Sierra Wireless AirPrime EM7355 Kurzanleitung zur Einrichtung

AirPrime EM7355

Hardware Integration Guide

4112880

Rev 1

Distribution under NDA only

Contents subject to change

Preface

Rev 1 Dec.12 Proprietary and Confidential - Contents subject to change 3

Important

Notice Due to the nature of wireless communications, transmission and reception of data

can never be guaranteed. Data may be delayed, corrupted (i.e., have errors) or be

totally lost. Although significant delays or losses of data are rare when wireless

devices such as the Sierra Wireless modem are used in a normal manner with a

well-constructed network, the Sierra Wireless modem should not be used in

situations where failure to transmit or receive data could result in damage of any

kind to the user or any other party, including but not limited to personal injury,

death, or loss of property. Sierra Wireless accepts no responsibility for damages

of any kind resulting from delays or errors in data transmitted or received using

the Sierra Wireless modem, or for failure of the Sierra Wireless modem to

transmit or receive such data.

Safety and

Hazards Do not operate the Sierra Wireless modem in areas where blasting is in progress,

where explosive atmospheres may be present, near medical equipment, near life

support equipment, or any equipment which may be susceptible to any form of

radio interference. In such areas, the Sierra Wireless modem MUST BE

POWERED OFF. The Sierra Wireless modem can transmit signals that could

interfere with this equipment.

Do not operate the Sierra Wireless modem in any aircraft, whether the aircraft is

on the ground or in flight. In aircraft, the Sierra Wireless modem MUST BE

POWERED OFF. When operating, the Sierra Wireless modem can transmit

signals that could interfere with various onboard systems.

Note: Some airlines may permit the use of cellular phones while the aircraft is on the

ground and the door is open. Sierra Wireless modems may be used at this time.

The driver or operator of any vehicle should not operate the Sierra Wireless

modem while in control of a vehicle. Doing so will detract from the driver or

operator's control and operation of that vehicle. In some states and provinces,

operating such communications devices while in control of a vehicle is an offence.

Limitation of

Liability The information in this manual is subject to change without notice and does not

represent a commitment on the part of Sierra Wireless. SIERRA WIRELESS AND

ITS AFFILIATES SPECIFICALLY DISCLAIM LIABILITY FOR ANY AND ALL

DIRECT, INDIRECT, SPECIAL, GENERAL, INCIDENTAL, CONSEQUENTIAL,

PUNITIVE OR EXEMPLARY DAMAGES INCLUDING, BUT NOT LIMITED TO,

LOSS OF PROFITS OR REVENUE OR ANTICIPATED PROFITS OR REVENUE

ARISING OUT OF THE USE OR INABILITY TO USE ANY SIERRA WIRELESS

PRODUCT, EVEN IF SIERRA WIRELESS AND/OR ITS AFFILIATES HAS BEEN

ADVISED OF THE POSSIBILITY OF SUCH DAMAGES OR THEY ARE

FORESEEABLE OR FOR CLAIMS BY ANY THIRD PARTY.

Notwithstanding the foregoing, in no event shall Sierra Wireless and/or its

affiliates aggregate liability arising under or in connection with the Sierra Wireless

product, regardless of the number of events, occurrences, or claims giving rise to

liability, be in excess of the price paid by the purchaser for the Sierra Wireless

product.

Hardware Integration Guide

4 Proprietary and Confidential - Contents subject to change 4112880

Patents This product may contain technology developed by or for Sierra Wireless Inc.

This product includes technology licensed from QUALCOMM®.

This product is manufactured or sold by Sierra Wireless Inc. or its affiliates under

one or more patents licensed from InterDigital Group.

Trademarks AirCard®is a registered trademark of Sierra Wireless. Sierra Wireless™,

AirPrime™, Watcher™, and the Sierra Wireless logo are trademarks of Sierra

Wireless.

Windows®is a registered trademark of Microsoft Corporation.

QUALCOMM®is a registered trademark of QUALCOMM Incorporated. Used

under license.

Other trademarks are the property of their respective owners.

Contact

Information

Consult our website for up-to-date product descriptions, documentation,

application notes, firmware upgrades, troubleshooting tips, and press releases:

www.sierrawireless.com

Revision

History

Sales Desk: Phone: 1-604-232-1488

Hours: 8:00 AM to 5:00 PM Pacific Time

E-mail: [email protected]

Post: Sierra Wireless

13811 Wireless Way

Richmond, BC

Canada V6V 3A4

Technical support: support@sierrawireless.com

RMA support: [email protected]

Fax: 1-604-231-1109

Web: www.sierrawireless.com

Revision

number Release date Changes

1December 2012 FCC/IC certification

Rev 1 Dec.12 Proprietary and Confidential - Contents subject to change 5

Contents

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7

Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Required connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

Power supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Module power states . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

RF Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

RF connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Shielding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Antenna and cabling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

Ground connection. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Interference and sensitivity. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Interference from other wireless devices . . . . . . . . . . . . . . . . . . . . . . . . .14

Host-generated RF interference . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

Device-generated RF interference . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15

Methods to mitigate decreased Rx performance . . . . . . . . . . . . . . . . . . .15

Radiated Spurious Emissions (RSE) . . . . . . . . . . . . . . . . . . . . . . . . . . . .15

Radiated sensitivity measurement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Regulatory Compliance and Industry Certifications . . . . . . . . . . . . . . . . . . .17

Important notice . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Safety and hazards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Important compliance information for North American users. . . . . . . . . . . . 18

Acronyms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21

Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Hardware Integration Guide

6 Proprietary and Confidential - Contents subject to change 4112880

Rev 1 Dec.12 Proprietary and Confidential - Contents subject to change 7

1: Introduction

The Sierra Wireless EM7355 Embedded Module is an M.2 modem

that provides LTE, DC-HSPA+, HSPA+, HSDPA, HSUPA, WCDMA,

GSM, GPRS, EDGE, CDMA, and GNSS connectivity for notebook,

ultrabook, and tablet computers over several radio frequency bands.

The device also supports 2G/3G roaming.

Accessories

A hardware development kit is available for AirPrime M.2 modules.

The kit contains hardware components for evaluating and developing

with the module, including:

•Development board

•Cables

•Antennas

•Other accessories

For over-the-air LTE testing, ensure that suitable antennas are used.

Required connectors

Table 1-1 describes the connectors used to integrate the EM7355

Embedded Module into your host device.

Table 1-1: Required host-module connectors

Connector type Description

RF cables •Mate with M.2-spec connectors

•Three connector jacks

EDGE (67 pin) •Slot B compatible—Per the M.2 standard (PCI Express NGFF

(M.2) Electromechanical Specification Revision 0.7), a generic

75 pin position EDGE connector on the motherboard uses a

mechanical key to mate with the 67 pin notched module

connector.

•Manufacturers include LOTES (part #APCI0018-P001A01),

Kyocera, JAE, Tyco, and Longwell.

SIM •Industry-standard connector.

Hardware Integration Guide

8 Proprietary and Confidential - Contents subject to change 4112880

Rev 1 Dec.12 Proprietary and Confidential - Contents subject to change 9

2: Power

Power supply

The host provides power to the EM7355 through multiple power and

ground pins. The host must provide safe and continuous power (via

battery or a regulated power supply) at all times; the module does not

have an independent power supply, or protection circuits to guard

against electrical issues.

For detailed pinout and voltage/current requirements of this module,

see the AirPrime EM7355 Product Technical Specification &

Customer Design Guidelines.

Module power states

The module has five power states, as described in Ta b l e 2-1.

Table 2-1: Module power states

State Details

Host is powered

Module is powered

USB interface active

RF enabled

Normal

(Default

state)

•Module is active

•Default state. Occurs when VCC is first applied, Full_Card_Power_Off# is

deasserted (pulled high), and W_DISABLE#1 is deasserted

•Module is capable of placing/receiving calls, or establishing data connections on the

wireless network

•Current consumption is affected by several factors, including:

•Radio band being used

•Transmit power

•Receive gain settings

•Data rate

   

Low power

(‘Airplane

mode’)

•Module is active

•Module enters this state:

•Under host interface control:

·Host issues AT+CFUN=0 ([1] AT Command Set for User Equipment (UE)

(Release 6) (Doc# 3GPP TS 27.007))), or

·Host asserts W_DISABLE#1, after AT!PCOFFEN=0 has been issued.

•Automatically, when critical temperature or voltage trigger limits have been

reached))

   

Hardware Integration Guide

10 Proprietary and Confidential - Contents subject to change 4112880

Sleep •Normal state of module between calls or data connections

•Module cycles between wake (polling the network) and sleep, at network provider-

determined interval.

   

Off •Host keeps module powered off by asserting Full_Card_Power_Off# (signal pulled

low or left floating)

•Module draws minimal current

•See Full_Card_Power_Off# and RESET# on page 41 for more information.

  

Disconnected •Host power source is disconnected from the module and all voltages associated with

the module are at 0 V.    

Table 2-1: Module power states (Continued)

State Details

Host is powered

Module is powered

USB interface active

RF enabled

Andere Handbücher für AirPrime EM7355

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sierra Wireless Modem Handbücher

Sierra Wireless

Sierra Wireless AirLink MP895 Bedienungsanleitung

Sierra Wireless

Sierra Wireless GL6100 Bedienungsanleitung

Sierra Wireless

Sierra Wireless Sprint Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirLink GX400 Bedienungsanleitung

Sierra Wireless

Sierra Wireless iPASS Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 595 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 326U Bedienungsanleitung

Sierra Wireless

Sierra Wireless Raven XT Bedienungsanleitung

Sierra Wireless

Sierra Wireless Compass 597 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 250U Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 402 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AIRCARD 595U Bedienungsanleitung

Sierra Wireless

Sierra Wireless iPass Compass 885 Bedienungsanleitung

Sierra Wireless

Sierra Wireless Airlink Raven X Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 881 Wireless Modem Bedienungsanleitung

Sierra Wireless

Sierra Wireless RavenXTV Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 800 Series Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 402 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 597E Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirLink GL7 00 Series Bedienungsanleitung

Sierra Wireless

Sierra Wireless 306 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirLink MP595 Bedienungsanleitung

Sierra Wireless

Sierra Wireless Telstra Elite Leitfaden

Beliebte Modem Handbücher anderer Marken

Davicom

Davicom DM562AP Bedienungsanleitung

EpiValley

EpiValley TATA indicom SXC-1080 Bedienungsanleitung

Zte

Zte WiMAX Bedienungsanleitung

Intelimax

Intelimax MA-2060 Bedienungsanleitung

SMC Networks

SMC Networks D3CM1604V Gebrauchs- und Pflegehandbuch

Telstra

Telstra Wi-Fi 4G Advanced Pro X Bedienungsanleitung

Thrane&Thrane

Thrane&Thrane imarsat EXPLORER 300 Bedienungsanleitung

Samsung

Samsung AceLink SAM-335A Bedienungsanleitung

Enfora

Enfora Enabler-G Kurzanleitung zur Einrichtung

iRZ

iRZ ATM2-232 Bedienungsanleitung

Zhone

Zhone 6310 Bedienungsanleitung

Paradyne

Paradyne Hotwire 7976 Bedienungsanleitung

US Robotics

US Robotics 3453C Bedienungsanleitung

MaxTech

MaxTech Plug & Play Internal Voice/FAX/Data/SVD... Bedienungsanleitung

Zte

Zte MF823 Bedienungsanleitung

Four-Faith

Four-Faith F1403 Bedienungsanleitung

Gemtek

Gemtek WiMAX WIXFBR-103 Bedienungsanleitung

Zoom

Zoom 1070 Series Bedienungsanleitung