UTICA BOILERS TriFire Installationsanleitung

Knockdown Boiler Assembly Instructions -

TriFire Model

Remove all components from crate. It may be to the1. installer’s advantage to place the cast iron boiler block

close to where the nal installation location will be.

Install rubber grommets in rear top plate. Attach with

2. brass bolts and washers. See Figure 1.

Figure 1

Rear of boiler

P/N 240007211, Rev. A [04/08]

KNOCKDOWN ASSEMBLY

Instructions for

TriFire Oil Fired Boiler

SUPPLEMENTAL INSTRUCTIONS

This assembly must be completed by a qualied installer or service agency, in accordance with the

manufacturer’s instructions, and in accordance with all codes and requirements of the authority having

jurisdiction. Failure to follow these instructions could result in re or explosion resulting in property dam-

age, personal injury, or loss of life.

WARNING

Wrap insulation around boiler with the smooth side out.3.

If necessary, overlap underneath boiler. Wrap 2 band-

ing strips around insulation. As shown in Figure 2,

Cinch banding together with plastic buckles provided.

Cut off excess banding material.

Figure 2

Insulation straps with buckles

Attach pipe nipples to supply and return outlets. Be4. sure to use pipe dope before screwing into boiler. See

Figure 3.

Figure 3

Attach insulation to rear of boiler. Attach insulation5. straps with plastic buckles as shown in Figure 4. Cut

off excess strap material as shown.

Figure 4

Place the control panel on the top of the boiler with the6. burner wire harness on the right. See Figure 4A.

Figure 4A

Insert brass bolts into threaded holes on front of boiler7. as shown in Figure 5. Do not tighten down. These

bolts will hold the side Jacket panels on the boiler.

Figure 5

KNOCKDOWN BOILER ASSEMBLY

Place the side jackets on the bolts from the previ-8. ous step. Be sure to route the burner wire harness as

shown in Figure 6.

Figure 6

11”

Attach the burner harness zip tie to right side jacket. If9.

no hole is present, drill 1/8” dia. See Figure 6.

Attach the lower rear panel, then attach the upper

10.

rear panel with the screws provided. See Figure 7

(Nipples removed for clarity.)

Figure 7

Rear of boiler

Attach the front control panel with the screws provided.11.

Check the clearance between the two side panels and en-

sure there is the same clearance top and bottom. Tighten

down the bolts mentioned in step 6. See Figure 8.

Figure 8

Attach the front panel by setting onto the rivets in the12.

side jackets. See gure 9.

Figure 9

KNOCKDOWN BOILER ASSEMBLY

Attach the top panel with the screws provided.13.

Proceed to the section “Packaged Boiler Assembly” in14.

the Installation, Operation and Maintenance manual.

KNOCKDOWN BOILER ASSEMBLY

For technical assistance with this product call toll free 1-800-325-5479

ECR International

PO Box 4729

Utica, NY 13504-4729

www.ecrinternational.com

Inhaltsverzeichnis

Andere UTICA BOILERS Kessel Handbücher

UTICA BOILERS

UTICA BOILERS STARFIRE 3 STEAM Technisches Dokument

UTICA BOILERS

UTICA BOILERS UBSSC-299 Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS TRIFIRE II Series Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS UB95M-200 Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS OMGB Series Betriebsanleitung

UTICA BOILERS

UTICA BOILERS MGC-8D Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS MAH-125 Bedienungsanleitung

UTICA BOILERS

UTICA BOILERS PEG-C Bedienungsanleitung

UTICA BOILERS

UTICA BOILERS OLSSV-050 Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS SFM6225W Bedienungsanleitung

UTICA BOILERS

UTICA BOILERS UCS-240 Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS UB95M-200 Bedienungsanleitung

UTICA BOILERS

UTICA BOILERS DV-B Series Montage- und Bedienungsanleitung

UTICA BOILERS

UTICA BOILERS USC SERIES Leitfaden

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

UTICA BOILERS

UTICA BOILERS MAHF-125 Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS USC SERIES Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS UB90-50 Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS MGB Series Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS Trifire 3 Series Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS MGC 3 Series Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS DVB-50 Betriebsanleitung

UTICA BOILERS

UTICA BOILERS STARFIRE 3 WATER Gebrauchsanweisung

UTICA BOILERS

UTICA BOILERS MGB-50J Gebrauchsanweisung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung

Radiant

Radiant R2K 55 Handbuch