SSANGYONG Actyon 2008.01 Bedienungsanleitung

GENERAL

0000-00

GENERAL

1. DIMENSIONS........................................

2. SPECIFICATIONS.................................

3. VEHICLE IDENTIFICATION...................

4. MAINTENANCE INTERVAL...................

5. RECOMMENDED FLUIDS AND

LUBRICANTS........................................

6. JACK-UP POINTS (DOTTED CIRCLES).

7. PIN ARRANGEMENT OF DIAGNOSTIC

CONNECTOR........................................

8. ELECTRIC COMPONENTS AND

LAYOUT................................................

9. STANDARD BOLTS SPECIFICATIONS.

GENERAL

0-2

CTYON 2008.01

0000-00

GENERAL

0-3

GENERAL

ACTYON 2008.01

0000-00

4110-01

GENERAL

1. DIMENSIONS

0-4

CTYON 2008.01

0000-00

GENERAL

2. SPECIFICATIONS

0-5

GENERAL

ACTYON 2008.01

0000-00

0-6

CTYON 2008.01

0000-00

GENERAL

3. VEHICLE IDENTIFICATION

Engine Number (G23D) Chassis Number

Engine Number (D20DT)

The engine number is stamped on the

upper rear left-hand side of the cylinde

block.

The chassis number is stamped on

the frame behind the front right tire.

The engine number is stamped on the

lower area of cylinder block in the

intake manifold side.

Certification Label

The certification label is located on

the driver's door sill (B pillar).

0-7

GENERAL

ACTYON 2008.01

0000-00

4. MAINTENANCE INTERVAL

* Use only approved Ssangyong genuine parts.

Maintenance service and record retention are the owner's responsibility. You should retain

evidence that proper maintenance has been performed on your vehicle in accordance with the

scheduled maintenance service chart.

* EU Countries: Only countries that belong to EU. (It does not apply to all countries in EU.)

ENGINE CONTROL SYSTEM

NOTE 1: Adjust as required; When excessive smoke is visible (black or white)

Poor performance/economy

Chart Symbols:

Inspect these items and their related parts. If necessary, correct, clean, replenish, adjust or replace.

I -

(1)* If vehicle is operated under severe condition:

Frequent stop-and-go traffic, extended idling, short driving distance below 6 km, driving distance

below 16 km when the outside temperature remains below freezing

Driving in a hilly or mountainous terrain, sandy, or dusty area

High load driving such as trailer towing

Taxi, patrol service or delivery service (extended idling and excessive driving with low speed)

Check the engine oil level and leak every 3,000 km (2,000 miles) or before starting a long trip.

(2)* If vehicle is operated under severe condition, driving in dusty condition or sandy condition,

pollutant area or off-road driving, frequently inspect the air cleaner, if necessary, change the

air cleaner.

(3)* More frequent maintenance is required if under dusty driving condition.

(4)* Refer to "Recommended fluids, coolant and lubricants".

* Water separator: When replace the engine oil, also drain the water from the fuel filter.

1) Diesel Engine

Replace or change.R -

0-8

CTYON 2008.01

0000-00

GENERAL

* EU Countries: Only countries that belong to EU. (It does not apply to all countries in EU.)

ENGINE CONTROL SYSTEM

Chart Symbols:

Inspect these items and their related parts. If necessary, correct, clean, replenish, adjust or replace.

Replace or change.

I -

R -

(3)* Refer to "Recommended fluids and lubricants".

(4)* More frequent maintenance is required if the vehicle is operated under any of the following

conditions:

In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher, or

In hilly or moutainous terrain, or

When doing frequent trailer towing, or

Uses such as found in taxi, police or delivery service.

(5)* Inspect manual transmission fluid every 15,000 km (Inspect the leak of fluid at any time,

occasionally), then change every 60,000 km

(6)* Change automatic transmission fluid and every 60,000 km if the vehicle is mainly driven

under severe conditions: Towing a trailer or off-road driving (Inspect the leak of fluid at any

time, occasionlly)

(7)* After completion of off-road operation, the underbody of the vehicle should be throughly

inspected. Examine threaded fasteners for looseness.

(8)* If necessary, rotate and balance wheels.

(9)* After completion of off-road operation, the drive shaft boots should be inspected.

(10)* Inspect propeller shaft grease every 5,000 km or 3 months if the vehicle is mainly driven

under severe condition.

Severe Conditions in Air Conditioner Filter

- Pollutant area or off-road driving, extended air conditioner or heater operation

In off-road or dusty road, or

In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher, or

In hilly or moutainous terrain.

0-9

GENERAL

ACTYON 2008.01

0000-00

* Use only approved Ssangyong genuine parts.

Maintenance service and record retention are the owner's responsibility. You should retain

evidence that proper maintenance has been performed on your vehicle in accordance with the

scheduled maintenance service chart.

* EU Countries: Only countries that belong to EU. (It does not apply to all countries in EU.)

ENGINE CONTROL SYSTEM

Chart Symbols:

Inspect these items and their related parts. If necessary, correct, clean, replenish, adjust or replace.

Replace or change.

In order to secure engine long life and effective break-in, first oil (factory filled) would be recommended to

drain with in 10,000 km.

I -

R -

**-

(1)* If vehicle is operated under severe condition: short distance driving, extensive idling or

driving in dusty condition, shorten the service interval.

(2)* If vehicle is operated under severe condition, pollutant area or off-road driving, driving in

dusty condition or sandy condition, frequently inspect the air cleaner, if necessary,

change the air cleaner.

(3)* Refer to "Recommended fluids and lubricants".

2) Gasoline Engine

0-10

CTYON 2008.01

0000-00

GENERAL

* EU Countries: Only countries that belong to EU. (It does not apply to all countries in EU.)

CHASSIS AND BODY

Chart Symbols:

Inspect these items and their related parts. If necessary, correct, clean, replenish, adjust or replace.

Replace or change.

I -

R -

(3)*Refer to "Recommended fluids and lubricants".

(4)*More frequent maintenance is required if the vehicle is operated under any of the

following conditions:

In heavy city traffic where the outside temperature regularly reaches 32°C (90°F) or higher, or

In hilly or moutainous terrain, or

When doing frequent trailer towing, or

Uses such as found in taxi, police or delivery service.

(5)* Inspect manual transmission fluid every 15,000 km (Inspect the leak of fluid at any time,

occasionally), then change every 60,000 km

(6)* Change automatic transmission fluid and every 60,000 km if the vehicle is mainly driven

under severe conditions. (Inspect the leak of fluid at any time, occasionlly)

Inhaltsverzeichnis

Andere SSANGYONG Automobil Handbücher

SSANGYONG

SSANGYONG NEW CHAIRMAN Bedienungsanleitung

SSANGYONG

SSANGYONG Rexton 2008 Bedienungsanleitung

SSANGYONG

SSANGYONG KORANDO 2005 Bedienungsanleitung

SSANGYONG

SSANGYONG KYRON 2007.04 Bedienungsanleitung

SSANGYONG

SSANGYONG Rodius 2012.07 Bedienungsanleitung

SSANGYONG

SSANGYONG korando C200 Bedienungsanleitung

SSANGYONG

SSANGYONG Korando Bedienungsanleitung

SSANGYONG

SSANGYONG Rexton W 2012.06 Bedienungsanleitung

SSANGYONG

SSANGYONG Rexton Y200 Bedienungsanleitung

SSANGYONG

SSANGYONG REXTON II 2006 Bedienungsanleitung

SSANGYONG

SSANGYONG 2004 Rexton 2.7XDi Gebrauchsanweisung

SSANGYONG

SSANGYONG Korando 2010 Bedienungsanleitung

SSANGYONG

SSANGYONG ACTYON 2010.01 Bedienungsanleitung

SSANGYONG

SSANGYONG Rodius 2013 Bedienungsanleitung

SSANGYONG

SSANGYONG KYRON 2006.03 Bedienungsanleitung

SSANGYONG

SSANGYONG KYRON 2010.01 Bedienungsanleitung

SSANGYONG

SSANGYONG RODIUS 2005.07 Bedienungsanleitung

SSANGYONG

SSANGYONG KYRON 2006 Betriebsanleitung

SSANGYONG

SSANGYONG REXTON Bedienungsanleitung

SSANGYONG

SSANGYONG TURISMO 2015 Technisches Handbuch

SSANGYONG

SSANGYONG Korando 2013 Bedienungsanleitung

SSANGYONG

SSANGYONG 2010 Kyron Bedienungsanleitung

SSANGYONG

SSANGYONG Kyron D100 2005 Bedienungsanleitung

SSANGYONG

SSANGYONG KYRON 2006 Bedienungsanleitung

Beliebte Automobil Handbücher anderer Marken

Toyota

Toyota 2000 Tundra Bedienungsanleitung

CITROËN

CITROËN DS4 DSign Bedienungsanleitung

Cadillac

Cadillac CTS 2008 Bedienungsanleitung

Porsche

Porsche Boxster S Bedienungsanleitung

KIAM

KIAM SPORTAGE 2014 Stücklistenhandbuch

GMC

GMC 2013 Terrain Montageanleitung

Lexus

Lexus 2015 CT 200h Bedienungsanleitung

GMC

GMC T-Series 1999 Bedienungsanleitung

Mercury

Mercury 1998 Mystique Bedienungsanleitung

Mercury

Mercury 2007 Mariner Bedienungsanleitung

Mazda

Mazda 2007 Mazdaspeed 3 Leitfaden

Mazda

Mazda 2014 CX-5 Bedienungsanleitung

GMC

GMC Chevrolet Express 2022 Bedienungsanleitung

GMC

GMC 1997 Jimmy Bedienungsanleitung

Chevrolet

Chevrolet 2012 Malibu Bedienungsanleitung

Skoda

Skoda FABIA RS - ANNEXE 118 Bedienungsanleitung

Seat

Seat toledo Bedienungsanleitung

PEUGEOT

PEUGEOT 206 CC Bedienungsanleitung