Spectra T200 Bedienungsanleitung

Service Procedure Quick Reference

TAP Replacement

T200 –T380 –T680

August 2017 V2

Page 1 of 4

Not a substitute for official published procedural guide

Detailed instructions/videos located at support.spectralogic.com

Tools & Supplies

Replacement TAP assembly kit

Flat blade screwdriver

#1 Phillips screwdriver - stubby

#2 Phillips screwdriver

USB flash drive (FAT32)

oFor collecting Auto-support Log File (ASL)

Estimated Time

45 minutes

ESD Protection

Required

Library Power

Off

Data I/O Operations

Discontinue

Verify with customer that data I/O to all drives has halted

Robotic Movement

Discontinue

Verify robotic movement has halted

Verify with customer that move requests from host have been halted

Admin./Superuser

BlueScale Login

Required

Considerations

It is recommended that all tapes are removed from drives by customer before

procedure to avoid potential stuck tapes after power-up

T680 libraries have two TAPs. Confirm with Spectra Support which TAP is to

be replaced: upper (TAP 1), lower (TAP 2), or both

Procedure Overview

(continued next page)

1. Power off library using front panel power button. At rear of library, turn off circuit

breaker switches and disconnect power cables

2. Firmly pull top edge of filter cover panel toward you to release top edge

(magnetically held in place), then lift panel upward and away from library

3. Loosen two captive screws at bottom of library front panel, lift front panel up and

remove

4. Disconnect sensor cable connector (left of TAP) from library chassis

5. Loosen captive screw located just above disconnected cable

Service Procedure Quick Reference

TAP Replacement

T200 –T380 –T680

August 2017 V2

Page 2 of 4

Not a substitute for official published procedural guide

Detailed instructions/videos located at support.spectralogic.com

Procedure Overview

(continued)

(continued next page)

6. Using a flat blade screwdriver release door latch to open TAP door

7. Guide sensor cable around gear assembly so that it is clear and free

8. Carefully pry coupler stud away from TAP rail slider and lever arm of TAP door to

disengage end of lever arm from TAP assembly

9. Loosen three remaining captive screws on TAP door mounting panel

10. Lift TAP door mounting panel away from chassis while guiding sensor cable

through cutout on panel

11. TeraPacks directly adjacent to TAP assembly can be dislodged during service.

Prior to replacing front panel, verify these TeraPacks are properly

seated/positioned by ensuring that:

Neither side of a TeraPack is resting on top of a guide rail

TeraPacks are flush with end of guide rails. There are detents molded into

guide rails and bottom of TeraPacks to assist in positioning

oTeraPacks positioned too far into library can result in robotic movement

errors and/or damage to robotics or media

12. Firmly pull locking clip toward you until it disengages from screw

13. Rotate top edge of TAP assembly downward, then lift assembly up to disengage it

from mounting tab on chassis and remove from library

14. Remove chamber shelf below TAP area. Save shelf guides from shelf to install on

replacement shelf sent in TAP assembly kit

15. Install replacement shelf and three rightmost shelf guides

16. Install modified shelf guide that came in TAP assembly kit in leftmost position,

with notched end toward inside of library

17. Install replacement TAP assembly orienting locking clip to right and door latch

toward front

Angle top edge downward and slide into chassis so bottom edge fits between

guide rail and chassis and onto mounting tab on chassis

Rotate top edge of assembly upward until entire TAP assembly is flush against

chassis

Service Procedure Quick Reference

TAP Replacement

T200 –T380 –T680

August 2017 V2

Page 3 of 4

Not a substitute for official published procedural guide

Detailed instructions/videos located at support.spectralogic.com

Procedure Overview

(continued)

(continued next page)

18. Firmly push locking clip toward back of library to secure TAP assembly

If unable to seat locking clip, verify entire TAP assembly is flush with chassis

19. Orient TAP door mounting panel with door to left. Slot in panel fits over

alignment pin in chassis

20. Guide sensor cable connector through cutout in left side of door mounting panel

21. Rotate left side of door mounting panel until it is flush against chassis

Verify door latch and release piston fit into cutouts on door frame, piston

moves freely

22. Tighten four captive screws to secure door mounting panel to chassis

23. Inside the TAP, insert coupler stud through lever arm and into PEM nut on TAP

assembly

24. Close TAP door and listen for an audible click to indicate latch has engaged

25. Route sensor cable under gear assembly and reconnect to chassis

26. Reinstall library front panel by inserting alignment pin at top of front panel into

chassis and pivot panel downward. Check that LCD display is centered in panel

cutout, then tighten two captive screws at bottom of front panel

27. Reinstall filter cover by positioning tabs on back of cover into slots in front panel.

Slide cover downward, push upper edge of filter cover towards library until

magnets secure it to front panel

28. Plug in library power cords and switch circuit breakers to on position. Power on

library

29. Login in as superuser or administrator and run the following diagnostic

Maintenance > Diagnostics > All Motion Basic Tests then click Run Utility

30. When testing has completed, the “Diagnostic Results”screen displays “Success” or

“Failed” for each test

If any test fails –double check your work

Re-run utility after corrective action has been taken

If test continues to fail - contact Spectra Technical Support

31. Create an Auto-support Log File (ASL) and forward to Spectra Technical Support

Obtain permission from customer prior to performing this step

Service Procedure Quick Reference

TAP Replacement

T200 –T380 –T680

August 2017 V2

Page 4 of 4

Not a substitute for official published procedural guide

Detailed instructions/videos located at support.spectralogic.com

Procedure Overview

(continued)

ASL’s do not contain sensitive customer information such as passwords,

encryption keys etc.

Reference knowledge base article KBA-02258 (Spectra Support Portal)

32. Return malfunctioning TAP assembly to Spectra Logic

Andere Handbücher für T200

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Spectra Lagerung Handbücher

Spectra

Spectra T Series Bedienungsanleitung

Spectra

Spectra T950 Bedienungsanleitung

Spectra

Spectra T50e Bedienungsanleitung

Spectra

Spectra T-Finity Bedienungsanleitung

Spectra

Spectra T120 Bedienungsanleitung

Spectra

Spectra T50e Bedienungsanleitung

Spectra

Spectra nTier Verde Array Bedienungsanleitung

Spectra

Spectra T950 Bedienungsanleitung

Spectra

Spectra T50e Handbuch

Spectra

Spectra T50e Bedienungsanleitung

Spectra

Spectra T-Finity Betriebsanleitung

Spectra

Spectra T200 Bedienungsanleitung

Spectra

Spectra POWERBOX 3000C SERIES Bedienungsanleitung

Spectra

Spectra T50e Bedienungsanleitung

Spectra

Spectra Stack Tape Library Bedienungsanleitung

Spectra

Spectra BlackPearl Bedienungsanleitung

Spectra

Spectra T-Finity Betriebsanleitung

Spectra

Spectra BlackPearl Series Bedienungsanleitung

Spectra

Spectra Logic BlackPearl NAS Solution Bedienungsanleitung

Spectra

Spectra T950 Bedienungsanleitung

Spectra

Spectra T50e Bedienungsanleitung

Spectra

Spectra Verde Bedienungsanleitung

Spectra

Spectra T50e Leitfaden

Spectra

Spectra Verde Bedienungsanleitung

Beliebte Lagerung Handbücher anderer Marken

QNAP

QNAP TS 32PXU Series Bedienungsanleitung

LaCie

LaCie RUGGED RAID Bedienungsanleitung

Freecom

Freecom CLS DOCK Bedienungsanleitung

PNY

PNY Attache P-FD64MBATT3 Bedienungsanleitung

HP StorageWorks MSL2024 Bedienungsanleitung

OLT

OLT 6x6 Maximizer Bedienungsanleitung

Transcend

Transcend JetFlash 160 Bedienungsanleitung

LaCie

LaCie RUGGED MINI Bedienungsanleitung

Thunderbolt

Thunderbolt 600 Bedienungsanleitung

Panasonic

Panasonic LB-DH8 series Handbuch

Intel

Intel RAID High Availability Bedienungsanleitung

LaCie

LaCie 12big Thunderbolt 3 Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T50e Bedienungsanleitung

Panasonic

Panasonic LKM-F931-1 Bedienungsanleitung

Tabernus

Tabernus Enterprise Erase E2400 Bedienungsanleitung

Rocstor

Rocstor COMMANDER 3F series Bedienungsanleitung

HP P9000 Bedienungsanleitung

Western Digital

Western Digital Ultrastar Data60 Bedienungsanleitung