Sun Microsystems StorEdge 3000 Series Bedienungsanleitung

Sun Microsystems, Inc.

www.sun.com

Submit comments about this document at: http://www.sun.com/hwdocs/feedback

Sun StorEdge™3000 Family

Rack Installation Guide for

2U Arrays

Part No. 817-3629-10

September 2003, Revision A

Please

Recycle

Sun Microsystems, Inc. and Dot Hill Systems Corporation may have intellectual property rights relating to technology embodied in this product

or document. In particular, and without limitation, these intellectual property rights may include one or more of the U.S. patents listed at

http://www.sun.com/patents and one or more additional patents or pending patent applications in the U.S. and other countries.

This product or document is distributed under licenses restricting its use, copying distribution, and decompilation. No part of this product or

document may be reproduced in any form by any means without prior written authorization of Sun and its licensors, if any.

Third-party software is copyrighted and licensed from Sun suppliers.

Parts of the product may be derived from Berkeley BSD systems, licensed from the University of California. UNIX is a registered trademark in

the U.S. and in other countries, exclusively licensed through X/Open Company, Ltd.

Sun, Sun Microsystems, the Sun logo, Sun StorEdge, AnswerBook2, docs.sun.com, and Solaris are trademarks or registered trademarks of Sun

Microsystems, Inc. in the U.S. and in other countries.

U.S. Government Rights—Commercial use. Government users are subject to the Sun Microsystems, Inc. standard license agreement and

applicable provisions of the FAR and its supplements.

DOCUMENTATION IS PROVIDED “AS IS” AND ALL EXPRESS OR IMPLIED CONDITIONS, REPRESENTATIONS AND WARRANTIES,

INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE OR NONINFRINGEMENT,

ARE DISCLAIMED, EXCEPT TO THE EXTENT THAT SUCH DISCLAIMERS ARE HELD TO BE LEGALLY INVALID.

Sun Microsystems, Inc. et Dot Hill Systems Corporation peuvent avoir les droits de propriété intellectuels relatants à la technologie incorporée

dans le produit qui est décrit dans ce document. En particulier, et sans la limitation, ces droits de propriété intellectuels peuvent inclure un ou

plus des brevets américains énumérés à http://www.sun.com/patents et un ou les brevets plus supplémentaires ou les applications de brevet

en attente dans les Etats-Unis et dans les autres pays.

Ce produit ou document est protégé par un copyright et distribué avec des licences qui en restreignent l’utilisation, la copie, la distribution, et la

décompilation. Aucune partie de ce produit ou document ne peut être reproduite sous aucune forme, par quelque moyen que ce soit, sans

l'autorisation préalable et écrite de Sun et de ses bailleurs de licence, s’il y ena.

Le logiciel détenu par des tiers, et qui comprend la technologie relative aux polices de caractères, est protégé par un copyright et licencié par des

fournisseurs de Sun.

Des parties de ce produit pourront être dérivées des systèmes Berkeley BSD licenciés par l’Université de Californie. UNIX est une marque

déposée aux Etats-Unis et dans d’autres pays et licenciée exclusivement par X/Open Company, Ltd.

Sun, Sun Microsystems, le logo Sun, Sun StorEdge, AnswerBook2, docs.sun.com, et Solaris sont des marques de fabrique ou des marques

déposées de Sun Microsystems, Inc. aux Etats-Unis et dans d’autres pays.

LA DOCUMENTATION EST FOURNIE “EN L’ÉTAT” ET TOUTES AUTRES CONDITIONS, CONDITIONS, DECLARATIONS ET

GARANTIES EXPRESSES OU TACITES SONT FORMELLEMENT EXCLUES, DANS LA MESURE AUTORISEE PAR LA LOI APPLICABLE,

Y COMPRIS NOTAMMENT TOUTE GARANTIE IMPLICITE RELATIVE A LA QUALITE MARCHANDE, A L'APTITUDE A UNE

UTILISATION PARTICULIERE OU A L’ABSENCE DE CONTREFAÇON.

iii

Contents

1. Mounting the Array in Racks and Cabinets 1–1

1.1 Overview of Rackmount Kits 1–1

1.2 One-Person Installation Requirements 1–2

1.3 Reviewing the Tools 1–3

1.4 Converting Your Front Bezel Locks So the Keys Cannot Be Removed 1–4

2. Mounting in Sun Cabinets 2–1

2.1 Overview of Assembly 2–1

2.2 Rear Bracket Configuration 2–4

2.3 Middle Bracket Configuration 2–12

3. Telco Rackmounting 3–1

3.1 Flushmount Configuration 3–1

3.2 Center-of-Gravity Configuration 3–5

4. Powering On and Checking LEDs 4–1

A. Mounting Holes in the Sun StorEdge 72-Inch Expansion Cabinet A–1

iv Sun StorEdge 3000 Family Rack Installation Guide for 2U Arrays • September 2003

1-1

CHAPTER 1

Mounting the Array in Racks and

Cabinets

This document describes mounting Sun StorEdge 3000 Family arrays in supported

racks and cabinets. Topics covered in this chapter are:

■“Overview of Rackmount Kits” on page 1-1

■“One-Person Installation Requirements” on page 1-2

■“Reviewing the Tools” on page 1-3

■“Converting Your Front Bezel Locks So the Keys Cannot Be Removed” on

page 1-4

1.1 Overview of Rackmount Kits

For late-breaking news about additional supported racks and cabinets, refer to the

Release Notes for the model of the array that you are installing. You can find the

Release Notes at:

http://www.sun.com/products-n-solutions/hardware/docs/

Network_Storage_Solutions/Workgroup/3310

Tip – The instructions in this guide can save you a lot of time if you read them

carefully. The entire assembly procedure should take less than thirty minutes if you

follow all the instructions provided in this guide.

The following table lists the supported cabinets and racks and other required kits,

the rackmount kits that apply to each one, and the location of the installation

instructions in this guide.

1-2 Sun StorEdge 3000 Family Rack Installation Guide for 2U Arrays • September 2003

* The Sun StorEdge 72-inch expansion cabinet requires the X9818A door kit for the Sun StorEdge 3000 Family 2U

arrays.

**The Sun Rack 900 cabinet also requires the X6825A door kit and the X6835A EMI kit with these arrays.

1.2 One-Person Installation Requirements

Two people should install each array; however, one person can install the array:

■In a Sun cabinet if the rail kit contains rear brackets with flanges that provide

support

■In a Telco rack if the person has an appropriate equipment lift that can ensure

safety and ease of installation

For a one-person installation, remove the power supplies and disk drives to reduce

weight and to be safe. If possible, position the array on top of another device or shelf

in the rack to hold the unit as you attach all the brackets.

TABLE 1-1 Supported Cabinets With Associated Rackmount Kits

Supported Cabinet or Rack

Rackmount Kit

Needed

Installation

Instructions

Sun StorEdge 72-inch Expansion Cabinets*

SG-XARY030A

XTA-3310-RK-19U “Middle Bracket

Configuration” on

page 2-12

Sun Fire Cabinets

SF-XCAB

XTA-3310-RK-19U “Middle Bracket

Configuration” on

page 2-12

Sun Rack 900 Cabinet**

SR9-XKL038A-IP

XTA-3310-RK-19U “Middle Bracket

Configuration” on

page 2-12

Standard EIA Cabinets XTA-3310-RK-19U “Rear Bracket

Configuration” on

page 2-4

Telco flushmount racks XTA-3310-RK-19F “Flushmount

Configuration” on

page 3-1

Telco center-of-gravity racks XTA-3310-RK-19C “Center-of-Gravity

Configuration” on

page 3-5

Chapter 1 Mounting the Array in Racks and Cabinets 1-3

Caution – If you have only one person to perform the installation in a Sun cabinet

and do not have rear brackets with flanges or special equipment lift, you must

remove the power supplies and hard disk drives from the array before installing the

array in a rack.

To reduce the weight of the array during the rackmounting procedure, refer to the

Sun StorEdge 3000 Family FRU Installation Guide for your array, and follow

instructions on removing drives and power supplies. A fully populated array weighs

over 50 pounds; an array without drives and power supplies weighs about 30

pounds.

1.3 Reviewing the Tools

The following tools are used to complete this procedure:

■Medium Phillips screwdriver

■Allen wrench (provided; used with 6-mm screws and #12-24 x 3/8-inch

sockethead screws)

Caution – Do not use any power tools with any procedures. Power tools can strip

or damage connections.

1-4 Sun StorEdge 3000 Family Rack Installation Guide for 2U Arrays • September 2003

1.4 Converting Your Front Bezel Locks So

the Keys Cannot Be Removed

The bezel on your array has two locks whose keys can be removed when the locks

are in either the locked or open position. It is possible to reconfigure the locks so that

the keys cannot be removed. It is most convenient to make this optional change

when removing the bezel prior to installing the array in a rack or cabinet.

FIGURE 1-1 Front Bezel and Front Bezel Locks of an Array

To change the locks so the keys cannot be removed, follow these steps:

1. Remove the bezel by gently pivoting the swing arms out of their ear sockets, and

make sure the key is in the locked position, with the pawl extending horizontally

past the edge of the bezel (see the first panel of FIGURE 1-2).

2. Hold the key in place and use a 12-mm or 3/8-inch nut driver to remove the

locking nut that holds the pawl in place, as shown in the first panel of FIGURE 1-2.

Caution – Be sure to hold the key in place. Otherwise there is a risk of breaking the

small tab on the lock that serves as a stop.

3. Lift the pawl off the threaded part of the lock body, as shown in the second panel

of FIGURE 1-2.

4. Set the pawl aside, face up, so that you can remember its orientation when you

replace it.

5. Use the key to turn the lock 180 degrees, as shown in the third panel of FIGURE 1-2

6. Replace the pawl in the same orientation as before, as shown in the fourth panel

of FIGURE 1-2.

7. Hold the key in place and use the nut driver to refasten the locking nut that holds

the pawl in place, as shown in the fifth panel of FIGURE 1-2. Be careful not to cross-

thread the nut.

Bezel locks

Chapter 1 Mounting the Array in Racks and Cabinets 1-5

FIGURE 1-2 Sequence of Steps to Change Front Bezel Locks So Keys Cannot Be Removed

Caution – Be sure to hold the key in place. Otherwise there is a risk of breaking the

small tab on the lock that serves as a stop.

8. Replace the bezel.

Note – To convert your bezel locks back so that the keys can be removed, repeat the

preceding steps.

Pawl

1-6 Sun StorEdge 3000 Family Rack Installation Guide for 2U Arrays • September 2003

Andere Handbücher für StorEdge 3000 Series

Inhaltsverzeichnis

Andere Sun Microsystems Server Handbücher

Sun Microsystems

Sun Microsystems Sun Ray 150 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Netra CT 810 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Ultra Enterprise 450 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Fire V100 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Fire X4140 Installations- und Betriebsanleitung

Sun Microsystems

Sun Microsystems Sun Fire V480 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Netra T4 AC100 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Ultra Enterprise 6000 Systems Benutzerhandbuch

Sun Microsystems

Sun Microsystems SUN FIRE 280R Bedienungsanleitung

Sun Microsystems

Sun Microsystems Netra X1 Service-Handbuch

Sun Microsystems

Sun Microsystems SPARC T5120 Service-Handbuch

Sun Microsystems

Sun Microsystems Sun Fire E6900 Technisches Handbuch

Sun Microsystems

Sun Microsystems Fire X4600 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Fire X4150 Server Bedienungsanleitung

Sun Microsystems

Sun Microsystems Enterprise Expansion Cabinet Optional Power... Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Fire X4100 Service-Handbuch

Sun Microsystems

Sun Microsystems Sun Fire V480 Handbuch

Sun Microsystems

Sun Microsystems Sun Fire V890 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Fire X2100 M2 Bedienungsanleitung

Sun Microsystems

Sun Microsystems SPARC T5120 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Fire X4250 Installations- und Betriebsanleitung

Sun Microsystems

Sun Microsystems Fire X4800 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Fire X4150 Server Bedienungsanleitung

Sun Microsystems

Sun Microsystems Netra CT 820 Bedienungsanleitung

Beliebte Server Handbücher anderer Marken

HP AlphaServer ES47 Bedienungsanleitung

Dell

Dell PowerEdge R410 Bedienungsanleitung

PowerNAS

PowerNAS CMA Bedienungsanleitung

Supero

Supero FatTwin F617R3-FT Bedienungsanleitung

MSI

MSI P1-109N-L70 Bedienungsanleitung

Dell

Dell PowerEdge XE9640 Handbuch

Dell

Dell PS4100 Montageanleitung

EtroVISION

EtroVISION EV3151 Bedienungsanleitung

NEC

NEC Express5800/T110j Bedienungsanleitung

HP ProLiant Gen9 Bedienungsanleitung

Compaq

Compaq ProLiant 3000 Handbuch

Dell

Dell PowerEdge 3YPMN Bedienungsanleitung

iRobo

iRobo IPC2U Bedienungsanleitung

Nortel

Nortel 1000 Con?guration guide Bedienungsanleitung

Asus

Asus AP7500 Bedienungs- und Wartungshandbuch

Avid Technology

Avid Technology AirSpeed 5000 Bedienungsanleitung

HP Integrity rx2600 Installationsanleitung

Milestone

Milestone Husky IVO 350T Bedienungsanleitung