The boss SRCH51101 Bedienungsanleitung
PORTABLE INFRARED HEATER
Adequate ventilation must be provided.
WARNING: NOT FOR HOME OR RECREATIONAL VEHICLE USE.
ANSI Z83.7/CSA 2.14-2000,
ANSI Z83.7a/CSA 2.14a-2007,
ANSI Z83.7b/CSA 2.14b-2009.
4:30 CST
Model SRCH51101:Suitable for 4.5 lb gas cylinder ( included )
Model SRCH51101A: Suitable for 5 lb gas cylinder ( not included )
2
SAFETY INFORMATION
YOU
IMPROPER
GENERATES
-
INSTRUCTION MANUAL
3
SAFETY INFORMATION
The heater is designed for use as a construction heater in accordance with ANSI Z83.7/CSA 2.14-2000,
ANSI Z83.7a/CSA 2.14a-2007, ANSI Z83.7b/CSA 2.14b-2009. Other standards govern the use of
Check with your local fire safety authority if you have
questions about heater use.
Carbon Monoxide Poisoning:
Propane Gas:
to safe and proper operation of this heater.
1. The installation must conform with local codes or, in the absence of local codes, with the Stan-
square inches (774.2 cm ) of fresh, outside air before using heater.
2
area.
content.
9. Minimum heater clearances from combustibles: Sides - 3 feet (0.91 m), Top - 6 feet (1.83 m).
10. Keep cylinder(s) below 120
once.
t be replaced prior to the heater being put
and Propane
Installation Code,CSA B149.1.
or any type of unvented or enclosed
dard
49
15
14
12
4.
13
11
Some areas are affected by carbon monxide more than others. Early signs of carbon monoxide
poisoning resemble the flu, with headaches, dizziness and/or nausea. If you have these signs, TURN
THE HEATER OFF IMMEDIATELY, move to a well-ventilated area with ample fresh air, and contact
your physician immediately
for proper ventilation and have heater serviced
.
For indoor use only. When used indoors, area must be well-ventilated.
When properly used, the heater provides safe and economical
heating.
4
SAFETY INFORMATION
16. Do not use heater if altered.
17. Operate this heater only on a stable and level surface.
18. Never block air inlet (top of base) or air outlet (around top of shell) of heater.
19. Keep heater away from strong drafts, wind, water spray, rain, or dripping water.
20. Never operate this heater while sleeping. Never leave the heater unattended while in operation.
21. Keep children and animals away from heater.
22. Never move, handle or service a hot or operating heater. Severe burns may result. You must wait
15 minutes after turning heater off.
23. To prevent injury, wear gloves when handling heater.
24. Always remove cylinder from heater after each use. Always store cylinder outdoors in a well
ventilated space out of the reach of children. Never store cylinder in a building, garage, or any
other enclosed area. Never store cylinder near high heat,
exceed 120°F (49° C).
25. Turn off propane supply to heater when not in use.
26. Use only original replacement parts. This heater must use design-specific parts. Do not substitute
or use generic parts. Improper replacement parts could cause serious or fatal injuries.
27. Keep all connections and fittings clean. Make sure cylinder valve outlet is clean. Check the rubber
“O” ring on the heater inlet fuel connector for damage before each use. Replace if worn or
damaged.
28. The heater should not face directly toward any propane gas container within 20 feet (6m).
29. This appliance can only be installed in a building under construction, repair or improvement;
and can not be installed in any inhabited dwelling unit or inhabited sections of a building.
UNPACKING
1. Remove all packing items applied to heater for shipment. Keep plastic cover caps (attached to
inlet connector and hose/regulator assembly) for storage.
2. Remove all items from carton.
3. Check all items for shipping damage. If heater is damaged, promptly inform retailer where you
bought heater.
5
TABLE OF CONTENTS
2
4
6
6
8
8
9-13
14
15
16
16
6
17
18
Safety Information..................................................................................................................
Unpacking..............................................................................................................................
Ventilation................................................................................................................................
Propane Supply......................................................................................................................
Parts List.................................................................................................................................
Replacement Parts.................................................................................................................
Installation..............................................................................................................................
Safety Check...........................................................................................................................
Operation..............................................................................................................................
Storage & Maintenance.........................................................................................................
Burner Check........................................................................................................................
......................................................................................................
Troubleshooting....................................................................................................................
Warranty and Repair Service................................................................................................
7
Exploded View.................................................................................................................................
Operating Specifications
6
Operating Specifications
Fuel System: The hose/regulator assembly attaches to the propane gas supply. This provides
fuel to the heater.
Ignition System: Integrated Ignition lights the burner.
VENTILATION
WARNING:
Provide at least 120 square inches (774.2 cm2) opening of fresh,
outside air while running heater. If proper fresh, outside air ventilation is not provided,
carbon monoxide poisoning can occur. Provide proper fresh, outside air ventilation
before running heater.
PROPANE SUPPLY
Use this heater only with a propane vapor withdrawal supply system.
Fuel Information
Only
T
Position
Rating
Fuel
Consumption/Hour
0.47 lb
(0.21 kg) (0.42 kg)
10,000 Btu/Hr 20,000 Btu/Hr
HIGH
This heater is designed to operate with 4.5lb or 5lb cylinder.
The cylinder quantity relies on envionment and temperature variables. Less gas is vaporized at lower
temperatures. Your local propane gas dealer will help you select the proper supply system.
7
EXPLODED VIEW
8
PARTS LIST
1. Guard
2. Burner assembly
3. Badge
4. Front panel
5. Door locker
6. Hanging ring
7. Hanging ring bracket
8. Left side shield
9. Anti-tilt switch
10. Left side panel
11. Corner shield
12. Valve
13. Knob bezel
14. Knob
15. Burner assembly shield 1
16. Handle A
17. Handle B
18. Locking ring
19. Valve baffle
20. Buckle
21. Regulator and hose assembly
22. Door
23. Door axis
24. Cylinder connection bar
25. 4.5 lbs gas cylinder
26. Cylinder fixing wire
27. Right side shield
28. Support pole A
29. Right side panel
30. Support pole B
31. Top panel
32. Cylinder connection bar brac-
ket
33. Bottom panel
34. Cylinder holder
35. Washer 2
36. Washer 1
1pc
1pc
1pc
1pc
1pc
2pcs
2pcs
1pc
1pc
1pc
4pcs
1pc
1pc
1pc
1pc
1pc
1pc
1pc
1pc
1pc
1pc
1pc
2pcs
1pc
1pc
1pc
1pc
2pcs
1pc
2pcs
1pc
2pcs
1pc
1pc
2pcs
4pcs
REF.# DESCRIPTION QTY REF.# DESCRIPTION QTY
37. Burner assembly shield 3 1pc
REPLACEMENT PARTS
WARNING: Use only original
replacement parts. This heater
must use parts.
Do not substitute or use generic
parts. Improper replacement
parts could cause serious or fa-
PARTS UNDER WARRANTY
If burner will not light after repeated tries,
do not attempt to repair heater. Call Shinerich
customer service at: 1-866-814-0585.
When calling Shinerich , have ready
your name and address
how heater was malfunctioning
purchase date
model and serial numbers of your heater
38. Burner assembly shield 2 1pc
39. Sling strap 1pc
tal injuries. Using original
replacement parts will also pro-
tect your warranty coverage for -
parts replaced under warranty.
9
INSTALLATION
WARNING: Test all gas piping and connections for leaks after installation or
service. Never use an open flame to check for a leak. Apply a mixture of liquid
soap and water to all joints. If there is a leak, bubbles will form. Correct all leaks
immediately.
STEP 1
STEP 2
Press the two door buckles at the same time and then open the door (22).
5
22
Turn the door locker (5) to unlocked position“ ”as shown.
Door buckle
Unlocked
10
INSTALLATION
Step 3
Step 4
35
D5 washers 4pcs
M5 x 18 bolts 4pcs
M5 x 12 bolts 4pcs
M5 nuts 4pcs
32
33
29 26
10
Place 2 cylinder connection bar brackets (32) on bottom panel (33) and 2 washers (35) under bottom
panel (33) in position, then secure them with 4 M5x18 bolts, 4 D5 washers and 4 M5 nuts.
Connect the cylinder fixing wire (26) to left side panel (10) and right side panel (29) with 4 M5x12
bolts.
NOTE: When using a smaller diameter gas cylinder (such as 4.5lb gas cylinder ), install the cylinder
fixing wire to front holes. When using a bigger diameter gas cylinder (such as 5lb Worthington gas
cylinder or 5lb Manchester gas cylinder), install the cylinder fixing wire to rear holes.
Please refer to Fig.1 and Fig.2 in Page11.
Dieses Handbuch passt für folgende Modelle
1
Inhaltsverzeichnis
Beliebte Heizung Handbücher anderer Marken
Empire Heating Systems
Empire Heating Systems WCC65 Bedienungsanleitung
Wetekom
Wetekom 92 86 43 Bedienungsanleitung
Desa
Desa SPC170-F Bedienungsanleitung
Watlow
Watlow Watrod Electric Tubular Heaters Bedienungsanleitung
Haverland
Haverland ECO-DRY GPS Series Stücklistenhandbuch
Stelpro
Stelpro ASILVC2060 Series Bedienungsanleitung