Thomann BOTEX Chainhoist Controller CHC-4 Bedienungsanleitung

Chainhoist Controller CHC-4, CHC-8

Motor Controller

User Manual

Thomann GmbH

Hans-Thomann-Straße 1

96138 Burgebrach

Germany

Telephone: +49 (0) 9546 9223-0

Internet: www.thomann.de

19.12.2023, ID: 422822, 422852 (V5)

Table of contents

1 General information................................................................................................................................. 5

1.1 Symbols and signal words............................................................................................................... 5

2 Safety instructions..................................................................................................................................... 7

3 Features....................................................................................................................................................... 10

4 Installation.................................................................................................................................................. 11

4.1 Mechanical installation.................................................................................................................. 11

4.2 Electrical installation....................................................................................................................... 12

5 Starting up.................................................................................................................................................. 14

6 Connections and controls................................................................................................................... 17

7 Operating.................................................................................................................................................... 23

8 Technical specications....................................................................................................................... 25

9 EU Declaration Of Conformity........................................................................................................... 28

10 Troubleshooting...................................................................................................................................... 31

11 Protecting the environment.............................................................................................................. 33

Table of contents

Chainhoist Controller CHC-4, CHC-8 3

Motor Controller

4Chainhoist Controller CHC-4, CHC-8

Motor Controller

1 General information

This document contains important instructions for the safe operation of the product. Read and

follow the safety instructions and all other instructions. Keep the document for future refer‐

ence. Make sure that it is available to all those using the product. If you sell the product to

another user, be sure that they also receive this document.

Our products and documentation are subject to a process of continuous development. They

are therefore subject to change. Please refer to the latest version of the documentation, which

is ready for download under www.thomann.de.

1.1 Symbols and signal words

In this section you will nd an overview of the meaning of symbols and signal words that are

used in this document.

General information

Chainhoist Controller CHC-4, CHC-8 5

Motor Controller

Signal word Meaning

DANGER! This combination of symbol and signal word indicates an

immediate dangerous situation that will result in death or

serious injury if it is not avoided.

CAUTION! This combination of symbol and signal word indicates a pos‐

sible dangerous situation that can result in minor injury if it

is not avoided.

NOTICE! This combination of symbol and signal word indicates a pos‐

sible dangerous situation that can result in material and

environmental damage if it is not avoided.

Warning signs Type of danger

Warning – high-voltage.

Warning – danger zone.

General information

6Chainhoist Controller CHC-4, CHC-8

Motor Controller

2 Safety instructions

This device is used to control electrically operated chain hoists. The device is designed for pro‐

fessional use only and is not suitable for use in households. Use the device only as described in

this user manual. Any other use or use under other operating conditions is considered to be

improper and may result in personal injury or property damage. No liability will be assumed for

damages resulting from improper use.

This device may be used only by persons with sucient physical, sensorial, and intellectual

abilities and having corresponding knowledge and experience. Other persons may use this

device only if they are supervised or instructed by a person who is responsible for their safety.

Safety

DANGER!

Risk of injury and choking hazard for children!

Children can suocate on packaging material and small parts. Children can injure themselves when handling the device. Never allow

children to play with the packaging material and the device. Always store packaging material out of the reach of babies and small

children. Always dispose of packaging material properly when it is not in use. Never allow children to use the device without supervi‐

sion. Keep small parts away from children and make sure that the device does not shed any small parts (such knobs) that children

could play with.

DANGER!

Danger to life due to electric current!

Within the device there are areas where high voltages may be present. Never remove any covers. There are no user-serviceable parts

inside. Do not use the device when covers, safety equipment or optical components are missing or damaged.

Intended use

Safety instructions

Chainhoist Controller CHC-4, CHC-8 7

Motor Controller

DANGER!

Risk of death from electrical current!

A short circuit can cause res and loss of life. Always use a properly insulated CEE cable to connect the unit to the 400 V mains grid.

Do not modify the CEE cable or the CEE plug. If the insulation is damaged, immediately switch o the power supply and have it

repaired. If in doubt, contact a qualied electrician.

DANGER!

Risk of death from electrical current!

Hazardous voltage may be present at cable ends and screw terminals. The connection of screw terminals and all maintenance and

repair work on the electrical installation of the device may only be performed by a qualied electrician. Always perform maintenance

and repair work when the device is free from voltage. Failure to comply may result in electric shock and risk of re and loss of life.

Always observe all electrical safety instructions applicable in the country of operation.

NOTICE!

Risk of re due to covered vents and neighbouring heat sources!

If the vents of the device are covered or the device is operated in the immediate vicinity of other heat sources, the device can over‐

heat and burst into ames. Never cover the device or the vents. Do not install the device in the immediate vicinity of other heat

sources. Never operate the device in the immediate vicinity of naked ames.

NOTICE!

Damage to the device if operated in unsuitable ambient conditions!

The device can be damaged if it is operated in unsuitable ambient conditions. Only operate the device indoors within the ambient

conditions specied in the “Technical specications” chapter of this user manual. Avoid operating it in environments with direct sun‐

light, heavy dirt and strong vibrations. Avoid operating it in environments with strong temperature uctuations. If temperature uc‐

tuations cannot be avoided (for example after transport in low outside temperatures), do not switch on the device immediately.

Never subject the device to liquids or moisture. Never move the device to another location while it is in operation. In environments

with increased dirt levels (for example due to dust, smoke, nicotine or mist): Have the device cleaned by qualied specialists at reg‐

ular intervals to prevent damage due to overheating and other malfunctions.

Safety instructions

8Chainhoist Controller CHC-4, CHC-8

Motor Controller

NOTICE!

Damage to the device due to high voltages!

The device can be damaged if it is operated with the incorrect voltage or if high voltage peaks occur. In the worst case, excess vol‐

tages can also cause a risk of injury and res. Make sure that the voltage specication on the device matches the local power grid

before plugging in the device. Only operate the device from professionally installed mains sockets that are protected by a residual

current circuit breaker (FI). As a precaution, disconnect the device from the power grid when storms are approaching or it the device

will not be used for a longer period.

Safety instructions

Chainhoist Controller CHC-4, CHC-8 9

Motor Controller

3 Features

nMotor controller for directly controlled electric chain hoists

nIndependent control for up to

– 4 motors (item no. 422822)

– 8 motors (item no. 422852)

nInput

– Cable with CEE plug

nOutputs

– item no. 422822: 4 × 4-pin CEE chassis sockets with hinged lid, 1 × 16-pin multi-pin

industrial connector for use with a breakout box

– item no. 422852: 4 × 4-pin CEE chassis sockets with hinged lid, 2 × 16-pin multi-pin

industrial connectors for use with a breakout box

nLine circuit breaker for each phase

nLine circuit breaker for rotary switch and emergency stop switch

Features

10 Chainhoist Controller CHC-4, CHC-8

Motor Controller

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere thomann Controller Handbücher

thomann

thomann Stairville LED Pixel Rail Drive640 MKII Bedienungsanleitung

thomann

thomann the t.racks DSP 4x4 Amp 4.250 Bedienungsanleitung

thomann

thomann Stairville LED-Commander 16/2 Bedienungsanleitung

thomann

thomann STAIRVILLE DMX-Master MK II ENC Bedienungsanleitung

thomann

thomann the t.racks DSP 4x4 Mini Amp Bedienungsanleitung

thomann

thomann the t.racks DSP 204 Bedienungsanleitung

thomann

thomann BOTEX SDC-6 Bedienungsanleitung

thomann

thomann the t.racks 8x8 Matrix Bedienungsanleitung

thomann

thomann SDC-16 Bedienungsanleitung

thomann

thomann Stairville DMX Invader 1024 NET Bedienungsanleitung

thomann

thomann STAIRVILLE DDC-12 Bedienungsanleitung

thomann

thomann Botex Dr. RDM Bedienungsanleitung

thomann

thomann Stairville Replay Show Bedienungsanleitung

thomann

thomann Botex LED Stripe All-in-One Control Bedienungsanleitung

thomann

thomann BOTEX Rainbow Rider DMX Bedienungsanleitung

thomann

thomann Stairville LED Pixel Rail Drive640 MKII Bedienungsanleitung

thomann

thomann the t.racks DSP 4x4 Mini Amp Bedienungsanleitung

Beliebte Controller Handbücher anderer Marken

Digiplex

Digiplex DGP-848 Betriebsanleitung

YASKAWA

YASKAWA SGM series Bedienungsanleitung

Sinope

Sinope Calypso RM3500ZB Bedienungsanleitung

Isimet

Isimet DLA Series Style 2 Installationshandbuch

LSIS

LSIS sv-ip5a Bedienungsanleitung

Rockwell Automation

Rockwell Automation 1769-L31 Bedienungsanleitung

Airflow

Airflow Uno hab Bedienungsanleitung

ABB

ABB ACS580-01 drives Bedienungsanleitung

Panasonic

Panasonic GM1 Series Bedienungsanleitung

Emerson

Emerson SW93 Bedienungsanleitung

AutoAqua

AutoAqua Smart ATO micro SATO-120P Bedienungsanleitung

Panasonic

Panasonic FP? Positioning Unit RTEX Bedienungsanleitung

Samson

Samson Type 5824 Service-Handbuch

Alpha IP

Alpha IP MIOB 21001 Bedienungsanleitung

Siemens

Siemens OpenAir GMA 1 Series Bedienungsanleitung

Surecom

Surecom SR-629 Bedienungsanleitung

Fishman

Fishman TriplePlay Bedienungsanleitung

Regulus

Regulus SRS1 T Bedienungsanleitung

thomann BOTEX Chainhoist Controller CHC-4 Bedienungsanleitung

Beliebte Controller Handbücher anderer Marken