Sony DPP-MS300 Marketing Bedienungsanleitung

SERVICE MANUAL

DIGITAL PHOTO PRINTER

US Model

Canadian Model

SPECIFICATIONS

DPP-MS300

9-928-127-11

– Continued on next page –

– 2 –

Flexible Circuit Board Repairing

• Keep the temperature of the soldering iron around 270 ˚C dur-

ing repairing.

• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).

• Be careful not to apply force on the conductor when soldering

or unsoldering.

Notes on chip component replacement

• Never reuse a disconnected chip component.

• Notice that the minus side of a tantalum capacitor may be dam-

aged by heat.

ATTENTION AU COMPOSANT AYANT RAPPORT

À LA SÉCURITÉ!

LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE !

SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE

DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ

DE FONCTIONNEMENT. NE REMPLACER CES COM-

POSANTS QUE PAR DES PIÈCES SONY DONT LES

NUMÉROS SONT DONNÉS DANS CE MANUEL OU

DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK !OR DOTTED

LINE WITH MARK !ON THE SCHEMATIC DIAGRAMS

AND IN THE PARTS LIST ARE CRITICAL TO SAFE

OPERATION. REPLACE THESE COMPONENTS WITH

SONY PARTS WHOSE PART NUMBERS APPEAR AS

SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-

LISHED BY SONY.

SAFETY CHECK-OUT

After correcting the original service problem, perform the follow-

ing safety check before releasing the set to the customer:

Check the antenna terminals, metal trim, “metallized” knobs,

screws, and all other exposed metal parts for AC leakage.

Check leakage as described below.

LEAKAGE TEST

TheAC leakage from any exposed metal part to earth ground and

from all exposed metal parts to any exposed metal part having a

return to chassis, must not exceed 0.5 mA (500 microampers.).

Leakage current can be measured by any one of three methods.

1. A commercial leakage tester, such as the Simpson 229 or RCA

WT-540A. Follow the manufacturers’instructions to use these

instruments.

2. A battery-operatedAC milliammeter. The Data Precision 245

digital multimeter is suitable for this job.

3. Measuring the voltage drop across a resistor by means of a

VOM or battery-operated AC voltmeter. The “limit” indica-

tion is 0.75 V, so analog meters must have an accurate low-

voltage scale. The Simpson 250 and Sanwa SH-63Trd are ex-

amples of a passive VOM that is suitable. Nearly all battery

operated digital multimeters that have a 2VAC range are suit-

able. (See Fig. A)

Fig. A. Using an AC voltmeter to check AC leakage.

1.5 k

Ω

0.15

FAC

voltmeter

(0.75 V)

To Exposed Metal

Parts on Set

Earth Ground

– 3 –

TABLE OF CONTENTS

1. GENERAL

Identifying the parts ..................................................... 1-1

Setting Up .................................................................... 1-1

Printing ......................................................................... 1-4

Making Various Prints ................................................. 1-6

About “Memory Stick” ................................................ 1-10

About PC cards ............................................................ 1-10

2. DISASSEMBLY ...................................................... 2-1

3. MECHANICAL ADJUSTMENTS.................... 3-1

4. ELECTRICAL ADJUSTMENTS...................... 4-1

Power Supply Block .................................................... 4-3

Video Block.................................................................. 4-4

5. DIAGRAMS

5-1. Block Diagram – VIDEO Section – ........................... 5-1

5-2. Block Diagram – MAIN Section –.............................. 5-3

5-3. Block Diagram – CENTRONICS Section – ............... 5-5

5-4. Block Diagram

– PC CARD/MEMORY STICK Section –.................. 5-7

5-5. Block Diagram – HERD/SENSOR/

MOTOR/POWER SUPPLY Section – ........................ 5-9

5-6. Frame Schematic Diagram .......................................... 5-11

5-7. Notes for Printed Wiring Board and

Schematic Diagram...................................................... 5-13

5-8. Printed Wiring Board – VS-40 Board – ..................... 5-15

5-9. Schematic Diagram – VS-40 Board – ......................... 5-16

5-10. Printed Wiring Board – VI-40 Board – ....................... 5-17

5-11. Schematic Diagram – VI-40 Board – .......................... 5-19

5-12. Printed Wiring Board – DK-40 Board – .................... 5-23

5-13. Schematic Diagram – DK-40 Board (1/3) – .............. 5-25

5-14. Schematic Diagram – DK-40 Board (2/3) – .............. 5-28

5-15. Schematic Diagram – DK-40 Board (3/3) – .............. 5-31

5-16. Printed Wiring Board – MP-40 Board – .................... 5-33

5-17. Schematic Diagram – MP-40 Board – ........................ 5-35

5-18. Printed Wiring Boards – FE-40/JK-40 Boards – ....... 5-39

5-19. Schematic Diagram – FE-40/JK-40 Boards –............. 5-41

5-20. Printed Wiring Board – SW-40 Board – .................... 5-43

5-21. Schematic Diagram – SW-40 Board – ....................... 5-45

5-22. Printed Wiring Boards

– HP-40/JD-40/MD-40/RD-40 Boards – .................... 5-47

5-23. Schematic Diagram

– HP-40/JD-40/MD-40/RD-40 Boards – .................... 5-49

5-24. IC Pin Function Description ........................................ 5-59

6. EXPLODED VIEWS............................................. 6-1

7. ELECTRICAL PARTS LIST ............................ 7-1

1-1

SECTION 1

GENERAL This section is extracted from in-

struction manual(3-866-753-11).

1-2

1-3

1-4

1-5

1-6

1-7

Andere Handbücher für DPP-MS300 Marketing

Inhaltsverzeichnis

Andere Sony Drucker Handbücher

Sony

Sony UP-D70XR Bedienungsanleitung

Sony

Sony UP-DR80MD Bedienungsanleitung

Sony

Sony DPP-EX50 Bedienungsanleitung

Sony

Sony UP-D2600 Bedienungsanleitung

Sony

Sony DPP-FPHD1 Instruction Manual (Photo Printer) Bedienungsanleitung

Sony

Sony CVP-M1 Bedienungsanleitung

Sony

Sony DPP-EX50 Bedienungsanleitung

Sony

Sony UPD-X100 Bedienungsanleitung

Sony

Sony FilmStation UP-DF750 Bedienungsanleitung

Sony

Sony UP-890CE Bedienungsanleitung

Sony

Sony UP-D898MD Bedienungsanleitung

Sony

Sony UP-D6500 Bedienungsanleitung

Sony

Sony PIX1L Bedienungsanleitung

Sony

Sony UP-CX1 series Bedienungsanleitung

Sony

Sony SpectaProof UP-D9500 Bedienungsanleitung

Sony

Sony DPP-M55 Marketing Bedienungsanleitung

Sony

Sony DPP-FP50 Fall 2005 Bedienungsanleitung

Sony

Sony UP-D711MD Bedienungsanleitung

Sony

Sony UP-897MD Bedienungsanleitung

Sony

Sony DPP-FP97 Bedienungsanleitung

Sony

Sony DPP-FP65 Bedienungsanleitung

Sony

Sony UP-GR700 Bedienungsanleitung

Sony

Sony DPP-FP75 Bedienungsanleitung

Sony

Sony UPX-C300 Bedienungsanleitung

Beliebte Drucker Handbücher anderer Marken

Canon

Canon i70 Series Bedienungsanleitung

Evolis

Evolis Elypso Bedienungsanleitung

Kyocera

Kyocera FS-9530DN Bedienungsanleitung

Canon

Canon LASER SHOT LBP-1210 Bedienungsanleitung

Samsung

Samsung BIXOLON SRP-350plusF Bedienungsanleitung

Canon

Canon PIXMA PRO-1 Series Bedienungsanleitung

Canon

Canon PIXMA G3560 Einrichtungshandbuch

Dell

Dell Color Laser Printer 2130cn Bedienungsanleitung

Tektronix

Tektronix Phaser 840 Bedienungsanleitung

Brother

Brother 1440 - HL B/W Laser Printer Kurzanleitung

Fuji Xerox

Fuji Xerox DocuPrint P375 dw Bedienungsanleitung

WOOSIM

WOOSIM PORTI-S30 Bedienungsanleitung

Olivetti

Olivetti PG L2140 Bedienungsanleitung

Konica Minolta

Konica Minolta bizhub 224e Bedienungsanleitung

Canon

Canon LBP113w Bedienungsanleitung

Xerox

Xerox DocuColor 5000 Bedienungsanleitung

Canon

Canon PRO-500 Series Einrichtungshandbuch

Epson

Epson ET-7750 Betriebsanleitung