Sharp SJ-V39L-GY Bedienungsanleitung

SJ-V35L

SJ-V39L

SERVICE MANUAL

SX026SE40BPST

SHARP CORPORATION

REFRIGERATOR-FREEZER

Refrigerant; HFC-134a

Refer to "HFC-134a COOLING UNIT" Service Manual for handling this refrigerant.

DESTINATION ............................. T

Intheinterestsofuser-safety(Requiredbysafetyregulationsinsome

countries) thesetshouldberestoredtoitsoriginalconditionandonly

parts identical to those specified should be used.

MODELS

TABLE OF CONTENTS

page

SPECIFICATIONS ............................................................................................................................................. 2

DESIGNATION OF VARIOUS PARTS............................................................................................................... 4

LIST OF ELECTRICAL PARTS.......................................................................................................................... 6

WIRING DIAGRAM ............................................................................................................................................ 7

FUNCTIONS .......................................................................................................................................................9

DEODORIZING OPERATION.......................................................................................................................... 12

ASSEMBLING PROCEDURES OF MAIN PARTS AND CAUTIONS ...............................................................13

COOLING UNIT ............................................................................................................................................... 18

REPLACEMENT PARTS LIST......................................................................................................................... 19

SJ-V39LSJ-V35L

SJ-V35L-GY

SJ-V39L-GY

SJ-V35L

SJ-V39L

Items SJ-V35L SJ-V39L

Type 3-Door 3-Door

Outer dimensions Height 1578mm(62.2") 1777mm(70.0")

Width 635mm(25.0") 635mm(25.0")

Depth 670mm(26.4") 670mm(26.4")

Rated storage volume 315 liter(11.1 cu.ft) 368 liter(13.0 cu.ft)

F: 88 liter(3.1 cu.ft) F: 88 liter(3.1 cu.ft)

R: 142 liter(5.0 cu.ft) R: 195 liter(6.9 cu.ft)

V: 85 liter(3.0 cu.ft) V: 85 liter(3.0 cu.ft)

Rated gross volume 318 liter(11.2 cu.ft) 371 liter(13.1 cu.ft)

F: 89 liter(3.1 cu.ft) F: 89 liter(3.1 cu.ft)

R:143 liter(5.1 cu.ft) R: 196 liter(7.0 cu.ft)

V: 86 liter(3.0 cu.ft) V: 86 liter(3.0 cu.ft)

Defrosting System Heater system

Start Automatic

Finish Automatic

Temperature control Automatic (Adjustable)

No-frost freezer Yes

Interior lamp 1

Caster 4

Evaporating pan 1

Freezer Freezer shelf 2

Compartment Freezing room 1

Ice cube maker 1

Ice cube box 1

Freezer pocket (S) 1

Freezer pocket (L) 1

Refrigerator Chilled case 1

Compartment Refrigerator shelf(S) 1

Refrigerator shelf(L) - 1

Three position 1

adjustable shelf

Egg pocket 1 -

Egg holder(S) 1 -

Egg holder(L) 1 2

Utility pocket 1 -

Utility pocket - 3

Small pocket - 3

Bottle pocket (S) 1

Bottle pocket (L) 1

Vegetable Compartment Yes

(Vegetable case 1, Parting Plate 1, Fruit case 1)

Deodorizing system Yes

SPECIFICATIONS

SJ-V35L

SJ-V39L

RATING

Items SJ-V35L SJ-V39L

Rated voltage (V~) 220-240

Rated frequency (Hz) 50

Climate class T

Rated input (W) 139-145 165-175

Rated input of heating elements (W) 128-152

Defrosting input (W) 128-152

Refrigerant (Charging quantity) HFC-134a(115g) HFC-134a(120g)

Net weight (kg) 69 73

COLOR

Items SJ-V35L-GY, SJ-V39L-GY

Outside color Gray

Inside color White

Source cord 2pin

Plug type A-1

SJ-V35L

SJ-V39L

DESIGNATION OF VARIOUS PARTS

1. Freezer temp. control knob

2. Freezer shelf (Free case)

3. Freezing room

4. Ice cube maker

5. Ice cube box (Ice storage box)

6. Chilled case

7. Light (Lamp)

8. Refrigerator temp. control knob

9. Refrigerator shelf (S) (Refrigerator tray)

10. Refrigerator shelf (L) (Refrigerator tray L)

11. Three position adjustable shelf (Free set shelf)

12. Caster

13. Adjustable feet (Adjustable leg)

14. Evaporating pan & Evaporating pan cover

15. Fan switch

16. Freezer pocket (S) (F-door pocket S HS)

17. Freezer pocket (L) (F-door pocket L HS)

18. Magnetic door seal (Door packing)

19. Egg holder (S) (Egg tray)

20. Egg holder (L) (Egg tray)

21. Egg pocket (Door pocket HS)

22. Utility pocket (Door pocket HS)

23. Utility pocket (Door pocket S HS)

24. Small pocket (Dressing pocket)

25. Fan & light switch

26. Bottle pocket (S) (Bottle pocket S)

27. Bottle holder (Bottle guard)

28. Bottle pocket (L) (Bottle pocket HS)

The names in parenthesis are the denominations used in the REPLACEMENT PARTS LIST.

EXTERNAL DESCRIPTION

19,20

SJ-V35L SJ-V39L

29. Vegetable compartment

Vegetable case

Parting plate

(Bottle guard)

Fruit case

SJ-V35L

SJ-V39L

CONSTRUCTIONS

Figure D-1 (SJ-V35L)

Fan motor (Left)

F-thermostat (Right)

Evaporator

Defrost thermostat

Defrost heater

Damper thermostat

R-C box

Multi louver

Protect cover

Starting relay

Overload relay

Compressor

Door switch 2P

Door switch 3P

Mark; Cold air flow

Figure D-2 (SJ-V39L)

Fan motor (Left)

F-thermostat (Right)

Evaporator

Defrost thermostat

Defrost heater

Damper thermostat

R-C box

Multi louver

Protect cover

Starting relay

Overload relay

Compressor

Door switch 2P

Door switch 3P

SJ-V35L

SJ-V39L

LIST OF ELECTRICAL PARTS

ITEMS TYPE NAME RATING SPECIFICATIONS

Damper thermostat MM1-6129 Open : 0.5˚C , Close : -4˚C

Defrost thermostat US602S 250V,8A Open : 10˚C , Close : 1˚C

Timer ND0804M2PR 200-240V Integration type

50/ 60Hz Cycle time : 8h43m(50Hz)

Delay time : 4m50s(50Hz)

Thermo. fuse (defrost) SF70E 250V,10A Cut off temperature : 72˚C

Door switch PS100-01T 250V,0.5A 2 terminals type push-button

(Freezer compartment)

Door switch PS100-T 250V,0.5A 3 terminals type push-button

(

Refrigerator compartment

)

Fan motor 3R00044B 220/240V,50Hz

Lamp — 240V,10W E-12

Lamp socket — 250V,1A E-12 (Hard plastic body type)

F-thermostat MM1-8038 ON : -20˚C , OFF : -25˚C

Defrost heater MM1-4021 220/230/240V 378Ωwith deodorizer

Compressor FL1568SZ 220/230/240V

50Hz Main : 13.3ΩTerminal shape

Aux : 25.6Ω

Cooling capacity 188W

Starting relay PETOSAT 300V 22Ω

Protector 2.0C36A1 — 130˚C / 60˚C

Common

Main coil

Aux. coil

SJ-V35L

SJ-V39L

WIRING DIAGRAM

Be sure to replace the electrical parts with specified ones for maintaining the safety and performance of the set.

Compressor

Starting Relay

(B)(B)(P)

(P)(W)

Defrost

Thermo.

(P)

R Door

Switch

F Door

Switch

(O)(S-B)

Lamp Fan

Motor

(Br) (Br)

F-Thermostat (R)

(W) Thermo.

Fuse

(Bk)

Defrost

Heater

Defrost

Timer

Protector

CONNECTED IN TERMINAL BOX

CONNECTOR

Plug/

Cord

S-B

:BLUE

:BLACK

:BROWN

:GRAY

:ORANGE

:SKY-BLUE

:PINK

:RED

:WHITE

:YELLOW 1 2

(B)

(G)

Figure W-1. Wiring Diagram

SJ-V35L

SJ-V39L

Figure W-2. Electric Accessories Layout

O-1

G-1

P-1

B-1

Br-1

R-1

Bk-1

W-1

C1(LR-09-1V)

Fan

Motor

Defrost

Thermo.

F-Thermostat Thermo.

Fuse

Defrost

Heater

Defrost

Timer

Compressor

Starting relay

F Door

Switch

C2 (3P-110V)

C6 (SGF-21T-5)

W-2

C7 (SGF-21T-5)

W-3

Protector

Terminal cover

Plug/Cord

Tube

P-2

O-1

R-1

Bk-1

G-2

P-1

S-B-1

Br-2

G-1

W-2

C3 (LR-09-1V)

C5 (LR-06-1V)

W-2

R Door

Switch

C4 (3P-110V)

B-2

P-2

3S-B-1

Tube

CE-2

(Br)

CE-2

(B)

CE-2

(G)

FREEZER

REFRIGERATOR

MACHINE ROOM

(Food liner)

(RC-box ass’y)

(Food liner)

(E.V cover ass’y)

Lamp

TERMINAL BOX

W-3

SJ-V35L

SJ-V39L

1. ADJUSTABLE TEMPERATURE CONTROL

(1) Temperature control of freezer

Thermostat (senses freezer temperature) operates on ON/OFF switchover to control the compressor and

allows the freezer temperature to keep at a suitable temperature.

However adjust the freezer temp. control knob as follows depending upon the storing condition of foods.

Figure F-1.

(2) Temperature control of refrigerator

Damper-thermostat senses temperature of the refrigerator and changes the opening angle of the damper

automatically.

However, as the Damper-thermostat has no function to switch on or off the compressor and cool air

circulating fan, the freezer temperature control causes temperature in the refrigerator to vary to some

extent.

However, adjust the refrigerator temp. control knob as follows depending upon the cooling condition.

Figure F-2.

NOTE: The refrigerator temperature is affected also by the freezer temperature. If the freezer temp.

control knob is set at the position "MAX", the temperature tends to be lower than the following

values, and if set at near the position "MIN", temperature tends to be higher.

If the refrigerator is operated for a long time with the freezer temperature control sets the "MAX"

position, foods stored in the refrigerator compartment may also freeze.

When refrigerator temperature control sets to the "CHILLED ZONE", some foods stored may

freeze.

In this case adjust control set back to the "MED" position.

When refrigerator temperature control sets to the "CHILLED ZONE", some foods stored in fresh

cases may also become frozen.

The values shown above refer to the measurement carried out center area and 1/3 of overall height from the bottom

at each of the refrigerator and the freezer after machine has been operated at an ambient temperature of 30˚C with no

food stored and the door closed until the temperature is stabilized.

The values vary depending upon frequency of opening and closing the door, ambient temperature, amount of stored

foods and manner of storing foods.

FUNCTIONS

MIN

MED

MAX

FREEZER TEMP. CONTROL

Coldest

KNOB

SETTING

MAX

(Coldest)

MIN

PURPOSE

For making ice rapidly or fast 

freezing.

For storing frozen food for a

short period (up to one month).

When frozen food or ice cream

is not stored.

For normal freezing.

MED

When restocking with fresh 

food.

VALUE OF 

TEMPERATURE

Approx. -21˚C

Approx. -18˚C

Approx. -15˚C

KNOB

SETTING

MED

CHILLED

ZONE

(Coldest)

MIN

PURPOSE

For keeping freshness of

food longer.

For normal operation.

When the refrigerator provides 

excessive cooling.

When the refrigerator does 

not provide sufficient cooling.

VALUE OF

TEMPERATURE

refrigerator chilled room

Approx. 

0˚C Approx. 

-3˚C

Approx. 

6˚C Approx. 

4˚C

Approx. 3˚C Approx. 1˚C

The values shown above refer to the case where the freezer temp. control

knob is set at "MED".

Coldest

MIN

MED

CHILLED

ZONE

REFRIGERATOR TEMP. CONTROL

SJ-V35L

SJ-V39L

2. DEFROSTING

(1) No defrosting operation is necessary

No defrosting operation is necessary.

As this machine is so designed that a built-in

evaporator cools air and a fan circulates cooled

air, neither the freezer nor the refrigerator is

frosted, though the evaporator is frosted.

The frosted evaporator is defrosted automatically

due to the function of defrosting timer and heater,

requiring no defrosting operation.

(2) Where is melted frost brought

1. Melted frost is brought into the evaporating

panat thebottom ofthe setand isevaporated

here by the heat of sub condenser.

2. Besuretousetheevaporatingpan as inserted

so as to be level with the outer case.

(3) The following circuit diagrams in the table show automatic defrosting function of the refrigerator with

timer and defrost thermostat.

Operation Electric diagram Description

1. Cooling

(Normal)

2. Defrosting

(Time 20 to 30 min.)

3. Drain

(Time approx. 5 min.)

4. Cooling (start)

The integration timer integrates running

time of the compressor. When it reaches

cycle time of defrost timer, the timer

contact is changed to start defrosting.

When the defrost thermostat becomes

OFF, the timer motor at rest starts running.

During the operation time (delay time of

defrost timer), defrosted water is drained

outside the refrigerator.

Timer contact is changed to cooling

operation and the compressor starts

running and the timer motor stops.

Defrost thermostat contact becomes ON

when it’s cooled. And the timer moter

starts running. (Figure F-4.)

Figure F-4.

Figure F-5 .

Figure F-6.

Figure F-7.

TM COMP

Defrost thermostat ON Compressor running

Timer motor running

Timer contact

Defrost

thermostat (ON)

Compressor

Timer motor

SOURCE

TM COMP

Defrost thermostat OFF Compressor running

Timer motor running

Thermostat Timer contact

Defrost

thermostat (OFF)

Compressor

Timer motor

SOURCE

TM COMP

Defrost thermostat OFF Compressor stops

Timer motor running

Thermostat Timer contact

Defrost

thermostat (OFF)

Compressor

Timer motor

SOURCE

TM COMP

Defrost thermostat ON Compressor stops

Timer motor stops

Thermostat Timer contact

Defrost

thermostat (ON)

Compressor

Timer motor

SOURCE

Thermostat

The timer contact is changed to start

defrosting, the timer motor stops, and

power is supplied to the defrost heater.

It takes about 20 to 30 min. to defrost.

When little frosted the defrosting takes

little time.

When much frosted, the

defrosting takes much time.

Defrost heater

Thermo. fuse

Defrost heater

Thermo. fuse

Defrost heater

Thermo. fuse

Defrost heater

Thermo. fuse

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sharp Kühlschrank Handbücher

Sharp

Sharp SJ-GF60AR Bedienungsanleitung

Sharp

Sharp SJ-LE134M1X-EU Bedienungsanleitung

Sharp

Sharp SJ-BA05DMXL1-UA Bedienungsanleitung

Sharp

Sharp SJ-BF237M01X-EN Bedienungsanleitung

Sharp

Sharp SJ-25P Bedienungsanleitung

Sharp

Sharp SJ-XP580G Bedienungsanleitung

Sharp

Sharp SJ-25P Bedienungsanleitung

Sharp

Sharp SJ-340V Bedienungsanleitung

Sharp

Sharp SJ-25P Bedienungsanleitung

Sharp

Sharp SJ-PC58A Bedienungsanleitung

Sharp

Sharp SJ-48J Bedienungsanleitung

Sharp

Sharp SJ-BA34IHXI2-EU Bedienungsanleitung

Sharp

Sharp SJ-BB04IMXW1-EU Bedienungsanleitung

Sharp

Sharp SJ-EK29L Bedienungsanleitung

Sharp

Sharp SJ-RF22E-DS Bedienungsanleitung

Sharp

Sharp SJ-P68M Bedienungsanleitung

Sharp

Sharp SJ-19T-H2 Bedienungsanleitung

Sharp

Sharp SJ-BR15G Bedienungsanleitung

Sharp

Sharp SJ-F85VM-SS Bedienungsanleitung

Sharp

Sharp SJ-X345E Bedienungsanleitung

Sharp

Sharp SJ-BB05DTXW1-EU Bedienungsanleitung

Sharp

Sharp SJ-F73SP-SL Bedienungsanleitung

Sharp

Sharp SJ-50M Bedienungsanleitung

Sharp

Sharp SJ-EK19P Bedienungsanleitung

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

Stengel

Stengel KU 1101 A++ Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

Amana

Amana ASD2524VES00 Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Samsung

Samsung RF323TE Bedienungsanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

True

True TS-28 Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung

Teledyne

Teledyne 6712FR and Betriebsanleitung