Snorkel SL26RTE Kurzanleitung

SL26RTE SL30RTE PARTS

MANUAL

GENERAL INFORMATION

INTRODUCTION SLE 1-1

REPAIR PARTS

GENERAL ASSEMBLY SL30RTE 2-1

GENERAL ASSEMBLY SL26RTE 2-2

HYDRAULIC HOSE ASSEMBLY 2-3

CHASSIS ASSY SL26/30SL 2-4

LOWER CONTROL PANEL ASSY ELEC - CE 2-5

STEER, AXLE FLOAT & TILT CYLINDER 2-6

CONTROL MODULE ASSEMBLY 2-7

CONTROL CABINET ASSEMBLY 2-8

FUEL TANK ASSEMBLY - DIESEL 2-9

HYDRAULIC VALVE BLOCK MOVEMENT SLE 2-10

HYDRAULIC VALVE BLOCK DRIVE 2-11

HYDRAULIC OIL TANK ASSEMBLY 2-12

ELEVATING ASSEMBLY SL26SL 2-13

ELEVATING ASSEMBLY SL30SL 2-14

HYDRAULIC CYLINDER ASSEMBLY - MAIN LIFT 2-15

PLATFORM ASSEMBLY - SL30SL 2-16

PLATFORM ASSEMBLY SL26SL 2-17

PLATFORM ASSEMBLY - SLIDE OUT SECTION 2-18

UPPER CONTROL PANEL ASSY ELEC - CE 2-19

UPPER CONTROL PANEL ASSEMBLY SL30- ADDITIONS 2-20

UPPER CONTROL PANEL ASSEMBLY SL26 - ADDITIONS 2-21

DECAL KIT SL26RTE - ENGLISH 2-22

DECAL KIT SL30RTE - ENGLISH 2-23

MAINTENANCE

SERVICE AND REPAIR 3-1

TROUBLESHOOTING 3-2

SCHEMATICS

SCHEMATICS SLE 4-1

OPTIONS

Removable Upper Control Box SL 5-1

TOW HITCH 5-2

A A

B B

PARTS & SERVICES

MANUAL

Part Number 516123-200E

OCT 2019

Serial Number SL26RTE and after

Serial Number SL30RTE and after

SL26/30ERT SERVICE AND PARTS MANUAL

FOREWORD

This manual is divided into six sections namely;

SECTION 1: INTRODUCTION

General description and machine specications.

SECTION 3: SERVICE AND REPAIR

Preventative maintenance and service information.

SECTION 4: TROUBLESHOOTING

Causes and solutions to typical problems.

SECTION 5: SCHEMATICS

Schematics and valve block diagrams with

description and location of components.

SECTION 6: ILLUSTRATED PARTS BREAKDOWN

Complete parts list with illustrations.

SPECIAL INFORMATION

NOTE: Provides helpful information.

D A N G E R

Indicates an imminently hazardous situation which if not avoided, will result in

death or serious injury.

W A R N I N G

Indicates a potentially hazardous situation which if not avoided, could

result in death or serious injury.

Indicates a potentially hazardous situation which if not avoided,

may result in minor or moderate injury.

C A U T I O N

SECTION 2: OPERATION AND SPECIFICATION

See seperate Operators Manual.

WORKSHOP PROCEDURES

All information contained in this manual is based on the latest product information available at the

time of printing. We reserve the right to make changes at any time without notice.

No part of this publication may be reproduced, stored in retrieval system or transmitted in any

form by any means whether electronic, mechanical, photocopying, recording or otherwise with-

out the prior written permission of the publisher. This also includes text, gures and tables.

Detailed prescriptions of standard workshop procedures, safety

principles and service operations are not included.

Please note that this manual contains warnings and cautions

against some specic service methods which could cause personal

injury or could damage a machine or make it unsafe.

Please understand that these warnings cannot cover all conceivable

ways in which service, whether or not recommended by Snorkel,

might be carried out, or of the possible hazardous consequences of

each conceivable way, nor could snorkel investigate all such ways.

Anyone using service procedures or tools whether or not recom-

mended by Snorkel must satisfy themselves thoroughly that neither

personal saftey nor machine safety will be jeopardized.

C A U T I O N

Page 1 - 1

INTRODUCTION

PURPOSE

The purpose of this service and parts manual is to provide instructions and illustrations for

the operation and maintenance of this work platform manufactured by Snorkel.

SCOPE

The manual includes procedures for proper operation, maintenance, adjustment and repair

of this product as well as recommended maintenance schedules and troubleshooting.

GENERAL DESCRIPTION

The work platform consists of the platform, controller, elevating assembly, power module,

control module and chassis.

W A R N I N G

DO NOT use the work platform without guardrails properly assembled and

in place.

PLATFORM

The platform has a reinforced steel oor, 1.1 m (43.5 inches) high guardrails with a mid rail,

152 mm (6 inches) toe boards and an entry gate at the rear of the platform. The guardrails

can be folded down for transportation purposes.

Features of the SL26/SL30ERT is shown in Figure 1-1.

1. Platform

2. Platform controller assembly

3. Elevating assembly

4. Power module

5. Control module

6. Chassis

Figure 1-1: Work platform

Page 1 - 2

PLATFORM CONTROLLER

The platform controller contains the controls to operate the machine. It is located at the front

of the platform. A complete explanations of control functions can be found in section 2.

ELEVATING ASSEMBLY

The platform is raised and lowered by the elevating assembly. The hydraulic pump driven

by the engine, powers the cylinders. Solenoid operated valves control raising and lowering.

CHASSIS

The chassis is a structural frame that supports all the components of the SL26/30SL work

platform.

PURPOSE OF EQUIPMENT

The objective of the work platform is to provide a quickly deployable, self propelled, variable

height work platform to elevate personnel and materials to overhead work areas.

SPECIAL LIMITATIONS

Travel with the platform raised is limited to a creep speed range.

Elevating of the work platform is limited to rm, even surfaces only. The auto level feature is

designed to level the platform in a situation where the ground has no more than a 13 degree

slope side to side and 9 degrees front to back. If the platform is not level to within 2 degrees,

a warning alarm will sound and platform elevation above approximately 1 m will be disabled.

D A N G E R

The elevating function shall ONLY be used when the work platform is level and on

a rm surface.

The work platform is NOT intended to be driven over uneven, rough or soft terrain

when elevated.

INTRODUCTION

REPAIRPARTS

SL26RTE SL30RTE PARTS MANUAL GENERAL ASSEMBLY SL30RTE

GENERAL ASSEMBLY SL30RTE Tue Feb 16 03:25:45 UTC 2021 2-1

アイテム部品番号名前数量 UOM

Not

Shown 514770-800E-NM GENERALASSEMBLYSL30RTE EA

1 505603-000 PLATFORMASSEMBLYSL26RTE 1 EA

2 505501-000 CHASSISASSYSL26/30RTE 1 EA

3 505602-000 ELEVATINGASSEMBLYSL26RTE 1 EA

4 516059-000 BatteryPowermodule 1 EA

5 505515-000 Controlmodule 1 EA

SL26RTE SL30RTE PARTS MANUAL GENERAL ASSEMBLY SL30RTE

GENERAL ASSEMBLY SL30RTE Tue Feb 16 03:25:45 UTC 2021 2-1

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Snorkel Hubarbeitsbühne Handbücher

Snorkel

Snorkel 460SJ Bedienungsanleitung

Snorkel

Snorkel S3215L Bedienungsanleitung

Snorkel

Snorkel A38E Bedienungsanleitung

Snorkel

Snorkel EPV Series Bedienungsanleitung

Snorkel

Snorkel MHP 15J Bedienungsanleitung

Snorkel

Snorkel MHP1335 Gebrauchs- und Pflegehandbuch

Snorkel

Snorkel S2255RT Bedienungsanleitung

Snorkel

Snorkel MHP 15/44HD Bedienungsanleitung

Snorkel

Snorkel TB66JRT Bedienungsanleitung

Snorkel

Snorkel ATB 50 Bedienungsanleitung

Snorkel

Snorkel MHP 15 J Gebrauchs- und Pflegehandbuch

Snorkel

Snorkel TM12 Series Bedienungsanleitung

Snorkel

Snorkel MHP14AT Handbuch

Snorkel

Snorkel TB125J Betriebsanleitung

Snorkel

Snorkel MHP1335 Bedienungsanleitung

Snorkel

Snorkel S3370BE Kurzanleitung

Snorkel

Snorkel TB42J Bedienungsanleitung

Snorkel

Snorkel S1930E Bedienungsanleitung

Snorkel

Snorkel AB46JE Bedienungsanleitung

Snorkel

Snorkel 16GTRD Bedienungsanleitung

Snorkel

Snorkel SL30SL Bedienungsanleitung

Snorkel

Snorkel AB60J Betriebsanleitung

Snorkel

Snorkel MHP1335 Betriebsanleitung

Snorkel

Snorkel A62JRT Bedienungsanleitung

Beliebte Hubarbeitsbühne Handbücher anderer Marken

Genie

Genie Z-80 Bedienungsanleitung

Genie

Genie Z-45/25 Bedienungsanleitung

JLG

JLG Skytrak 6036 Gebrauchs- und Pflegehandbuch

Terex

Terex Z80H-7733 Bedienungsanleitung

Terex

Terex Gyro 4020 Bedienungsanleitung

Terex

Terex Genie Z-51/30 J Bedienungsanleitung

LGMG

LGMG T65JE Bedienungsanleitung

Genie

Genie Z-135/70 Bedienungsanleitung

Oshkosh Corporation

Oshkosh Corporation JLG H800AJ Gebrauchs- und Pflegehandbuch

Oshkosh

Oshkosh JLG 1500SJ Installations- und Benutzerhandbuch

Skyjack

Skyjack SJ30AJE Bedienungsanleitung

Oshkosh

Oshkosh JLG 800A Installations- und Benutzerhandbuch

Terex

Terex Genie Z-135/70 Bedienungsanleitung

Skyjack

Skyjack SJ 46AJ Bedienungsanleitung

Molift

Molift Quick Raiser 205 Bedienungsanleitung

Terex

Terex Genie Z-135/70 Installations- und Betriebsanleitung

Terex

Terex Genie ZX-135/70 Installations- und Betriebsanleitung

Oshkosh Corporation

Oshkosh Corporation JLG E300A Bedienungsanleitung