Sierra Wireless AirPrime SL808 Series Bedienungsanleitung

WA_DEV_LG_UGD_001

002

March 30, 2011

AirPrime SL Series

Migration Guide

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 2

Migration Guide

Important Notice

Due to the nature of wireless communications, transmission and reception of data can never be

guaranteed. Data may be delayed, corrupted (i.e., have errors) or be totally lost. Although significant

delays or losses of data are rare when wireless devices such as the Sierra Wireless modem are used

in a normal manner with a well-constructed network, the Sierra Wireless modem should not be used

in situations where failure to transmit or receive data could result in damage of any kind to the user or

any other party, including but not limited to personal injury, death, or loss of property. Sierra Wireless

accepts no responsibility for damages of any kind resulting from delays or errors in data transmitted or

received using the Sierra Wireless modem, or for failure of the Sierra Wireless modem to transmit or

receive such data.

Safety and Hazards

Do not operate the Sierra Wireless modem in areas where blasting is in progress, where explosive

atmospheres may be present, near medical equipment, near life support equipment, or any equipment

which may be susceptible to any form of radio interference. In such areas, the Sierra Wireless modem

MUST BE POWERED OFF. The Sierra Wireless modem can transmit signals that could interfere with

this equipment. Do not operate the Sierra Wireless modem in any aircraft, whether the aircraft is on

the ground or in flight. In aircraft, the Sierra Wireless modem MUST BE POWERED OFF. When

operating, the Sierra Wireless modem can transmit signals that could interfere with various onboard

systems.

Note: Some airlines may permit the use of cellular phones while the aircraft is on the ground and the door

is open. Sierra Wireless modems may be used at this time.

The driver or operator of any vehicle should not operate the Sierra Wireless modem while in control of

a vehicle. Doing so will detract from the

some states and provinces, operating such communications devices while in control of a vehicle is an

offence.

Limitations of Liability

warranties of any kind, either expressed or

implied, including any implied warranties of merchantability, fitness for a particular purpose, or

noninfringement. The recipient of the manual shall endorse all risks arising from its use.

The information in this manual is subject to change without notice and does not represent a

commitment on the part of Sierra Wireless. SIERRA WIRELESS AND ITS AFFILIATES

SPECIFICALLY DISCLAIM LIABILITY FOR ANY AND ALL DIRECT, INDIRECT, SPECIAL,

GENERAL, INCIDENTAL, CONSEQUENTIAL, PUNITIVE OR EXEMPLARY DAMAGES INCLUDING,

BUT NOT LIMITED TO, LOSS OF PROFITS OR REVENUE OR ANTICIPATED PROFITS OR

REVENUE ARISING OUT OF THE USE OR INABILITY TO USE ANY SIERRA WIRELESS

PRODUCT, EVEN IF SIERRA WIRELESS AND/OR ITS AFFILIATES HAS BEEN ADVISED OF THE

POSSIBILITY OF SUCH DAMAGES OR THEY ARE FORESEEABLE OR FOR CLAIMS BY ANY

THIRD PARTY.

Notwithstanding the foregoing, in no event shall Sierra Wireless and/or its affiliates aggregate liability

arising under or in connection with the Sierra Wireless product, regardless of the number of events,

occurrences, or claims giving rise to liability, be in excess of the price paid by the purchaser for the

Sierra Wireless product.

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 3

Migration Guide

Patents

This product may contain technology developed by or for Sierra Wireless Inc.

This product includes technology licensed from QUALCOMM®3G.

This product is manufactured or sold by Sierra Wireless Inc. or its affiliates under one or more patents

licensed from InterDigital Group.

Trademarks

AirCard®and Watcher®are registered trademarks of Sierra Wireless. Sierra Wireless™, AirPrime™,

AirLink™, AirVantage™and the Sierra Wireless logo are trademarks of Sierra Wireless.

, , ®, inSIM®, WAVECOM®, WISMO®, Wireless Microprocessor®,

Wireless CPU®, Open AT®are filed or registered trademarks of Sierra Wireless S.A. in France and/or

in other countries.

Windows®and Windows Vista®are registered trademarks of Microsoft Corporation.

Macintosh and Mac OS are registered trademarks of Apple Inc., registered in the U.S. and other

countries.

QUALCOMM®is a registered trademark of QUALCOMM Incorporated. Used under license.

Other trademarks are the property of the respective owners.

Contact Information

Sales Desk:

Phone:

1-604-232-1488

Hours:

8:00 AM to 5:00 PM Pacific Time

E-mail:

sales@sierrawireless.com

Post:

Sierra Wireless

13811 Wireless Way

Richmond, BC

Canada V6V 3A4

Fax:

1-604-231-1109

Web:

www.sierrawireless.com

Consult our website for up-to-date product descriptions, documentation, application notes, firmware

upgrades, troubleshooting tips, and press releases: www.sierrawireless.com

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 4

Migration Guide

Document History

Version

Date

Updates

001

November 29, 2010

Creation

002

March 30, 2011

Added compatibility information for SL501x.

Updated the UART1 signals for SL80xx in Table 13 and Table 29; added

Table 14 to describe support for full UART in SL80xx.

Added Table 19 GPIOs available on the SL Series Embedded Modules.

Updated available GPIOs on the SL809xfrom 3 to 4 (pin 4 of the SL809x is

now GPIO_0).

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 5

Contents

1. INTRODUCTION ..................................................................................................8

2. REFERENCE DOCUMENTS................................................................................9

2.1. List of References.........................................................................................................9

2.2. Glossary.......................................................................................................................9

3. GENERAL DESCRIPTION.................................................................................10

3.1. General Information....................................................................................................10

3.2. Product Name.............................................................................................................12

4. HARDWARE COMPATIBILITY..........................................................................13

4.1. Electrical Compatibility................................................................................................13

4.1.1. Block Level Functional Compatibility....................................................................13

4.1.1.1. RF Band.................................................................................................................. 14

4.1.1.2. Temperature Range ................................................................................................ 14

4.1.1.3. Power Supply.......................................................................................................... 15

4.1.2. Application Design Limitation...............................................................................16

4.1.2.1. Antenna Interface.................................................................................................... 16

4.1.2.2. Audio Interface........................................................................................................ 18

4.1.2.3. JTAG and UART1 Interface..................................................................................... 20

4.1.2.4. UART2 Interface...................................................................................................... 23

4.1.2.5. USB Interface.......................................................................................................... 25

4.1.2.6. SIM Detection.......................................................................................................... 26

4.1.2.7. Voltage Regulator Output......................................................................................... 27

4.1.2.8. GPIO(s)................................................................................................................... 29

4.1.2.9. Digital Control Signal............................................................................................... 31

4.1.2.10. Features Only Supported by SL6087...................................................................... 33

4.1.2.11. Features Only Supported by SL6087/SL80xx ......................................................... 34

4.1.2.12. Features Only Supported by SL501x...................................................................... 34

4.2. Soldering Pad Design.................................................................................................35

4.3. Stencil Design.............................................................................................................36

4.4. Mechanical Differences...............................................................................................36

5. SL SERIES EMBEDDED MODULE PIN OUT....................................................37

6. INTERFACE SELECTION..................................................................................42

6.1. Standalone Operation Terminal ..................................................................................42

6.2. Remote Accessible Terminal.......................................................................................43

6.2.1. Access through UART .........................................................................................43

6.2.2. Access through USB............................................................................................44

6.3. External Peripheral Attached.......................................................................................44

6.3.1. Buzzer/LED.........................................................................................................44

6.3.2. Audio Device.......................................................................................................45

6.3.2.1. Digital Audio Device ................................................................................................ 45

6.3.2.2. Analog Audio Device ............................................................................................... 46

6.4. Debugging Purpose....................................................................................................47

6.4.1. JTAG (SL808x, SL809x and SL501x) / UART 1 (SL6087)....................................47

6.4.2. BOOT..................................................................................................................48

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 6

List of Figures

Figure 1. Block Level Functional Compatibility........................................................................... 13

Figure 2. Recommended Schematic Design of Antenna Port Selection for SL6087, SL80xx and

SL501x ...................................................................................................................................16

Figure 3. Recommended Schematic Design for the SL6087 JTAG Pins.....................................22

Figure 4. Recommended Schematic Design for Using SL808x/SL809x 1V8 or SL501x 2V6

Regulator Output.............................................................................................................................27

Figure 5. SL Series Embedded Module Power On/Off Control by an External Application

Processor ................................................................................................................................... 31

Figure 6. Recommended Schematic Design for Fixed Hardware Configuration of the On/Off

Control ................................................................................................................................... 32

Figure 7. Recommended External Open Drain Driving Circuit for Flash LED..............................32

Figure 8. Recommended Soldering PAD Design........................................................................35

Figure 9. Stencil Design for the SL6087.....................................................................................36

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 7

List of Tables

Table 1. Comparison Table Between the SL6087, SL808x, SL809x and SL501x ......................10

Table 2. SL Embedded Module with Product Name..................................................................12

Table 3. RF Band Supported by the SL Series Embedded Modules.......................................... 14

Table 4. Operating Temperature Range of the SL Series Embedded Modules..........................14

Table 5. Operating Voltages of the SL Series Embedded Modules ........................................... 15

Table 6. Antenna Interface of the SL Series Embedded Modules..............................................17

Table 7. Analog Audio Interface Pin Out of SL6087and SL808x................................................18

Table 8. Speaker Output Difference Between the SL6087 and SL808x.....................................19

Table 9. Digital Audio Interface Pin Out of the SL Series Embedded Modules...........................19

Table 10. Digital Audio Interface Features of the SL Series Embedded Modules......................... 20

Table 11. JTAG Pin Out of SL808x, SL809x and SL501x and UART1 Pin Out of SL6087...........20

Table 12. JTAG Pin Out of SL6087 ............................................................................................21

Table 13. Common UART Interface on the SL Series Embedded Modules................................. 23

Table 14. Configurations for Supporting a Full UART on the SL80xx/SL501x.............................. 23

Table 15. UART Baud Rate Limit of the SL Series Embedded Modules...................................... 24

Table 16. Common USB Interface on the SL Series Embedded Modules....................................25

Table 17. SIM Detection Pin of the SL6087 or VREG pin of the SL808x/SL809x and SL501x .....26

Table 18. Regulator Output of the SL Series Embedded Module ................................................28

Table 19. GPIOs available on the SL Series Embedded Modules...............................................29

Table 20. Common GPIO(s) of the SL Series Embedded Modules .............................................30

Table 21. On / Off Logic, pin 43, of the SL Series Embedded Modules .......................................31

Table 22. BOOT Pin of the SL6087 ............................................................................................33

Table 23. Features Only Supported by SL6087 ..........................................................................33

Table 24. Features Only Supported by SL6087/SL80xx..............................................................34

Table 25. Features Only Supported by SL501x...........................................................................34

Table 26. Thickness of the SL Series Embedded Modules..........................................................36

Table 27. Pin Out List of the SL Series Embedded Modules.......................................................37

Table 28. Necessary Pins forWorking as a Standalone Operation Terminal...............................42

Table 29. UART Interface of the SL Series Embedded Modules................................................. 43

Table 30. USB Interface of the SL Series Embedded Modules.................................................... 44

Table 31. Buzzer/LED Interface of the SL Series Embedded Modules........................................44

Table 32. Digital Audio Interface Pin Out of SL Series Embedded Modules.................................45

Table 33. Analog Audio Interface Pin Out of the SL Series Embedded Modules.......................... 46

Table 34. JTAG Pin Out of the SL808x, SL809x and SL501x; or UART 1 on the SL6087............47

Table 35. JTAG Pin Out of the SL6087.......................................................................................48

Table 36. BOOT Pin of the SL6087 ............................................................................................48

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 8

1. Introduction

This document aims to provide a guideline for designing applications based on the AirPrime SL

series. Recommendations are provided to maximize the compatibility between the modules when

using different variants of the SL series for the same application from GSM version (SL6xxx) to HSPA

version (SL8xxx), or to CDMA/EVDO version (SL5xxx).

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 9

2. Reference Documents

2.1. List of References

[1] AirPrime SL6087 Product Technical Specification and Customer Design Guidelines

Reference: WA_DEV_SL6087_PTS_001

[2] AirPrime SL808x Product Technical Specification and Customer Design Guidelines

Reference: 2400058

[3] AirPrime SL809x Product Technical Specification and Customer Design Guidelines

Reference: WA_DEV_SL8090_PTS_001

[4] AirPrime SL501x Product Technical Specification and Customer Design Guidelines

Reference: 4110802

[5] AirPrime SL Series Customer Process Guidelines

Reference: WM_DEV_LG_PTS_001

[6] AirCard/AirPrime UMTS Devices Supported AT Command

Reference: 2130617

2.2. Glossary

Term

Definition

GND

Ground

Not Connected

When a pin is marked as not connected, it means that no connection should be

made from the pin to the application board.

Reserved

When a pin is marked as Reserved, it means that no connection should be made

from the module pin to the application board; and that there might be a

connection to the pin from within the module.

WA_DEV_LG_UGD_001 Rev 002 March 30, 2011 10

3. General Description

3.1. General Information

The table below defines the SL6087, SL808x, SL809x and the SL501x embedded modules.

Table 1. Comparison Table Between the SL6087, SL808x, SL809x and SL501x

SL6087

SL808x

SL809x

SL501x

Quad band GSM EDGE

CGPS compatible

Quad band GSM EDGE

Dual band UMTS HSPA

GPS-one support (1)

Quad band GSM EDGE

Tri band UMTS HSDPA and HSUPA

GPS-one support(1)

Dual band IS-95A/B and CDMA 2X

Release0/A

Dual band IS-856 1xEV-DO Revision A

gpsOne™(1) and stand-alone GPS

GSM / GPRS Class 10, EDGE

HSDPA 3.6Mbps

UL 384kbps

HSDPA 14.4Mbps

HSUPA 5.76Mbps

1xEV-DO Rev. A

FL/RL 3.1 Mbps / 1.8 Mbps

-30°C / +70°C Class A

-40°C / +85°C Class B

SL8080/ SL8082/ SL8084 (industrial

grade):

-30°C / +70°C Class A

-40°C / +85°C Class B

-40°C / +85°C Storage

SL8081/ SL8083/ SL8085

(commercial grade):

-20°C / +60°C Class A

-30°C / +75°C Class B

-40°C / +85°C Storage

SL8090/ SL8092 (industrial grade):

-30°C / +70°C Class A

-40°C / +85°C Class B

-40°C / +85°C Storage

SL8091/ SL8093 (commercial grade):

-20°C / +60°C Class A

-30°C / +75°C Class B

-40°C / +85°C Storage

-30°C / +70°C Class A

-40°C / +85°C Class B

Andere Handbücher für AirPrime SL808 Series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sierra Wireless Steuereinheit Handbücher

Sierra Wireless

Sierra Wireless AirPrime AR7582-1 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime EM7511 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime WP75 Series Installationshandbuch

Sierra Wireless

Sierra Wireless AirPrime AR7594 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime HL8518 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirPrime AR7584 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless mangOH Green DV4 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirPrime XS1110 Betriebsanleitung

Sierra Wireless

Sierra Wireless AirPrime EM7565 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime EM7690 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime HL77 Series Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirPrime WS Series Installationshandbuch

Sierra Wireless

Sierra Wireless AirPrime HL7519 Bedienungsanleitung

Sierra Wireless

Sierra Wireless MC5720 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime SL8080 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime WP7504 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless MC Series Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime WP8548 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime EM7355 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime SL6087 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirPrime XA1110 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirPrime series Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirPrime MC7330 Bedienungsanleitung

Beliebte Steuereinheit Handbücher anderer Marken

Festo

Festo Compact Performance CP-FB6-E Stücklistenhandbuch

Elo TouchSystems

Elo TouchSystems DMS-SA19P-EXTME Bedienungsanleitung

JS Automation

JS Automation MPC3034A Bedienungsanleitung

JAUDT

JAUDT SW GII 6406 Series Kurzanleitung

Spektrum

Spektrum Air Module System Bedienungsanleitung

BOC Edwards

BOC Edwards Q Series Bedienungsanleitung

KHADAS

KHADAS BT Magic Bedienungsanleitung

Etherma

Etherma eNEXHO-IL Bedienungsanleitung

PMFoundations

PMFoundations Attenuverter Bedienungsanleitung

GEA

GEA VARIVENT Bedienungsanleitung

Walther Systemtechnik

Walther Systemtechnik VMS-05 Bedienungsanleitung

Altronix

Altronix LINQ8PD Montageanleitung

Eaton

Eaton Powerware Series Bedienungsanleitung

WAGO

WAGO 750-407/040-000 Bedienungsanleitung

Sony

Sony CCU-590 Bedienungsanleitung

Graco

Graco 25D614 Bedienungsanleitung

Task Force Tips

Task Force Tips YE-RF-900 Programmierhandbuch

Shini

Shini SPV-U Series Bedienungsanleitung