SPIDER SC1500 Bedienungsanleitung

Property of SafeWorks LLC. This information is proprietary and may not be copied or reproduced without written consent of SafeWorks LLC.Swing Stage Checklist 705997-1 Rev C

Checklist for Operating Swing Stages on Wind Turbine Exteriors

√Read the Code of Safe Practices prior to using platform.

√ ReadthehoistOperational Manual prior to using platform.

√ PerformtheHoist Daily Inspections prior to using the platform.

√ ReadtheGenerator Requirements on the Checklist prior to using platform.

√ Verifytotalplatformweightandliveloaddoesnotexceedhoist’sratedload.

√ Whende-riggingthesecondarywirerope,toremovethesecondarywireropefromthehoist,pushthe 

 primaryinletguidetothesidetoreleasethesecondarysafetybrake.

√ Verifythatfallarrestsystemsdonotallowtheworkertofalla

distance greater than 6 feet.

√ Knowthemaximumwindspeedallowedforexteriorwork

 inthewindfarm.Carryananemometertomeasurewind 

 speed.Donotworkinunsafewindorweatherconditions.

√ Ensuretaglinesaresecuredtostructuraluprightsof

platform. (1)

√ Verifyfallarrestanchorboltsaretightenedto150ft-lbsof 

torque. (2)

√ Keepthedeckcleartoeliminatetriphazards.Usework 

 bucketstostorematerialsoutsidethedeck/platformarea.

√ Verifykellumgripsonpowersupplyareattachedproperlyto

stirrup.

WARNINGS

√ Topreventdamagetoequipment,de-rigplatformduring 

 severeweatherconditions.

√ Inspectwireropesforkinks,brokenwiresorbirdcagingprior

to rigging.

√ Donotoverloadtheplatform.Conrmthatweightofthe

totalequipmentincludingworkers,tools,wireropes,power

cordandaccessoriesdoesnotexceedhoistratedload.

√ Verifyallrollersonstirrupmastturnfreelyandthatthereare

nosignsofexcessivewear.(3)

√ Donotdrill,cut,removepartsfromormodifytheplatform.

 Ifyouneedsomethingdifferentontheplatform,call

 SPIDERat877-774-3370forassistance.

√ Ifhoistisnotoperatingproperly,readtheoperationmanualfortroubleshootinghelp.

Primary (red)

Secondary ( grey)

2 (2x)

1 (4x)

√ Fallarrestanchorhastwoconnectionpoints;one

 peroperator.Theseconnectionpointsaretobe

 usedwithashock-absorbinglanyard.(4)

√ Verifythelifelineisproperlyattachedtothe

 platformatthetoprailbumperplate.Thelifeline

isusedtostabilizetheplatformonthebladeor

 tower.Toreleaselifelinefromropegrab,pull

ropetowardsropegrabandthenreleasecam.

(5)

√ Verifythesupportisinplaceandboltsare 

secure. (6)

√ Verifythehoistnameplateinformationmeetsthe

 requirementsforvoltagesuppliedtothehoistand

 capacityratingsoftheplatform.(7)

√ Verifythestoragebucketisproperlyattachedto

 theplatformanddrainholesinthebucketare

 freefromdebris.Toremoveorrelocatethe

 storagebucket,pullthespring-loadedpinto

disengage it from the platform. (8)

√ Verifythehoistlanyardisattachedtothehoist

 carryinghandleandthestirrupasshownin

detailed picture to secure hoist in the upright

position. (9)

√ Verifytherollerbumpersaresecuredtothe

 platform.Verifytherollerbumpersturnfreely

and are in good condition. (10)

√ Verifythehitchpinsareinstalledandaresecured

 withahairpin.(11)

4 (2x)

10 (6x)

11 (2x)

Property of SafeWorks LLC. This information is proprietary and may not be copied or reproduced without written consent of SafeWorks LLC.Swing Stage Checklist 705997-1 Rev C

SpiderrecommendsthefollowinggeneratorsforusewithitsSC1000andSC1500electrictractionhoistsrunningon

110VACand208VACsingle-phase60Hz,and208VAC3-phase60Hz.

HoistModel PartNumber HoistCapacityinlbs VoltageAC AmperagePhase MinimumKWperhoist*

SC1500 9015,9016  1500  208 9.9 1  6

SC1500 9035,9036  1500  208 6.9 3  6

*Whenusing3hoistsormoreonaplatform,consultSpiderproductsupportat+1(206)394-5319forpropergensetratings.

Theserecommendedgensetratingsaretheminimumrecommendedbasedonintermittentplatformmovement(lessthan10

minutesofcontinuousupwardtravel)andstandardambientconditions.

Usingalargercapacitygeneratorisalwaysacceptable,andisadvisedifanyofthefollowingarepresent:

 • Ambienttemperatureover100°F

 • Relativehumidityover50%

 • Siteelevationabovethan5000feet

 • Cordlengthover250feet,wheretransformerisnotused.

 • Runningthehoistscontinuouslyformorethantenminutes

IMPORTANT:Verifythevoltageoperatingrangeofthehoistbeforepluggingitintothegenerator.Voltagethatistoohighortoo

lowwilldamageahoist,causingworkdelaysandexpensiverepairs.Consultthehoistoperator’smanualbeforeyoustart.Use

abuckorboosttransformertoadjustoutputvoltageofthegeneratortomeetthehoist’sspeciedvoltage.Verifythatthetrans-

formeriswiredforthedesiredbuckorboostfunction.

Key Term What you need to know:

Portable Engine- Anengine-drivengeneratoror‘genset’.Engineconvertsfuelintomechanicalpower;

Generator set generatorconvertsmechanicalpowerintoelectricalpower.

Fuel   Eitherdieseloil,gasoline,naturalgasorpropanevapor.

Governor  Adjuststheenginethrottlepositiontomaintainenginespeedandoutputfrequencyasloadschange.

Voltage Regulator Controlstheoutputvoltageastheloadchanges.Usuallynotadjustableonportableunits.

Frequency (Hz) ThenumberoftimespersecondtheACvoltageandcurrentgofrommaximumtominimum

   andbacktomaximum.

   Directlycontrolledbytheenginespeed

   DeterminesthespeedofanACmotordrivenbythegenset

Ambient conditions Theairtemperature,humidityandelevationabovesealevelusedtorategensets

Generator ratings Theamountofpoweragensetcanproduceoveralengthoftimewithoutdamage

   Intermittentrating:Thehighestoutputavailableforashortperiodoftime

   Standbyrating:Forusewhenutilitiesgoout,runningnomorethan60hoursayear

   Continuousrating:Powerlevelproducedcontinuously,mustbeasteadyload

   Primerating:Forusewhengensetisprimarysourceofpower,running24hoursadayunder

   varyingloads.

!! Increased air temperature, humidity and elevation reduces the engine power output,

and the generator output power ratings

Contact Spider at 877-774-3370

Generator Size Recommendations

& Operations Overview

Inverters  AnelectronicdevicethatconvertsDCelectricalpowerintoACelectricalpower.

   InvertergeneratorsuseaDCgeneratorconnectedtoaninvertercreatingACpower.

   Typicallyquieter,weighless,uselessfuel.

   Limitedpoweroutputandeasilydamagedbysuddenloadsurges.

3-Phase Power Electricalpowerprovidedbythegridin3phases,orseparatelines.Usedforequipmentwithhigh

startup loads

Single-Phase PowerUsedformosttoolsanddevices.Oneofthethreecircuitscomingfromthegrid.

Startup/Run Factor Powerrequiredwhenanelectricalmotorisstartedwithaloadalreadyappliedtoit

   (suchasahoistsupportingaplatform).

   Powerrequiredforascaffoldhoistmotorcanbe3timestherunpower.

Power Cord  Connectsthegensetandmotor,includesplug(male)andsocket(female)connectoratends.

   Orientationofconnectorpinsandsockets(xtox,ytoy,etc)oneachwiremustbecorrectorthevoltage

   and/orphasewillbeincorrect

TROUBLESHOOTING POOR HOIST PERFORMANCE AND DAMAGE DUE TO:

Low Engine Speed/ Outputfrequencymeasuredwithamulti-meteratthepoweroutletorendofthepowercordmust

Output Frequency measurebetween58and62Hz.Ifyougetadifferentreading,consulttheoperator’smanualor

   contactthegenset’sauthorizedserviceprovider

   Checktoseeifthegensetissetin“energysaver”mode.Thismodeidlestheengineuntilaloadis

   appliedtoit.Thehighstartuploadsofahoistmotorcandamagethegensetwheninthismode,

   andalsothehoistmotor.Keepthegensetinfullrunmode.

Incorrect Voltage Ifoutputvoltageatthegensetgaugepanelormeasuredwithamulti-meteratthegensetoutletis

   lessthantheratedhoistvoltagewithnoload,donotusethegensettopowerthehoist.Checkthe

   gensetoperator’smanualforhowtoadjusttheoutputvoltageorcontactthegen-set’sauthorized

   serviceprovider.

   Ifthevoltageattheoppositeendofthecordislessthantheratedhoistvoltageornovoltageis

   measured,checkforincorrectsocket/plugalignmentinthecord,plugandsocket.

   Orientationofconnectorpinsandsockets(xtox,ytoy,etc)oneachwiremustbecorrectorthevoltage

   and/orphasewillbeincorrect

Low Fuel Level Lowfuelsupplyaffectsthegen-setspeed,causingvoltageandpowersurgesthatcandamagethehoist.

   Consultthegensetoperator’smanualsforfuelconsumptionratesandmakesureenoughfuelis

   availablefortheoperatingshift.

   Consultthegensetoperator’smanualsafetyconsiderationsduringrefuelingandonre-startingafter

refueling

Intake, Exhaust and Restrictingthegensetairintake,exhaustorcoolingsystemswillresultinlowpoweroutput,overheating

Cooling System anddamage.Thegensetmustbeinanopenspacewithplentyofroomaroundittodrawinairandlet

Blockage exhaustgasesleavethearea.

AlwaysfollowOperator’sManualsinstructions,dailyoperationstests,andtroubleshootingsteps.

ContactSpiderat877-774-3370formoreassistance.

Contact Spider at 877-774-3370

Andere Handbücher für SC1500

Dieses Handbuch passt für folgende Modelle

Andere SPIDER Hebesystem Handbücher

SPIDER

SPIDER SC1000-RE Bedienungsanleitung

Beliebte Hebesystem Handbücher anderer Marken

morse

morse 82H-124 Bedienungsanleitung

Braun

Braun NL955 Series Bedienungsanleitung

haacon

haacon 1889.10 Bedienungsanleitung

Protekt

Protekt AT 252 Bedienungsanleitung

R. Beck Maschinenbau

R. Beck Maschinenbau HS 600 Bedienungsanleitung

Nova Technology International, LLC

Nova Technology International, LLC NAS Series Bedienungsanleitung

Genie

Genie Z-60/34 Bedienungsanleitung

Screen Technics

Screen Technics INTERFIT Vertical Up Lift Bedienungsanleitung

Mortuary Lift

Mortuary Lift ULTIMATE 1000 Bedienungsanleitung

Custom Equipment

Custom Equipment Hy-Brid 3 Series Programmierhandbuch

Custom Equipment

Custom Equipment Hy-Brid Lifts 2 Series Programmierhandbuch

Hy-Brid Lifts

Hy-Brid Lifts HB-P3.6 Programmierhandbuch

BERG

BERG BeNomic EasyLeaf Bedienungsanleitung

Powermate

Powermate LiftGate LG-3 Bedienungsanleitung

Snorkel

Snorkel TM12 Series Bedienungsanleitung

Terberg

Terberg OMNIDEKA Bedienungsanleitung

Harmar Mobility

Harmar Mobility AL625 Betriebsanleitung

Rotary

Rotary SPO16 Bedienungsanleitung