Sun Microsystems SPARCstorage Library Bedienungsanleitung

SPARCstorageLibraryServiceManual

Part No.:802-2143-11

Revision A,June 1995

A Sun Microsystems, Inc. Business

2550 Garcia Avenue

Mountain View, CA 94043 U.S.A.

415 960-1300 FAX 415 969-9131

Warning – Procedures contained in this manual must be performed by

qualified service-trained maintenance providers.

Refer to the section ”Safety Information” in the Preface and Chapter 4, “Safety

Information.”

Please

Recycle

1995 Sun Microsystems, Inc.

2550 Garcia Avenue, Mountain View, California 94043-1100 U.S.A.

herein with their permission. This product and related documentation are protected by copyright and distributed under

licenses restricting its use, copying, distribution, and decompilation. No part of this product or related documentation may be

reproduced in any form by any means without prior written authorization of Sun and its licensors, if any.

Portions of this product may be derived from the UNIX®and Berkeley 4.3 BSD systems, licensed from UNIX System

Laboratories, Inc., a wholly owned subsidiary of Novell, Inc., and the University of California, respectively. Third-party font

software in this product is protected by copyright and licensed from Sun’s font suppliers.

RESTRICTED RIGHTS LEGEND: Use, duplication, or disclosure by the United States Government is subject to the restrictions

set forth in DFARS 252.227-7013 (c)(1)(ii) and FAR 52.227-19.

The product described in this manual may be protected by one or more U.S. patents, foreignpatents, or pending applications.

TRADEMARKS

Sun, the Sun logo, Sun Microsystems, SunDiag, and Solaris are trademarks or registered trademarks of Sun Microsystems, Inc.

in the U.S. and certain other countries. UNIX is a registered trademark in the United States and other countries, exclusively

licensed through X/Open Company, Ltd. OPEN LOOK is a registered trademark of Novell, Inc. PostScript and Display

PostScript are trademarks of Adobe Systems, Inc. All other product names mentioned herein are the trademarks of their

respective owners.

All SPARC trademarks, including the SCD Compliant Logo, are trademarks or registered trademarks of SPARC International,

Inc. SPARCstation, SPARCserver, SPARCengine, SPARCstorage, SPARCware, SPARCcenter, SPARCclassic, SPARCcluster,

SPARCdesign, SPARC811, SPARCprinter, UltraSPARC, microSPARC, SPARCworks, SPARCompiler and SPARCstorage are

licensed exclusively to Sun Microsystems, Inc. Products bearing SPARC trademarks are based upon an architecture developed

by Sun Microsystems, Inc.

The OPEN LOOK®and Sun™ Graphical User Interfaces were developed by Sun Microsystems, Inc. for its users and licensees.

Sun acknowledges the pioneering efforts of Xerox in researching and developing the concept of visual or graphical user

interfaces for the computer industry. Sun holds a non-exclusive license from Xerox to the Xerox Graphical User Interface,

which license also covers Sun’s licensees who implement OPEN LOOK GUIs and otherwise comply with Sun’s written license

agreements.

X Window System is a product of the X Consortium, Inc.

THIS PUBLICATION IS PROVIDED “AS IS” WITHOUT WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED,

INCLUDING, BUT NOT LIMITED TO, THE IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A

PARTICULAR PURPOSE, OR NON-INFRINGEMENT.

THIS PUBLICATION COULD INCLUDE TECHNICAL INACCURACIES OR TYPOGRAPHICAL ERRORS. CHANGES ARE

PERIODICALLY ADDED TO THE INFORMATION HEREIN; THESE CHANGES WILL BE INCORPORATED IN NEW

EDITIONS OF THE PUBLICATION. SUN MICROSYSTEMS, INC. MAY MAKE IMPROVEMENTS AND/OR CHANGES IN

THE PRODUCT(S) AND/OR THE PROGRAM(S) DESCRIBED IN THIS PUBLICATION AT ANY TIME.

iii

Contents

Preface. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . xvii

Part 1—System Information

1. Product Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1

1.1 Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4

1.1.1 Front Panel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4

1.1.2 Back Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6

1.1.3 Front Internal Components . . . . . . . . . . . . . . . . . . . . 1-7

1.1.4 Back Internal Components. . . . . . . . . . . . . . . . . . . . . 1-9

Part 2—Troubleshooting

2. Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1

2.1 Error Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2

2.1.1 Hardware Errors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2

2.1.2 SCSI Sense Key Errors . . . . . . . . . . . . . . . . . . . . . . . . 2-7

2.2 Tape Drive LEDs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-8

2.3 Primary Menu. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-9

iv SPARCstorage Library Service Manual—June 1995

▼To access the primary menu . . . . . . . . . . . . . . . . . . . 2-10

2.3.1 Interface Menu. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-11

2.3.1.1 Control Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . 2-11

▼To set the tape library to LCD Interface Mode 2-11

▼To set the tape library to SCSI Interface Mode 2-12

▼To set the tape library to Sequential CTS 1,

CTS 2, or Dual Sequential Modes . . . . . . . . . . 2-13

2.3.2 Configuration Menu. . . . . . . . . . . . . . . . . . . . . . . . . . 2-15

2.3.2.1 Set SCSI IDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-16

▼To view or change SCSI IDs . . . . . . . . . . . . . . . 2-17

2.3.2.2 Set SCSI Parity Checking . . . . . . . . . . . . . . . . . 2-18

▼To set parity checking . . . . . . . . . . . . . . . . . . . . 2-18

2.3.2.3 Sequential Options . . . . . . . . . . . . . . . . . . . . . . 2-19

▼To set the restart option. . . . . . . . . . . . . . . . . . . 2-19

▼To set the loop option . . . . . . . . . . . . . . . . . . . . 2-20

2.3.2.4 Adjust Contrast . . . . . . . . . . . . . . . . . . . . . . . . . 2-20

▼To adjust the contrast . . . . . . . . . . . . . . . . . . . . 2-20

2.3.2.5 Back Light. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-20

▼To turn the back light on or off . . . . . . . . . . . . 2-20

2.3.2.6 Set Date. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-21

▼To set the date. . . . . . . . . . . . . . . . . . . . . . . . . . . 2-21

2.3.2.7 Set Time. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-21

▼To set the time . . . . . . . . . . . . . . . . . . . . . . . . . . 2-21

2.3.2.8 Set Security. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-22

Contents v

▼To enable or disable security . . . . . . . . . . . . . . 2-22

2.3.2.9 Set Serial Number . . . . . . . . . . . . . . . . . . . . . . . 2-23

▼To enter the serial number into the firmware. 2-23

2.3.3 Maintenance Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-24

2.3.3.1 Clean Drive Menu . . . . . . . . . . . . . . . . . . . . . . . 2-24

2.3.3.2 Demo Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-24

▼To run the Drive Demo test . . . . . . . . . . . . . . . 2-24

▼To run the Slot Demo test . . . . . . . . . . . . . . . . . 2-26

2.3.3.3 Diagnostics Menu . . . . . . . . . . . . . . . . . . . . . . . 2-27

▼To run the Self Test . . . . . . . . . . . . . . . . . . . . . . 2-29

▼To run the Position to Element diagnostic . . . 2-30

▼To run the Park test . . . . . . . . . . . . . . . . . . . . . . 2-31

▼To run the Move Cartridge test . . . . . . . . . . . . 2-32

▼To run the Scan test . . . . . . . . . . . . . . . . . . . . . . 2-33

▼To run the Scan With Range test . . . . . . . . . . . 2-34

▼To run the Home Gripper test . . . . . . . . . . . . . 2-35

▼To run the Home CHM test . . . . . . . . . . . . . . . 2-35

▼To run the Cycle Pick/Place test . . . . . . . . . . . 2-36

▼To run the Cycle Gripper test. . . . . . . . . . . . . . 2-37

▼To run the Cycle S Axis test . . . . . . . . . . . . . . . 2-38

▼To run the Cycle L Axis test . . . . . . . . . . . . . . . 2-39

▼To run the Cycle Solenoid test . . . . . . . . . . . . . 2-40

2.3.4 Library Information Menu. . . . . . . . . . . . . . . . . . . . . 2-41

2.3.4.1 SCSI Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-41

vi SPARCstorage Library Service Manual—June 1995

▼To check or set the SCSI Mode Parameters. . . 2-42

2.3.4.2 Statistics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-45

▼To review statistics for the tape library. . . . . . 2-45

2.3.4.3 System Sensors. . . . . . . . . . . . . . . . . . . . . . . . . . 2-47

▼To check the status of the sensors . . . . . . . . . . 2-47

2.3.4.4 Command History. . . . . . . . . . . . . . . . . . . . . . . 2-48

▼To display the most recent history events . . . 2-48

2.3.4.5 Drive Info Menu . . . . . . . . . . . . . . . . . . . . . . . . 2-49

▼To display information from

the Drive Info Menu . . . . . . . . . . . . . . . . . . . . . 2-49

▼To determine the meaning of

the tape drive LEDs. . . . . . . . . . . . . . . . . . . . . . 2-51

▼To clean the tape drive using

the display panel . . . . . . . . . . . . . . . . . . . . . . . . 2-52

▼To manually clean a tape drive . . . . . . . . . . . . 2-54

2.3.4.6 Inventory Menu. . . . . . . . . . . . . . . . . . . . . . . . . 2-55

2.3.4.7 Label Info . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-55

▼To display bar code label information. . . . . . . 2-55

2.3.4.8 Occupied Info. . . . . . . . . . . . . . . . . . . . . . . . . . . 2-57

▼To display element occupied information . . . 2-57

2.3.4.9 Position Info . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-58

▼To display element position information . . . . 2-58

3. Diagnostics. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1

3.1 SunDiag System Exerciser. . . . . . . . . . . . . . . . . . . . . . . . . . 3-1

▼To set the SPARCstorage Library to one of

the Sequential Modes to run SunDiag . . . . . . . . . . . 3-1

Contents vii

3.2 Diagnostics Menu. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2

Part 3—Preparing for Service

4. Safety and Tool Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1

4.1 Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1

4.2 Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3

4.3 System Precautions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4

4.4 Tools and Equipment Required . . . . . . . . . . . . . . . . . . . . . 4-6

Part 4—Subassembly Removal and Replacement

5. Internal Access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1

5.1 Rack-Mounted Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1

5.1.1 Preparing to Remove the Tape Library . . . . . . . . . . 5-1

5.1.2 Removing the Tape Library . . . . . . . . . . . . . . . . . . . . 5-5

5.1.3 Removing the Top Cover . . . . . . . . . . . . . . . . . . . . . . 5-8

5.1.4 Replacing the Top Cover . . . . . . . . . . . . . . . . . . . . . . 5-9

5.1.5 Installing the Tape Library. . . . . . . . . . . . . . . . . . . . . 5-9

5.2 Tower Unit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-12

5.2.1 Removing the Top Cover . . . . . . . . . . . . . . . . . . . . . . 5-12

5.2.2 Removing the Right Plastic and Metal Panels. . . . . 5-14

5.2.3 Replacing the Right Plastic and Metal Panels . . . . . 5-16

5.2.4 Replacing the Top Cover . . . . . . . . . . . . . . . . . . . . . . 5-16

5.3 Tabletop Unit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-17

6. Removing and Installing Replacement Parts. . . . . . . . . . . . . . 6-1

6.1 Tape Drive in the Drive Carrier or Drive Blank . . . . . . . . 6-2

6.1.1 Removing the Drive Carrier or Drive Blank . . . . . . 6-2

viii SPARCstorage Library Service Manual—June 1995

6.1.2 Installing the Drive Carrier or Drive Blank . . . . . . . 6-5

6.2 Power Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6

6.2.1 Preparing to Remove and Replace

the Power Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6

6.2.2 Removing the Power Supply. . . . . . . . . . . . . . . . . . . 6-6

6.2.3 Installing the Power Supply . . . . . . . . . . . . . . . . . . . 6-11

6.3 Fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-13

6.3.1 Removing and Replacing the Fuse . . . . . . . . . . . . . . 6-13

6.4 SMC Controller Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-15

6.4.1 Preparing to Remove and Install

the SMC Controller Card . . . . . . . . . . . . . . . . . . . . . . 6-15

6.4.2 Removing the SMC Controller Card. . . . . . . . . . . . . 6-16

6.4.3 Install the SMC Controller Card . . . . . . . . . . . . . . . . 6-23

6.5 Bar Code Scanner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-26

6.5.1 Preparing to Remove and Install

the Bar Code Scanner . . . . . . . . . . . . . . . . . . . . . . . . . 6-26

6.5.2 Removing the Bar Code Scanner. . . . . . . . . . . . . . . . 6-27

6.5.3 Installing the Bar Code Scanner . . . . . . . . . . . . . . . . 6-31

Part 5—Illustrated Parts Breakdown

7. Illustrated Parts Breakdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1

7.1 Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1

Part 6—Appendixes, Glossary, Index

A. Product Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-1

A.1 Tape Drive Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . A-1

A.2 SPARCstorage Library Specifications . . . . . . . . . . . . . . . . A-3

Contents ix

A.2.1 External Dimensions. . . . . . . . . . . . . . . . . . . . . . . . . . A-3

A.2.2 Weight. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-4

A.2.3 Environmental Specifications . . . . . . . . . . . . . . . . . . A-4

A.2.4 Power Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . A-5

A.2.4.1 AC Input Voltages . . . . . . . . . . . . . . . . . . . . . . . A-5

A.2.4.2 AC Input Power. . . . . . . . . . . . . . . . . . . . . . . . . A-5

A.2.4.3 AC Power Consumption. . . . . . . . . . . . . . . . . . A-5

A.2.4.4 Fuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A-6

A.2.5 Safety and Regulatory Compliance Specifications . A-6

A.2.5.1 Safety Agency Standards . . . . . . . . . . . . . . . . . A-6

A.2.5.2 Electrostatic Discharge (ESD). . . . . . . . . . . . . . A-6

B. Functional Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . B-1

B.1 Elements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . B-1

B.2 Default Element Addresses. . . . . . . . . . . . . . . . . . . . . . . . . B-2

C. SCSI Targeting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-1

C.1 Relationship of the SPARCstorage Library

to the SCSI Bus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-1

C.1.1 Initiator or Host. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-1

C.1.2 SCSI Targets. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-2

C.1.3 SCSI Bus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-3

C.2 SCSI Guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-3

D. Error Codes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . D-1

D.1 Not Ready—Sense Key 2h. . . . . . . . . . . . . . . . . . . . . . . . . . D-2

D.2 Hardware Error—Sense Key 4h . . . . . . . . . . . . . . . . . . . . . D-2

xSPARCstorage Library Service Manual—June 1995

D.3 Illegal Request—Sense Key 5h . . . . . . . . . . . . . . . . . . . . . . D-5

D.4 Unit Attention—Sense Key 6h . . . . . . . . . . . . . . . . . . . . . . D-7

D.5 Aborted Command—Sense Key Bh . . . . . . . . . . . . . . . . . . D-8

Glossary. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Glossary-1

Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Index-1

Andere Handbücher für SPARCstorage Library

Inhaltsverzeichnis

Andere Sun Microsystems Lagerung Handbücher

Sun Microsystems

Sun Microsystems StorEdge 3900 Series Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorageTek T10000 Handbuch

Sun Microsystems

Sun Microsystems ZFS Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Enterprise 6500 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Enterprise Tape Library 4/1000 Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun Storage J4200 Stücklistenhandbuch

Sun Microsystems

Sun Microsystems Blade 6000 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorageTek SL500 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorEdge 5310 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorEdge3000 Series Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun StorEdge T3 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorEdge 6920 System Bedienungsanleitung

Sun Microsystems

Sun Microsystems Sun StorEdge T3 Einrichtungshandbuch

Sun Microsystems

Sun Microsystems Sun StorEdge 3900 Series Betriebsanleitung

Sun Microsystems

Sun Microsystems StorEdge 6120 Bedienungsanleitung

Sun Microsystems

Sun Microsystems storedge L25 Bedienungsanleitung

Sun Microsystems

Sun Microsystems SUN-OCC-SMC576 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorEdge 3510 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorageTek 6540 Montageanleitung

Sun Microsystems

Sun Microsystems StorageTek StreamLine SL8500 Gebrauchsanweisung

Sun Microsystems

Sun Microsystems StorageTek 5320 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorEdge L7 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorEdge 6130 Bedienungsanleitung

Sun Microsystems

Sun Microsystems StorEdge L400 Bedienungsanleitung

Beliebte Lagerung Handbücher anderer Marken

QNAP

QNAP TS 32PXU Series Bedienungsanleitung

LaCie

LaCie RUGGED RAID Bedienungsanleitung

Freecom

Freecom CLS DOCK Bedienungsanleitung

PNY

PNY Attache P-FD64MBATT3 Bedienungsanleitung

HP StorageWorks MSL2024 Bedienungsanleitung

OLT

OLT 6x6 Maximizer Bedienungsanleitung

Transcend

Transcend JetFlash 160 Bedienungsanleitung

LaCie

LaCie RUGGED MINI Bedienungsanleitung

Thunderbolt

Thunderbolt 600 Bedienungsanleitung

Panasonic

Panasonic LB-DH8 series Handbuch

Intel

Intel RAID High Availability Bedienungsanleitung

LaCie

LaCie 12big Thunderbolt 3 Bedienungsanleitung

Spectra Logic

Spectra Logic T-Series Spectra T50e Bedienungsanleitung

Panasonic

Panasonic LKM-F931-1 Bedienungsanleitung

Tabernus

Tabernus Enterprise Erase E2400 Bedienungsanleitung

Rocstor

Rocstor COMMANDER 3F series Bedienungsanleitung

HP P9000 Bedienungsanleitung

Western Digital

Western Digital Ultrastar Data60 Bedienungsanleitung