo Top 25 DS Bedienungsanleitung

Frigidaire

Frigidaire FAZ12ES2A Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric MSC-GE20VB Bedienungsanleitung

Mitsubishi Electric

Mitsubishi Electric PLA-M100EA Bedienungsanleitung

Daikin

Daikin Split Sensira R32 Bedienungsanleitung