SportsPlay 581-422 Bedienungsanleitung

581-422 12’ Primary Tripod 4 Seat Swing

* IMPORTANT *

Please retain this instruction sheet in your files. It contains important replacement

parts information. All equipment should be installed in accordance with these

instructions. It is important to use and maintain all public playground equipment

properly. Playground equipment, which is improperly maintained, can cause serious

injury. Periodical inspections, maintenance, repair and/or replacement of damaged parts

is necessary for safe operation of equipment and safety of users. Resilient surfacing

should be used under all playground equipment. Appropriate publications, available at no

charge, from the Consumer Product Safety Commission, include “A Handbook for Public

Playground Safety”. You can receive your free copy by calling 1-301-504-0708.

PACKING LIST HARDWARE BAG

1 CTN Hardware Bag 8 585-520 2 3/8” Swing Hanger

2 PIPE 1 343-210A 2 3/8” OD x 11’ long 3 583-518A Center Fitting

8 PIPE 1 583-603A 1 7/8” OD x 15’ long 2 583-519A End Fitting

4 585-955 Cut Proof Belt Seat

8 317-140 4/0 chain x 9’6” long

16 585-901 S-Hook

14 196-802 ½” x ½” Socket Set Screw

1 416-400 ¼” Socket Key

1 805-532 Warning Label

1 805-534 SportsPlay Label

1 Maintenance Checklist

1 CTN 10 PIPE 11 TOTAL PCS WT 360# CLASS 70

581-422 12’ Primary Tripod 4 Seat Swing

GENERAL FOOTING RECOMMENDATIONS

Diameter & Depth of footings illustrated are satisfactory in most applications for pipe

sizes up to 2 3/8” diameter. Varying soil & climatic conditions may require deeper &

heavier footings in some areas. Check local building codes.

Detail: Detail:

Permanent Installation Suggested Bracing Method

* If resilient surfacing is to be less than 12”, then additional pipe should be put in

concrete to maintain proper finish grade for equipment.

USE AREA & FOOTING LAYOUT:

581-422 12’ Primary Tripod 4 Seat Swing

GENERAL USE/FALL ZONE & FOOTING RECOMMENDATIONS

SINGLE AXIS SWINGS:

The Use/Fall Zone should extend to the front & rear, a minimum distance of twice the

height of the Top Rail above the resilient surfacing material. The Use/Fall Zone to the

sides should follow the general recommendation of six feet minimum. This six-foot zone

may overlap that of an adjacent swing structure.

ROTATING SWINGS:

The Use/Fall Zone should extend in all directions the length of the swing chain plus six

feet. The six-foot minimum fall zone from the supporting structure also applies, and may

overlap the six-foot zone of an adjacent swing structure.

GENERAL MAINTENANCE INSTRUCTIONS:

Check MONTHLY for loose bolts, damaged or broken parts. Tighten and/or replace

immediately. On swings and any equipment that uses S-Hooks and/or Swing Hangers check

the bearing surfaces for wear. Replace any parts that show a reduction of 25% from the

original size.

ASSEMBLY AND INSTALLATION:

NOTE: All threaded ends of bolts protruding beyond nuts must be cut off

and/or peened to eliminate sharp edges. No more than two threads

should extend beyond face of nut. All washers, “T” nuts and other

fastener hardware used on round pipe or tubing must be hammered down to

conform to the curved underlying surface to eliminate catch points. DO

NOT tighten nuts more than hand-tight until entire assembly is

completed.

STEP #1: Assemble swing frame on side, on ground. If more than one section,

assemble section by section. Layout parts so that when frame is

erected, legs will be in approximately correct position.

Note: Combination of a 583-518A center fitting and a 583-519A End

Fitting is required for a complete Primary Tripod Swing End Fitting.

581-422 12’ Primary Tripod 4 Seat Swing

STEP #2: Remove swing hanger pendulums from the swing hanger assemblies. Using

S-hooks, attach seats to chain and chain to swing hanger pendulums.

Close the S-hooks to within .034” (1/32”) using S-hook pliers.

STEP #3: Assemble top portion of swing hangers on top rail following spacing on

page 1 diagram.

STEP #4:

Footing holes may be marked out and dug from footing layout, however,

it is easier to position swing in proper location, mark holes, move

swing aside, and dig holes.

STEP #5: Stand swing upright onto legs and brace in footing holes so that 2’ –

3’ of pipe will be under intended level of resilient surfacing and top

rail is at desired height.

STEP #6: Plumb and level entire unit. Tighten set screws by using short length

of pipe on end of socket key to add leverage. Pour concrete. Crown

surface. Wait 48 hours before removing braces and using equipment.

STEP #7: Attach assembled seats to swing hangers by reattaching the pendulums to

the swing hangers. Do not over tighten bolt on pendulum. Hangers must

move freely.

STEP #8: Attach warning label and Manufacturer’s Identification label to a clean

surface. The labels should be attached in a location where they are

clearly visible and legible and away from normal hand and foot

placement areas. The labels must be replaced if they become illegible,

destroyed or removed. Contact your SportsPlay distributor for

replacements.

Andere Handbücher für 581-422

Andere SportsPlay Babyschaukel Handbücher

SportsPlay

SportsPlay 581-242HD Bedienungsanleitung

SportsPlay

SportsPlay 581-220F Bedienungsanleitung

SportsPlay

SportsPlay 581-641HD Bedienungsanleitung

SportsPlay

SportsPlay 10 PRIMARY BIPOD SWING Bedienungsanleitung

SportsPlay

SportsPlay 581-422 Bedienungsanleitung

SportsPlay

SportsPlay 581-353H Bedienungsanleitung

SportsPlay

SportsPlay 382-411 Bedienungsanleitung

SportsPlay

SportsPlay 581-352F Bedienungsanleitung

SportsPlay

SportsPlay 8 MODERN BIPOD ADA SWING Bedienungsanleitung

SportsPlay

SportsPlay 381-404H Bedienungsanleitung

SportsPlay

SportsPlay 581-230-8H Bedienungsanleitung

Beliebte Babyschaukel Handbücher anderer Marken

Fisher-Price

Fisher-Price 79739 Bedienungsanleitung

Hudora

Hudora Comfort Montageanleitung

Fisher-Price

Fisher-Price G5914 Bedienungsanleitung

Fisher-Price

Fisher-Price M5585 Bedienungsanleitung

stilum

stilum seta Technische Daten

stilum

stilum volucris 2 Technische Daten

stilum

stilum patis2 Bedienungsanleitung

Fisher-Price

Fisher-Price K7192 Bedienungsanleitung

Graco

Graco OASIS Bedienungsanleitung

highwood

highwood Lehigh Porch Swing Bedienungsanleitung

VERTBAUDET

VERTBAUDET 70334 0022 Bedienungsanleitung

Blumfeldt

Blumfeldt Hollywood Bedienungsanleitung

Graco

Graco Swing N' Bounce Bedienungsanleitung

Fisher-Price

Fisher-Price L7193 Bedienungsanleitung

Fisher-Price

Fisher-Price CBV62 Bedienungsanleitung

Oliver & Kids

Oliver & Kids 697793 Bedienungsanleitung

Kids II

Kids II Bright Starts Safari Smiles 60403-ES Bedienungsanleitung

Sunjoy

Sunjoy L-GZ330PCO-1 Bedienungsanleitung