Sunjoy Fant L-DN1308SCO Bedienungsanleitung

1 of 11

OWNER’S MANUAL

Item# L-DN1308SCO

This appliance complies with “ANSI Z21.97-2014/CSA 2.41-2014, Outdoor Decorative Gas Appliances.

DANGER

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. If odor continues, keep away from the

appliance and immediately call your gas

supplier or fire department.

WARNING: For Outdoor Use Only.

WARNING:

Improper installation, adjustment, alteration,

service or maintenance can cause injury or

property damage. Read the installation,

operating and maintenance instructions

thoroughly before installing or servicing this

equipment.

WARNING

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or

any other appliance.

An LP-cylinder not connected for use should not be stored in the vicinity of this or any other

appliance.

DANGER CARBON MONOXIDE HAZARD

This appliance can produce carbon monoxide which has no odor.

Using it in an enclosed space can kill you.

Never use this appliance in an enclosed space such as a camper, tent,

car or home.

Propane tank not included

AA battery needed, not included

2 of 11

TABLE OF CONTENTS

General information …………….…….………………….………………..………….…… 2

Specification……….……………………………………….……………….……….……… 3

Important safety information and precaution……………….….….….….…….…… 3-4

Expanded view……………………………………………………….……….……..……… 5

Parts list……………………….………………………….…………………………….……6

Installation………………………….………………………..………………….…….………7

Location……………………………………………………………………….…….…….….. 8

Set up……………………………………………………………….…………….……...…… 8

Gas connection ………………………………….……………….……………….……… 8-9

Operation……………………………………………………………….……………...…….. 9

Leak check………………………………………………………….…………………...…… 9

Ignite lighting………………………………………………………….…………………. 9-10

Storage and Maintenance………………………………………….……...............… 10-11

Trouble shooting ………………………………………………...….………………..… 11

Limited warranty……………………………………………………………….….…… 11-12

Cleaning and maintenance………………………………………………………………12

GENERAL INFORMATION

IMPORTANT

Please take time to read these instructions thoroughly and follow each step carefully for safe

and easy operation. Keep this manual to consumer for installer and consumer future

reference/use. We would like to hear from you with any comments or suggestions. In the

continental U.S. or Canada, you can call us toll-free at 1-866-578-6569 from 8 a.m. to 5 p.m.

CST Monday –Friday.

You can also send us an email using the feedback icon at [email protected]

3 of 11

SPECIFICATION

IMPROTANT SAFETY INFORMATION AND PRECAUTION

When the appliance is for connection to a fixed piping system, the installation must conform with

local codes ,or in the absences of local codes with the National Fuel Gas Code, ANSI Z223.1/NFPA54;

International Fuel Gas Code, Natural Gas and Propane Installation Code, CSA B149.1;or Propane

Storage and Handling Code,B149.2,as applicable.

The LP gas supply cylinder to be used must be:

1- Constructed and marked in accordance with the U.S. Department of Transportation (D.O.T.)

Specifications for LP-Gas Cylinders, or the Standard for Cylinders, Spheres and Tubes for

transportation of Dangerous Goods and Commission, CAN/CSA-B339 as applicable;

2- Provided with a listed overfilling prevention device;

3- Provided with a cylinder connection device compatible with the connection for the appliance.

Always place the appliance on a firm and level surface.

Solid fuels shall not be burned in this gas appliance. Burn ONLY Tempered Glass (INCLUDED).

The appliance shall be used only outdoors in a well-ventilated space and shall not be used in a

building, garage or any other enclosed area.

When in use, keep the appliance area clear and at least 40 in / 101.6 cm side clearance from

combustible materials, gasoline and other flammable liquid and vapors. Do not use the appliance

under overhead combustible surfaces. Certain items or materials, when stored under the appliance or

nearby, will be subjected to radiant heat and could be damaged.

Inspect the hose assembly and burner prior to each use. If there is evidence of excessive abrasion

or wear or if the hose or burner is damaged, it must be replaced by appropriate part form the

manufacturer.

Inspect the gas connections of the appliance prior to each use. Do not to operate the unit if there is a

gas leak. Have the appliance inspected annually by a qualified service person.

Product name

Fant Fire Pit

Model NO.:

L-DN1308SCO

Rated Heat Input

38,000BTU/HR

Fuel

Propane-LP

Gas Supply

20 lb. LP-Gas cylinder

Manifold Pressure

11 Inches W.C.

Orifice Size (diameter)

1.75mm

Gas Supply Pressure

Max.250 PSI

4 of 11

The pressure regulator and hose assembly provided with the appliance must be used. The

replacement part must be the same as the part specified by manufacturer.

The assembly of LP-gas and leak checking, please refer to the “Gas connection”on page 8 and “leak

Test”on page 9.

Children and adults should be alerted to the hazards of high surface temperatures and should

stay away to avoid burns or prevent clothing ignition.

Young children and pets should be carefully supervised when they are in the area of the

appliance.

Any guard or other protective device removed for servicing the appliance must be replaced

prior to operation.

Clothing or other flammable materials should not be hung from the appliance.

Do not use the appliance if any part has been under water. Immediately call a qualified technician to

inspect the appliance and to replace any part of the control system and any gas control which has been

under water.

LP-gas supply cylinder to be used must be constructed and marked in accordance with the

specifications for LP-gas cylinders of the U.S. Department of Transportation (DOT).

The cylinder supplies system must be arranged for vapor withdrawal and the cylinder must include a

collar to protect the cylinder valve.

Use only 20 lb / 9 kg LP-Gas cylinders.

Do not burn wood or any other materials in this appliance.

The appliance must be isolated from the gas supply piping system by

closing its individual manual shutoff valve during any pressure testing of

the gas supply piping system at test pressure equal to or less than 1/2psi

(3.5kPa).

Properly place the hose out of pathways where people may trip over it or in areas where there may

be subject to accidental damage.

The burner must be replaced prior to the appliance being put into operation if it is evident that the

burner is damaged. The replacement burner must be the same as the part specified by manufacturer.

The cleaning of the appliance including the burner, please refer to “Clean and Maintenance”on page

12.

5 of 11

EXPANDED VIEW

6 of 11

NO.

Description

Qty

Cover

Table Base

Box

Door

Cullet (Tempered Glass)

1 (2.5KG)

Armor Plate Screen

Windshield 2

Windshield 1

Ignition Wire

Battery Box

Control Knob

Control Valve

Pressure Regulator

Nozzle Subassembly

Thermocouple

Nozzle Support Bar

Burner

Fire Bowl

Parts List

If you want to replace the parts listed, please contact Customer Service Center: 1-866-578-6569.

7 of 11

LOCATION

Your Gas appliance must be installed on a flat, stable surface, away from any combustible materials or

construction.

SET-UP

Your Gas appliance comes assembled, ready for a Gas connection.

1- Remove the appliance from container box and place it on any level, outdoor, non-combustible

surface.

NOTE: Do not place this appliance on grass or dirt area. This may prevent proper safety venting.

2- Open the gas door, put the cylinder inside.

3- Unscrew the battery box as shown in Fig 1.Insert the negative electrode side of the battery into the

bottom of battery box as shown in Fig 2. Then screw the battery box as shown in Fig 3.

Fig 1 Fig 2 Fig 3

Note: If the battery of the pulse electronic igniter runs out of power, please replace the new battery as

above.

Gas Connection

1- Open the door, put the chain and control valve outside. See Fig 4.

2- Put the cylinder into the cylinder rack. See Fig 5.

3- Connect the regulator and the cylinder as per Fig.6. Make sure there is no leakage or damage

(please refer to “Leak Test”on page 9 and the damage checking on page 4).

4- Fix the cylinder by the chain. See Fig 7.

8 of 11

OFF

HIGH

MAX

BAS

ARRET

LOW

OPERATION

LEAK TEST

1- Make sure the control knob is on the “OFF”position.

2- Make sure the gas cylinder is correctly and securely connected to the pressure regulator, without

over tightening it.

3- Turn on the gas cylinder valve. Apply 50% soap and 50% water solution to the gas hose and

connections between the control knob and gas cylinder.

4- If something is leaking, you will see bubbles form. In case of leaks, turn off the gas supply, undo the

leaking connection, re-connect it and try again. If the leak persists, consult Customer Service Center for

assistance.

5- If the connection is sound, continue to the next step.

IGNITE LIGHTING

1- Make sure control valve is OFF.

2- Turn on gas tank valve.

3- Press in and turn control valve knob counterclockwise

to High to ignite. See the figure to the right.

4- If burner is lit, do not stop pressing in the control valve knob for

a minute to heat the thermocouple.

5- When control valve knob is released, the burner should be lit. If not, turn control valve knob

clockwise to OFF. Wait 5 minutes after completing Step 3 before attempting to re-ignite.

6- Press in and turn control valve knob to desired heat input, HIGH ~ LOW.

!!!WARNING!!!

Do not use an open flame to check for leaks.

Do not smoke during testing.

Do not test indoors.

A leak check must be performed whenever the gas cylinder is replaced.

Fig 6

9 of 11

NOTE: While in use, the burner flame should be mainly blue in appearance with a small amount of yellow.

The flame can be identified by the following figure.

Warning: Lighting the appliance improperly could lead to an unsafe condition.

7- Press in and turn the control valve knob clockwise to OFF to shut down appliance. Close the gas

cylinder valve when the appliance is not in use.

(CAUTION: Do not kink flexible gas hose. If it is kinked, a gas leak could occur.)

STORAGE AND MAINTENANCE

To obtain the best performance from your appliance, you must perform the following storage and

maintenance activities on a regular basis:

Allow at least 35 minutes for the appliance to cool down after use, before disconnecting and

removing the gas cylinder.

Store the gas cylinder in a dry, well-ventilated and sheltered area protected from inclement weather

and dust, out of the reach of children, and not in a building, garage or any other closed area.

The appliance may be stored indoors only if the cylinder is disconnected and removed.

Keep the appliance area clear and free from combustible materials, gasoline and other flammable

vapors and liquids.

Installation and repair should be done by a qualified service person. The appliance should be

inspected before use and at least annually by a qualified service person. More frequent cleaning

may be required as necessary it is imperative that the control compartment,

Burner and circulating air passageways of the appliance be kept clean.

If disassemble the burner when cleaning the appliance, please reassemble

it according to the picture on the right to make sure the burner induction tunnel is

on and exactly cover the orifice base. It is imperative that the control compartment, burner and

circulating air passageways of the appliance be kept clean. It is recommended not to disassemble

the burner.

Incorrect Flame

Y E LLO W T IPS

B LU E

H IG H

LO W

Correct Flame

BLUE LOW

10 of 11

Permanent installation and repair should be done by a qualified service person. The appliance

should be inspected annually by a qualified service person.

TROUBLE SHOOTING

PROBLEM OBSERVED

POSSIBLE CAUSE

CORRECTIVE MEASURES

Gas odor

—Gas leak

—See “If you smell gas:” on front

cover of manual

—Check all gas connections

Delayed ignition

—Low gas pressure

—Clogged or dirty burner

ports

—Blocked orifice

—Spent battery

—Check gas supply pressure

—Clean burner ports, see manual

section

—Check orifice opening

—Change a new battery

Incorrect burner flame

—Incorrect gas supply or

pressure

—Blocked orifice

—Clogged or dirty burner

ports

—Check gas supply pressure

—Check and clean orifice opening

—Clean burner ports

If you want to replace the parts listed, please contact Customer Service Center: 1-888-301-0332.

LIMITIED WARRANTY

Subject to the conditions set out below, this product is warranted to the original purchaser to be free from

defects in workmanship and materials for twelve (12) months from the date of purchase.

Satisfactory proof of the purchase date must be furnished at the time of notification of the defect for

any claim under the warranty to be enforceable.

This warranty covers all parts found defective in workmanship and/or materials during the warranty

period and can be repaired or replaced at the discretion of the manufacturer at no cost to the original

purchaser.

This warranty will be void if the product has not been assembled, installed or operated according to

the instructions, or subjected to abuse, improperly treated, neglected, rusted by exposure to the

elements, misused and/or if any repairs, maintenance, or service has been done by an unauthorized

person.

Returns must be properly packaged and freight prepaid to the dealer from whom the product was

acquired.

The manufacturer, distributor and retailer will not be liable for any incidental or consequential loss or

Inhaltsverzeichnis

Andere Sunjoy Außenkamin Handbücher

Sunjoy

Sunjoy HAMPTON A301004901 Bedienungsanleitung

Sunjoy

Sunjoy L-DN1123SCO-B Bedienungsanleitung

Sunjoy

Sunjoy A301016300 Bedienungsanleitung

Sunjoy

Sunjoy Augusta L-FT1101PST-M Bedienungsanleitung

Sunjoy

Sunjoy A301002400 Bedienungsanleitung

Sunjoy

Sunjoy L-FT456PST-2B Bedienungsanleitung

Sunjoy

Sunjoy Grandview A208001100 Bedienungsanleitung

Sunjoy

Sunjoy Vail L-FT769PST Bedienungsanleitung

Sunjoy

Sunjoy HD PORTOFINO Bedienungsanleitung

Sunjoy

Sunjoy D-FT005PST Bedienungsanleitung

Sunjoy

Sunjoy L-DN1856SST-E-T Bedienungsanleitung

Sunjoy

Sunjoy D-FT004PST Betriebsanleitung

Sunjoy

Sunjoy D-FT013PST Bedienungsanleitung

Sunjoy

Sunjoy Manhattan L-DN2523SST-B-T Bedienungsanleitung

Sunjoy

Sunjoy Heirloom Bay L-DN1202SST Bedienungsanleitung

Sunjoy

Sunjoy L-FT253PST-6A-1 Bedienungsanleitung

Sunjoy

Sunjoy L-FT1101PST-B Bedienungsanleitung

Sunjoy

Sunjoy A301016200 Bedienungsanleitung

Sunjoy

Sunjoy L-FT231PST Bedienungsanleitung

Sunjoy

Sunjoy L-FT563PST Bedienungsanleitung

Sunjoy

Sunjoy Costa A301017500 Bedienungsanleitung

Sunjoy

Sunjoy A208020000 Bedienungsanleitung

Sunjoy

Sunjoy Courtyard L-DN2193SST-B-T Bedienungsanleitung

Sunjoy

Sunjoy L-FT710PST Benutzerhandbuch

Beliebte Außenkamin Handbücher anderer Marken

Outdoor Plus

Outdoor Plus PISMO OPT-2448 Bedienungsanleitung

Legacy

Legacy Fire Pit Bedienungsanleitung

Coleman

Coleman 5055-710 Bedienungsanleitung

Jensen

Jensen 300NG Bedienungsanleitung

FEUERHAND

FEUERHAND PYRON Bedienungsanleitung

Firegear

Firegear KWB-NG1 Kurzanleitung

Classics

Classics FP35077 Bedienungsanleitung

Jensen

Jensen 1590LP Bedienungsanleitung

Mayer Barbecue

Mayer Barbecue HEIZA MFK-220 Bedienungsanleitung

Costway

Costway NP11018 Bedienungsanleitung

Target

Target Foxborough Bedienungsanleitung

Blumfeldt

Blumfeldt Merano Bedienungsanleitung

Blooma

Blooma Brasero Ulong Bedienungsanleitung

The Fireplace

The Fireplace JETMASTER 700 D Bedienungsanleitung

Superior

Superior VRE4543EN Bedienungsanleitung

Morsø

Morsø Forno Bedienungsanleitung

dobar

dobar CONICO 35439E Bedienungsanleitung

EAST OAK

EAST OAK GFT22001 Bedienungsanleitung