SportsPlay Equipment RABBIT HUTCH Bedienungsanleitung

301-141 RABBIT HUTCH (Perm.)

Page 1

REV 11/17/09

301-141.I.CC.1109.2

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

IMPORTANT

Please retain this instruction sheet in your files. It contains important

replacement parts information. All equipment should be installed in accordance

with these instructions. It is important to use and maintain all public playground

equipment properly. Playground equipment, which is improperly maintained, can

cause serious injury. Periodical inspections, maintenance, repair and/or

replacement of damaged parts is necessary for safe operation of equipment and

safety of users. Resilient surfacing should be used under all playground

equipment. Appropriate publications, available at no charge, from the Consumer

Product Safety Commission, include “A Handbook for Public Playground Safety”. You

can receive your copy by calling 1-301-504-0708.

PACKING LIST

HARDWARE BAG

CTN

Hardware

Bag

116-608

3/8” x 2” Hex Head Bolt

CTN

113-306

2 –Ring Ladder

116-535

5/16” x 1 ½” Button Hd Bolt

SKID

113-044

Shell

216-512

5/16” Button Hd Nut

BDL

113-601

Legs

326-501

5/16” Lock Washer

416-350

3/16” Socket Key

326-601

3/8” Lock Washer

805-532

Warning Label

805-534

SportsPlay Label

Maintenance Checklist

2 CTN 1 BDL 1 SKID 4 TOTAL PCS WT 210# CLASS 70

301-141 RABBIT HUTCH (Perm.)

Page 2

REV 11/17/09

301-141.I.CC.1109.2

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS

Stationary & Portable equipment –Use/Fall Zones should extend a minimum of 6 feet in all

directions from the perimeter of the equipment ground space. This area should be covered

with the required amount of resilient safety surfacing material. For some equipment –

Use/Fall Zones can overlap. See Consumer Product Safety Commission Guidelines.

Diameter & Depth of footings illustrated are satisfactory in most applications for pipe

sizes up to 2 3/8” diameter. Varying soil & climatic conditions may require deeper &

heavier footings in some areas. Check local building codes.

•If resilient surfacing is to be less than 12”, then additional pipe should be put in concrete

to maintain proper finish grade for equipment.

301-141 RABBIT HUTCH (Perm.)

Page 3

REV 11/17/09

301-141.I.CC.1109.2

SportsPlay Equipment, Inc., 5642 Natural Bridge, St. Louis, MO 63120 (314) 389-4140

www.sportsplayinc.com

GENERAL ASSEMBLY INSTRUCTIONS:

Check all the parts and hardware with the packing list to be sure you have received

everything needed to assemble this product. CONTACT YOUR LOCAL DISTRIBUTOR WITH

NOTIFICATION OF ANY MISSING OR DAMAGED PARTS. Contact must be made within ten days of

receipt of your order.

Only hand-tighten nuts & bolts on initial assembly. Final tightening should be done

EVENLY after final assembly when unit has bee plumbed and leveled.

GENERAL MAINTENANCE INSTRUCTIONS:

Check MONTHLY for loose bolts, damaged or broken parts. Tighten and/or replace

immediately.

SPECIFIC ASSEMBLY INSTRUCTIONS:

NOTE:

All threaded ends of bolts protruding beyond nuts must be cut off and/or peened

to eliminate sharp edges. No more than two threads should extend beyond face

of nut. All washers, “T” nuts, and other fastener hardware used on round pipe

or tubing must be hammered down to conform to the curved underlying surface to

eliminate catch points.

STEP #1:

Place 113-306, 2-Ring Ladder onto ground with ring that has (4) holes in it

facing upwards.

STEP #2:

Place 113-044 shell on top of 2-Ring Ladder so that the ladder will be beneath

the shell.

STEP #3:

Attach 2-Ring Ladder to Shell using 5/16” x 1-1/2” Button Head Bolts, 5/16”

Lock Washers, and 5/16” Button Head Nuts. Tighten Button Head Bolts and Nuts

with 3/16” Socket Key. See Detail A at the bottom of this page.

STEP #4:

Turn shell upside down and attach 113-610 Shell legs to Shell using 3.8” x 2”

Hex Head Bolts with 3/8” Lock Washers. See Detail B at the bottom of this

page.

STEP #5:

Check and tighten all Bolts and Nuts.

STEP #6:

Turn shell over onto its legs and position, mark and dig holes. See footing

drawing on page 2.

STEP #7:

Use suggested bracing method on page 2 for holding completed assembly in

position while pouring concrete into footing holes.

STEP #8:

Allow at least 48 hours for concrete to harden before using equipment.

STEP #9:

Attach Warning Label and Manufacturer’s Identification Label to a clean

surface. The Labels should be attached in a location where they are clearly

visible and legible and away from normal hand and foot placement areas. The

Labels must be replaced if the become illegible, destroyed or removed. Contact

your Distributor for replacement Labels.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere SportsPlay Equipment Spielgeräte und Spielplatzausstattung Handbücher

SportsPlay Equipment

SportsPlay Equipment SENSORI TUNNEL 521-105 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 801-212-H Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment SCRAMBLER Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment TOT TOWN FUN CENTER 4 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment Super Dome Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 801-112 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment DINOSAUR RIDER Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment Teeter Spring Rider Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment See Saw 12 Seat Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 302-133 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 801-412-H Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 501-876 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment TOT TOWN FUN CENTER 2 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 301-134 JR. DOME (Perm.) Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 111-201 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment Junior 311-145 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment MUSTANG EASY RIDER 361-501 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 801-212M-H Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 302-102 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 302-135 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 301-135 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 581-620 Bedienungsanleitung

SportsPlay Equipment

SportsPlay Equipment 302-141 Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung

HAGS

HAGS Lillie Expansion module w Dolly Bedienungsanleitung