Sunjoy L-DN1377SAL-A Bedienungsanleitung

Made In China 1 / 11

ASSEMBLY INTRUCTION

ITEM#：L-DN1377SAL-A

D-DN1377SAL-A

L-DN1499PAL

L-DN1500PAL

This appliance complies with “ANSI Z21.97-2014/CSA 2.41-2014, Outdoor Decorative Gas Appliances.

WARNING: For Outdoor Use Only.

WARNING

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

An LP-cylinder not connected for use should not be stored in the vicinity of this or any other appliance.

DANGER CARBON MONOXIDE HAZARD

This appliance can produce carbon monoxide which has no odor.

Using it in an enclosed space can kill you.

Never use this appliance in an enclosed space such as a camper, tent, car or home.

Propane tank not included

AA battery needed, not included

DANGER

If you smell gas:

Shut off gas to the appliance.

Extinguish any open flame.

If odor continues, keep away from the

appliance and immediately call your gas supplier or fire

department.

WARNING: Improper installation, adjustment,

alteration, service or maintenance can cause injury or

property damage. Read the installation, operating and

maintenance instructions thoroughly before installing or

servicing this equipment.

Made In China 2 / 11

TABLE OF CONTENTS

General information

…………………………………………………………………………………..

Specifications

………………………………………………………………………………………..

Important safety information and precaution

……………………………………………………

3-4

Expanded view

………………………………………………………………………………………..

Parts list

……………………………………………………………………………………………….

Installation

……………………………………………………………………………………………

Location

……………………………………………………………………………………………….

Set up

…………………………………………………………………………………………………...

Gas connection

………………………………………………………………………………………….

8-9

Operation

……………………………………………………………………………………………….

Leak check

……………………………………………………………………………………………...

Ignition

…………………………………………………………………………………………………

9-10

Storage and Maintenance

…………………………………………………………………………….

10-11

Trouble shooting

……………………………………………………………………………………...

Limited warranty

……………………………………………………………………………………...

Cleaning and maintenance

………………………………………………………………………..

GENERAL INFORMATION

IMPORTANT

For technical assistance on assembly or replacement parts, you can call us toll-free at 1-866-578-6569 from 8 a.m. EST

to 8 PM PST. You may email to customer.care@sunjoygroup.com or visit www.sunjoyonline.com to place your order

or fax your parts replacement order form together with your purchase receipt to 1 (740) 283-3549 for assistance.

Made In China 3 / 11

SPECIFICATIONS

IMPORTANT SAFETY INFORMATION AND PRECAUTION

When the appliance is for connection to a fixed piping system, the installation must conform with local codes ,or in

the absences of local codes with the National Fuel Gas Code, ANSI Z223.1/NFPA54; International Fuel Gas Code,

Natural Gas and Propane Installation Code, CSA B149.1;or Propane Storage and Handling Code,B149.2,as applicable.

The LP gas supply cylinder to be used must be:

1- Constructed and marked in accordance with the U.S. Department of Transportation (D.O.T.) Specifications

for LP-Gas Cylinders, or the Standard for Cylinders, Spheres and Tubes for transportation of Dangerous Goods

and Commission, CAN/CSA-B339 as applicable;

2- Provided with a listed overfilling prevention device;

3- Provided with a cylinder connection device compatible with the connection for the appliance.

Always place the appliance on a firm and level surface.

Solid fuels shall not be burned in this gas appliance. Burn ONLY Tempered Glass (INCLUDED).

The appliance shall be used only outdoors in a well-ventilated space and shall not be used in a building, garage or

any other enclosed area.

When in use, keep the appliance area clear and at least 40 in / 101.6 cm side clearance from combustible materials,

gasoline and other flammable liquid and vapors. Do not use the appliance under overhead combustible surfaces. Certain

items or materials, when stored under the appliance or nearby, will be subjected to radiant heat and could be damaged.

Inspect the hose assembly and burner prior to each use. If there is evidence of excessive abrasion or wear or if the

hose or burner is damaged, it must be replaced by appropriate part form the manufacturer.

Inspect the gas connections of the appliance prior to each use. Do not to operate the unit if there is a gas leak. Have the

appliance inspected annually by a qualified, service person.

The pressure regulator and hose assembly provided with the appliance must be used. The replacement part must be

Model NO.

L-DN1377SAL-A/D-DN1377SAL-A/ L-DN1499PAL

Rated Heat Input

50,000BTU/HR

Fuel

Propane-LP

Gas Supply

20 lb. LP-Gas cylinder

Manifold Pressure

11 Inches W.C.

Orifice Size (diameter)

2.18mm

Gas Supply Pressure

Max.250 PSI

Made In China 4 / 11

the same as the part specified by manufacturer.

The assembly of LP-gas and leak checking, please refer to the “Gas connection” on page 8 and “Leak Test” on page 9.

Children and adults should be alerted to the hazards of high surface temperatures and should stay away to

avoid burns or prevent clothing ignition.

Young children and pets should be carefully supervised when they are in the area of the appliance.

Any guard or other protective device removed for servicing the appliance must be replaced prior to operation.

Clothing or other flammable materials should not be hung from the appliance.

Do not use the appliance if any part has been under water. Immediately call a qualified technician to inspect the

appliance and to replace any part of the control system and any gas control which has been under water.

LP-gas supply cylinder to be used must be constructed and marked in accordance with the specifications for LP-gas

cylinders of the U.S. Department of Transportation (DOT).

The cylinder supplies system must be arranged for vapor withdrawal and the cylinder must include a collar to protect

the cylinder valve.

Use only 20 lb / 9 kg LP-Gas cylinders.

Do not burn wood or any other materials in this appliance.

The appliance must be isolated from the gas supply piping system by closing its

individual manual shutoff valve during any pressure testing of the gas supply piping

system at test pressure equal to or less than 1/2psi (3.5kPa).

Properly place the hose out of pathways where people may trip over it or in areas

where there may be subject to accidental damage.

If it is evident that the burner is damaged, the burner must be replaced prior to the appliance being put into operation.

The replacement burner must be the same as the part specified by manufacturer.

For cleaning of the appliance including the burner, please refer to “Clean and Maintenance” on page 12.

Made In China 5 / 11

EXPANDED VIEW

Made In China 6 / 11

PARTS LIST

Label

Part Number

Description

QTY

DN1499XXX01

Lazy Susan

DN1499XXX02

Table Top

DN1499XXX03

Main Body

DN1499XXX04

Base

LPSBLSH41

Cullet (Tempered Glass)

1 (4.1KG)

DN1499XXX05

Armor Plate Screen

DN1499XXX06

Windshield 1

DN1499XXX07

Windshield 2

LPDHZXY1L07

Ignition Wire

LPDHQ2W35D27

Battery Box

LPKGXN01

Control Knob

LPFB14WB14HXD

Control Valve

LPJYF070N

Pressure Regulator

DN1499XXX08

Nozzle Subassembly

LPRD07

Thermocouple

DN1499XXX09

Nozzle Support Bar

LPFRT2421

Burner

DN1499XXX10

Fire Bowl

PARTS LIST

Label

Part Number

Description

QTY

Image of Part

YM06015C

Bolt M6x15

VD06C

Flat Washer M6

TD06C

Spring Washer M6

A04D

Spanner

Made In China 7 / 11

INSTALLATION

Installation will be much easier with two or more people.

Fig 1: Put Table Top (B) on Main Body (C), then use Bolt (AA) to lock them from the bottom up.

Fig 2: Put Lazy Susan (A) on Table Top (B).

If you want to replace any of the parts listed, please contact Customer Service Center: 1-866-578-6569.

Made In China 8 / 11

LOCATION

Your Gas appliance must be installed on a flat, stable surface, away from any combustible materials or construction.

SET-UP

Your Gas appliance comes assembled, ready for a Gas connection.

1- Remove the appliance from container box and place it on any level, outdoor, non-combustible surface.

NOTE: Do not place this appliance on grass or dirt area. This may prevent proper safety venting.

2- Open the gas door, put the cylinder inside.

3- Unscrew the battery box as shown in Fig 1.Insert the negative electrode side of the battery into the bottom of battery

box as shown in Fig 2. Then screw the battery box as shown in Fig 3.

Fig 1 Fig 2 Fig 3

Note: If the battery of the pulse electronic igniter runs out of power, please replace the new battery as shown above.

Gas Connection

1- Open the door, put the chain and control valve outside. See Fig 4.

2- Put the cylinder into the cylinder rack. See Fig 5.

3- Connect the regulator and the cylinder as per Fig.6. Make sure there is no leakage or damage (please refer to “Leak Test”

on page 9 and the bullet checkpoints on Page 4).

4- Secure the cylinder by the chain. See Fig 7.

Fig 7

Fig 4

Fig 5

Fig 6

Made In China 9 / 11

OPERATION

LEAK TEST

1- Make sure the control knob is on the “OFF” position.

2- Make sure the gas cylinder is correctly and securely connected to the pressure regulator, without over tightening it.

3- Turn on the gas cylinder valve. Apply a 50% soap and 50% water solution to the gas hose and connections between

the control knob and gas cylinder.

4- If something is leaking, you will see bubbles form. In case of leaks, turn off the gas supply, undo the leaking

connection, re-connect it and try again. If the leak persists, consult Customer Service Center for assistance.

5- If the connection is sound, continue to the next step.

Ignition

1- Make sure control valve is OFF.

2- Turn on gas tank valve.

3- Press in and turn control valve knob counterclockwise

to High to ignite. See the figure to the right.

4- If burner is lit, do not stop pressing in the control valve knob for

1 minute to heat the thermocouple.

5- When control valve knob is released, the burner should be lit. If not, turn control valve knob clockwise to OFF. Wait 5

minutes after completing Step 3 before attempting to re-ignite.

6- Press in and turn control valve knob to desired heat input, HIGH ~ LOW.

NOTE: While in use, the burner flame should be mainly blue in appearance with a small amount of yellow. The flame can

be identified by the following figure.

!!!WARNING!!!



Do not use an open flame to check for leaks.



Do not smoke during testing.



Do not test indoors.

A leak check must be performed whenever the gas cylinder is replaced.

Incorrect Flame

Y ELLO W T IPS

B LU E

H IG H

LO W

Correct Flame

LOW

HIGH

OFF

Made In China 10 / 11

STORAGE AND MAINTENANCE

To obtain the best performance from your appliance, you must perform the following storage and maintenance activities on

a regular basis:

Allow at least 35 minutes for the appliance to cool down after use, before disconnecting and removing the gas

cylinder.

Store the gas cylinder in a dry, well-ventilated and sheltered area protected from inclement weather and dust, out of

the reach of children, and not in a building, garage or any other closed area.

The appliance may be stored indoors only if the cylinder is disconnected and removed.

Keep the appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

Installation and repair should be done by a qualified service person. The appliance should be inspected before

use and at least annually by a qualified service person. More frequent cleaning may be required as necessary it is

imperative that the control compartment,

burner and circulating air passageways of the appliance be kept clean.

If you disassemble the burner when cleaning the appliance, please reassemble

it according to the picture on the right to make sure the burner induction tunnel is

on and exactly cover the orifice base.

TROUBLE SHOOTING

PROBLEM OBSERVED

POSSIBLE CAUSE

CORRECTIVE MEASURES

Gas odor

—Gas leak

—See “If you smell gas:” on front cover of

manual

—Check all gas connections

Delayed ignition

—Low gas pressure

—Clogged or dirty burner ports

—Blocked orifice

—Spent battery

—Check gas supply pressure

—Clean burner ports, see manual section

—Check orifice opening

—Change a new battery

Incorrect burner flame

—Incorrect gas supply or pressure

—Blocked orifice

—Clogged or dirty burner ports

—Check gas supply pressure

—Check and clean orifice opening

—Clean burner ports

If you want to replace and of the parts listed, please contact Customer Service Center: 1-866-578-6569..

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sunjoy Außenkamin Handbücher

Sunjoy

Sunjoy A301016300 Bedienungsanleitung

Sunjoy

Sunjoy A302003700 Bedienungsanleitung

Sunjoy

Sunjoy L-FT253PST-6A-1 Bedienungsanleitung

Sunjoy

Sunjoy D-FT013PST Bedienungsanleitung

Sunjoy

Sunjoy Stoneridge L-DN1773SST-D-T Bedienungsanleitung

Sunjoy

Sunjoy Augusta L-FT1101PST-M Bedienungsanleitung

Sunjoy

Sunjoy Courtyard L-DN2193SST-B-T Bedienungsanleitung

Sunjoy

Sunjoy L-FT723PST-D Bedienungsanleitung

Sunjoy

Sunjoy Vail L-FT769PST Bedienungsanleitung

Sunjoy

Sunjoy D-FT480PST-E Bedienungsanleitung

Sunjoy

Sunjoy A301016500 Bedienungsanleitung

Sunjoy

Sunjoy L-OF079PST-1 Bedienungsanleitung

Sunjoy

Sunjoy HD PORTOFINO Bedienungsanleitung

Sunjoy

Sunjoy D-FT370PCO-4 Bedienungsanleitung

Sunjoy

Sunjoy L-FT1097PST-A Betriebsanleitung

Sunjoy

Sunjoy L-FT231PST Bedienungsanleitung

Sunjoy

Sunjoy Grandview A208001100 Bedienungsanleitung

Sunjoy

Sunjoy L-CM057PST-2 Bedienungsanleitung

Sunjoy

Sunjoy L-FT710PST Benutzerhandbuch

Sunjoy

Sunjoy D-FT007PST Bedienungsanleitung

Sunjoy

Sunjoy D-FT009PST Bedienungsanleitung

Sunjoy

Sunjoy Costa A301017500 Bedienungsanleitung

Sunjoy

Sunjoy Squaw Valley L-FT629PST Bedienungsanleitung

Sunjoy

Sunjoy L-FT039PSS-A Bedienungsanleitung

Beliebte Außenkamin Handbücher anderer Marken

Outdoor Plus

Outdoor Plus PISMO OPT-2448 Bedienungsanleitung

Legacy

Legacy Fire Pit Bedienungsanleitung

Coleman

Coleman 5055-710 Bedienungsanleitung

Jensen

Jensen 300NG Bedienungsanleitung

FEUERHAND

FEUERHAND PYRON Bedienungsanleitung

Firegear

Firegear KWB-NG1 Kurzanleitung

Classics

Classics FP35077 Bedienungsanleitung

Jensen

Jensen 1590LP Bedienungsanleitung

Mayer Barbecue

Mayer Barbecue HEIZA MFK-220 Bedienungsanleitung

Costway

Costway NP11018 Bedienungsanleitung

Target

Target Foxborough Bedienungsanleitung

Blumfeldt

Blumfeldt Merano Bedienungsanleitung

Blooma

Blooma Brasero Ulong Bedienungsanleitung

The Fireplace

The Fireplace JETMASTER 700 D Bedienungsanleitung

Superior

Superior VRE4543EN Bedienungsanleitung

Morsø

Morsø Forno Bedienungsanleitung

dobar

dobar CONICO 35439E Bedienungsanleitung

EAST OAK

EAST OAK GFT22001 Bedienungsanleitung