SPORTSPOWER WP-746 Bedienungsanleitung

FOR RESIDENTIAL USE ONLY

ASSEMBLY REQUIRES AT LEAST FOUR ADULTS

Please keep this instruction manual for future reference.

Sherwood Wood Swing Set

Style # (WP-746)

OWNER’S MANUAL

ASSEMBLY, INSTALLATION, CARE, MAINTENANCE AND USER INSTRUCTIONS

DO NOT RETURN TO THE STORE

For Customer Service, please call 1-866-370-2131 Mon – Fri 9am – 5pm Eastern Time

or visit www.sportspowerltd.net

Sportspower Limited

Level 20, Parkview Centre, 7 Lau Li Street, Causeway Bay, Hong Kong

WARNING

Dear Valued Customer,

Congratulations on your Sherwood Wood Swing Set purchase! Please read and completely

understand the contents of this owner’s manual. This manual contains specific instructions that must be

followed to prevent injuries.

This equipment is for residential use only. This product is NOT intended for public or commercial

use. The warranty will be voided if used in a commercial application.

The product was designed to be used by children between the ages of 3-10. Children must NOT play

on this set until it is properly assembled and inspected by an adult. Adult supervision is required at all

times while children are playing on the equipment. Do not allow children under six (6) years old to be

near during the assembly of this product due to choking hazards of small parts.

The equipment must be installed on level ground. Uneven ground must be leveled prior to

installation. Installation on sloping or uneven ground will put stress on the joints, causing the unit to

become loose and unstable which may result in serious injuries. You must ensure there are no

obstructions or structures (e.g. electrical wires, branches, house, fence, garage, etc) within six (6) feet in

any direction from the equipment.

The U.S. Consumer Product Safety Commission’s Outdoor Home Playground Safety Handbook

recommends to install and maintain the playground equipment over at least 9 inches of wood chips,

mulch or shredded rubber (for equipment up to 8 feet high) or sand or pea gravel (for equipment no more

than 5 feet high) as shock absorbing material. Dirt and grass, which are the most prevalent surfaces

under home playground equipment, do not adequately protect children from serious head injuries. Install

protective surfacing at least six feet in all directions from play equipment. For swings, the surface should

extend, in back and front, twice the height of the suspending bar. Do not install your playset over hard

surface, e.g. asphalt, concrete, packed earth, tile or brick floor. Do not allow children to use the product

during windy or wet weather conditions. You should consult a local licensed contractor about ways to

anchor the product in your location.

Please thoroughly read and follow the instructions in this Owner’s Manual to ensure proper and

enjoyable play for your children. The equipment must be checked before each use and maintained

regularly. This includes, but is not limited to inspecting the equipment for cracks, excess wear, missing

parts, loose connections, and for overall integrity. When the set shows any signs of weakness or

damage, you must stop using the product immediately, properly store the set or restrict access by users

until the condition is resolved.

Your product is warranted against defects in material and workmanship. Extended warranty is also

offered to those customers registering their products at www.sportspowerltd.net within 14 days from the

date of purchase. Please refer to our warranty policy at the back of this manual for details.

If you experience any problems with your product, do not return to the store. For customer

service, please call 1-866-370-2131 Monday-Friday 9:00am-5:00pm Eastern Time or visit

www.sportspowerltd.net

INTRODUCTION

Trhbrt

IMPORTANT WARNINGS AND INSTRUCTIONS ……………………………………………………. . 3

IMPORTANT CONSUMER INFORMATION SHEET …………………………………………………… 8

COMPLETE PRODUCT VIEW…………………………………………………………………………… 13

TOOLS NEEDED …………………………………………………………………………………..…….... 14

WOOD PARTS LIST…………………………………...…………………………………………….......... 15

HARDWARE PARTS LIST ………………………...……………………………………………………... 17

COMPONENT PARTS LIST ………………………...………………………………………………… ... 18

ASSEMBLY AND INSTALLATION INSTRUCTIONS ……………………………………….…………. 19

PRODUCT WARRANTY ………………………………………………………………………………… 40

TABLE OF CONTENTS

Trhbrt

BEFORE YOU BEGIN: Carefully read all instructions in this manual before assembling and using this

product. The unit must be assembled by adults. Heavy duty working gloves must be worn to avoid

injuries during assembly.

WARNING

READ ALL INSTRUCTIONS BEFORE ASSEMBLING OR USING THIS EQUIPMENT

AGE LIMIT

 This product is designed to be used by children between the ages of 3 to 10. Maximum

user weight for each component of the playset is 100 pounds (45kg), allowing up to

maximum six (6) children to play at the same time.

 The play set is designed for children over three (3) years of age. Use by smaller children

can result in entrapment and serious injury.

 On-site adult supervision is required at all times for children of all ages.

 Do not allow use by children with any physical condition that may affect his/her ability to use

this equipment safely.

IMPORTANT:

 Children must NOT play on this set until it is properly assembled and inspected by an adult.

 The wood play set must be properly installed and anchored BEFORE children can play on it.

 You MUST read and follow all instructions in this manual before installing or attempting to

use the wooden playground.

 Please keep this instruction manual for future reference.

 Never add extra length to chain or rope. The chains or ropes provided are the maximum

length designed for the swinging element.

Failure to follow these important requirements may result in the warranty being voided and/or

serious injury. Please supervise your children carefully during the installation and assembly of

the wood play set.

Please also pay close attention to the periodic maintenance that is required to keep your wood

play set in a safe condition for maximum enjoyment of backyard fun!

IMPORTANT WARNINGS AND INSTRUCTIONS

Trhbrt

WARNING

BEFORE YOU BEGIN ASSEMBLY:

 Take a complete inventory of components using the parts list.

 Sort and lay out the wood pieces. Label each piece of wood for easy reference. For easy

identification during the assembly process, write the board’s letter on masking tape and adhere to

each piece of the wood. Some wooden components may twist or warp in the carton after packaging.

Usually, these parts straighten out when assembled. You may also see some cracking of the grain.

This is normal.

 Sort all hardware according to size. Do not worry if extra hardware is included.

Find a safe play location.

 You MUST install the wooden playset on level ground. Uneven ground must be leveled prior to

installation. The manufacturer cannot assume responsibility for any failure from incorrect

installation. Installing on sloping ground will put stress on all the joints, which will cause the set to

become loose and unstable.

 Find a location where the equipment can be placed more than 6 feet from any structure or

obstruction (ex: electrical wires, branches, house, fence, garage) The safe play area refers to a

zone extending 6’ beyond the gym set on all sides, including the space above the gym set.

 The safe play area must be free of all structures, landscaping, tress and branches, rocks, wires and

other obstacles to safe play. Children can be seriously injured running or swinging into these

obstacles.

 Remove any rocks or any jagged or sharp object that could endanger your children’s’ safety.

 Remove all tripping hazards from the safe play area. Tripping hazards include but are not limited to:

roots, stumps, rocks, landscaping, sprinkler heads, railroad ties, plumbing, and electrical

connections.

Do NOT install your swing set over gravel,

asphalt, packed earth or any other hard

surface. The following is a list of

recommended ground covers from the

Consumer Product Safety Commission.

SUGGESTED MATERIAL

UNCOMPRESSED DEPTH

Double Shredded Bark Mulch 9”

Uniform Wood Chips 12”

Fine Gravel 12”

Fine Sand 12”

IMPORTANT WARNINGS AND INSTRUCTIONS

Trhbrt

BEFORE YOU BEGIN: Carefully read all instructions in this manual before assembling and

using this product. The unit must be assembled by adults. Heavy duty working gloves must be

worn to avoid injuries during assembly.

WARNING

READ ALL INSTRUCTIONS BEFORE ASSEMBLING OR USING THIS EQUIPMENT

Observing the following statements and warnings reduces the likelihood of serious or fatal injury.

PLAY SUPERVISION



DO NOT allow more than one child to play on the individual swing or slide at the same time.

 DO NOT allow children to stand on the swing seat.

 DO NOT allow children to walk too close to moving parts. ALWAYS keep a safe distance to

avoid being struck by other children while playing.

 DO NOT allow children to twist the swing chains or ropes, or loop them over the top support

bar as this may reduce the strength of the chain or rope.

 Owners shall be responsible for maintaining the legibility of the warning labels.

 Instruct children not to use the equipment in a manner other than intended.

 DO NOT swing empty seats as this may cause injuries.

 ALWAYS guide children to sit in the center of swinging parts, with their full weight placed in

the seat center and holding on to the swing chains.

 DO NOT allow children to jump off the equipment while it is in motion. ALWAYS come to a

full stop before dismounting.

 ALWAYS dress children appropriately for playing, e.g. wear well-fitted rubber sole shoes,

and remove loose or sharp items such as jewelry, hair accessories, scarves, ponchos that

may become entangled in the equipment or cause injuries.

 ALWAYS make sure children remove their bike or other sports helmets before playing on the

playground. Helmets can become entrapped in the playground, posing a strangulation

hazard.

 DO NOT allow children to climb onto swing or jump to and from different play areas of the

equipment. ALWAYS return safely to the ground before approaching another play area.

 DO NOT allow children to climb on structural parts (e.g. legs, top bar). These are structural

components and are not designed for play.

 ALWAYS check the slide or other parts exposed to the body for extreme heat from the sun

before allowing children to use the equipment.

 ALWAYS prevent access and secure from any unauthorized use when there is no adult

supervision.

 DO NOT allow pets or other animals near the equipment to prevent damage or injuries.

IMPORTANT WARNINGS AND INSTRUCTIONS

Trhbrt

INSPECTION PRIOR TO EACH USE OR DAILY INSPECTION

 DO NOT use the equipment if any bolts or nuts are missing or loose. ALWAYS check to ensure the

equipment and all parts are well secured and stable before each use.

 ALWAYS clear the play area of any rocks, sharp objects, or any materials that could be potentially

hazardous to users.

 DO NOT attach items to the equipment that are not specifically designed for use with the equipment,

including, but not limited to, jump ropes, clothesline, pet leashes, cables and chains as they may

cause choke hazards.

 The wood, steel and plastic parts used in your product are subject to normal wear. Gradual

deterioration of the material will occur, the speed of which will depend on the level of exposure to UV

rays, airborne pollution, outdoor weather conditions such as rain and wind and the amount of use.

You must inspect the equipment prior to every use. This includes, but is not limited to inspecting the

set for cracks, excess wear, missing parts, loose connections, and for overall integrity. When the

set shows any signs of weakness, you must stop using the play set immediately, properly store the

set or restrict access by users until the condition is resolved.

 Verify that the suspended climbing ropes, chain or cable are secured at both ends and

tightened, so that there is no loose ropes, chain or cable hanging that can result in choking

hazard.

WEATHER CONDITIONS

 DO NOT use this equipment if the swing seat, slide or other parts are wet. Use the playset only when

the parts are clean and dry. If the equipment is wet, the user could slip and suffer injuries.

 Please be aware of weather conditions when using the equipment. If it is too windy, users could lose

control and suffer injuries. The playground equipment must be properly anchored, stored away or

restricted from use during inclement weather such as heavy winds or severe weather storms. You

should consult a local contractor about ways to anchor the product in your location.

DISPOSAL INSTRUCTIONS

 Please use care when disassembling the equipment. Wear heavy duty working gloves to avoid

injuries.

 Fully disassemble the entire swing and climber before disposal. Do not leave partially disassembled

equipment parts in areas accessible by children.

 All plastic and steel parts could be recycled. Take it to your local recycling center. Do not let children

play with any disassembled parts destined for disposal, such as chains, slide, tubing, bolts, nuts,

screws, etc.

IMPORTANT WARNINGS AND INSTRUCTIONS

Trhbrt

AT THE BEGINNING OF EACH PLAY SEASON:

 Tighten all hardware.

 Lubricate all metallic moving parts per manufacturer’s instructions.

 Check all protective coverings on bolts, pipes, edges, and corners. Replace if they are

loose, cracked, or missing.

 Check all moving parts including swing seats, ropes, cables, and chains for wear, rust, or

other deterioration. Replace as needed.

 Check metal parts for rust. If found, sand and repaint using a nonlead-based paint meeting

the requirements of 16 CFR 1303.

 Check all wood members for deterioration and splinters. Sand down splinters and replace

deteriorating wood members.

 Reinstall any plastic parts, such as swing seats or any other items that were removed for the

cold season.

 Rake and check depth of loose fill protective surfacing materials to prevent compaction and

to maintain appropriate depth. Replace as necessary.

TWICE A MONTH DURING PLAY SEASON:

 Tighten all hardware.

 Check all protective coverings on bolts, pipes, edges, and corners. Replace if they are

loose, cracked, or missing.

 Rake and check depth of loose fill protective surfacing materials to prevent compaction and

to maintain appropriate depth. Replace as necessary.

ONCE A MONTH DURING PLAY SEASON:

 Lubricate all metallic moving parts per manufacturer’s instructions.

 Check all moving parts including swing seats, ropes, cables, and chains for wear, rust, or

other deterioration. Replace as needed.

At the end of each play season or when the temperature drops below 32°F (temperature

to be selected by the manufacturer).

 Remove plastic swing seats and other items as specified by the manufacturer and take

indoors or do not use.

 Rake and check depth of loose fill protective surfacing materials to prevent compaction and

to maintain appropriate depth. Replace as necessary.

 Owners shall be responsible for maintaining the legibility of the warning labels.

When conducting inspections, it is recommended that you use the Outdoor Home

Playground Safety Checklist published by the US Consumer Product Safety

Commission, a copy of which is contained in this user manual.

IMPORTANT WARNINGS AND INSTRUCTIONS

Trhbrt

The Consumer Product Safety Commission estimates there are about 200,000 playground related injuries

involving children each year. Injuries involving this hazard pattern tend to be among the most serious of all

playground injuries and have the potential to be fatal, particularly when the injury is to the head. The surface under

and around playground equipment can be a major factor in determining the injury-causing potential of a fall. It is self

evident that a fall onto a shock absorbing surface is less likely to cause a serious injury than a fall onto a hard

surface. Playground equipment should never be placed on hard surfaces such as concrete or asphalt and while

grass may appear to be acceptable it may quickly turn to hard packed earth in areas of high traffic. Shredded bark,

mulch, wood chips, fine sand or fine gravel are considered to be acceptable shock absorbing surface when installed

and maintained at a sufficient depth under and around playground equipment.

Table below lists the maximum height from which a child would not be expected to sustain a life-threatening

head injury in a fall onto four different loose-fill surfacing materials if they are installed and maintained at depths of

6” (15.25CM), 9” (22.9CM), and 12” (30.5CM).

FALL HEIGHT IN FEET FROM WHICH

A LIFE THREATENING HEAD INJURY WOULD NOT BE EXPECTED

TYPE OF MATERIAL 6”(15.25CM)

DEPTH

9”(22.9CM) DEPTH

12”(30.5CM)

DEPTH

Double shredded bark mulch 6”(15.25CM) 10”(25.4CM) 11”(27.94CM)

Wood Chips 6”(15.25CM) 7”(17.8CM) 12”(30.5CM)

Fine Sand 5”(12.7CM) 5”(12.7CM) 9”(22.86CM)

Fine Gravel 6”(15.25CM) 7”(17.8CM) 10”(25.4CM)

However, it should be recognized that all injuries due to falls cannot be prevented no matter what surfacing

material is used. We recommend that a shock absorbing material should extend a minimum of 6ft in all directions

from the perimeter of stationary equipment such as climbers and slides. However, because children may

deliberately jump from a moving swing, the shock absorbing material should extend in the front and rear of a swing

a minimum distance of 2 times the height of the pivot point measured from a point directly beneath the pivot on the

supporting structure.

This information is intended to assist in comparing the relative shock-absorbing properties of various materials.

No particular material is recommended over another. However, each material is only effective when

Properly maintained. Materials should be checked periodically and replenished to maintain correct depth as

determined necessary for your equipment. The choice of a material depends on the type and height of the

playground equipment, the availability of the material in your area and its cost.

Note: The maximum fall height for this product is 6 feet. The minimum ground Clearance between the bottom of the

suspended plays and the playing or ground service must be 8 inches.

This information has been extracted from the CPSC publication on" Playground Safety". You can obtain more

information by sending a postcard to the: Office of public Affairs，U.S. Consumer Product Safety Commission，

Washington，D.C.20207

IMPORTANT CONSUMER INFORMATION SHEET

Trhbrt

The following guidelines are extracts from the Consumer Product Safety Commission Outdoor

Home Playground Safety Handbook. It is recommended that you read the entire handbook and

take necessary precautions to prevent serious injuries to your children, including:

CHOOSING A SITE

 When you choose a home playground, a location away from roads and driveways and readily visible

from inside the home and patios or porches, is important.

 Create a site free of obstacles that could cause injuries such as low overhanging tree branches,

overhead wires, tree stumps and/or roots, large rocks, bricks and concrete.

 Choose a level location for the equipment. This can reduce the likelihood of the play set tipping over

and loose-fill surfacing materials washing away during heavy rains. Some sites may need regrading

to improve drainage or to reduce the slope.

 Locate play set at least 6 feet from any structure or obstacles, such as a house, fence, sheds, trees

or poles. Swings should be further away from structures to the front and rear of the swings-a

distance equal to twice the height of the top bar from which the swing is suspended.

 Locate bare metal platforms and slides out of direct sunlight to reduce the likelihood of serious burns.

A slide that faces north will receive the least direct sunlight.

SELECT PROTECTIVE SURFACING

One of the most important things you can do to reduce the likelihood of serious head injuries is to install

shock-absorbing protective surfacing under and around your play set. The protective surfacing should be

applied to a depth that is suitable for the equipment height in accordance with ASTM F1292. There are

different types of surfacing to choose from; whichever product you select, follow these guidelines:

Do not install home playground equipment over concrete, asphalt, or any other hard surface. A

fall onto a hard surface can result in serious injury to the equipment user. Grass and dirt are not

considered protective surfacing because wear and environmental factors can reduce their shock

absorbing effectiveness. Carpeting and thin mats are generally not adequate protective

surfacing.

Loose-Fill Materials

 Maintain a minimum depth of 9 inches of loose-fill materials such as wood mulch/chips, engineered

wood fiber (EWF), or shredded/recycled rubber mulch for equipment up to 8 feet high; and 9 inches

of sand or pea gravel for equipment up to 5 feet high. NOTE: An initial fill level of 12 inches will

compress to about a 9-inch depth of surfacing over time. The surfacing will also compact, displace,

and settle, and should be periodically refilled to maintain at least a 9-inch depth.

 Use containment, such as digging out around the perimeter and/or lining the perimeter with

landscape edging. Don’t forget to account for water drainage.

 Check and maintain the depth of the loose-fill surfacing material. To maintain the right amount of

loose-fill materials, mark the correct level on play equipment support posts. That way you can easily

see when to replenish and/or redistribute the surfacing.

 Do not install loose fill surfacing over hard surfaces such as concrete or asphalt.

IMPORTANT CONSUMER INFORMATION SHEET

Inhaltsverzeichnis

Andere SPORTSPOWER Spielgeräte und Spielplatzausstattung Handbücher

SPORTSPOWER

SPORTSPOWER INF-2081 Wartungshandbuch

SPORTSPOWER

SPORTSPOWER WP-612R Wartungshandbuch

SPORTSPOWER

SPORTSPOWER M7TEG Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER PERSONALISED WOODEN PLAYHOUSE Betriebsanleitung

SPORTSPOWER

SPORTSPOWER 3VY6U Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER 4UPWX Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER 2BLAH Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER M7TEJ Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER SL-019 Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER MSC-3990 Montageanleitung

SPORTSPOWER

SPORTSPOWER JUNIOR SEE SAW Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER CP-4979-S Wartungshandbuch

SPORTSPOWER

SPORTSPOWER WP-587 Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER 4XMNK Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER JET MAT MSC-5019 Kurzanleitung zur Einrichtung

SPORTSPOWER

SPORTSPOWER INF-1440-S Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER Sunny Cottage Wooden Playhouse Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER DFJ23 Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER 4XMNJ Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER Me and My Puppy Playhouse WP-379 Gebrauchs- und Pflegehandbuch

SPORTSPOWER

SPORTSPOWER MSC-4342 Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER US331 Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER MSC-4146 Bedienungsanleitung

SPORTSPOWER

SPORTSPOWER MSC-4118-BM Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung