Sanyo EM-V890 Betriebsanleitung

Si@’Mio

IFILE NO. I

SUPPLEMENT OF

SERVICE MANUAL Microwave Oven EM-V890(NEWZEALAND)

—/1

===!9” I

[. .

rProduct Code No. .437-315-01 ]‘

See the service manual of EM-870 ~( WM. “

640208 l-except the items described in this

service manual.

Foreword

Read this manual carefully, especially precaution on microwave energy, and follow the procedure strictly. Careless ser- -

vicing and testing may expose yourself to the microwave energy leakage.

PRECAUTIONS

PRECAUTIONS TO BE OBSERVED BEFORE AND DURING SERVICING TO AVOID POSSIBLE EXPOSURE TO EXCES-

SIVE MICROWAVE ENERGY

(a)

(b)

(c)

(d)

Do not operate or allow the oven to be operated with door open.

Make the following safety checks on all ovens to be serviced before activating the magnetron or other micro-

wave source, and make repairs as necessary:

(1) Interlock operation, (2) proper door closing, (3) seal and sealing surfaces (arcing, wear, and other dam-

age), (4) damage to or loosening of hinges and latches, (5) evidence of dropping or abuse.

Before turning on microwave power for any service test or inspection within the microwave generating com-

partments, check the magnetron, wave guide or transmission line, and cavity for proper alignment, integrity,

and connections.

Any defective or misadjusted components in the interlock, monitor, door seal, and microwave generation and

transmission systems shall be repaired, replaced, or adjusted by procedures described in this manual before

the oven is released to the owner.

REFERENCE NO. SS- 640141

..”

–TABLEOF CONTENTS–

Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1Test Procedures, ..-,..... . . . . . . . . . . . . . . . 3

Power Output Measurement . . . . . . . . . . . . . . . . . . 1Exploded View and Parts List.... . . . . . . . . . . . 4-8

Circuit Diagram ...........................2 Overall Circuit Diagram . . . . . . . . . . . . . . . . . . . ...9”’

2. pOwER OUTPUT MEASUREMENT

(1) Prepare 1000*5g tap water.

(2) Adjust water temperature to 10”*2”C.

(3) Pour water into acontainer made of borosilicate

glass, 180mm outer diameter cylinder, maximum

3mm thickness.

Note: Use the container kept on the room tempera-

ture.

(4) Place the container in the center of oven cavity.

(5) Set the heating time for 49 seconds and rating full

power and then start oven.

(6) Take the container out immediately when heating

time is up.

(7) Stir water for making even water temperature in the

1. SPECIFICATIONS

Rated Power Consumption,, 1,500 W

Microwave Output ................ 1,Ooow

[Adjustable 144W through

1,Ooow)

Frequency .............................. 2,4513 MHz*50MHz

Power Supply ........................ 240 V, 50 HZ

Rated Current ....................... 6.8 .Amp.

Safety Devices ...................... Thermal ProtectoI, Open at

122 ‘C for Cavity

Thermal Protector, Open at

135°C for Manetron

Fuse (Cartridge Type 8A)

Prima~ Interlock Switch

Interlock Monitor and

Door Sensing Switch and Relay 2

Timer ...................................... Electronic Digital, up to

99 min. 99 sec.

Overall Dimensions .............. 550(W) x453(D) x309(H) mm

Oven Cavity Size ................... 377(W) x404(D) x237(D) mm

Turn Table Diameter ............ 360 mm

Effective Capacity of Oven

Cavity ..................................... 31 Jiter

‘Net Weight ............................ Approx. 20 ‘g

container.

(8) Measure water temperature.

Water temperature rise shall be 8° to 12°C.

–l–

.... .... .“”, . . .. . . .-, . ..

...”

3. CIRCUIT DIAGRAM

240 V50HZ

k-l 4r-$1

.,:.

:?:>,

. .

.. ‘. .

:..’.

-.:.’-

FUSE I~-Lil

ys!

8A(T) I—=—-J I

@\ ITHERMAL PROTECTOR

FOR CAVITY OPEN 122i5° C

On 650JIH IBR

[~”~ ;

i!0.068pF(x~

1- T

~2x2200PF(Y1

———— —— BK

CAVITY LAMP

wBK

THERMAL PROTECTOR

FOR MAGNETRON OPEN

135t5°c (

_______-

j~~NNECTOR

-J

GEAR MOTOR

f>SK

@g;;~gK

SWITCH

f>0

NC* NO

BLOWER MOTOR

CONNECTOR HIGH VOLTAGE TRANSFORMER

r_._— -——— -———. —— 1

-——.———

G‘“2

RELAY 2

+-’

‘l@ n’ I

J:’”” II II

%+RELAY311CONNECT: ti______l__D_: ~

BK\

S102

IIP~TRI-TI -

!RELAY1

Is 1II

STEP-DOWN

TRANSFOR~ER 3}

r———-

1* IIDOOR

—

,SENSING DIODE

IICONTROL ISWITCH

CIRCUIT

III@~ MAGNETRON $&.,u. -

BOARD 10MEG.OHM

f!~i 0.97MFD

-=.-.~_J_J ~2.4KVAC

L––.

WIRING COLOR

‘-- BK :BLACK BR :BROWN

w:WHITE

o:ORANGE BL :BLUE

R:RED

Notes: Thesigrr~ –Theparts marked with~ are supplied high

voltage which isexceeded250V.

The sign @-Thepa~s marked with @have specialchar-

acteristicsimportant for microwave leakage.

When replacingany of these parts use only

manufacturer’sspecified parts.

1- .— -J

————— .—— ——— “J ~

————

Figure 1

-2–

4. TEST PROCEDURES

.“.

:. .,

:,.

,,. .

‘,. .

–3–

. .. ,.-. ...’.... . . ... .

.. i

5. EXPLODED VIEW AND PARTS LIST

CAVITY PARTS

..-.

.-. ..

.>--.2

-. .’-

....

Key

No. Part No. Description Q’ty

16171246377 Cabinet (Also order Circuit Diaqram 1

-when replacing Cabinet. )

24110825201 Screw, Truss Hd.Tapping, 4x10mm 7

3411 1606007 Screw. Tapping TRS +SRT 4x10mm 3

.4 6171452013 Oven Cavity’** (Not service Part) 1

56171451399 Bottom Plate*** 1

66171445435 Plastic Foot with Canoe Clip 4

7411 0110802 Bolt, Hex. Hd. Machine with Spring 2

Washer &Bolt Washer, 5x14mm,

86171240795 Hinge Lower*** 1

94110892500 Washer, 5mm, U1

10 4110105808 SCR EVR PAN 4x10mm 2

’11 6171305616 Gear Motor M2LJ50ZA12 1

12 6171208481 Insulation Sheet 1

‘Items not illustrated

Key

No. Part No. Description Q’ty

13 6170805315 Special Washer 1

14 6171514155 Turn table Shaft 1

15 6171242416 Roller 1

16 6171098372 Rotating Tray 1

17 6171281149 Duct, Humidity Senser 1

18 6171473865 Humidity Sensor 1

19 4110076900 Screw, Pan Hd.,Tapping, 3x6mm,

6171451573 Cavity Cover 2

20 1

21 411 1606106 Screw S- TPG TRS +SRT 4x10mm 1

22 6171184679 Insulation Sheet 1

23 411 1606205 Screw TPG TRS +SRT 4x10mm 1

24 6171241235 Thermostat Cavity 122°C 1

●6171623628 Name Plate 1

●6171623611 Circuit Diagram 1

–4–

-., ....- .. . . . . .. . .

.“

““’”

SWITCHES AND MICROWAVE PARTS

(l”

Notes The sign ❑-The pa ❑

rts marked with $are supplied high

voltage which is exceeded 250V.

The sign @-The parrs marked with@ have special char-

acteristics important for microwave leakage.

When replacing any of these parts use onlv

manufacturer’s specified parts,

Key

No. Part No. Description C1’ty

1 411 0825201 Screw, Truss Hd. Tapping, 4x10mm 6

26171385113 Power Supply Cord Complete 1

3 6171569605 High Voltage Transformer, 1

H5T-V860SAP

46171505603 Duct, Msg. Inlet 1

56171385984 Stay, Cavity &Magnetron 1

64110076900 Screw, Pan Hd. Tapping, 3x6mm,

C2-2 2

7~1”~ 124 f259 Thermostat, Magnetron, 135CC 1

84,50023308 Magnetron. 2M247H(8)*** 1

94230227503 Fuse, 250 V8A 1

10 6171414042 Terminal Circuit 8oard Complete 1

11 6171451627 Lead Wire Ass’y with Diode 1

12 617124379? Lead Wire Ass’y (Transformer to 1

Capacitor)

13 6171378870 Capacitor Band 1

14 6171449716 High Voltage Capacitor, l.1mfd.2.1 KV 1

15 6171241082 Space Partition (Blower) 1

16 6171306927 Blower Motor 1

17 4110772109 Screw, Truss Hd. Tapping, 2

4x20mm, Z1-1

Key

No. Part No. Description f.1’ty

18 6170751179 Blower Fan 1

19 411011 5609 Bolt HEX C-SCT 4x20 3

20 6171405330 Duct, Mag, Exhaust 1

21 6171103618 Lamp, 2413v25W 1

22 6171241280 Lamp Socket 1

23 6171241181 Latch Lever*** 1

24 6171524741 Micro Switch, primary, and Door** 2

Sensing V-5930D***

2.5 617004 557s Micro Switch, Interlock Monitor 1

V-5220 DZ***

27 6171241174 Lever Stopper’** 1

29 411 1025808 Screw, E- Tapping TRRS +TW 2

,4x10 mm, Z1

30 411 1606007 Scr~w TPG TRS +SRT 4x10mm 1

31 411 1606106 Scre~ S-TAP TRS +SRT 4x1O mm 2

32 411 0014704 Screw, Pan Hd. Tapping, 4x1O mm, 1

33 6171325713 Insulation Sheet 1

,-..-

....’

,,.

–5-

....’”. .. ’.’ .,. . . .

.’ i

DOOR PARTS

8***

/’

45 /7 *** 4*** c

...-

[

Key

No.

●** ALL SERVICE (3N MICROWAVE OVENS SHOULD BE PERFORMED BY AtXJALIFIED TECHNICIAN

USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS

IDENTIFIED BY ATRIPLE ASTER ISK(**’)

Pan No. Description —

6171520934 Door Cover**”

6171520941 Door Panel’”

6171385908 Door Main Frame ”’”lAlso order

Door Sheet when replacing Door

Main Frame)

6171520958 Choke Dielectric”*’

6171246483 Door Sheet*”* 1

Q’ty

Key

No. Part No.

64110541903

7 6171240955

84110110802

Description

Nut. Hex. Hd. with Washer, 5mm

Hinge, Upper**”

Bolt, Hex. Hd. Machine with Spring

Washer and Bolt Washer, 5x14mm,

~,,..

Spring***

Door Latch***

,10 ***

***

a’ty

–6-

... . .. .. . .. . .

CONTROL PANEL PARTS

3-6 ***

1***

4***

2***

\8***

***

5***

,~-.

.“..

,-,

:..

,.,

●** ALL SERVICE (3N MICROWAVE OVENS SHOULD BE PERFORMED BY AQUALIFIED TECHNICIAN

USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS

IDENTIFIED BY ATRIPLE ASTER ISK(”*”) ~

Key

No. Part No. Description at y

16171623505 Control Sheet””* (Also order Touch 1

Key Board When replacing Control

sheet)

26171623512 Touch Key Board*’* (Also order 1

Control sheet when replacing Touch

Key Board)

36171514346 Control plate”’” 1

46171521030 Control Frame*** 1

Key

No. Part No. Description Q’ty

6171623567 Operating Instructions 1

6171623642 Carton Box Complete 1

iTy

No.

—

Part No. IDescription

6171623161 Control Base’”

6171616767 Power &Control Circuit Board

Complete

411 1295805 Screw, Bin Tapping, 3X10mm

6170809559 Spring, Door Release Lever***

6171514339 Door Release Lever”’*

-i

Q’ty

--l

–7-

CONTROL CIRCXJIT BOARD

(Part No. 617161 6767I) ~‘P-6

.’. -

TP-2 —

.-.,

,...

TP-3 -

—TP-7

—TP-4

—TP-1

Ground

‘TP-5

– 8–

“’m

R143

10R

6. OVERALL CIRCUIT DIAGRAM ‘61/$1

~80/At

,..

~5G

371

>?0

P45

.-..

.’ . ..

P47 /1:

W142

!OK

5102 12

Acz30v-24av/5oHz

FUSE =I650 PHx2

THERMAL

0.068 u F PROTECTOR

THERMAL T=200PFx2

PROTECTOR

000R u

SENSING 0102

1N4002 -5V

SWITCH 4?orl 4700

I29

L.—-—. J

OPEN ~

UI04

27,7

R105

??n

11 0103

1SS132

pglu

PRIMARY

INTERLOCK

SWITCH

:E:;;:

BLOWER

nMOTER

RL2 ,< RL2 +r-———-

121

0102

C3330 I

L——__—J

0104

1SS132

RL1 Q106 ,$

330fl OPEN ~

rRlto I

3. 3x

3i,, I

BZl

62KM1 Q109

-15V lK

(~MAGNETRON

r(2J @ @ @Slol

10P

o6~POWER BEVEBAGC (@ -G123,,, lx 5

,,,

1 7 OEFROST MEAT FfEtiEAT @~R124 lK 33

2 8 9125, ,, ~K 34

POTATO Hi/LO :::::: 8

3 9 Iflzo,,, lK 35

CASSE80LE START V#aIlbo L@s 9

4STOP o

CLEAR ‘lME -’ FISH R127 lK 36

—

Rlll k

lK ,010s

I01 A123Y

.I0105

.I15 S132 27

._L—-————A —

0! Q113

nI?112

010K 4’TK C102

/50v

011 1

()+0. Iv

013 CI06

--- 11N4002 1M4002

51 0. Olu Zoll

+/Fiov If05. 6ESB3

Zola C13 E

@Dt3ESE2

IRll 47”

Cll z1d.7K z?10V

/1000W :

/25v ;

.————-—

1°

~1 I

~-5,

II iI Ill

.013

Ill

011 A564A

IzBB27 o-12V 6-5V

0106

1SS132 . .

. . AIOv r

‘1 R13 220n

I,,,, +

I,,, A’15 10K

JR14’

A>20n

~dy Ov f

~..

--- ————-—

PT1 P05M-v890 – 9–

Andere Handbücher für EM-V890

Andere Sanyo Mikrowellenofen Handbücher

Sanyo

Sanyo EM-N102 Bedienungsanleitung

Sanyo

Sanyo EM-U1000 Gebrauchs- und Pflegehandbuch

Sanyo

Sanyo EM-710OF Bedienungsanleitung

Sanyo

Sanyo EM-S1563 Bedienungsanleitung

Sanyo

Sanyo EM-X4111 Bedienungsanleitung

Sanyo

Sanyo EM-U1000W Gebrauchs- und Pflegehandbuch

Sanyo

Sanyo EM-X680 Bedienungsanleitung

Sanyo

Sanyo EM-C1900 Bedienungsanleitung

Sanyo

Sanyo EMC 1400 Bedienungsanleitung

Sanyo

Sanyo EM-X491S Bedienungsanleitung

Sanyo

Sanyo EMS-8600S Bedienungsanleitung

Sanyo

Sanyo EM-C1901 Bedienungsanleitung

Sanyo

Sanyo EM-X471S Betriebsanleitung

Sanyo

Sanyo EM-C2001UK Bedienungsanleitung

Sanyo

Sanyo EM607TW Bedienungsanleitung

Sanyo

Sanyo EM-F301WS Bedienungsanleitung

Sanyo

Sanyo EM870FS Bedienungsanleitung

Sanyo

Sanyo EM-P672WS Bedienungsanleitung

Sanyo

Sanyo EMS6588S - USA Countertop Microwave Oven 1.0 cu.ft. Capacity... Gebrauchs- und Pflegehandbuch

Sanyo

Sanyo EM-S100 Bedienungsanleitung

Sanyo

Sanyo EM-P692WS Bedienungsanleitung

Sanyo

Sanyo EM-S1567B Bedienungsanleitung

Sanyo

Sanyo EM-SL60C Bedienungsanleitung

Sanyo

Sanyo EM?S667S Bedienungsanleitung

Beliebte Mikrowellenofen Handbücher anderer Marken

Daewoo

Daewoo KOG-574R0S Bedienungsanleitung

LG MH7040SS Bedienungsanleitung

Sharp

Sharp R-895(AL)M Bedienungsanleitung

Dometic

Dometic DOTRM13W Bedienungsanleitung

Sharp

Sharp R-393M Bedienungsanleitung

KitchenAid

KitchenAid KMCX4510 Montageanleitung

Smeg

Smeg S45MCX1 Bedienungsanleitung

Russell Hobbs

Russell Hobbs RHM2044 Bedienungsanleitung

Sunbeam

Sunbeam SMW759 Bedienungsanleitung

Gallet

Gallet FMOE230S Bedienungsanleitung

Bosch

Bosch CEG732X.1B Bedienungsanleitung

Dometic

Dometic Roadmate 230 Bedienungsanleitung

Samsung

Samsung SJ0396W Bedienungsanleitung

Sharp

Sharp R-240 Bedienungsanleitung

Electrolux

Electrolux EMS2840 Bedienungsanleitung

Daewoo

Daewoo KOC-984T2S13 Bedienungsanleitung

Impecca

Impecca CM07M2 Bedienungsanleitung

Samsung

Samsung CE2927 Bedienungsanleitung