Siemens C75 Einrichtungshandbuch

Company Confidential s Com

Page 1of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

Service Repair Documentation

Level 2.5 light – C75

Release Date Department Notes to change

1.0 08.06.2005 ICM MP CCQ GRM T New document

Company Confidential s Com

Page 2of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

Introduction

This Service Repair Documentation is intended to carry out repairs on Siemens repair level

2.5 light. The described failures shall be repaired in Siemens authorized local workshops

only,

The level 2.5 (former Level 2.5e) partners are obliged to repair level 2 classified boards, up

to their repair level, under consideration of the information given by level 2.5 (former level

2.5e) repair instruction.

All repairs have to be carried out in an ESD protected environment and with ESD protected

equipment/tools. For all activities the international ESD regulations have to be considered.

Assembling/disassembling has to be done according to the latest C75 Level 2 repair

documentation. It has to be ensured that every repaired mobile Phone is checked according

to the latest released General Test Instruction document (both documents are available in

the Technical Support section of the C-market).

Check at least weekly C-market for updates and consider all C75 related Customer Care

Information

C75 Partnumber on IMEI label: S30880-S6970-#xxx

, while # may be any letter (A-Z) and xxx may be any number from 100, 101, 102....

Scrap Handling: All Scrap information given in this manual are related to the

SCRAP-Rules and instructions.

Attention: Consider the new "LEAD-FREE" soldering rules

(available in the communication market), avoid excessive heat.

If you have any questions regarding the repair procedures or technical questions spare not

hesitate to contact our technical support team in Kamp-Lintfort, Germany:

Tel.: +49 2842 95 4666

Fax: +49 2842 95 4302

E-mail: [email protected]

Company Confidential s Com

Page 3of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

Table of Content

1C75 board layout...........................................................................................................................4

2Connector SIM Card Reader.........................................................................................................5

3Connector IO Jack.........................................................................................................................6

4Connector Board to Board.............................................................................................................8

5Connector Battery .........................................................................................................................9

6Connector Camera......................................................................................................................10

7Connector Display.......................................................................................................................10

8IRDA............................................................................................................................................12

9JOYSTICK...................................................................................................................................13

Company Com

Page 4of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

Confidential s

1 C75 board layout

Jigs, Tools and working materials for all described repairs:

-hot air blower

-soldering gun

-tweezers

-flux Connector

Display Connector

Board to

Board

Joystick

-solder

Connector

Camera IRDA Connector

SIM Card

Reade

IO Jack

Slim

Connector

Battery

Connector

Antenna

Company Confidential s Com

Page 5of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

2 Connector SIM Card Reader

Fault Symptoms

Customer: GRT:

Handset does not accept SIM card SIM Card Problems

Connector SIM Card Reader

Use soldering iron to remove defective component. Avoid excessive heat! Watch surrounding components!

Resolder new component afterwards.

E-commerce order number: L50634-Z97-C406

E-commerce order name: CONNECTOR SIM CARD READER R65 (B)

Soldering temperature: ~ 360°C TIP Temp.

IRIS Diagnose Code: 43300 Interface/SIM Card reader/Mechanical Damage

Company Confidential s Com

Page 6of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

3 Connector IO Jack

Fault Symptoms

Customer: GRT:

Charging Problems No connection to GRT

Problems with external loudspeaker or microphone when using a car kit Tbd.

Problems with accessories connected at the IO connector

Connector IO Jack

Use soldering iron to remove defective component. Avoid excessive heat! Watch surrounding components!

Resolder new component afterwards.

E-commerce order number: L36334-Z93-C303

E-commerce order name: IO-JACK SLIM 12-POL

Soldering temperature: ~ 360°C TIP Temp.

IRIS Diagnose Code: 46100 Interface/Charging Connector/Mechanical Damage

47300 Interface/Data Interface/Mechanical Damage

4B100 Interface/Headset Connector/Mechanical Damage

Company Confidential s Com

Page 7of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

Important additional soldering hints

The MMC Reader is located on the opposite of the SLIM-Lumberg connector.

Therefore the risk to damage the plastic material of this MMC-Reader is

potentially high if excessive heat is used while removal or soldering of the

SLIM-Lumberg connector.

Please follow these instructions:

a) Remove the SLIM-Lumberg connector with a soldering iron and Desolder

Wick

b) Clean the Pads afterwards

c) Solder the new connecter by using soldering iron under consideration of

the max. allowed temperature range.

Samples of critical area:

Lock mechanism damaged Lock mechanism OK

Company Confidential s Com

Page 8of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

4 Connector Board to Board

Fault Symptoms

Customer: GRT:

Keyboard malfunction Keyboard malfunction

Keypad illumination does not work Tbd.

Connector Board to Board

Use hot air blower to remove defective component. Avoid excessive heat! Watch surrounding components!

Resolder new component afterwards.

E-commerce order number: L50634-Z97-C383

E-commerce order name: CONNECTOR BOARD TO BOARD 12-POL. X75

Soldering temperature: ~ 360°C TIP Temp.

IRIS Diagnose Code: 32100 Keys / Main / No Function

32200 Keys / Main / Reduced Functionality

36000 Keys / Illumination

Company Confidential s Com

Page 9of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

5 Connector Battery

Fault Symptoms

Customer: GRT:

Mobile does not switch on No connection to GRT

Connector BATTERY

Use hot air blower to remove defective component. Avoid excessive heat! Watch surrounding components!

Resolder new component afterwards.

E-commerce order number: L36334-Z97-C336

E-commerce order name: CONNECTOR BATTERY 3-POL R65

Soldering temperature: ~ 360°C TIP Temp.

IRIS Diagnose Code: 13000 Battery/Mechanical Damage

Company Confidential s Com

Page 10 of 13

Service Repair Documentation

TI_Repair_L2,5L_C75_R1.0

6 Connector Camera

Fault Symptoms

Customer: GRT:

Camera malfunction Tbd.

Connector CAMERA

Use hot air blower to remove defective component. Avoid excessive heat! Watch surrounding components!

Resolder new component afterwards.

E-commerce order number: L50634-Z97-C379

E-commerce order name: CONNECTOR CAMERA-SOCKET

Soldering temperature: ~ 360°C TIP Temp.

IRIS Diagnose Code: BA000 Accessories / Camera

Andere Handbücher für C75

Inhaltsverzeichnis

Andere Siemens Handy Handbücher

Siemens

Siemens 1168 Bedienungsanleitung

Siemens

Siemens CX70 Bedienungsanleitung

Siemens

Siemens SX56 Bedienungsanleitung

Siemens

Siemens SX1 Bedienungsanleitung

Siemens

Siemens Mobile Bedienungsanleitung

Siemens

Siemens A75 Bedienungsanleitung

Siemens

Siemens ME75 Bedienungsanleitung

Siemens

Siemens C75 Bedienungsanleitung

Siemens

Siemens Xelibri X6 Bedienungsanleitung

Siemens

Siemens A56i Bedienungsanleitung

Siemens

Siemens C62 Bedienungsanleitung

Siemens

Siemens ME75 Bedienungsanleitung

Siemens

Siemens A70 Einrichtungshandbuch

Siemens

Siemens Gigaset S45 Bedienungsanleitung

Siemens

Siemens A57 Bedienungsanleitung

Siemens

Siemens Gigaset SL55 Bedienerhandbuch

Siemens

Siemens AF51 Bedienungsanleitung

Siemens

Siemens A70 Bedienungsanleitung

Siemens

Siemens S75 Bedienungsanleitung

Siemens

Siemens RUGGEDCOM i802 Bedienungsanleitung

Siemens

Siemens RF182C Bedienungsanleitung

Siemens

Siemens S2588 Bedienungsanleitung

Siemens

Siemens S35i Bedienungsanleitung

Siemens

Siemens S35i Bedienungsanleitung

Beliebte Handy Handbücher anderer Marken

Zte

Zte BLADE A520 Bedienungsanleitung

Nokia

Nokia Lumia 620 Bedienungsanleitung

Blackbe;rry

Blackbe;rry KEYone Bedienungsanleitung

Bea-fon

Bea-fon X5 Premium Bedienungsanleitung

Blackbe;rry

Blackbe;rry 8707 Series Bedienungsanleitung

Blackbe;rry

Blackbe;rry Storm Betriebsanleitung

LG LM-X420QN Bedienungsanleitung

LifeWatch

LifeWatch V Bedienungsanleitung

Bea-fon

Bea-fon SILVER LINE SL860 Bedienungsanleitung

IKI Mobile

IKI Mobile KF4.5i Bedienungsanleitung

Hitech

Hitech HT-850 Bedienungsanleitung

Yezz

Yezz Fashion F10 Bedienungsanleitung

Point Mobile

Point Mobile PM60 Bedienungsanleitung

Blackbe;rry

Blackbe;rry Q10 Bedienungsanleitung

Blackbe;rry

Blackbe;rry Bold 9900 Bedienungsanleitung

Blackbe;rry

Blackbe;rry STORM 9500 - VERSION 5.0 Bedienungsanleitung

LG LM-K420EMW Bedienungsanleitung

ISAFE MOBILE

ISAFE MOBILE IS655.2 Bedienungsanleitung